爱德万甜中间体3-羟基-4-甲氧基肉桂醛的合成

doi:10.16085/j.issn.1000-6613.2022-0153

摘要/Abstract

摘要：

3-羟基-4-甲氧基肉桂醛是制备新型的二肽超高甜度甜味剂爱德万甜的重要中间体。目前制备该中间体的主要方法是通过异香兰素与乙醛在强碱存在下进行羟醛缩合反应，但由于乙醛容易发生自缩合反应从而存在反应条件极为苛刻和3-羟基-4-甲氧基肉桂醛收率低等问题，本文以乙酸乙烯作为反应物替代乙醛与异香兰素发生反应合成3-羟基-4-甲氧基肉桂醛，采用单因素实验考察了反应温度、反应时间、NaOH浓度和异香兰素与乙酸乙烯配比对该反应的影响，并在此基础上进行了响应面优化。在优化的反应条件（NaOH浓度4.5mol/L，反应温度10℃，反应时间12h，异香兰素与乙酸乙烯摩尔比1∶2）下，3-羟基-4-甲氧基肉桂醛收率为71.44%±2.21%。为了进一步提高产品收率，探索了添加相转移催化剂对该反应的强化作用，发现PEG-200对强化该反应有显著作用，3-羟基-4-甲氧基肉桂醛收率可达83.12%±2.18%。

关键词: 合成, 3-羟基-4-甲氧基肉桂醛, 乙酸乙烯, 催化, 优化

Abstract:

3-Hydroxy-4-methoxy cinnamaldehyde is an important intermediate for the preparation of advantame, which is a novel dipeptide sweetener with super-high potency. At present, this intermediate is mainly synthesized by Aldol condensation reaction of isovanillin and acetaldehyde in the presence of strong base. However, since acetaldehyde is prone to self-condensation, there are problems such as harsh reaction conditions and low yield of 3-hydroxy-4-methoxy cinnamaldehyde. In this paper, a new process for preparation of 3-hydroxy-4-methoxy cinnamaldehyde by using vinyl acetate as a reactant in place of acetaldehyde to react with isovanillin was studied. The influences of reaction temperature, reaction time, NaOH dosage and molar ratio of isovanillin to vinyl acetate on the reaction were investigated by single factor experiments. On the basis of the single factor experiments, the response surface optimization was carried out. Results showed that the yield of 3-hydroxy-4-methoxy cinnamaldehyde was 71.44%±2.21% under optimal conditions: NaOH concentration of 4.5mol/L, reaction temperature of 10℃, reaction time of 12h and the molar ratio of isovanillin to vinyl acetate of 1∶2. In order to further improve the product yield, the strengthening effect of adding a phase transfer catalyst to the reaction system was explored. It was found that PEG-200 had a significant catalytic effect on the reaction, and the yield of 3-hydroxy-4-methoxy cinnamaldehyde achieved 83.12%±2.18%.

Key words: synthesis, 3-hydroxy-4-methoxycinnamaldehyde, vinyl acetate, catalysis, optimization

中图分类号:

TQ215

方聪, 刘怡雪, 黎四芳. 爱德万甜中间体3-羟基-4-甲氧基肉桂醛的合成[J]. 化工进展, 2022, 41(11): 6053-6060.

FANG Cong, LIU Yixue, LI Sifang. Synthesis of 3-hydroxy-4-methoxy cinnamaldehyde as intermediate of advantame[J]. Chemical Industry and Engineering Progress, 2022, 41(11): 6053-6060.

