零价铁耦合厌氧氨氧化系统高效同步脱氮除磷

doi:10.16085/j.issn.1000-6613.2024-1536

化工进展 ›› 2025, Vol. 44 ›› Issue (6): 3132-3143.DOI: 10.16085/j.issn.1000-6613.2024-1536

• 专栏：化工生态环境前沿交叉新技术 • 上一篇

零价铁耦合厌氧氨氧化系统高效同步脱氮除磷

雷雪艳¹(), 朱易春¹^,², 张超¹^,²(), 郝宛婷¹, 陈仔龙¹, 宋贤威¹, 黄书昌¹^,², 董姗燕¹^,²

^1.江西理工大学土木与测绘工程学院，江西赣州 341000
^2.河流源头水生态保护江西省重点实验室，江西赣州 341000

收稿日期:2024-09-20 修回日期:2024-11-06 出版日期:2025-06-25 发布日期:2025-07-08
通讯作者: 张超
作者简介:雷雪艳（2000—），女，硕士研究生，研究方向为污水生物脱氮。E-mail：1811059875@qq.com。
基金资助:
国家自然科学基金(52260004);江西省自然科学基金(20232BAB204098);江西省教育厅科技研究项目(GJJ210874);江西理工大学高层次人才科研启动项目(205200100642);江西理工大学研究生创新专项资金(XY2023-S116);江西理工大学研究生创新专项资金(XY2024-S152440);大学生创新训练计划(DC202310407063)

Efficient synchronous nitrogen and phosphorus removal in zero valent iron coupled anaerobic ammonia oxidation system

LEI Xueyan¹(), ZHU Yichun¹^,², ZHANG Chao¹^,²(), HAO Wanting¹, CHEN Zilong¹, SONG Xianwei¹, HUANG Shuchang¹^,², DONG Shanyan¹^,²

^1.School of Civil Engineering and Surveying & Mapping Engineering, Jiangxi University of Science and Technology, Ganzhou 341000, Jiangxi, China
^2.Jiangxi Provincial Key Laboratory of Water Ecological Conservation at Headwater Regions, Ganzhou 341000, Jiangxi, China

Received:2024-09-20 Revised:2024-11-06 Online:2025-06-25 Published:2025-07-08
Contact: ZHANG Chao

摘要/Abstract

摘要：

为实现生活污水高效同步脱氮除磷，构建了零价铁耦合厌氧氨氧化系统，探究了零价铁对厌氧氨氧化短期脱氮除磷效能、颗粒污泥特性和关键酶活性的影响，并分析了系统高效同步脱氮除磷机理。结果表明，当零价铁投加量为1g，温度为35℃，反应12h后，氨氮、总氮和总磷浓度分别为0.82mg/L、5.36mg/L和0.66mg/L，总氮和总磷去除率分别比对照组高出14.8%和70.3%。此时颗粒污泥表面覆盖了少量的零价铁及其氧化物和沉淀物，颜色变黑，质地变硬，结构强度增大，铁元素占比达到35.4%。颗粒污泥中松散结合型EPS减少，紧密结合型EPS增加，有利于提高颗粒污泥的沉降性能和抵御外界不利因素的影响。颗粒污泥表面的羟基和羰基等含氧官能团增加，促进了厌氧氨氧化系统中的新陈代谢活动。厌氧氨氧化系统中硝酸还原酶、亚硝酸还原酶和联氨合成酶活性增加，从而提高了系统的脱氮效能。该研究可为生活污水中氮磷的高效低碳同步去除提供理论基础。

关键词: 零价铁, 厌氧氨氧化, 生活污水, 脱氮, 除磷

Abstract:

