煤基石脑油萃取脱芳复合萃取剂

doi:10.16085/j.issn.1000-6613.2016-1971

化工进展 ›› 2017, Vol. 36 ›› Issue (08): 2897-2902.DOI: 10.16085/j.issn.1000-6613.2016-1971

煤基石脑油萃取脱芳复合萃取剂

薛凤凤, 李冬, 张琳娜, 朱永红, 冯弦, 裴亮军, 李稳宏

西北大学化工学院, 陕西省资源化工应用工程技术研究中心, 陕西西安 710069

收稿日期:2016-10-28 修回日期:2017-01-16 出版日期:2017-08-05 发布日期:2017-08-05
通讯作者: 李冬,副教授。
作者简介:薛凤凤(1993-),女,硕士研究生。E-mail:xuefengfeng1223@163.com。
基金资助:
国家自然科学基金青年基金（21206136）、陕西省科技统筹创新工程计划（2014KTCL01-09）、教育部博士点新教师基金（20126101120013）、陕西省教育厅产业化培育项目（14JF026，15JF031）、陕西省青年科技新星项目（2016KJXX-32）及西北大学优秀青年学术骨干支持计划项目。

Composite extractant of liquid-liquid extraction aromatics for the coal-derived naphtha

XUE Fengfeng, LI Dong, ZHANG Linna, ZHU Yonghong, FENG Xian, PEI Liangjun, LI Wenhong

School of Chemical Engineering, Northwest University, Shaanxi Research Center of Chemical Engineering Technology for Resource Utilization, Xi'an 710069, Shaanxi, China

Received:2016-10-28 Revised:2017-01-16 Online:2017-08-05 Published:2017-08-05

摘要/Abstract

摘要： 采用液液抽提方法研究不同萃取剂对煤基石脑油中芳烃溶解性和选择性的影响，得到了适用于低芳石脑油芳烃脱除的复合萃取剂。本文首先研究了煤基石脑油C₆、C₇、C₈芳烃在5种萃取剂中的分配系数和选择性系数，优选出二甲基亚砜（DMSO）作为主萃取剂。其次，以甲基环己烷和甲苯为低芳模拟油，以DMSO为主萃取剂，DMF、环丁砜、NFM及TEG为辅萃取剂，研究其液液相平衡规律，并用Hand方程对实验数据关联，确定出DMF为适合的辅助溶剂。最后，以芳烃脱除率和脱芳油收率为指标，探究了复合萃取剂DMSO+DMF对煤基石脑油芳烃脱除的影响。研究结果表明：在优化工艺条件下，经5级错流萃取，复合萃取剂DMSO+10%（体积分数）DMF对煤基石脑油具有较好的脱芳效果，其芳烃的分配系数最高达0.215，选择性系数最大为9.96，总芳烃质量分数由原来的12.36%降低到了1.30%，达到120^#溶剂油中芳烃含量的标准。

关键词: 煤基石脑油, 液液萃取, 相平衡, 复合萃取剂, 溶剂油

Abstract: The purpose of the study was to research the effects of various extractants on the solubility and the selectivity of aromatics from coal-derived naphtha. Using liquid-liquid extraction technology,the composite extractants were obtained for removing aromatics of the low aromatic naphtha. Firstly,considering the selective coefficient(S) and the partition coefficient(K) of C₆,C₇,C₈ aromatics in the coal-derived naphtha system with the five extractants,the main extractant dimethyl suifoxide(DMSO)was optimized. Secendly,the LLE data of the composite extractants and the low aromatic simulate oil prepared by the methyl cyclohexane and toluene systems were measured based on the main extractant DMSO supplemented with DMF,sulfolane,NFM or TEG. The experimental data were correlated by the hand correlation,and the auxiliary extractant DMF was proved to be more appropriate. Finally,the aromatic removal rate and the yield of solvent oil were served as indexes. The study explored the effects of composite extractant DMSO+DMF on removal of aromatics from coal-derived naphtha. The results showed that after five stages counter-current extraction under the optimized process conditions,the composite extractant DMSO+10%DMF had good effects on the removal of aromatics from coal-derived naphtha. The distribution coefficient of the aromatics from coal-derived naphtha was up to 0.215 and the maximum selectivity coefficient was 9.96. The total aromatic content decreased from 12.36% to 1.30%,reaching the standard of aromatic content in 120 solvent oil.

