低强度超声波对短程硝化污泥的影响

doi:10.16085/j.issn.1000-6613.2019-1304

摘要/Abstract

摘要：

以周期性超声辐照的污泥为研究对象，在序批式反应器（SBR）中开展超声波对短程硝化效果的研究，并进一步研究超声波对酶活性、脱氮速率、胞外聚合物的影响。结果表明，0.1~0.7W/mL的超声波均可促进短程硝化，最高亚硝酸盐积累率（NAR）达98.21%。超声波通过强化氨单加氧酶（AMO）活性，抑制亚硝酸盐氧化酶（NXR）活性促进短程硝化，AMO活性最高同比增长63.84%，NXR活性最高下降89.03%。比脱氮速率、反应器脱氮速率并不完全与酶活性变化趋势一致，AOB关键酶活性仅与比氨氧化速率（SAOR）变化一致，而NOB关键酶活性与反应器亚硝酸盐氧化速率（NOR）一致，超声波引起的污泥减少对AOB菌群数量的负面影响大于NOB。周期性超声后，污泥EPS的总量随声能密度先增加后减少，超声波对LB-EPS的剥离大于TB-EPS，对多糖的剥离大于蛋白质，较高的声能密度会造成蛋白质的积累。

关键词: 低声能密度, 短程硝化, 酶活性, 胞外聚合物, 脱氮速率

Abstract:

Taking activated sludge treated by periodic ultrasonic irradiation as the research object, the effect of ultrasonic on partial nitrification was studied in the sequencing batch reactor(SBR), and the effect on enzyme activity, nitrogen removal rate and extracellular polymer substance(EPS) was researched further. The results showed that partial nitrification could be promoted by ultrasonic which ranged in power density from 0.1 to 0.7W/mL, and the highest nitrite accumulation rate (NAR) reached 98.21%. Ultrasonic promoted partial nitrification by enhancing ammonia monohydrogenase (AMO) and suppressing nitrite oxidoreductase (NXR). The highest AMO activity increased by 63.84% and the NXR activity decreased by 89.03%. The specific nitrogen oxidation rate and reactor nitrogen oxidation rate were not completely consistent with the variation trend of enzyme activity. The key enzyme activity of AOB was only consistent with the variation trend of specific ammonia nitrogen oxidation rate (SAOR). The key enzyme activity of NOB and the reactor nitrite oxidation rate (NOR) were consistent, and the sludge reduction caused by ultrasound had more negative effect on the number of AOB bacteria than it had on NOB. After having periodic ultrasonication, the total amount of EPS increased first and then decreased with the power density. Ultrasonic detachment of LB-EPS was greater than it of TB-EPS, and the peeling of polysaccharide was greater than it of protein. Higher power density would cause protein accumulation.

Key words: low acoustic power density, partial nitrification, enzyme activity, extracellular polymer substance, nitrogen removal rate

中图分类号:

X703.1

任黎晔,朱易春,张光明,连军锋,章璋,李鑫,黄书昌,田帅,袁佳彬. 低强度超声波对短程硝化污泥的影响[J]. 化工进展, 2020, 39(4): 1591-1596.

Liye REN,Yichun ZHU,Guangming ZHANG,Junfeng LIAN,Zhang ZHANG,Xin LI,Shuchang HUANG,Shuai TIAN,Jiabin YUAN. Effect of low-intensity ultrasonic on partial nitrification sludge[J]. Chemical Industry and Engineering Progress, 2020, 39(4): 1591-1596.