In order to realize efficient synchronous nitrogen and phosphorus removal from the domestic wastewater, a zero-valent iron coupled anaerobic ammonium oxidation (anammox) system was constructed, and the short-term effects of zero-valent iron on the nitrogen and phosphorus removal efficacy of anammox, the characteristics of granular sludge, and the key enzyme activities were investigated, and the mechanism of the system's efficient synchronous nitrogen and phosphorus removal was analyzed. The results showed that when the dosage of zero-valent iron was 1.0g, the temperature was 35℃, and the reaction time was 12h, the concentrations of ammonia nitrogen, total nitrogen and total phosphorus were 0.82mg/L, 5.36mg/L and 0.66mg/L, respectively, and the removal efficiencies of total nitrogen and total phosphorus were higher than those of the control group by 14.8% and 70.3%, respectively. At this time, the surface of granular sludge was covered with a small amount of zero-valent iron and its oxides and precipitates. The color became darker, the texture became harder, the structural strength increased, and the proportion of iron reached 35.4%.The decrease of loosely bound EPS and the increase of tightly bound EPS in the granular sludge were favorable to improve the settling performance of the granular sludge and resist the influence of external unfavorable factors. The increase of oxygen-containing functional groups, such as hydroxyl and carbonyl groups, on the surface of granular sludge promoted the metabolic activities in the anammox system. The activities of nitrate reductase, nitrite reductase and hydrazine synthase were increased in the anammox system, which improved the nitrogen removal efficiency of the system. This study can provide a theoretical basis for the efficient and low-carbon simultaneous removal of nitrogen and phosphorus from domestic wastewater.

Key words: zero-valent iron, anammox, domestic sewage, nitrogen removal, phosphorus removal

中图分类号:

X703.1

雷雪艳, 朱易春, 张超, 郝宛婷, 陈仔龙, 宋贤威, 黄书昌, 董姗燕. 零价铁耦合厌氧氨氧化系统高效同步脱氮除磷[J]. 化工进展, 2025, 44(6): 3132-3143.

LEI Xueyan, ZHU Yichun, ZHANG Chao, HAO Wanting, CHEN Zilong, SONG Xianwei, HUANG Shuchang, DONG Shanyan. Efficient synchronous nitrogen and phosphorus removal in zero valent iron coupled anaerobic ammonia oxidation system[J]. Chemical Industry and Engineering Progress, 2025, 44(6): 3132-3143.

