陶瓷膜过滤技术在油田含油污水中的应用研究进展

doi:10.16085/j.issn.1000-6613.2017.05.042

摘要/Abstract

摘要： 油田含油污水的高效处理是油田可持续开发的关键，陶瓷膜过滤技术由于具有分离效果好、无二次污染等优点已成为目前的研究热点。本文分析了陶瓷膜的油水分离机理，调研了国内外陶瓷膜过滤技术处理油田含油污水的研究现状，同时介绍了陶瓷膜过滤技术在海上油田含油污水处理中的应用，重点分析了膜分离效果的影响因素，主要包括膜本身的性能、原料液的性质、过程的操作参数以及其他影响因素。其中膜本身的性能主要体现在膜孔径和膜材料上；原料液的性质主要取决于含油量、pH、浓度和温度；而过程的操作参数主要包括跨膜压差和膜面流速；其他因素主要有反冲洗、吸附剂和混凝剂。然后分析了膜污染的机理，介绍了目前膜清洗的方法。最后分析了膜技术应用中存在的问题，对未来研究的方向提出了几点建议。

关键词: 含油污水, 膜, 过滤, 活性炭, 膜污染, 膜清洗

Abstract: The treatment of oilfield oily wastewater is the key to the sustainable development of oil field. Ceramic membrane filtration technology has become a hot research topic due to its good separation effect and without secondary pollution. In this paper,the oil-water separation mechanism of ceramic membrane was analyzed,The research status of domestic and foreign ceramic membrane filtration treatment of oilfield oily wastewater was investigated. At the same time,application of ceramic membrane filtration technology in the treatment of oily wastewater in offshore oilfield was introduced. The influence factors on the effect of membrane filtration were analyzed,which are consist of the performance of the membrane itself,the nature of the raw material,the operating parameters of the process and so on. The performance of the membrane itself is mainly reflected in membrane pore size and membrane material. The nature of the feed liquid mainly depends on the oil content,pH,feed concentration and temperature. The operating parameters of the process mainly include trans-membrane pressure and membrane surface flow rate. Other factors mainly have reverse washing,adsorbent and coagulant. The fouling mechanism of membrane was analyzed,and the current cleaning method for membrane was introduced. Finally,the problems existing in the application of membrane technology were analyzed,and some suggestions for the future research has been put forward.

Key words: oily wastewater, membrane, filtration, activated carbon, membrane fouling, membrane cleaning

中图分类号:

TE991

黄斌, 张威, 王莹莹, 傅程, 许瑞, 史振中. 陶瓷膜过滤技术在油田含油污水中的应用研究进展[J]. 化工进展, 2017, 36(05): 1890-1898.

HUANG Bin, ZHANG Wei, WANG Yingying, FU Cheng, XU Rui, SHI Zhenzhong. Application and research progress of ceramic membrane filtration technology in the treatment of oily wastewater in oil field[J]. Chemical Industry and Engineering Progress, 2017, 36(05): 1890-1898.

