水力喷射空气旋流器用于吸收处理工业尾气中的氨气

doi:10.16085/j.issn.1000-6613.2016.s1.005

化工进展 ›› 2016, Vol. 35 ›› Issue (S1): 26-30.DOI: 10.16085/j.issn.1000-6613.2016.s1.005

水力喷射空气旋流器用于吸收处理工业尾气中的氨气

程治良, 全学军, 徐飞, 代明星

重庆理工大学化学化工学院, 重庆 400054

收稿日期:2015-11-11 修回日期:2015-12-13 出版日期:2016-06-30 发布日期:2016-07-08
通讯作者: 程治良(1986-),男,博士,讲师,研究方向为特种废水、废气的处理。E-mail purper@cqut.edu.cn。
基金资助:
重庆市基础与前沿研究计划(cstc2015jcyjA20005)及重庆理工大学(2014ZD04,2014XH16)项目。

Ammonia absorption of chemical flues gas by acid solution in a water-sparged aerocyclone reactor

CHENG Zhiliang, QUAN Xuejun, XU Fei, DAI Mingxing

School of Chemistry and Chemical Engineering, Chongqing University of Technology, Chongqing 400054, China

Received:2015-11-11 Revised:2015-12-13 Online:2016-06-30 Published:2016-07-08

摘要/Abstract

摘要： 针对工业尾气中氨气吸收存在的传质效率低、设备易于堵塞等问题,本文采用新型超重力气液传质设备水力喷射空气旋流器(WSA),以稀硫酸溶液为吸收剂,开展了氨气吸收处理研究。研究考察了初始NH₃浓度、进口气速、喷孔面积以及中心排气管直径等操作参数和WSA结构参数对氨气吸收处理效率的影响。研究结果表明,NH₃吸收率随着初始NH₃浓度和进口气速的增大均呈现先增大后降低的规律。NH₃吸收率随着WSA的喷孔面积的增大先增大后趋于平缓,但却随着WSA的中心排气管直径的增大而降低,但压降也随之增大。在NH₃浓度为4500mg/m³左右,进口气速为26.46m/s时,采用喷孔面积为565.5mm²、中心排气管直径为32mm的WSA,NH₃吸收去除率可达99.5%以上。该工艺在工业尾气中的NH₃回收处理方面具有较大的应用前景。

关键词: 气体旋流器, 吸收, 气液两相流, 分离

Abstract: In order to overcome the disadvantage of low efficiency and serious scaling and clogging in traditional ammonia absorption process using packed beds as the absorber.In this paper, water-sparged aerocyclone (WSA), a new gas-liquid mass transfer equipment was used for ammonia absorption of chemical flues gas by dilute sulphuric acid solution.The effect of operation parameters of initial ammonia concentration, flues gas inlet velocity and WSA structure parameters of sparge hole area and diameter of vortex finder on ammonia absorption efficiency were investigated.The results showed that the ammonia absorption efficiency increased firstly and then decreased with the increase of initial ammonia concentration and flues gas inlet velocity.It increased fast at first and then tended to increase slowly with the increase of sparge hole area, however, it decreased with the increase of diameter of vortex finder.When initial ammonia concentration of 4500mg/m³, flues gas inlet velocity of 26.46m/s, using the WSA of sparge hole area of 565.5mm² and diameter of vortex finder of 32mm, the ammonia absorption efficiency could be as high as more than 99.5%.These results provide a kind of alternative for ammonia absorption of chemical flues gas in chemical industry.

Key words: gas cyclone, absorption, gas-liquid flow, separation

中图分类号:

TQ028
X51

程治良, 全学军, 徐飞, 代明星. 水力喷射空气旋流器用于吸收处理工业尾气中的氨气[J]. 化工进展, 2016, 35(S1): 26-30.

CHENG Zhiliang, QUAN Xuejun, XU Fei, DAI Mingxing. Ammonia absorption of chemical flues gas by acid solution in a water-sparged aerocyclone reactor[J]. Chemical Industry and Engineering Progree, 2016, 35(S1): 26-30.