图/表 11

参考文献 33

[1]	GAO Xinjie, ZHANG Liang, LIU Jinjin, et al. First application of the novel anaerobic/aerobic/anoxic (AOA) process for advanced nutrient removal in a wastewater treatment plant[J]. Water Research, 2024, 252: 121234.
[2]	ZHOU Ming, WANG Yantang, ZHU Lisha, et al. Sulfur-pyrite-limestone biological filter for simultaneous nitrogen and phosphorus removal from wastewater treatment plant effluent: Interaction mechanisms of autotrophic and heterotrophic denitrification[J]. Journal of Water Process Engineering, 2023, 56: 104301.
[3]	雷雪艳, 晏雯雯, 张超, 等. 湿干比对不同人工快速渗滤系统处理厌氧折流板反应器出水的影响[J]. 江西冶金, 2023, 43(3): 259-264.
	LEI Xueyan, YAN Wenwen, ZHANG Chao, et al. Effect of wet/dry ratio on anaerobic baffled reactor effluent treatment with different constructed rapid infiltration systems[J]. Jiangxi Metallurgy, 2023, 43(3): 259-264.
[4]	ZUO Fumin, YUE Wenhui, GUI Shuanglin, et al. Resilience of anammox application from sidestream to mainstream: A combined system coupling denitrification, partial nitritation and partial denitrification with anammox[J]. Bioresource Technology, 2023, 374: 128783.
[5]	ZHAO Qi, LI Jianwei, DENG Liyan, et al. From hybrid process to pure biofilm anammox process: Suspended sludge biomass management contributing to high-level anammox enrichment in biofilms[J]. Water Research, 2023, 236: 119959.
[6]	YUAN Quan, JIA Zhen, ROOTS Paul, et al. A strategy for fast anammox biofilm formation under mainstream conditions[J]. Chemosphere, 2023, 318: 137955.
[7]	SHAW Dario R, Muhammad ALI, KATURI Krishna P, et al. Extracellular electron transfer-dependent anaerobic oxidation of ammonium by anammox bacteria[J]. Nature Communications, 2020, 11(1): 2058.
[8]	简志强, 周高婷, 龚斌, 等. 微米零价铁去除磷酸盐效果与机理研究[J]. 环境工程技术学报, 2021, 11(5): 927-934.
	JIAN Zhiqiang, ZHOU Gaoting, GONG Bin, et al. Study on the efficacy of micron zero-valent iron on phosphate removal and its mechanism[J]. Journal of Environmental Engineering Technology, 2021, 11(5): 927-934.
[9]	HE Xuejie, FAN Xing, CAO Meng, et al. Iron-electrolysis assisted anammox/denitrification system for intensified nitrate removal and phosphorus recovery in low-strength wastewater treatment[J]. Water Research, 2024, 253: 121312.
[10]	FENG Li, LI Jin, MA Haoran, et al. Effect of Fe(Ⅱ) on simultaneous marine anammox and feammox treating nitrogen-laden saline wastewater under low temperature: Enhanced performance and kinetics[J]. Desalination, 2020, 478: 114287.
[11]	YANG Biao, SUN Jiawei, WANG Zhongyu, et al. Sustainable biochar application in anammox process: Unveiling novel pathways for enhanced nitrogen removal and efficient start-up at low temperature[J]. Bioresource Technology, 2024, 402: 130773.
[12]	GUO Kehuan, LI Wenxuan, WANG Yae, et al. Low strength wastewater anammox start-up and stable operation by inoculating sponge-iron sludge: Cooperation of biological iron and iron bacteria[J]. Journal of Environmental Management, 2022, 322: 116086.
[13]	ZHANG Miao, LI Biao, WANG Dongbin, et al. New insights into iron enhancing anammox performance: Effects, mechanisms and potential applications[J]. Journal of Water Process Engineering, 2024, 61: 105363.
[14]	周健, 完颜德卿, 黄勇, 等. ANAMMOX菌利用零价铁还原硝酸盐脱氮研究[J]. 环境科学, 2016, 37(11): 4302-4308.
	ZHOU Jian, WANYAN Deqing, HUANG Yong, et al. Biotransformation of nitrate to nitrogen gas driven by ANAMMOX microbes via zero-valent iron under anaerobic conditions[J]. Environmental Science, 2016, 37(11): 4302-4308.
[15]	雷欣, 闫荣, 慕玉洁, 等. 铁元素对厌氧氨氧化菌脱氮效能的影响[J]. 化工进展, 2021, 40(5): 2730-2738.
	LEI Xin, YAN Rong, MU Yujie, et al. Effect of iron on nitrogen removal efficiency of anaerobic ammonium oxidation bacteria[J]. Chemical Industry and Engineering Progress, 2021, 40(5): 2730-2738.
[16]	CHEN Yao, JIA Fangxu, LIU Yingjie, et al. The effects of Fe(Ⅲ) and Fe(Ⅱ) on anammox process and the Fe-N metabolism[J]. Chemosphere, 2021, 285: 131322.
[17]	JIANG Yushi, CHEN Yuqi, WANG Ying, et al. Novel insight into the inhibitory effects and mechanisms of Fe(Ⅱ)-mediated multi-metabolism in anaerobic ammonium oxidation (anammox)[J]. Water Research, 2023, 242: 120291.
[18]	周文永, 王京扬, 张艳萍. 氮负荷波动条件下Fe³⁺对厌氧氨氧化系统的影响[J]. 环境科学与技术, 2022, 45(5): 7-14.
	ZHOU Wenyong, WANG Jingyang, ZHANG Yanping. Effect of Fe³⁺ on anammox system under fluctuating nitrogen load[J]. Environmental Science & Technology, 2022, 45(5): 7-14.
[19]	史天茜, 石永辉, 武新颖, 等. Fe²⁺对厌氧氨氧化EGSB反应器运行性能的影响[J]. 化工进展, 2023, 42(9): 5003-5010.
	SHI Tianxi, SHI Yonghui, WU Xinying, et al. Effects of Fe²⁺ on the performance of Anammox EGSB reactor[J]. Chemical Industry and Engineering Progress, 2023, 42(9): 5003-5010.
[20]	CHEN Yongxing, ZHANG Chuchu, CHEN Zhenguo, et al. Fe(Ⅱ)-driven spatiotemporal assembly of heterotrophic and anammox bacteria enhances simultaneous nitrogen and phosphorus removal for low-strength municipal wastewater[J]. Bioresource Technology, 2024, 401: 130713.
[21]	FENG Kun, LOU Yu, LI Yitian, et al. Conductive carrier promotes synchronous biofilm formation and granulation of anammox bacteria[J]. Journal of Hazardous Materials, 2023, 447: 130754.
[22]	LIU Xuerui, WANG Lixia, ZHENG Jinli, et al. Multi-omics analysis reveals the collaboration and metabolisms of the anammox consortia driven by soluble/non-soluble Fe(Ⅲ) as the sole iron element[J]. Journal of Environmental Management, 2024, 352: 120124.
[23]	FENG Cuijie, LOTTI Tommaso, CANZIANI Roberto, et al. Extracellular biopolymers recovered as raw biomaterials from waste granular sludge and potential applications: A critical review[J]. Science of the Total Environment, 2021, 753: 142051.
[24]	YAN Yuan, WANG Yayi, WANG Weigang, et al. Comparison of short-term dosing ferrous ion and nanoscale zero-valent iron for rapid recovery of anammox activity from dissolved oxygen inhibition[J]. Water Research, 2019, 153: 284-294.
[25]	GAO Ran, JIN Hao, HAN Mengru, et al. Iron-mediated DAMO-anammox process: Revealing the mechanism of electron transfer[J]. Journal of Environmental Management, 2024, 356: 120750.
[26]	周正, 刘凯, 王凡, 等. 磷酸盐对厌氧氨氧化活性污泥脱氮效能的影响[J]. 环境科学, 2017, 38(6): 2453-2460.
	ZHOU Zheng, LIU Kai, WANG Fan, et al. Influence of phosphate on nitrogen removal efficiency of ANAMMOX sludge[J]. Environmental Science, 2017, 38(6): 2453-2460.
[27]	ZHANG Xiaojing, ZHOU Yue, ZHAO Siyu, et al. Effect of Fe (Ⅱ) in low-nitrogen sewage on the reactor performance and microbial community of an ANAMMOX biofilter[J]. Chemosphere, 2018, 200: 412-418.
[28]	WANG Xiqing, Tao LYU, DONG Renjie, et al. Dynamic evolution of humic acids during anaerobic digestion: Exploring an effective auxiliary agent for heavy metal remediation[J]. Bioresource Technology, 2021, 320: 124331.
[29]	GUO Beibei, CHEN Yuanhao, Lu LYU, et al. Transformation of the zero valent iron dosage effect on anammox after long-term culture: From inhibition to promotion[J]. Process Biochemistry, 2019, 78: 132-139.
[30]	YAO Zongbao, WANG Fang, WANG Chunliu, et al. Anaerobic ammonium oxidation coupled to ferric iron reduction in the sediment of a eutrophic lake[J]. Environmental Science and Pollution Research International, 2019, 26(15): 15084-15094.
[31]	杨杰源, 朱易春, 赖雅芬, 等. 低强度超声波对高负荷厌氧氨氧化EGSB反应器运行性能的影响[J]. 化工进展, 2024, 43(2): 1098-1108.
	YANG Jieyuan, ZHU Yichun, LAI Yafen, et al. Effect of low intensity ultrasound on operation performance of high load Anammox-EGSB reactor[J]. Chemical Industry and Engineering Progress, 2024, 43(2): 1098-1108.
[32]	PENG Mengwen, QI Jing, YAN Peng, et al. Insight into the structure and metabolic function of iron-rich nanoparticles in anammox bacteria[J]. Science of the Total Environment, 2022, 806: 150879.
[33]	MAALCKE Wouter J, REIMANN Joachim, DE VRIES Simon, et al. Characterization of anammox hydrazine dehydrogenase, a key N₂-producing enzyme in the global nitrogen cycle[J]. Journal of Biological Chemistry, 2016, 291(33): 17077-17092.