Key words: coal-derived naphtha, liquid-liquid extraction, phase equilibrium, composite extractant, solvent oil

中图分类号:

TE624.5

薛凤凤, 李冬, 张琳娜, 朱永红, 冯弦, 裴亮军, 李稳宏. 煤基石脑油萃取脱芳复合萃取剂[J]. 化工进展, 2017, 36(08): 2897-2902.

XUE Fengfeng, LI Dong, ZHANG Linna, ZHU Yonghong, FENG Xian, PEI Liangjun, LI Wenhong. Composite extractant of liquid-liquid extraction aromatics for the coal-derived naphtha[J]. Chemical Industry and Engineering Progress, 2017, 36(08): 2897-2902.

参考文献

[1] 王秀红.煤液化油中芳烃/环烷烃分离规律及其机理研究[D]. 太原:太原理工大学,2011. WANG X H. Separation rule of aromatics/cyclichydrocarbon in coal liquefaction and its mechanism in separation[D]. Taiyuan:Taiyuan University of Technology,2011.
[2] 范建峰,张忠清,姚春雷,等. 中低温煤焦油加氢生产清洁燃料油试验研究[J]. 煤炭学报,2013,38(10):1868-1871. FAN J F,ZHANG Z Q,YAO C L,et al. Study on hydrogenation of medium temperature coal tar to clean fuel[J]. Journal of Coal Science,2013,38(10):1868-1871.
[3] 李冬,李稳宏,高薪,等. 中低温煤焦油加氢改质工艺研究[J]. 煤炭转化,2009,32(4):81-83. LI D,LI W H,GAO X,et al. Hydro-upgranding process of medium and low temperature coal[J]. Journal of Coal Conversion,2009,32(4):81-83.
[4] 张琳娜,李冬,朱永红,等.煤基石脑油萃取脱芳制备溶剂油工艺研究[J]. 精细化工,2016,33(6):703-708. ZHANG L N,LI D,ZHU Y H,et al. Study on the liquid-liquid extraction aromatic process for the coal-derived naphtha to produce solvent oil[J]. Fine Chemicals,2016,33(6):703-708.
[5] 姜广策,张生娟,王永刚.低温煤焦油中特定芳烃组分的选择性分离[J]. 化工学报,2015,66(6):2131-2138. JIANG G C,ZHANG S J,WANG Y G. Selective separation of aromatic hydrocarbons from low temperature coal tar[J].CIESC Journal,2015,66(6):2131-2138.
[6] 王云芳,袁倩,迟正伟. 环丁砜抽提重石脑油芳烃体系相平衡研究[J]. 高校化学工程学报,2014,28(3):460-465. WANG Y F,YUAN Q,CHI Z W. Study on equilibrium of of sulfolane and heavy naphtha extraction system[J]. Journal of Chemical Engineering of Chinese Universities,2014,28(3):460-465.
[7] 肖坤良,唐晓东,李晶晶,等. 石脑油脱芳技术研究进展[J].广州化工,2013,41(5):55-57. XIAO K L,TANG X D,LI J J,et al. Research advances in aromatics removal technology of naphtha[J]. Guangzhou Chemical Industry,2013,41(5):55-57.
[8] 朱自强,姚善泾,金彰礼. 流体相平衡原理及应用[M]. 杭州:浙江大学出版社,1990:10. ZHU Z Q,YAO S J,JING Z L. Principle and application of fluid phase equilibrium[M].Hangzhou:Zhejiang University Press,1990:10.
[9] 迟正伟.重芳烃抽提体系相平衡及热力学模型基础研究[D]. 青岛:中国石油大学(华东),2012. CHI Z W. Basic research of equilibrium and thermodynamic model for heavy aromatics extraction system[D]. Qingdao:China University of Petroleum(East China),2012.
[10] 史云鹤,李长明,周金波,等. 离心萃取法优选直馏石脑油脱芳烃萃取剂[J]. 应用化工,2015,44(5):899-902. SJI Y H,LI C M,ZHOU J B,et al. Dearomatization effect study of composite extractant NMP-DMF to straight-run naphtha[J]. Apply Chemical Industry,2015,44(5):899-902.
[11] LIU Jichang,SHEN Benxian,WANG Daqi,et al. Separating group compositions in naphtha by adsorption and solvent extraction to improve olefin yields of steam cracking process[J]. Journal of Petroleum Science & Engineering,2009,66(3/4):156-160.
[12] 袁倩. 重石脑油萃取脱芳技术基础研究[D]. 北京:中国石油大学,2013. YUAN Q. Bisic research of the technology for extracting aromatics from heavy naphtha[D]. Beijing:China Petroleum University,2013.
[13] 王成武,戴杰,齐鸣斋. 间苯二酚溶剂萃取液液相平衡研究[J]. 上海化工,2003(6):23-25. WANG C W,DAI J,QI M Z. Study on liquid-liquid equilibrium of solvent extraction of resorcinol[J]. Shanghai Chemistry Industry,2003(6):23-25.
[14] 潘燕.基于DMF溶液体系溶剂化过程和理论研究[D]. 合肥:合肥工业大学,2011. PAN Y. Study and calculation of ion solvation process in dimethylformamide(DMF)solution system[D]. Hefei:Hefei University of Technologyc,2011.