图/表 22

参考文献 24

1	AMINO Yusuke, MORI Kenich, TOMIYAMA Yasuyuki, et al. Development of new, low calorie sweetener: new aspartame derivative[M]//WEERASINGHE Deepthi K, DUBOIS Grant E. Sweetness and sweeteners: biology, chemistry, and psychophysics. Washington D C: ACS, 2008: 463-480.
2	BISHAY I E, BURSEY R G. Advantame[M]//O’BRIEN-Nabors Lyn. Alternative sweeteners. 4th edition. Boca Raton: CRC Press, 2012: 31-45.
3	OTABE A, FUJIEDA T, MASUYAMA T, et al. Advantame-an overview of the toxicity data[J]. Food and Chemical Toxicology: an International Journal Published for the British Industrial Biological Research Association, 2011, 49(S1): S2-S7.
4	RENWICK A G. Postscript on advantame: a novel high-potency low-calorie sweetener[J]. Food and Chemical Toxicology, 2011, 49: S1.
5	Food Safety Commission of Japan. Advantame: summary[R]. Tokyo: FSCJ, 2013.
6	EFSA Panel on Food Additives and Nutrient Sources added to Food ANS). Scientific opinion on the safety of advantame for the proposed uses as a food additive[J]. EFSA Journal, 2013, 11(7): 3301-3368.
7	ZHANG Jiyue, ZHANG Jianbo, YU Hangyu, et al. Theoretical risk assessment of dietary exposure to advantame among the Chinese population[J]. Biomedical and Environmental Sciences: BES, 2019, 32(12): 930-933.
8	DUBOIS Grant E, PRAKASH Indra. Non-caloric sweeteners, sweetness modulators, and sweetener enhancers[J]. Annual Review of Food Science and Technology, 2012, 3: 353-380.
9	Kay O’DONNELL. Aspartame, neotame and advantame[M]// Sweeteners and sugar alternatives in food technology. Oxford: John Wiley & Sons Inc., 2012: 117-136.
10	黎四芳. 高甜度甜味剂的生产与应用[M]. 厦门: 厦门大学出版社, 2021.
	LI Sifang. Production and application of high potency sweeteners[M]. Xiamen: Xiamen University Press, 2021.
11	方聪, 刘怡雪, 黎四芳. 新型超高甜度二肽甜味剂爱德万甜的研究进展[J]. 中国食品添加剂, 2021, 32(2): 128-136.
	FANG Cong, LIU Yixue, LI Sifang. Research progress in new ultra-high potency dipeptide sweetener advantame[J]. China Food Additives, 2021, 32(2): 128-136.
12	NAGASHIMA Kazutaka, AOKI Yuuichi, TAKEMOTO Tadashi, et al. Process for production of aspartyl dipeptide ester derivative, novel production intermediate therefor, and process for production thereof: US6794531[P]. 2004-09-21.
13	MORI Kenichi, FUJITA Shinji, FUNAKOSHI Nao, et al. Process for producing cinnamaldehyde derivatives, use thereof and the like: US7141263[P]. 2006-11-28.
14	陈博儒, 陈良, 朱思明. 甜味剂中间体3-羟基-4-甲氧基苯丙烯醛的合成工艺优化及其结构表征[J]. 食品工业科技, 2018, 39(22): 144-149.
	CHEN Boru, CHEN Liang, ZHU Siming. Optimization of synthesis process and structural characterization of 3-hydroxy-4-methoxy benzal acrolein—A aweetener intermediate[J]. Science and Technology of Food Industry, 2018, 39(22): 144-149.
15	CHEN Boru, LIU Qiang, WANG Huan, et al. Purification, characterization, and identification of 3-hydroxy-4-methoxy benzal acrolein—An intermediate of synthesizing advantame[J]. Food Science & Nutrition, 2020, 8(2): 744-753.
16	吴美红, 郑建仙. 超高倍甜味剂N-[3-(3-羟基-4-甲氧基苯基)丙基]-阿斯巴甜的合成研究[J]. 食品与发酵工业, 2009, 35(6): 1-5.
	WU Meihong, ZHENG Jianxian. Synthesis of high potency sweetener N-[3-(3-hydroxy-4-methoxyphenyl) propyl]-aspartyl-L-henylalaninel-methylester[J]. Food and Fermentation Industries, 2009, 35(6): 1-5.
17	刘怡雪. Advantame的合成[D]. 厦门: 厦门大学, 2018.
	LIU Yixue. The synthesis of advantame[D]. Xiamen: Xiamen University, 2018.
18	DIVI M K P， RAO M A N， NOWSHUDDIN S. Process for the preparation of advantame：US9512063[P]. 2016-12-06.
19	Gardner SWAIN C, POWELL Arnet L, SHEPPARD William A, et al. Mechanism of the cannizzaro reaction[J]. Journal of the American Chemical Society, 1979, 101(13): 3576-3583.
20	J J Vanden EYNDE, MUTONKOLE K, VAN HAVERBEKE Y. Surfactant-assisted organic reactions in water. Effect of ultrasound on condensation reactions between active methylene compounds and arylaldehydes[J]. Ultrasonics Sonochemistry, 2001, 8(1): 35-39.
21	丁秋平. 胶束中氨基酸直接催化Aldol反应研究[D]. 南昌: 江西师范大学, 2003.
	DING Qiuping. Study of the aldol reactions directly catalyzed by amino acids in aqueous micelles[D]. Nanchang: Jiangxi Normal University, 2003.
22	VASHISHTHA Manu, MISHRA Manish, SHAH Dinesh O. A novel approach for selective cross aldol condensation using reusable NaOH-cationic micellar systems[J]. Applied Catalysis A: General, 2013, 466: 38-44.
23	张媛媛, 郎万中, 褚联峰, 等. PVP相转移催化合成辛烯醛[J]. 广州化工, 2009, 37(9): 155-157, 160.
	ZHANG Yuanyuan, LANG Wanzhong, CHU Lianfeng, et al. Synthesis of 2-ethylhexenal with phase transfer catalyst PVP[J]. Guangzhou Chemical Industry, 2009, 37(9): 155-157, 160.
24	陈逸. 表面活性剂及其在相转移催化方面的应用研究[J]. 当代化工研究, 2019(1): 105-106.
	CHEN Yi. Surfactant and its application in phase transfer catalysis[J]. Modern Chemical Research, 2019(1): 105-106.