组别	峰中心位置及荧光强度
组别	峰A	峰B	峰C
0-LB（EPS）	265nm/479.2nm（243.548）	420nm/481nm（680.446）	285nm/327nm（1563.432）
0.5g-LB（EPS）	265nm/479nm（110.41）	410nm/478.2nm（308.793）	285nm/333.8nm（752.269）
1g-LB（EPS）	265nm/476.8nm（83.829）	410nm/479.8nm（229.394）	285nm/334.2nm（739.401）
2g-LB（EPS）	280nm/431nm（62.354）	405nm/469.4nm（145.001）	285nm/331.4nm（549.932）
4g-LB（EPS）	285nm/477nm（54.834）	410nm/474nm（159.905）	285nm/331.4nm（544.004）
8g-LB（EPS）	—	—	280nm/309.4nm（418.391）
0-TB（EPS）	290nm/345.6nm（1808.071）	425nm/475.8nm（2300.446）	—
0.5g-TB（EPS）	290nm/353.6nm（1069.614）	425nm/474.2nm（2233.245）	—
1g-TB（EPS）	290nm/354.4nm（1463.342）	425nm/475.2nm（2080.072）	—
2g-TB（EPS）	290nm/353.2nm（911.849）	425nm/474.6nm（1782.129）	—
4g-TB（EPS）	290nm/350.8nm（1150.633）	425nm/473.8nm（1669.835）	—
8g-TB（EPS）	290nm/355.4nm（1034.133）	425nm/477.2nm（1662.114）	—

