微生物燃料电池处理偶氮含盐废水的产电性能和降解过程

doi:10.16085/j.issn.1000-6613.2021-1334

化工进展 ›› 2022, Vol. 41 ›› Issue (6): 3306-3313.DOI: 10.16085/j.issn.1000-6613.2021-1334

微生物燃料电池处理偶氮含盐废水的产电性能和降解过程

潘文政¹^,²^,³(), 纪志永¹^,²^,³(), 汪婧¹^,²^,³, 李淑明¹^,²^,³, 黄智辉¹^,²^,³, 郭小甫²^,³, 刘杰¹^,²^,³, 赵颖颖¹^,²^,³, 袁俊生¹^,²^,³

^1.河北工业大学化工学院，天津 300130
^2.河北工业大学海水资源高效利用化工技术教育部工程研究中心，天津 300130
^3.河北省现代海洋化工技术协同创新中心，天津 300130

收稿日期:2021-06-25 修回日期:2021-09-21 出版日期:2022-06-10 发布日期:2022-06-21
通讯作者: 纪志永
作者简介:潘文政（1995—），男，硕士研究生，研究方向为工业废水处理。E-mail：pwz4614@126.com。
基金资助:
河北省自然科学基金杰出青年基金(B2019202423);河北省重点研发计划(19274003D)

Research on the electricity production performance and degradation process of microbial fuel cell treating azo-dye saline wastewater

PAN Wenzheng¹^,²^,³(), JI Zhiyong¹^,²^,³(), WANG Jing¹^,²^,³, LI Shuming¹^,²^,³, HUANG Zhihui¹^,²^,³, GUO Xiaofu²^,³, LIU Jie¹^,²^,³, ZHAO Yingying¹^,²^,³, YUAN Junsheng¹^,²^,³

^1.School of Chemical Engineering and Technology, Hebei University of Technology, Tianjin 300130, China
^2.Engineering Research Center of Seawater Utilization of Ministry of Education, School of Chemical Engineering and Technology, Hebei University of Technology, Tianjin 300130, China
^3.Hebei Collaborative Innovation Center of Modern Marine Chemical Technology, Tianjin 300130, China

Received:2021-06-25 Revised:2021-09-21 Online:2022-06-10 Published:2022-06-21
Contact: JI Zhiyong

摘要/Abstract

摘要：

偶氮含盐废水生化处理流程复杂、电耗高，且降解机理尚不明确。本研究基于酸性重铬酸钾法水热处理获取改性阳极，进而构建微生物燃料电池（microbial fuel cell，MFC）对偶氮含盐废水进行处理。考察了不同二价阴离子对MFC产电性能和降解有机物效果的影响，并探究了MFC对直接红13的降解机理。结果表明，偶氮含盐废水中含有硫酸钠时的产电性能高于含有碳酸钠的情况，MFC最大功率密度为265.38mW/m²、最大电流密度为1.10A/m²；MFC处理偶氮含盐废水时，对直接红13的去除率低于无额外添加盐时的效果（71.13%），对葡萄糖共基质的降解影响程度为：添加硫酸钠>添加碳酸钠>无额外添加盐。微生物群落和降解产物分析表明，MFC阳极生物膜通过变形菌门、拟杆菌门等微生物的协同作用实现了对直接红13的生物电化学降解，产电下降解产物以还原产物芳香胺为主。

关键词: 偶氮含盐废水, 微生物燃料电池, 电化学, 微生物群落, 产电, 降解

Abstract:

The biochemical treatment process of azo-dye saline wastewater was complicated, and had the problems of the electricity consumption and unclear degradation mechanism. In this research, being based on the acidic-potassium-dichromate-method hydrothermal treatment, the modified anode was obtained and then was applied to construct microbial fuel cell to treat azo-dye saline wastewater. The effects of different divalent anions on the electricity generation performance and the organics degradation of MFC were investigated, and the degradation mechanism of Direct Red 13 by MFC was also explored. The results showed that when the inorganic salt in the azo-dye saline wastewater was sodium sulfate, the maximum power density of MFC could reach 265.38mW/m², and the maximum current density was 1.10A/m², which was higher than that of the wastewater containing sodium carbonate. As the wastewater with additional salt, the removal rate of Direct Red 13 by MFC was much lower than that without additional (71.13%). The order of the removal efficiency of glucose was sodium sulfate > sodium carbonate > no additional. Analysis of microbial communities and degradation products showed that, the anode biofilm realized the bio-electrochemical degradation of Direct Red 13 through the synergistic effect of microorganisms like Proteobacteria and Bacteroides, and the degradation products were mainly reduced products (aromatic amines) under electricity generation.