参考文献

[1] 沈琛. 油田污水处理工艺技术新进展[M]. 北京:石油工业出版社,2008:1-3. SHEN C. New progress of oilfield wastewater treatment technology[M]. Beijing:Petroleum Industry Press,2008:1-3.
[2] 周卫东,佟德水,李罗鹏. 油田含油污水处理方法研究进展[J]. 工业水处理,2008,28(12):5-8. ZHOU W D,TONG D S,LI L P. Research and development of oilfield produced water treatment methods[J]. Industrial Water Treatment,2008,28(12):5-8.
[3] 张学佳,纪巍,王宝辉,等. 油田含油污水处理技术进展[J]. 工业安全与环保,2007,33(4):13-16. ZHANG X J,JI W,WANG B H,et al. Study on the treatment technology of oilfield produced water[J]. Industrial Safety and Environmental Protection,2007,33(4):13-16.
[4] ELISAMA V D S,JESSICA H B R,DANYELLE M D A,et al. Decontamination of produced water containing petroleum hydrocarbons by electrochemical methods:a minireview[J]. Environmental Science and Pollution Research,2014,21(14):8432-8441.
[5] 窦茂卫,苏保卫,高学理,等. 油田含油污水膜法处理技术应用研究进展[J]. 环境科学与技术,2011,34(8):124-130. DOU M W,SU B W,GAO X L,et al. Progress in membrane technology for treatment of oilfield produced water[J]. Environmental Science & Technology,2011,34(8):124-130.
[6] SALEM A,ABDUL W M. Challenges and trends in membrane technology implementation for produced water treatment:a review[J]. Journal of Water Process Engineering,2014,4:107-133.
[7] BEMARDO P,DRIOLI E. Membrane technology:latest applications in the refinery and petrochemical field[M]//ENRICO D,LIDIETTA G. Comprehensive membrane science and engineering. Oxford:Elsevier,2010:211-239.
[8] BILSTAD T,ESPEDAL E. Membrane separation of produced water[J]. Water Science & Technology,2015,34(9):239-246.
[9] 蔺爱国,刘培勇,刘刚,等. 膜分离技术在油田含油污水中的应用研究进展[J]. 工业水处理,2006,26(1):5-8. LIN A G,LIU P Y,LIU G,et al. Progress of membrane separation technique in oil-bearing water treatment in oil fields[J]. Industrial Water Treatment,2006,26(1):5-8.
[10] DAVID R. Oil and gas:treatment and discharge of produced waters offshore[J]. Filtration&Separation,2013,50(2):20-23.
[11] EBENEZER T I,GEORGE Z C. Produced water treatment technologies[J]. International Journal of Low:Carbon Technologies,2014,9(3):157-177.
[12] FAKHRU'L R A,PENDASHTEH A,ABDULLAH L C,et al. Review of technologies for oil and gas produced water treatment[J]. Journal of Hazardous Materials,2009,170(2/3):530-551.
[13] CHEN A S C,FLYNN J T,COOK R G,et al. Removal of oil,grease and suspended solids from produced water with ceramic cross flow microfiltration[J]. SPE Production Engineering,1991,6(2):131-136.
[14] SAREH R H A,MOHAMMAD R S,MAHMOOD H,et al. Ceramic membrane performance in microfiltration of oily wastewater[J]. Desalination, 2011,265(1/2/3):222-228.
[15] NAND B K,MOPARTHI A,UPPALURI R,et al. Treatment of oily wastewater using low cost ceramic membrane:comparative assessment of pore blocking and artificial neural network models[J]. Chemical Engineering Research and Design,2010,88(7):881-892.
[16] EBRAHIMI M,WILLERSHAUSEN D,ASHAGHI K S,et al. Investigations on the use of different ceramic membranes for efficient oil-field produced water treatment[J]. Desalination,2010,250(3):991-996.
[17] 刘凤云,曹洪奎. 陶瓷膜横向流微滤处理油田含油污水前景[J]. 油气田地面工程,1996,15(3):21-23. LIU F Y,CAO H K. Prospect on oilfield produced water treated by ceramic membrane transverse-flow microfiltration[J]. Oil-Gas Field Surface Engineering,1996,15(3):21-23.
[18] 单连斌. 用陶瓷膜做滤材处理含油废水的研究[J]. 环境保护科学,1996,22(3):26-29. SHAN L B. A study on oil containing waste water treatment using ceramic membrace as filter materia[J]. Environmental Protection Science,1996,23(3):26-29.