组别	峰中心位置及荧光强度
组别	峰A	峰B	峰C
0-LB（EPS）	265nm/479.2nm（243.548）	420nm/481nm（680.446）	285nm/327nm（1563.432）
0.5g-LB（EPS）	265nm/479nm（110.41）	410nm/478.2nm（308.793）	285nm/333.8nm（752.269）
1g-LB（EPS）	265nm/476.8nm（83.829）	410nm/479.8nm（229.394）	285nm/334.2nm（739.401）
2g-LB（EPS）	280nm/431nm（62.354）	405nm/469.4nm（145.001）	285nm/331.4nm（549.932）
4g-LB（EPS）	285nm/477nm（54.834）	410nm/474nm（159.905）	285nm/331.4nm（544.004）
8g-LB（EPS）	—	—	280nm/309.4nm（418.391）
0-TB（EPS）	290nm/345.6nm（1808.071）	425nm/475.8nm（2300.446）	—
0.5g-TB（EPS）	290nm/353.6nm（1069.614）	425nm/474.2nm（2233.245）	—
1g-TB（EPS）	290nm/354.4nm（1463.342）	425nm/475.2nm（2080.072）	—
2g-TB（EPS）	290nm/353.2nm（911.849）	425nm/474.6nm（1782.129）	—
4g-TB（EPS）	290nm/350.8nm（1150.633）	425nm/473.8nm（1669.835）	—
8g-TB（EPS）	290nm/355.4nm（1034.133）	425nm/477.2nm（1662.114）	—