图/表 5

参考文献 23

1	黄书昌, 朱易春, 连军锋. 不同曝气量下超声波对污泥沉降性能的影响[J]. 水处理技术, 2019, 45(2): 116-119.
	HUANG S C, ZHU Y C, LIAN J F. Effect of ultrasonic irradiation on sludge sedimentation performance under different aeration rate[J]. Technology of Water Treatment, 2019, 45(2): 116-119.
2	GUO J H, PENG Y J, YANG X, et al. Combination process of limited filamentous bulking and nitrogen removal via nitrite for enhancing nitrogen removal and reducing aeration requirements[J]. Chemosphere, 2013, 91(1): 68-75.
3	GABARRÓ J, GANIGUÉ G, GICH F, et al. Effect of temperature on AOB activity of a partial nitritation SBR treating landfill leachate with extremely high nitrogen concentration[J]. Bioresource Technology, 2012, 126: 283-289.
4	PENG Y Z, ZHU G B. Biological nitrogen removal with nitrification and denitrification via nitrite pathway[J]. Applied Microbiology & Biotechnology, 2006, 73(1): 15-26.
5	ANTHONISEN A C, LOEHR R C, PRAKASAM T B S, et al. Inhibition of nitrification by ammonia and nitrous acid[J]. Water Environment Federation, 1976, 48(5): 835-852.
6	唐欣, 乔森, 周集体. 低强度超声对短程硝化污泥活性的影响[J]. 安全与环境学报, 2017, 17(1): 273-278.
	TANG X, QIAN S, ZHOU Jiti. Influence of the lower intensity ultrasound on the activity of the partial nitrification sludge[J]. Journal of Safety and Environment. 2017, 17(1): 273-278.
7	GE S J, WANG S Y, YANG X, et al. Detection of nitrifiers and evaluation of partial nitrification for wastewater treatment: a review[J]. Chemosphere, 2015, 140: 85-98.
8	GAO S P, LEWIS G D, ASHOKKUMAR M, et al. Inactivation of microorganisms by low-frequency high-power ultrasound: 1. effect of growth phase and capsule properties of the bacteria[J]. Ultrasonics Sonochemistry, 2014, 21(1): 446-453.
9	朱易春, 王佳琪, 章璋, 等. 超声波参数对短程硝化的影响[J]. 中国给水排水, 2018, 34(5): 26-31.
	ZHU Y C, WANG J Q, ZHANG Z, et al. Effect of ultrasound parameters on partial nitrification[J]. China Water & Wastewater. 2018, 34(5): 26-31.
10	PILLI S, BHUNIA P, YAN S, et al. Ultrasonic pretreatment of sludge: a review[J]. Ultrasonics Sonochemistry, 2011, 18(1): 1-18.
11	ZHANG R N, JIN R F, LIU G F, et al. Study on nitrogen removal performance of sequencing batch reactor enhanced by low intensity ultrasound[J]. Bioresource Technology, 2011, 102(10): 5717-5721.
12	王佳琪. 低强度超声波促进短程硝化及其稳定性研究[D]. 赣州: 江西理工大学, 2018. WANG J Q. Enhancement and maintaince of partial nitrification by low-density ultrasound[D]. Ganhzou: Jiangxi University of Science and Technology, 2018.
13	GE S J, PENG Y Z, QIU S, et al. Complete nitrogen removal from municipal wastewater via partial nitrification by appropriately alternating anoxic/aerobic conditions in a continuous plug-flow step feed process[J]. Water Research, 2014, 55: 95-105.
14	BOURNAZOU M N C, HOOSHIAR K, ARELLANO-GARCIA H, et al. Model based optimization of the intermittent aeration profile for SBRs under partial nitrification[J]. Water Research, 2013, 47(10): 3399-3410.
15	国家环境保护总局. 水和废水监测分析方法[M]. 4版. 北京: 中国环境科学出版社, 2006.State Environmental Protection Administration. Standard methods for water and wastewater analysis[M]. 4th ed. Beijing: China Environmental Science Press, 2006.
16	JULOETTE L Y, HYMAN M R, ARP D J. Inhibition of ammonia oxidation in nitrosomonas europaea by sulfur compounds: thioethers are oxidized to sulfoxides by ammonia monooxygenase[J]. Applied and Environmental Microbiology, 1993, 59(11): 3718-3727.
17	OTTE S, SCHALK J, KUENEN J G, et al. Hydroxylamine oxidation and subsequent nitrous oxide production by the heterotrophic ammonia oxidizer alcaligenes faecalis[J]. Applied Microbiology and Biotechnology, 1999, 51(2): 255-261.
18	MA B, WANG S, LI Z W, et al. Magnetic Fe₃O₄ nanoparticles induced effects on performance and microbial community of activated sludge from a sequencing batch reactor under long-term exposure[J]. Bioresource Technology, 2017, 225: 377-385.
19	XIAO K K, CHEN Y, JIANG X, et al. Characterization of key organic compounds affecting sludge dewaterability during ultrasonication and acidification treatments[J]. Water Research, 2016, 105: 470-478.
20	LI J B, YE W, WEI D, et al. System performance and microbial community succession in a partial nitrification biofilm reactor in response to salinity stress[J]. Bioresource Technology, 2018, 270: 512-518.
21	林秋健. 厌氧氨氧化反应器效能及其指示酶研究[D]. 杭州: 浙江大学, 2019. LIN Q J. Performance and indicator enzyme of ANAMMOX reactor[D]. Hangzhou: Zhejiang University, 2019.
22	王梦杰, 员建, 马华继, 等. 低强度超声波对膨胀活性污泥沉降性能及污泥减量的影响[J]. 化工进展, 2017, 36(3): 1134-1139.
	WANG M J, YUAN J, MA H J, et al. Effects of low intensity ultrasonic treatment on settleability of bulking sludge and sludge reduction[J]. Chemical Industry and Engineering Progress, 2017, 36(3): 1134-1139.
23	WANG F, MA A Z, GUO C, et al. Ultrasound-intensified laccase production from trametes versicolor[J]. Ultrasonics Sonochemistry, 2013, 20(1): 118-124.