Key words: azo-dye saline wastewater, microbial fuel cell (MFC), electrochemistry, microbial community, electricity generation, degradation

中图分类号:

TM911.45

潘文政, 纪志永, 汪婧, 李淑明, 黄智辉, 郭小甫, 刘杰, 赵颖颖, 袁俊生. 微生物燃料电池处理偶氮含盐废水的产电性能和降解过程[J]. 化工进展, 2022, 41(6): 3306-3313.

PAN Wenzheng, JI Zhiyong, WANG Jing, LI Shuming, HUANG Zhihui, GUO Xiaofu, LIU Jie, ZHAO Yingying, YUAN Junsheng. Research on the electricity production performance and degradation process of microbial fuel cell treating azo-dye saline wastewater[J]. Chemical Industry and Engineering Progress, 2022, 41(6): 3306-3313.

图/表 10

参考文献 33

1	田颖, 赵崇, 刘晓宇, 等. 高含盐高有机物印染废水吸附脱除有机物的效果验证与探讨[C]//中国环境科学学会2019年科学技术年会——环境工程技术创新与应用分论坛论文集. 西安: 《环境工程》编辑部, 2019.
	TIAN Ying, ZHAO Chong, LIU Xiaoyu, et al. Discussion on the process of adsorption-evaporation-crystallization to the dyeing wastewater with high concentrations of salt and organic[C]// Chinese Society for Environmental Sciences, Science and Technology annual meeting 2019—Technology innovation and application of environmental engineering-Proceedings of the forum. Xi’an: Editorial Department of Environmental Engineering, 2019.
2	LOGAN B E, HAMELERS B, ROZENDAL R, et al. Microbial fuel cells: methodology and technology[J]. Environmental Science & Technology, 2006, 40(17): 5181-5192.
3	YANG Z G, PEI H Y, HOU Q J, et al. Algal biofilm-assisted microbial fuel cell to enhance domestic wastewater treatment: nutrient, organics removal and bioenergy production[J]. Chemical Engineering Journal, 2018, 332: 277-285.
4	李文英, 刘玉香, 任瑞鹏, 等. 微生物燃料电池在水与废水脱氮方面的研究进展[J]. 化工进展, 2019, 38(2): 1097-1106.
	LI Wenying, LIU Yuxiang, REN Ruipeng, et al. Research progress on removal of nitrogen in water and wastewater by microbial fuel cell[J]. Chemical Industry and Engineering Progress, 2019, 38(2): 1097-1106.
5	XIE B H, LIANG H, YOU H, et al. Microbial community dynamic shifts associated with sulfamethoxazole degradation in microbial fuel cells[J]. Chemosphere, 2021, 274: 129744.
6	RASHID T, SHER F, HAZAFA A, et al. Design and feasibility study of novel paraboloid graphite based microbial fuel cell for bioelectrogenesis and pharmaceutical wastewater treatment[J]. Journal of Environmental Chemical Engineering, 2021, 9(1): 104502.
7	AMARI S, BOSHROUYEH GHANDASHTANI M. Non-steroidal anti-inflammatory pharmaceutical wastewater treatment using a two-chambered microbial fuel cell[J]. Water and Environment Journal, 2020, 34(3): 413-419.
8	杨茜, 李轩, 蒋涛阳, 等. 高盐废水生物阴极MFCs产电及脱氮性能研究[J]. 应用化工, 2020, 49(1): 22-27.
	YANG Qian, LI Xuan, JIANG Taoyang, et al. Study on electricity generation and nitrogen removal performance of bio-cathode MFCs in high-salt wastewater[J]. Applied Chemical Industry, 2020, 49(1): 22-27.
9	付国楷, 张林防, 郭飞, 等. 榨菜废水MFC多周期运行产电性能及COD降解[J]. 中国环境科学, 2017, 37(4): 1401-1407.
	FU Guokai, ZHANG Linfang, GUO Fei, et al. Electricity generation and COD removal of MFC using mustard tuber wastewater as substrate in multi-cycle running[J]. China Environmental Science, 2017, 37(4): 1401-1407.
10	LIU G L, YU S X, LUO H P, et al. Effects of salinity anions on the anode performance in bioelectrochemical systems[J]. Desalination, 2014, 351: 77-81.
11	LEFEBVRE O, TAN Z, KHARKWAL S, et al. Effect of increasing anodic NaCl concentration on microbial fuel cell performance[J]. Bioresource Technology, 2012, 112: 336-340.
12	CAO X, ZHANG S, WANG H, et al. Azo dye as part of co-substrate in a biofilm electrode reactor-microbial fuel cell coupled system and an analysis of the relevant microorganisms[J]. Chemosphere, 2019, 216: 742-748.
13	李海红, 巴琦玥, 闫志英, 等. 不同原料厌氧发酵及其微生物种群的研究[J]. 中国环境科学, 2015, 35(5): 1449-1457.
	LI Haihong, BA Qiyue, YAN Zhiying, et al. Studies on microbial community of different materials and anaerobic fermentation[J]. China Environmental Science, 2015, 35(5): 1449-1457.
14	解井坤. 偶氮染料脱色特异微生物群落及其应用研究[D]. 西安: 陕西科技大学, 2015.
	XIE Jingkun. Azo dye specific degradation microbial community and its application research[D]. Xi’an: Shaanxi University of Science & Technology, 2015.