零价铁耦合厌氧氨氧化系统高效同步脱氮除磷

Efficient synchronous nitrogen and phosphorus removal in zero valent iron coupled anaerobic ammonia oxidation system

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

图/表 11

参考文献 33

相关文章 15

编辑推荐

Metrics

本文评价

[1]	田晴, 刘青盟, 李方, 杨波, 张思远, 关自良. 细菌的耐盐调控及其在高盐生物脱氮除磷工艺中的应用[J]. 化工进展, 2025, 44(1): 465-476.
[2]	赵星程, 贾方旭, 刘晨雨, 韩宝红, 梅宁, 姚宏. 实际规模PN/A工艺载体挂膜性能与微生物群落[J]. 化工进展, 2024, 43(9): 5242-5249.
[3]	黄鸿, 欧阳浩民, 杨依静, 李昌霖, 陈烁娜. 硫化零价铁-微生物复合吸附剂对磷酸三(2-氯乙基)酯的吸附-降解机制[J]. 化工进展, 2024, 43(8): 4704-4713.
[4]	海岩, 周鑫, 李艳. 单级固定床生物膜反应器主流厌氧氨氧化快速启动性能[J]. 化工进展, 2024, 43(4): 2201-2209.
[5]	葛四杰, 杨大鑫, 吕君, 王振, 张传义, 张文华. 复合硫基质驱动自养反硝化脱氮除磷效能与微生物群落结构[J]. 化工进展, 2024, 43(4): 2135-2143.
[6]	赵瑞强, 周鑫, 牛冰心. 废水处理硝酸盐异化还原与厌氧氨氧化/反硝化耦合工艺构建[J]. 化工进展, 2024, 43(3): 1593-1605.
[7]	彭程, 徐漪琳, 石钰婧, 张玟, 李宇涛, 王皓冉, 张卫, 占绣萍. 生物炭改性及其对除草剂污染水体和土壤修复的研究进展[J]. 化工进展, 2024, 43(2): 1069-1081.
[8]	杨杰源, 朱易春, 赖雅芬, 张超, 田帅, 谢颖. 低强度超声波对高负荷厌氧氨氧化EGSB反应器运行性能的影响[J]. 化工进展, 2024, 43(2): 1098-1108.
[9]	解舒婷, 代伟. 同步硝化反硝化除磷颗粒污泥的快速启动与强化[J]. 化工进展, 2024, 43(10): 5976-5983.
[10]	史天茜, 石永辉, 武新颖, 张益豪, 秦哲, 赵春霞, 路达. Fe²⁺对厌氧氨氧化EGSB反应器运行性能的影响[J]. 化工进展, 2023, 42(9): 5003-5010.
[11]	陈娜, 张肖静, 张楠, 马冰冰, 张涵, 杨浩洁, 张宏忠. 淬灭酶对亚硝化-混合自养脱氮系统的影响[J]. 化工进展, 2023, 42(7): 3816-3823.
[12]	李白雪, 信欣, 朱羽蒙, 刘琴, 刘鑫. SASD-A体系构建及进水不同S/N对脱氮工艺的影响机制[J]. 化工进展, 2023, 42(6): 3261-3271.
[13]	杨竞莹, 施万胜, 黄振兴, 谢利娟, 赵明星, 阮文权. 改性纳米零价铁材料制备的研究进展[J]. 化工进展, 2023, 42(6): 2975-2986.
[14]	李华华, 李逸航, 金北辰, 李隆昕, 成少安. 厌氧氨氧化-生物电化学耦合废水处理系统的研究进展[J]. 化工进展, 2023, 42(5): 2678-2690.
[15]	朱紫旋, 陈俊江, 张星星, 李祥, 刘文如, 吴鹏. 基于短程反硝化厌氧氨氧化新型污水生物脱氮工艺的研究进展[J]. 化工进展, 2023, 42(4): 2091-2100.