厌氧水解的新解读：快速水解和慢速水解

doi:10.16085/j.issn.1000-6613.2020-0910

摘要/Abstract

摘要：

挥发性脂肪酸（VFA）具有可生化性好、附加价值高等优点而得到广泛应用，厌氧消化产VFA是目前学术界的研究热点，但对有机物经过水解后的生物降解性能则少有论及，厌氧发酵过程中的水解产物存在“数量”和“质量”之间的权衡问题。为了进一步提高厌氧发酵过程中微生物对有机物的利用效率，突破水解对厌氧消化的限制性作用，从基质碳源释放快慢及厌氧发酵过程中碳源降解性能不同，本文将厌氧水解分为快速水解和慢速水解，分别阐述了两种水解方式的含义、分类以及优缺点，指出细胞内外碳源的释放速率和释放方式的不同是影响厌氧产酸和生物降解性能的决定性因素。最后指出快速水解与慢速水解相结合的分阶段联合处理方式，是今后厌氧消化产VFA的主要研究方向。

关键词: 厌氧, 水解, 发酵, 快速水解, 慢速水解, 挥发性脂肪酸

Abstract:

Volatile fatty acid (VFA) is widely used because of its good biodegradability and high additive value. Currently, production of VFA via anaerobic digestion is a research hotspot. However, the biodegradability of organic matter after hydrolysis was rarely discussed. There is a trade-off between quantity and quality of hydrolysates in anaerobic fermentation process. To further improve the utilization efficiency of organic substances by microorganisms in anaerobic fermentation process and break through the restrictive effect of hydrolysis on anaerobic digestion, anaerobic hydrolysis is divided into rapid hydrolysis and slow hydrolysis according to the different release speed of matrix carbon sources and the different degradation performance of carbon sources in anaerobic fermentation process. It expounds meanings, classifications, advantages, and disadvantages of the two hydrolysis methods respectively, indicating that the release rate and release mode of carbon sources inside and outside cells are the decisive factors affecting the anaerobic acid production and biodegradation performance. Finally, it points out that the combination of rapid hydrolysis and slow hydrolysis is the main research direction of VFA production by anaerobic digestion in the future.

Key words: anaerobic, hydrolysis, fermentation, rapid hydrolysis, slow hydrolysis, volatile fatty acid (VFA)

中图分类号:

X703

肖向哲, 陈思远, 滕俊, 董姗燕, 连军锋, 朱易春. 厌氧水解的新解读：快速水解和慢速水解[J]. 化工进展, 2021, 40(3): 1586-1593.

XIAO Xiangzhe, CHEN Siyuan, TENG Jun, DONG Shanyan, LIAN Junfeng, ZHU Yichun. A new interpretation of anaerobic hydrolysis: rapid hydrolysis and slow hydrolysis[J]. Chemical Industry and Engineering Progress, 2021, 40(3): 1586-1593.