15	周宇, 刘中良, 侯俊先, 等. 化学氧化改性微生物燃料电池阳极[J]. 化工学报, 2015, 66(3): 1171-1177.
	ZHOU Yu, LIU Zhongliang, HOU Junxian, et al. Microbial fuel cell anode modified by chemical oxidation[J]. CIESC Journal, 2015, 66(3): 1171-1177.
16	TANG X H, DU Z W, LI H R. Anodic electron shuttle mechanism based on 1-hydroxy-4-aminoanthraquinone in microbial fuel cells[J]. Electrochemistry Communications, 2010, 12(8): 1140-1143.
17	黄力华, 李秀芬, 任月萍, 等. 石墨烯掺杂聚苯胺阳极提高微生物燃料电池性能[J]. 环境科学, 2017, 38(4): 1717-1725.
	HUANG Lihua, LI Xiufen, REN Yueping, et al. Performance improvement of microbial fuel cell with polyaniline dopped graphene anode[J]. Environmental Science, 2017, 38(4): 1717-1725.
18	LOGAN B, CHENG S, WATSON V, et al. Graphite fiber brush anodes for increased power production in air-cathode microbial fuel cells[J]. Environmental Science & Technology, 2007, 41(9): 3341-3346.
19	高文军, 李卫红, 王喜明, 等. 3,5-二硝基水杨酸法测定蔓菁中还原糖和总糖含量[J]. 中国药业, 2020, 29(9): 113-116.
	GAO Wenjun, LI Weihong, WANG Ximing, et al. Determination of reducing sugar and total sugar in turnip by 3, 5-dinitrosalicylic acid colorimetry[J]. China Pharmaceuticals, 2020, 29(9): 113-116.
20	SHEN J, DU Z P, LI J F, et al. Co-metabolism for enhanced phenol degradation and bioelectricity generation in microbial fuel cell[J]. Bioelectrochemistry, 2020, 134: 107527.
21	GUO F, BABAUTA J T, BEYENAL H. The effect of additional salinity on performance of a phosphate buffer saline buffered three-electrode bioelectrochemical system inoculated with wastewater[J]. Bioresource Technology, 2021, 320: 124291.
22	GUO F, LUO H Q, SHI Z Y, et al. Substrate salinity: a critical factor regulating the performance of microbial fuel cells, a review[J]. Science of the Total Environment, 2021, 763: 143021.
23	HE Z, MANSFELD F. Exploring the use of electrochemical impedance spectroscopy (EIS) in microbial fuel cell studies[J]. Energy Environ. Sci., 2009, 2(2): 215-219.
24	MOHAN S V, CHANDRASEKHAR K. Solid phase microbial fuel cell (SMFC) for harnessing bioelectricity from composite food waste fermentation: Influence of electrode assembly and buffering capacity[J]. Bioresource Technology, 2011, 102(14): 7077-7085.
25	PRAJAPATI S, YELAMARTHI P S. Microbial fuel cell-assisted Congo red dye decolorization using biowaste-derived anode material[J]. Asia-Pacific Journal of Chemical Engineering, 2020, 15(5): e2558.
26	LIU H J, ZHANG Z H, XU Y, et al. Reduced graphene oxide@polydopamine decorated carbon cloth as an anode for a high-performance microbial fuel cell in Congo red/saline wastewater removal[J]. Bioelectrochemistry, 2021, 137: 107675.
27	SINGH A, KAUSHIK A. Suitability of wetland microbial consortium for enhanced and sustained power generation from distillery effluent in microbial fuel cell[J]. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 2020: 1-17.
28	ZHU Y L, CAO X W, CHENG Y T, et al. Performances and structures of functional microbial communities in the mono azo dye decolorization and mineralization stages[J]. Chemosphere, 2018, 210: 1051-1060.
29	ALMATOUQ A, BABATUNDE A O, KHAJAH M, et al. Microbial community structure of anode electrodes in microbial fuel cells and microbial electrolysis cells[J]. Journal of Water Process Engineering, 2020, 34: 101140.
30	DOELLE Horst. Bacterial metabolism[M]. 2nd ed. Brisbane: Academic Press, 1975: 199-255.
31	KANG C S, EAKTASANG N, KWON D Y, et al. Enhanced current production by Desulfovibrio desulfuricans biofilm in a mediator-less microbial fuel cell[J]. Bioresource Technology, 2014, 165: 27-30.
32	ZHU Y L, XU J L, CAO X W, et al. Characterization of functional microbial communities involved in different transformation stages in a full-scale printing and dyeing wastewater treatment plant[J]. Biochemical Engineering Journal, 2018, 137: 162-171.
33	LIN X Q, LI Z L, NAN J, et al. Biodegradation and metabolism of tetrabromobisphenol A in microbial fuel cell: behaviors, dynamic pathway and the molecular ecological mechanism[J]. Journal of Hazardous Materials, 2021, 417: 126104.