参考文献

[1] AMARIS C,BOUROUIS M,VALLÈS M.Passive intensification of the ammonia absorption process with NH₃/LiNO₃ using carbon nanotubes and advanced surfaces in a tubular bubble absorber[J].Energy,2014,68:519-528.
[2] 吕丹丹,种云霄,吴启堂, 等.过磷酸钙对氨气的吸附解吸特性研究[J].环境科学学报,2011,31(11):2506-2510.
[3] PAGANS E,FONT X,SANCHEZ A.Biofiltration for ammonia removal from composting exhaust gases[J]. Chemical Engineering Journal,2005,113:105-110.
[4] YIN J,XU W F.Ammonia biofiltration and community analysis of ammonia-oxidizing bacteria in biofilters[J]. Bioresource Technology,2009,100:3869-3876.
[5] 史良俊,许绿丝,陈孟,等.纳米TiO₂-Ag改性VACF处理氨气研究[J].环境工程学报,2009,6(3):1094-1098.
[6] HADLOCON L J S,SOBOYEJO A B O,ZHAO L,et al. Statistical modelling of ammonia absorption in an acid spray scrubber[J].Biosystems Engineering,2015,132:88-95.
[7] TAO W,UKWUANI A T.Coupling thermal stripping and acid absorption for ammonia recovery from dairy manure:ammonia volatilization kinetics and effects of temperature, pH and dissolved solids content[J].Chemical Engineering Journal,2015,280:188-196.
[8] 王媛媛,李素芳,余刚,等.添加醇对氨气在气液间传质性能的影响[J].环境污染与防治,2008,30(1):64-67.
[9] 赵清华,全学军,程治良,等.水力喷射-空气旋流器中气液传质特性及其机理[J].化工学报,2013,64(10):3652-3657.
[10] 陈建峰.超重力技术及应用[M].北京:化学工业出版社,2002:1-2.
[11] 孟晓丽,刘有智,焦纬洲,等.旋转填料床净化磷肥尾气中的氨气[J].化工进展,2008,27(2):308-310.
[12] QUAN X J,WANG F P,ZHAO Q H,et al.Air stripping of ammonia in a water-sparged aerocyclone reactor[J]. Journal of Hazardous Materials,2009,170(2/3):983-988.
[13] QUAN X J,YE C Y,XIONG Y Q,et al.Simultaneous removal of ammonia, P and COD from anaerobically digested piggery wastewater using an integrated process of chemical precipitation and air stripping[J].Journal of Hazardous Materials,2010,178(1-3):326-332.
[14] 程治良,全学军,代黎,等.水力喷射空气旋流器喷孔分布优化[J].化工学报,2013,64(9):3182-3188.
[15] 曹仲文.侧壁喷液的旋流吸收器内吸收过程的研究[D].无锡:江南大学,2008.
[16] 赵清华,全学军,项锦欣,等.水力喷射空气旋流器的气相压降特性[J].化工学报,2011,62(9):2507-2511.
[17] ELSAYED K,LACOR C.The effect of cyclone vortex finder dimensions on the flow pattern and performance using LES[J].Computers & Fluids,2013,71:224-239.
[18] 程治良,徐飞,全学军,等.排气管直径与深度对水力喷射空气旋流器传质性能的影响[J].化工学报,2015,66(5):1642-1648.
[19] 陈建磊,何利民,罗小明,等.柱状旋流分离器零轴速面分布特性模拟分析[J].化工学报,2013,64(9):3241-3249.

水力喷射空气旋流器用于吸收处理工业尾气中的氨气

Ammonia absorption of chemical flues gas by acid solution in a water-sparged aerocyclone reactor

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	崔守成, 徐洪波, 彭楠. 两种MOFs材料用于O₂/He吸附分离的模拟分析[J]. 化工进展, 2023, 42(S1): 382-390.
[2]	李世霖, 胡景泽, 王毅霖, 王庆吉, 邵磊. 电渗析分离提取高值组分的研究进展[J]. 化工进展, 2023, 42(S1): 420-429.
[3]	张凤岐, 崔成东, 鲍学伟, 朱炜玄, 董宏光. 胺液吸收-分步解吸脱硫工艺的设计与评价[J]. 化工进展, 2023, 42(S1): 518-528.
[4]	郭强, 赵文凯, 肖永厚. 增强流体扰动强化变压吸附甲硫醚/氮气分离的数值模拟[J]. 化工进展, 2023, 42(S1): 64-72.
[5]	李季桐, 王刚, 熊亚选, 徐钱. 不同工质单效吸收式制冷系统的能量和㶲分析[J]. 化工进展, 2023, 42(S1): 104-112.
[6]	赵晨, 苗天泽, 张朝阳, 洪芳军, 汪大海. 负压状态窄缝通道乙二醇水溶液传热特性[J]. 化工进展, 2023, 42(S1): 148-157.
[7]	杨寒月, 孔令真, 陈家庆, 孙欢, 宋家恺, 王思诚, 孔标. 微气泡型下向流管式气液接触器脱碳性能[J]. 化工进展, 2023, 42(S1): 197-204.
[8]	陈匡胤, 李蕊兰, 童杨, 沈建华. 质子交换膜燃料电池气体扩散层结构与设计研究进展[J]. 化工进展, 2023, 42(S1): 246-259.
[9]	贺美晋. 分子管理在炼油领域分离技术中的应用和发展趋势[J]. 化工进展, 2023, 42(S1): 260-266.
[10]	廖志新, 罗涛, 王红, 孔佳骏, 申海平, 管翠诗, 王翠红, 佘玉成. 溶剂脱沥青技术应用与进展[J]. 化工进展, 2023, 42(9): 4573-4586.
[11]	潘宜昌, 周荣飞, 邢卫红. 高效分离同碳数烃的先进微孔膜：现状与挑战[J]. 化工进展, 2023, 42(8): 3926-3942.
[12]	卜治丞, 焦波, 林海花, 孙洪源. 脉动热管计算流体力学模型与研究进展[J]. 化工进展, 2023, 42(8): 4167-4181.
[13]	娄宝辉, 吴贤豪, 张驰, 陈臻, 冯向东. 纳米流体用于二氧化碳吸收分离研究进展[J]. 化工进展, 2023, 42(7): 3802-3815.
[14]	周龙大, 赵立新, 徐保蕊, 张爽, 刘琳. 电场-旋流耦合强化多相介质分离研究进展[J]. 化工进展, 2023, 42(7): 3443-3456.
[15]	陈香李, 李倩倩, 张甜, 李彪, 李康康. 自愈合油水分离膜的研究进展[J]. 化工进展, 2023, 42(7): 3600-3610.