图/表 3

参考文献 52

1	Wee Shen LEE, CHUA A S M, YEOH Hak Koon, et al. A review of the production and applications of waste-derived volatile fatty acids[J]. Chemical Engineering Journal, 2014, 235: 83-99.
2	LAGOA-COSTA B, KENNES C, VEIGA M C. Cheese whey fermentation into volatile fatty acids in an anaerobic sequencing batch reactor[J]. Bioresource Technology, 2020, 308: 123226.
3	GRACIA J, MOSQUERA J, MONTENEGRO C, et al. Maximization of the volatile fatty acids production from the fermentation of activated sludge[J]. Chemical Engineering Transactions, 2020, 79: 217-222.
4	何顺, 李忠棠, 谭松凡, 等. 污泥协同香蕉秸秆中温厌氧发酵中pH对产酸的影响[J]. 环境工程, 2019, 37(2): 153-157.
	HE Shun, LI Zhongtang, TAN Songfan, et al. Effect of pH on production of acid in medium temperature anaerobic fermentation of sewage sludge and banana straw[J]. Environmental Engineering, 2019, 37(2): 153-157.
5	姜钰, 周宸宇, 张军, 等. 物料比对木薯渣与污泥干式厌氧共发酵产沼气的影响[J]. 环境工程, 2017, 35(4): 115-119.
	JIANG Yu, ZHOU Chenyu, ZHANG Jun, et al. Effect of mixing ratio on biogas produced by dry anaerobic co-digestion of cassava dregs and sewage sludge[J], Environmental Engineering, 2017, 35(4): 115-119.
6	BRYANT M P. Microbial methane production — theoretical aspects[J]. Journal of Animal Science, 1979, 48(1): 193-201.
7	KIELY G, TAYFUR G, DOLAN C, et al. Physical and mathematical modelling of anaerobic digestion of organic wastes[J]. Water Research, 1997, 31(3): 534-540.
8	贾舒婷, 张栋, 赵建夫, 等. 不同预处理方法促进初沉/剩余污泥厌氧发酵产沼气研究进展[J]. 化工进展, 2013, 32(1): 193-198.
	JIA Shuting, ZHANG Dong, ZHAO Jianfu, et al. Research on different pre-treatment methods for improving anaerobic digestion of primary/excess sludge of biogas production[J]. Chemical Industry and Engineering Progress, 2013, 32(1): 193-198.
9	ZHANG Dong, LI Xiaoshuai, JIA Shuting, et al. A review: factors affecting excess sludge anaerobic digestion for volatile fatty acids production[J]. Water Science and Technology, 2015, 72(5): 678-688.
10	LIU Hongbo, WANG Yuanyuan, WANG Ling, et al. Stepwise hydrolysis to improve carbon releasing efficiency from sludge[J]. Water Research, 2017, 119: 225-233.
11	XIE Guojun, LIU Bingfeng, WANG Qilin, et al. Ultrasonic waste activated sludge disintegration for recovering multiple nutrients for biofuel production[J]. Water Research, 2016, 93: 56-64.
12	SALSABIL M R, LAURENT J, CASELLAS M, et al. Techno-economic evaluation of thermal treatment, ozonation and sonication for the reduction of wastewater biomass volume before aerobic or anaerobic digestion[J]. Journal of Hazardous Materials, 2010, 174(1/2/3): 323-333.
13	ZHU Yanfang, LIU Hongbo, LIU He, et al. Filtration characteristics of anaerobic fermented sewage sludge for fatty acids production[J]. Separation and Purification Technology, 2015, 142: 8-13.
14	MA Sijia, HU Haidong, WANG Jinfeng, et al. The characterization of dissolved organic matter in alkaline fermentation of sewage sludge with different pH for volatile fatty acids production[J]. Water Research, 2019, 164: 114924.
15	LI Dongzhe, ZHOU Yan, TAN Youming, et al. Alkali-solubilized organic matter from sludge and its degradability in the anaerobic process[J]. Bioresource Technology, 2016, 200: 579-586.
16	邢奕, 王志强, 洪晨, 等. 不同pH值下胞外聚合物对污泥脱水性能及束缚水含量的影响[J]. 工程科学学报, 2015, 37(10): 1387-1395.
	XING Yi, WANG Zhiqiang, HONG Chen, et al. Influence of extracellular polymeric substances on sludge dewaterability and bound water content at various pH values[J]. Chinese Journal of Engineering, 2015, 37(10): 1387-1395.
17	RUIZ-HERNANDO M, CABANILLAS E, LABANDA J, et al. Ultrasound, thermal and alkali treatments affect extracellular polymeric substances (EPSs) and improve waste activated sludge dewatering[J]. Process Biochemistry, 2015, 50(3): 438-446.