电极液	pH	电导率/S·m^-1
阳极液
无	6.73~6.82	7.9±1.2
加30mmol/L Na₂SO₄	6.74~6.86	10.7±1.3
加30mmol/L Na₂CO₃	6.66~6.76	10.4±1.8
阴极液
无	6.59~6.88	9.1±2.1
加30mmol/L Na₂SO₄	6.72~6.88	12.3±1.6
加30mmol/L Na₂CO₃	6.61~6.79	11.9±1.5

电极液	pH	电导率/S·m^-1
阳极液
无	6.73~6.82	7.9±1.2
加30mmol/L Na₂SO₄	6.74~6.86	10.7±1.3
加30mmol/L Na₂CO₃	6.66~6.76	10.4±1.8
阴极液
无	6.59~6.88	9.1±2.1
加30mmol/L Na₂SO₄	6.72~6.88	12.3±1.6
加30mmol/L Na₂CO₃	6.61~6.79	11.9±1.5

编号	保留时间/min	可能的物质
1	3.82	苯胺
2	4.98	邻甲苯胺
3	6.78	1,4-苯二胺
4	9.07	2,4-二氨基甲苯
5	10.95	2-萘胺
6	12.62	5-硝基-邻甲苯胺
7	14.07	4-氨基联苯
8	15.31	钛酸二丁酯^①
9	16.66	4,4-二氨基二苯醚
10	18.21	3,3'-二甲基-4'4-二氨基二苯甲烷
11	20.04	4,4'-二氨基二苯硫醚

编号	保留时间/min	可能的物质
1	3.82	苯胺
2	4.98	邻甲苯胺
3	6.78	1,4-苯二胺
4	9.07	2,4-二氨基甲苯
5	10.95	2-萘胺
6	12.62	5-硝基-邻甲苯胺
7	14.07	4-氨基联苯
8	15.31	钛酸二丁酯^①
9	16.66	4,4-二氨基二苯醚
10	18.21	3,3'-二甲基-4'4-二氨基二苯甲烷
11	20.04	4,4'-二氨基二苯硫醚