声能密度/W·mL^-1	氨氮去除率/%	出水亚硝态氮/mg·L^-1	NAR	MLSS/mg·L^-1	SVI
0	85.61±1.64	17.73±2.53	0.91±0.08	2570±137	112.84
0.1	88.08±6.60	24.00±3.94	0.96±0.10	1320±166	303.03
0.3	96.74±7.08	21.81±3.74	0.97±0.07	1400±291	128.57
0.5	94.10±7.83	21.52±4.13	0.89±0.16	1310±318	76.34
0.7	96.34±5.24	24.80±3.90	0.98±0.07	1250±119	80.00

声能密度/W·mL^-1	氨氮去除率/%	出水亚硝态氮/mg·L^-1	NAR	MLSS/mg·L^-1	SVI
0	85.61±1.64	17.73±2.53	0.91±0.08	2570±137	112.84
0.1	88.08±6.60	24.00±3.94	0.96±0.10	1320±166	303.03
0.3	96.74±7.08	21.81±3.74	0.97±0.07	1400±291	128.57
0.5	94.10±7.83	21.52±4.13	0.89±0.16	1310±318	76.34
0.7	96.34±5.24	24.80±3.90	0.98±0.07	1250±119	80.00

[1]	曾天续, 张永显, 严渊, 刘宏, 马娇, 党鸿钟, 吴新波, 李维维, 陈永志. 羟胺对硝化菌活性及其动力学参数的影响[J]. 化工进展, 2023, 42(6): 3272-3280.
[2]	李芸, 崔楠, 熊星星, 黄志远, 王东亮, 许丹, 李军, 李泽兵. 稀土Er(Ⅲ)对短程硝化性能的影响及其抑制动力学特性[J]. 化工进展, 2023, 42(3): 1659-1668.
[3]	吴新波, 党鸿钟, 马娇, 严渊, 曾天续, 李维维, 张国珍, 陈永志. A²/O-BAF工艺短程硝化模式下反硝化除磷效能[J]. 化工进展, 2023, 42(2): 1089-1097.
[4]	胡璇, 陈滢. 聚酯纤维微塑料胁迫下活性污泥系统性能及微生物群落的变化情况[J]. 化工进展, 2023, 42(2): 1051-1060.
[5]	刘亚利, 张宏伟, 康晓荣. 微塑料对污泥厌氧消化的影响和机理[J]. 化工进展, 2022, 41(9): 5037-5046.
[6]	李冬, 高飞雁, 解一博, 李柱, 张杰. 有机负荷波动频次对好氧颗粒污泥的影响[J]. 化工进展, 2022, 41(12): 6680-6688.
[7]	李冬, 高鑫, 杨杰, 陈昊, 张杰. 长/短HRT联合低/高曝气实现短程硝化反硝化脱氮除磷[J]. 化工进展, 2022, 41(11): 6111-6119.
[8]	刘树根, 孔馨, 吕学斌, 刘庆岭, 陈冠益. 有机固体废物好氧处理抑制作用研究进展[J]. 化工进展, 2021, 40(12): 6818-6828.
[9]	李鑫, 朱易春, 连军锋, 秦欣欣, 田帅. 低强度超声波对ABR处理低浓度污水效果及污泥特性的影响[J]. 化工进展, 2021, 40(11): 6401-6408.
[10]	张兰河, 袁镇涛, 赵浩杰, 赵君田, 祝艺宁, 陈子成, 贾艳萍, 田书磊. 外加电流对AO工艺缺氧区脱氮效率与污泥絮凝的影响[J]. 化工进展, 2021, 40(11): 6369-6377.
[11]	陈翠忠, 李俊峰, 蓝明菊, 额热艾汗, 谢可飞, 徐威龙, 刘雅茹, 孙洪伟. 碳氮比对SBR系统硝化过程及EPS三维荧光光谱特性的影响[J]. 化工进展, 2020, 39(12): 5275-5282.
[12]	葛大令, 周鑫, RONELRudy Koubode, 阴泽阳, 张伟. 微氧EGSBBR产甲烷系统快速启动与微生物群落特性[J]. 化工进展, 2020, 39(12): 5203-5210.
[13]	黄书昌,朱易春,章璋,李鑫,田帅,连军锋,刘祖文. 声能密度对短程硝化启动及氨氮去除动力学的影响[J]. 化工进展, 2019, 38(9): 4335-4341.
[14]	孙和临,邵琼丽,李建昌,郑金柱,许坤德,龙宪钢. 温度对MEC阳极膜形成及胞外聚合物的影响[J]. 化工进展, 2019, 38(08): 3809-3815.
[15]	王子文, 曹蓉, 杨艳坤, 朱引, 王硕, 李激. 聚季铵盐调理污泥深度脱水过程与中试效能[J]. 化工进展, 2019, 38(07): 3458-3464.