[1]	岳子瀚, 龙臻, 周雪冰, 臧小亚, 梁德青. sⅡ型水合物储氢研究进展[J]. 化工进展, 2023, 42(10): 5121-5134.
[2]	贾文龙, 宋硕硕, 李长俊, 吴瑕, 杨帆, 张员瑞. 超临界CO₂萃取含油污泥研究现状与进展[J]. 化工进展, 2022, 41(12): 6573-6585.
[3]	王逸伟, 刘智琪, 孙强, 刘爱贤, 杨兰英, 宫敬, 郭绪强. 聚苯乙烯磺酸钠作用下Ⅰ型水合物的生成热力学与动力学[J]. 化工进展, 2021, 40(S1): 168-181.
[4]	胡倩, 周诗岽, 郭宇, 张雪艳, 王娇娇, 王国栋, 姬浩洋. 蜡晶析出对CO₂水合物相平衡及诱导特性的影响[J]. 化工进展, 2021, 40(5): 2452-2460.
[5]	赵振宇, 李洪, 李鑫钢, 高鑫. 基于介电性质差异的微波诱导强化蒸馏分离[J]. 化工进展, 2020, 39(6): 2275-2283.
[6]	李恩田,徐洋,姚培,朱媛媛,张怿涵,朱霞石. β-环糊精协同乙烯基咪唑离子液体脱除溶剂油中的萘[J]. 化工进展, 2020, 39(4): 1321-1328.
[7]	代梦玲, 孙志高, 李娟, 李翠敏, 黄海峰. 水合物储气促进技术研究进展[J]. 化工进展, 2020, 39(10): 3975-3986.
[8]	周麟晨,孙志高,李娟,李翠敏. 水合物形成促进剂研究进展[J]. 化工进展, 2019, 38(9): 4131-4141.
[9]	周宁,陈力,吕孝飞,李雪,黄维秋,赵会军,刘晅亚,陈兵. 大型LNG储罐连续泄漏扩散过程影响因素的分析[J]. 化工进展, 2019, 38(10): 4423-4436.
[10]	李晶晶, 杨柳, 唐晓东, 王治宇, 王春. 脱芳复合萃取剂的研究进展[J]. 化工进展, 2019, 38(06): 2915-2921.
[11]	杜博文, 陈康, 丁鑫, 姜召, 方涛. 超临界二氧化碳与二苯醚相平衡研究[J]. 化工进展, 2019, 38(04): 1662-1670.
[12]	孙保民, 高满达, 丁世兴, 苏逸峰. 合成煤中钠对煤燃烧及灰特性影响[J]. 化工进展, 2019, 38(02): 842-850.
[13]	杨启炜, 鲍宗必, 邢华斌, 任其龙. 离子液体萃取分离结构相似化合物研究进展[J]. 化工进展, 2019, 38(01): 91-99.
[14]	王东旭, 陈裕辉, 王洋, 李文艳, 肖海平, 康志忠. MgO含量对高钠煤灰熔融特性的影响[J]. 化工进展, 2018, 37(04): 1392-1401.
[15]	朱永红, 淡勇, 王莉莎, 李冬, 李稳宏. 煤基石脑油半再生催化重整制芳烃的工艺[J]. 化工进展, 2018, 37(03): 947-955.

煤基石脑油萃取脱芳复合萃取剂

Composite extractant of liquid-liquid extraction aromatics for the coal-derived naphtha

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价