[1]	张明焱, 刘燕, 张雪婷, 刘亚科, 李从举, 张秀玲. 非贵金属双功能催化剂在锌空气电池研究进展[J]. 化工进展, 2023, 42(S1): 276-286.
[2]	胡喜, 王明珊, 李恩智, 黄思鸣, 陈俊臣, 郭秉淑, 于博, 马志远, 李星. 二硫化钨复合材料制备与储钠性能研究进展[J]. 化工进展, 2023, 42(S1): 344-355.
[3]	张杰, 白忠波, 冯宝鑫, 彭肖林, 任伟伟, 张菁丽, 刘二勇. PEG及其复合添加剂对电解铜箔后处理的影响[J]. 化工进展, 2023, 42(S1): 374-381.
[4]	葛全倩, 徐迈, 梁铣, 王凤武. MOFs材料在光电催化领域应用的研究进展[J]. 化工进展, 2023, 42(9): 4692-4705.
[5]	雷伟, 姜维佳, 王玉高, 和明豪, 申峻. N、S共掺杂煤基碳量子点的电化学氧化法制备及用于Fe³⁺检测[J]. 化工进展, 2023, 42(9): 4799-4807.
[6]	王耀刚, 韩子姗, 高嘉辰, 王新宇, 李思琪, 杨全红, 翁哲. 铜基催化剂电还原二氧化碳选择性的调控策略[J]. 化工进展, 2023, 42(8): 4043-4057.
[7]	刘毅, 房强, 钟达忠, 赵强, 李晋平. Ag/Cu耦合催化剂的Cu晶面调控用于电催化二氧化碳还原[J]. 化工进展, 2023, 42(8): 4136-4142.
[8]	张亚娟, 徐惠, 胡贝, 史星伟. 化学镀法制备NiCoP/rGO/NF高效电解水析氢催化剂[J]. 化工进展, 2023, 42(8): 4275-4282.
[9]	王帅晴, 杨思文, 李娜, 孙占英, 安浩然. 元素掺杂生物质炭材料在电化学储能中的研究进展[J]. 化工进展, 2023, 42(8): 4296-4306.
[10]	杨静, 李博, 李文军, 刘晓娜, 汤刘元, 刘月, 钱天伟. 焦化污染场地中萘降解菌的分离及降解特性[J]. 化工进展, 2023, 42(8): 4351-4361.
[11]	李海东, 杨远坤, 郭姝姝, 汪本金, 岳婷婷, 傅开彬, 王哲, 何守琴, 姚俊, 谌书. 炭化与焙烧温度对植物基铁碳微电解材料去除As(Ⅲ)性能的影响[J]. 化工进展, 2023, 42(7): 3652-3663.
[12]	储甜甜, 刘润竹, 杜高华, 马嘉浩, 张孝阿, 王成忠, 张军营. 有机胍催化脱氢型RTV硅橡胶的制备和可降解性能[J]. 化工进展, 2023, 42(7): 3664-3673.
[13]	徐伟, 李凯军, 宋林烨, 张兴惠, 姚舜华. 光催化及其协同电化学降解VOCs的研究进展[J]. 化工进展, 2023, 42(7): 3520-3531.
[14]	龚鹏程, 严群, 陈锦富, 温俊宇, 苏晓洁. 铁酸钴复合碳纳米管活化过硫酸盐降解铬黑T的性能及机理[J]. 化工进展, 2023, 42(7): 3572-3581.
[15]	蒋博龙, 崔艳艳, 史顺杰, 常嘉城, 姜楠, 谭伟强. 过渡金属Co₃O₄/ZnO-ZIF氧还原催化剂Co/Zn-ZIF模板法制备及其产电性能[J]. 化工进展, 2023, 42(6): 3066-3076.

微生物燃料电池处理偶氮含盐废水的产电性能和降解过程

Research on the electricity production performance and degradation process of microbial fuel cell treating azo-dye saline wastewater

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

图/表 10

参考文献 33

相关文章 15

编辑推荐

Metrics

本文评价