因素	水平
因素	-1	0	1
A 反应时间/h	8	12	16
B 反应温度/℃	5	10	15
C NaOH浓度/mol·L^-1	0.14	0.18	0.22
D 异香兰素与乙酸乙烯摩尔比	1∶1.5	1∶2	1∶2.5

因素	水平
因素	-1	0	1
A 反应时间/h	8	12	16
B 反应温度/℃	5	10	15
C NaOH浓度/mol·L^-1	0.14	0.18	0.22
D 异香兰素与乙酸乙烯摩尔比	1∶1.5	1∶2	1∶2.5

序列	因素				收率/%
序列	A：反应时间	B：反应温度	C：NaOH 浓度	D：异香兰素与乙酸乙烯摩尔比	实际值	预测值
1	-1	0	1	0	37.94	38.92
2	0	-1	1	0	31.55	29.23
3	1	-1	0	0	36.61	37.56
4	-1	-1	0	0	34.17	35.31
5	1	1	0	0	30.57	30.59
6	-1	1	0	0	28.88	29.09
7	0	1	-1	0	25.36	25.66
8	-1	0	-1	0	41.13	40.71
9	0	0	0	0	69.23	71.44
10	0	0	0	0	71.25	71.44
11	0	0	0	0	70.98	71.44
12	1	0	-1	0	43.95	43.83
13	0	1	1	0	23.25	22.44
14	0	0	0	0	72.54	71.44
15	0	0	0	0	73.21	71.44
16	0	-1	-1	0	33.29	32.07
17	1	0	1	0	39.59	40.21
18	-1	0	0	1	45.82	44.61
19	0	1	0	1	28.79	28.75
20	0	0	-1	1	40.77	41.27
21	0	-1	0	1	33.98	34.52
22	1	0	0	1	46.78	46.12
23	0	0	1	1	37.02	37.89
24	0	0	-1	-1	39.11	39.40
25	0	-1	0	-1	32.93	33.83
26	0	0	1	-1	36.07	36.73
27	1	0	0	-1	45.78	44.97
28	0	1	0	-1	26.07	26.40
29	-1	0	0	-1	44.10	42.73

序列	因素				收率/%
序列	A：反应时间	B：反应温度	C：NaOH 浓度	D：异香兰素与乙酸乙烯摩尔比	实际值	预测值
1	-1	0	1	0	37.94	38.92
2	0	-1	1	0	31.55	29.23
3	1	-1	0	0	36.61	37.56
4	-1	-1	0	0	34.17	35.31
5	1	1	0	0	30.57	30.59
6	-1	1	0	0	28.88	29.09
7	0	1	-1	0	25.36	25.66
8	-1	0	-1	0	41.13	40.71
9	0	0	0	0	69.23	71.44
10	0	0	0	0	71.25	71.44
11	0	0	0	0	70.98	71.44
12	1	0	-1	0	43.95	43.83
13	0	1	1	0	23.25	22.44
14	0	0	0	0	72.54	71.44
15	0	0	0	0	73.21	71.44
16	0	-1	-1	0	33.29	32.07
17	1	0	1	0	39.59	40.21
18	-1	0	0	1	45.82	44.61
19	0	1	0	1	28.79	28.75
20	0	0	-1	1	40.77	41.27
21	0	-1	0	1	33.98	34.52
22	1	0	0	1	46.78	46.12
23	0	0	1	1	37.02	37.89
24	0	0	-1	-1	39.11	39.40
25	0	-1	0	-1	32.93	33.83
26	0	0	1	-1	36.07	36.73
27	1	0	0	-1	45.78	44.97
28	0	1	0	-1	26.07	26.40
29	-1	0	0	-1	44.10	42.73

方差来源	平方和	自由度	均方	F	P	显著性
回归方程	6249.78	14	446.41	223.75	< 0.0001	+ +
A	10.53	1	10.53	5.28	0.0376
B	130.75	1	130.75	65.53	< 0.0001	+ +
C	27.57	1	27.57	13.82	0.0023	+
D	6.90	1	6.90	3.46	0.0841
AB	0.14	1	0.14	0.070	0.7945
AC	0.34	1	0.34	0.17	0.6850
AD	0.13	1	0.13	0.065	0.8025
BC	0.034	1	0.034	0.017	0.8977
BD	0.70	1	0.70	0.35	0.5638
CD	0.13	1	0.13	0.063	0.8052
A²	979.04	1	979.04	490.72	< 0.0001	+ +
B²	4391.39	1	4391.39	2201.09	< 0.0001	+ +
C²	2118.43	1	2118.43	1061.82	< 0.0001	+ +
D²	1372.84	1	1372.84	688.11	< 0.0001	+ +
残差	27.93	14	2.00	—	—
失拟项	18.46	10	1.85	0.78	0.6603
纯误差	9.47	4	2.37	—	—
总和	6277.71	28	—	—	—