18	WATSON J D. Molecular Biology of the Gene[M]. 6th ed. California：Benjamin /Cummings Publishing Company, 2008.
19	晏波, 胡成生, 朱凡, 等. 磷酸铵镁沉淀法去除NH₃-N的影响因素及应用研究[J]. 环境化学, 2006, 24(6): 799-807.
	YAN Bo, HU Chengsheng, ZHU Fan, et al. Experiment study for ammonia-nitrogen removal from wastewater by magnesium ammonium phosphate precipitation[J]. Environmental Chemistry, 2006, 24(6): 799-807.
20	LI Yangyang, JIN Yiying, LI Jinhui, et al. Effects of thermal pretreatment on degradation kinetics of organics during kitchen waste anaerobic digestion[J]. Energy, 2017, 118: 377-386.
21	JIN Yiying, LI Yangyang, LI Jinhui. Influence of thermal pretreatment on physical and chemical properties of kitchen waste and the efficiency of anaerobic digestion[J]. Journal of Environmental Management, 2016, 180: 291-300.
22	MAGDALENA J A, GONZÁLEZ-FERNÁNDEZ C. Archaea inhibition: strategies for the enhancement of volatile fatty acids production from microalgae[J]. Waste Management, 2020, 102: 222-230.
23	LÜ Hang, LIU Daoguang, ZHANG Yanlin, et al. Effects of temperature variation on wastewater sludge electro-dewatering[J]. Journal of Cleaner Production, 2019, 214: 873-880.
24	YUAN Qiuyan, SPARLING R, OLESZKIEWICZ J A. VFA generation from waste activated sludge: effect of temperature and mixing[J]. Chemosphere, 2011, 82(4): 603-607.
25	Hyun Uk CHO, KIM Young Mo, CHOI Yunnam, et al. Influence of temperature on volatile fatty acid production and microbial community structure during anaerobic fermentation of microalgae[J]. Bioresource Technology, 2015, 191: 475-480.
26	LIN Richen, CHENG Jun, DING Lingkan, et al. Improved efficiency of anaerobic digestion through direct interspecies electron transfer at mesophilic and thermophilic temperature ranges[J]. Chemical Engineering Journal, 2018, 350: 681-691.
27	LIU Yali, LI Xin, KANG Xiaorong, et al. Effect of extracellular polymeric substances disintegration by ultrasonic pretreatment on waste activated sludge acidification[J]. International Biodeterioration & Biodegradation, 2015, 102: 131-136.
28	YAN Yuanyuan, FENG Leiyu, ZHANG Chaojie, et al. Ultrasonic enhancement of waste activated sludge hydrolysis and volatile fatty acids accumulation at pH 10.0[J]. Water Research, 2010, 44(11): 3329-3336.
29	PILLI S, YAN Song, TYAGI R D, et al. Anaerobic digestion of ultrasonicated sludge at different solids concentrations - computation of mass-energy balance and greenhouse gas emissions[J]. Journal of Environmental Management, 2016, 166: 374-386.
30	LU Dan, XIAO Keke, CHEN Yun, et al. Transformation of dissolved organic matters produced from alkaline-ultrasonic sludge pretreatment in anaerobic digestion: from macro to micro[J]. Water Research, 2018, 142: 138-146.
31	TIEHM A, NICKEL K, ZELLHORN M, et al. Ultrasonic waste activated sludge disintegration for improving anaerobic stabilization[J]. Water Research, 2001, 35(8): 2003-2009.
32	Sikyung CHO, SHIN Hangsik, KIM Donghoon. Waste activated sludge hydrolysis during ultrasonication: two-step disintegration[J]. Bioresource Technology, 2012, 121: 480-483.
33	ZHAO Jianwei, WANG Dongbo, LIU Yiwen, et al. Novel stepwise pH control strategy to improve short chain fatty acid production from sludge anaerobic fermentation[J]. Bioresource Technology, 2018, 249: 431-438.
34	WANG Xu, LI Yanbo, ZHANG Ya, et al. Stepwise pH control to promote synergy of chemical and biological processes for augmenting short-chain fatty acid production from anaerobic sludge fermentation[J]. Water Research, 2019, 155: 193-203.
35	AGABO-GARCÍA C, PÉREZ M, RODRÍGUEZ-MORGADO B, et al. Biomethane production improvement by enzymatic pre-treatments and enhancers of sewage sludge anaerobic digestion[J]. Fuel, 2019, 255: 115713.