[19] 王春梅,谷和平,王义刚,等. 陶瓷微滤膜处理含油污水的工艺研究[J]. 南京化工大学学报,2000,22(5):38-42. WANG C M,GU H P,WANG Y G,et al. Oily wastewater treatment with ceramic membrane[J]. Journal of Nanjing University of Chemical Technology,2000,22(5):38-42.
[20] 谷玉洪,薛家慧,刘凯文. 陶瓷微滤膜处理油田含油污水试验[J]. 油气田地面工程,2001,20(1):18-19. GU Y H,XUE J H,LIU K W. Test of ceramic microfiltration membrane for treatment of oilfield produced water[J]. Oil-Gas Field Surface Engineering,2001,20(1):18-19.
[21] 丁慧,彭兆洋,李毅,等. 无机陶瓷膜处理油田含油污水[J]. 环境工程学报,2013,7(4):1399-1404. DING H,PENG Z Y,LI Y,et al. Treatment of oilfield produced water by inorganic ceramic membrane[J]. Chinese Journal of Environmental Engineering,2013,7(4):1399-1404.
[22] 安家荣,宗媛,吴梁红,等. 含油污水陶瓷膜处理工艺的数值模拟[J]. 膜科学与技术,2012,32(3):59-63. AN J R,ZONG Y,WU L H,et al. Numerical simulation on ceramic membranes treatment technology of oily water[J]. Membrane Science and Technology,2012,32(3):59-63.
[23] ZHONG J,SUN X J,WANG C L. Treatment of oily wastewater produced from refinery processes using flocculation and ceramic membrane filtration[J]. Separation and Purification Technology,2003,32(1/2/3):93-98.
[24] CUI J Y,ZHANG X F,LIU H O,et al. Preparation and application of zeolite/ceramic microfiltration membranes for treatment of oil contaminated water[J]. Journal of Membrane Science,2008,325(1):420-426.
[25] 苏保卫,王铎,高学理,等. 海上采油水处理技术的研究进展[J]. 中国给水排水,2009,25(2):23-27. SU B W,WANG D,GAO X L,et al. Research progress in treatment technology of offshore oilfield wastewater[J]. China Water & Waste Water,2009,25(2):23-27.
[26] SILVIO E W,ANA M T L,CRISTIANO P B,et al. Evaluation of ceramic membranes for oilfield produced water treatment aiming reinjection in offshore units[J]. Journal of Petroleum Science and Engineering,2015,131:51-57.
[27] STRATHMANN H. Inorganic membranes-synthesis,characteristics and applications[J]. Chemical Engineering and Processing,1993,32(3):199-200.
[28] 徐南平,刑卫红,王沛. 无机膜在工业污水处理中的应用与展望[J]. 膜科学与技术,2000,20(3):23-28. XU N P,XING W H,WANG P. The development and application of inorganic membranes in the treatment of industrial waste water[J]. Membrane Science and Technology,2000,20(3):23-28.
[29] MUELLER J,CEN Y,DAVIS R H. Cross flow microfiltration of oily water[J]. Journal of Membrane Science,1997,129(2):221-235.
[30] EMANI S,UPPALURI R,PURKAIT M K. Cross flow microfiltration of oil-water emulsions using kaolin based low cost ceramic membranes[J]. Desalination,2014,341:61-71.
[31] WESCHENFELDER S E,BORGES C P,CAMPOS J C. Oilfield produced water treatment by ceramic membranes:bench and pilot scale evaluation[J]. Journal of Membrane Science,2015,495:242-251.
[32] ZSIRAI T,Al-JAML A K,QIBLAWEY H,et al. Ceramic membrane filtration of produced water:impact of membrane module[J]. Separation and Purification Technology,2016,165:214-221.
[33] VASANTH D,PUGAZHENTHI G,UPPALURI R. Performance of low cost ceramic microfiltration membranes for the treatment of oil-in-water emulsions[J]. Separation Science and Technology,2013,48(6):849-858.
[34] TORAJ M,AFSHIN P,MEHRDAD K,et al. Effect of operating conditions on microfiltration of an oil-water emulsion by a Kaolin membrane[J]. Desalination,2004,168:201-205.
[35] HUA F L,WANG Y J,TSANG Y F,et al. Study of microfiltration behavior of oily wastewater[J]. Journal of Environmental Science and Health Part A,2007,42(4): 489-496.
[36] 谷和平. 陶瓷膜处理含油乳化污水的技术开发及传递模型研究[D]. 南京:南京工业大学,2003. GU H P. Studies on the development of ceramic membrane technology for treating oily emulsion wastewater and the transport modeling[D]. Nanjing:Nanjing Tech University,2003.
[37] HUA F L,WANG Y J,TSANG Y F,et al. Performance study of ceramic microfiltration membrane for oily wastewater treatment[J]. Chemical Engineering Journal,2007,128(2):169-175.
[38] ZHAO Y,XING Y,XU N, et al. Effects of inorganic salt on ceramic membrane microfiltration of titanium dioxide suspension[J]. Journal of Membrane Science,2005,254(1/2):81-88.
[39] 沈浩,张春,陈超,等. 气升式陶瓷膜过滤装置处理油田含聚含油污水[J]. 化工学报,2016,67(9):3768-3775. SHEN H,ZHANG C,CHEN C,et al. Treatment of produced polymer-containing wastewater at oilfield using airlift ceramic membrane filtration equipment[J]. CIESC Journal,2016,67(9):3768-3775.
[40] 彭兆洋. 低渗透油田采出水膜处理工艺研究[D]. 哈尔滨:哈尔滨工业大学,2012. PENG Z Y. Study on membrane process used for treating oilfield produced water of low permeability oilfield[D]. Haerbin:Harbin Institute of Technology,2012.
[41] 徐超. 油田含油污水陶瓷膜处理技术研究[D]. 东营:中国石油大学,2010. XU C. Study on treatment of oily wastewater in oil-field by ceramic membrane technology[D]. Dongying:China University of Petroleum,2010.
[42] MEHRDAD E,ZOLTAN K,MAREN S,et al. Multistage filtration process for efficient treatment of oil-field produced water using ceramic membranes[J]. Desalination and Water Treatment,2012,42(1/2/3):17-23.
[43] MOHSEN A,MOHAMMAD R S,TORAJ M. Enhancement of oily wastewater treatment by ceramic microfiltration membranes using powder activated carbon[J]. Chemical Engineering and Technology,2011,34(8):1252-1258.
[44] MOHSEN A,ABOOZAR T. Effect of coagulant agents on oily wastewater treatment performance using mullite ceramic MF membranes:experimental and modeling studies[J]. Chinese Journal of Chemical Engineering,2013,21(11):1251-1259.
[45] MOHSEN A,MOHAMMAD R S,TORAJ M. Effect of metallic coagulant agents on oily wastewater treatment performance using mullite ceramic MF membranes[J]. Separation Science and Technology,2012,47(16):2290-2298.
[46] ASHAGHI K S,EBRAHIMI M,CZERMAK P. Ceramic ultra- and nanofiltration membranes for oilfield produced water treatment:a mini review[J]. Open Environmental Sciences,2007,1:1-8.
[47] 张志军,赵平. 陶瓷膜污染与清洗[J]. 河北工业科技,2009,26(1):61-64. ZHANG Z J,ZHAO P. Ceramic membrane fouling and cleaning[J]. Hebei Journal of Industrial Science and Technology,2009,26(1):61-64.
[48] 舒莉,吴波,邢卫红,等. 陶瓷膜污染的超声波辅助清洗[J]. 化工进展,2006,25(10):1184-1187. SHU L,WU B,XING W H,et al. Ultrasound-assisted cleaning of ceramic membrane[J]. Chemical Industry and Engineering Progress,2006,25(10):1184-1187.
[49] 黄有泉,武云龙,付馨,等. 陶瓷膜的三步清洗法及效果分析[J]. 工业用水与废水,2011,42(6):43-47. HUANG Y Q,WU Y L,FU X,et al. Study on three-step cleaning of ceramic membrane and analysis of its effects[J]. Industrial Water & Wastewater,2011,42(6):42-47.
[50] 黄有泉,武云龙,付馨,等. 陶瓷膜一步清洗法可行性研究[J]. 工业用水与废水,2012,43(1):42-45. HUANG Y Q,WU Y L,FU X,et al. Discussion on practicability of one-step cleaning of ceramic membrane[J]. Industrial Water & Wastewater,2012,43(1):42-45.
[51] 王志高,张斯凡,彭文博,等. 陶瓷膜处理油田含油污水的中试研究[C]//膜科学与技术编辑部. 第四届中国膜科学与技术报告会论文集. 北京:中国膜工业协会,2010:707-711. WANG Z G,ZHANG S F,PENG W B,et al. Pilot study of filtrating oilfield produced water with ceramic membrane[C]//Membrane Science and Technology Editorial Department. 4th China Conference on Membrane and Technology. Beijing:Membrane Industry Association of China,2010:707-711.