36	KIM H J, CHOI Y G, KIM G D, et al. Effect of enzymatic pretreatment on solubilization and volatile fatty acid production in fermentation of food waste[J]. Water Science and Technology, 2005, 52(10/11): 51-59.
37	MLAIK N, KHOUFI S, HAMZA M, et al. Enzymatic pre-hydrolysis of organic fraction of municipal solid waste to enhance anaerobic digestion[J]. Biomass and Bioenergy, 2019, 127: 105286.
38	ZHAO Xiaoling, ZHENG Zehui, CAI Yafan, et al. Accelerated biomethane production from lignocellulosic biomass: pretreated by mixed enzymes secreted by Trichoderma viride and Aspergillus sp[J]. Bioresource Technology, 2020, 309: 123378.
39	BAHREINI G, NAZARI L, Dang HO, et al. Enzymatic pre-treatment for enhancement of primary sludge fermentation[J]. Bioresource Technology, 2020, 305: 123071.
40	CHEN Yongdong, YANG Haifeng, ZHAO Ziyan, et al. Comprehensively evaluating the digestive performance of sludge with different lignocellulosic components in mesophilic anaerobic digester[J]. Bioresource Technology, 2019, 293: 122042.
41	YU Shuyu, ZHANG Guangming, LI Jianzheng, et al. Effect of endogenous hydrolytic enzymes pretreatment on the anaerobic digestion of sludge[J]. Bioresource Technology, 2013, 146: 758-761.
42	WEIDE T, BAQUERO C D, SCHOMAKER M, et al. Effects of enzyme addition on biogas and methane yields in the batch anaerobic digestion of agricultural waste (silage, straw, and animal manure)[J]. Biomass and Bioenergy, 2020, 132: 105442.
43	GUAN Renpeng, YUAN Xingzhong, WU Zhibin, et al. Functionality of surfactants in waste-activated sludge treatment: a review[J]. Science of the Total Environment, 2017, 609: 1433-1442.
44	ZHOU Aijuan, LIU Wenzong, VARRONE C, et al. Evaluation of surfactants on waste activated sludge fermentation by pyrosequencing analysis[J]. Bioresource Technology, 2015, 192: 835-840.
45	PAN Xiaofang, SUN Jian, ZHANG Youchi, et al. Effect of sodium dodecyl benzene sulfonate (SDBS) on the performance of anaerobic co-digestion with sewage sludge, food waste, and green waste[J]. Chemical Engineering Communications, 2020, 207(2): 242-252.
46	ZHOU Aijuan, YANG Chunxue, GUO Zechong, et al. Volatile fatty acids accumulation and rhamnolipid generation in situ from waste activated sludge fermentation stimulated by external rhamnolipid addition[J]. Biochemical Engineering Journal, 2013, 77: 240-245.
47	HUANG Xiangfeng, SHEN Changming, LIU Jia, et al. Improved volatile fatty acid production during waste activated sludge anaerobic fermentation by different bio-surfactants[J]. Chemical Engineering Journal, 2015, 264: 280-290.
48	WU Qinglian, GUO Wanqian, ZHENG Heshan, et al. Enhancement of volatile fatty acid production by co-fermentation of food waste and excess sludge without pH control: the mechanism and microbial community analyses[J]. Bioresource Technology, 2016, 216: 653-660.
49	HUANG Xiaoding, ZHAO Jianwei, XU Qiuxiang, et al. Enhanced volatile fatty acids production from waste activated sludge anaerobic fermentation by adding tofu residue[J]. Bioresource Technology, 2019, 274: 430-438.
50	ABDULLAH R, UEDA K, SAKA S. Hydrothermal decomposition of various crystalline celluloses as treated by semi-flow hot-compressed water[J]. Journal of Wood Science, 2014, 60(4): 278-286.
51	GUO Zechong, ZHOU Aijuan, YANG Chunxue, et al. Enhanced short chain fatty acids production from waste activated sludge conditioning with typical agricultural residues: carbon source composition regulates community functions[J]. Biotechnology for Biofuels, 2015, 8(1): 192.
52	HUANG Jingang, ZHOU Rongbing, CHEN Jianjun, et al. Volatile fatty acids produced by co-fermentation of waste activated sludge and henna plant biomass[J]. Bioresource Technology, 2016, 211: 80-86.

能量密度 /kW·L^-1	PTA /U·mg^-1	AK /U·mg^-1	PTB /U·mg^-1	BK /U·mg^-1	OAATC /U·mg^-1	CoA转移酶 /U·mg^-1
0	0.13	1.92	0.0015	0.067	0.39	0.33
0.25	0.15	2.03	0.0017	0.074	0.42	0.38
0.5	0.17	2.50	0.0019	0.093	0.52	0.46
1.0	0.24	3.30	0.0026	0.116	0.70	0.60
2.0	0.22	2.87	0.0023	0.096	0.58	0.55
4.0	0.19	2.67	0.0021	0.089	0.56	0.50

能量密度 /kW·L^-1	PTA /U·mg^-1	AK /U·mg^-1	PTB /U·mg^-1	BK /U·mg^-1	OAATC /U·mg^-1	CoA转移酶 /U·mg^-1
0	0.13	1.92	0.0015	0.067	0.39	0.33
0.25	0.15	2.03	0.0017	0.074	0.42	0.38
0.5	0.17	2.50	0.0019	0.093	0.52	0.46
1.0	0.24	3.30	0.0026	0.116	0.70	0.60
2.0	0.22	2.87	0.0023	0.096	0.58	0.55
4.0	0.19	2.67	0.0021	0.089	0.56	0.50

[1]	陈翔宇, 卞春林, 肖本益. 温度分级厌氧消化工艺的研究进展[J]. 化工进展, 2023, 42(9): 4872-4881.
[2]	李由, 吴越, 钟禹, 林琦璇, 任俊莉. 酸性熔盐水合物预处理麦秆高效制备木糖及其对酶解效率的影响[J]. 化工进展, 2023, 42(9): 4974-4983.
[3]	王雪婷, 顾霞, 徐先宝, 赵磊, 薛罡, 李响. 水热预处理对餐厨垃圾厌氧发酵产戊酸的影响[J]. 化工进展, 2023, 42(9): 4994-5002.
[4]	史天茜, 石永辉, 武新颖, 张益豪, 秦哲, 赵春霞, 路达. Fe²⁺对厌氧氨氧化EGSB反应器运行性能的影响[J]. 化工进展, 2023, 42(9): 5003-5010.
[5]	奚永兰, 王成成, 叶小梅, 刘洋, 贾昭炎, 曹春晖, 韩挺, 张应鹏, 田雨. 微纳米气泡在厌氧消化中的应用研究进展[J]. 化工进展, 2023, 42(8): 4414-4423.
[6]	刘洋, 叶小梅, 苗晓, 王成成, 贾昭炎, 曹春晖, 奚永兰. 农村有机生活垃圾干发酵氨胁迫下中试工艺[J]. 化工进展, 2023, 42(7): 3847-3854.
[7]	秦凯, 杨仕林, 李俊, 储震宇, 薄翠梅. 基于卡尔曼滤波算法的葡萄糖酶生物传感器高精度检测方法[J]. 化工进展, 2023, 42(6): 3177-3186.
[8]	李白雪, 信欣, 朱羽蒙, 刘琴, 刘鑫. SASD-A体系构建及进水不同S/N对脱氮工艺的影响机制[J]. 化工进展, 2023, 42(6): 3261-3271.
[9]	庄捷, 薛锦辉, 赵斌成, 张文艺. 猪粪厌氧消化进程中重金属与腐殖质的有机结合机制[J]. 化工进展, 2023, 42(6): 3281-3291.
[10]	李华华, 李逸航, 金北辰, 李隆昕, 成少安. 厌氧氨氧化-生物电化学耦合废水处理系统的研究进展[J]. 化工进展, 2023, 42(5): 2678-2690.
[11]	黄越, 赵立欣, 姚宗路, 于佳动, 李再兴, 申瑞霞, 安柯萌, 黄亚丽. 木质纤维类废弃物定向生物转化乳酸、乙酸研究进展[J]. 化工进展, 2023, 42(5): 2691-2701.
[12]	朱紫旋, 陈俊江, 张星星, 李祥, 刘文如, 吴鹏. 基于短程反硝化厌氧氨氧化新型污水生物脱氮工艺的研究进展[J]. 化工进展, 2023, 42(4): 2091-2100.
[13]	王玉, 余广炜, 江汝清, 黎长江, 林佳佳, 邢贞娇. 餐厨厌氧沼渣生物炭吸附盐酸环丙沙星[J]. 化工进展, 2023, 42(4): 2160-2170.
[14]	范思涵, 于国熙, 来超超, 何欢, 黄斌, 潘学军. 非生物改性对厌氧微生物产物光化学活性影响[J]. 化工进展, 2023, 42(4): 2180-2189.
[15]	孟晓山, 汤子健, 陈琳, 呼和涛力, 周政忠. 厌氧消化系统酸化预警及调控技术研究进展[J]. 化工进展, 2023, 42(3): 1595-1605.