复合热源热泵热水器变工况运行特性分析

doi:10.16085/j.issn.1000-6613.2017-0377

化工进展 ›› 2017, Vol. 36 ›› Issue (11): 3977-3985.DOI: 10.16085/j.issn.1000-6613.2017-0377

复合热源热泵热水器变工况运行特性分析

赵伟强, 李舒宏, 张小松

东南大学能源与环境学院, 江苏南京 210096

收稿日期:2017-03-07 修回日期:2017-05-15 出版日期:2017-11-05 发布日期:2017-11-05
通讯作者: 李舒宏,博士,教授,从事太阳能热利用研究。
作者简介:赵伟强(1990-),男,硕士研究生。
基金资助:
国家十二五科技支撑项目（2014BAJ01B05）。

Analysis of the operating characteristics of hybrid heat sources:heat pump water heater under variable conditions

ZHAO Weiqiang, LI Shuhong, ZHANG Xiaosong

School of Energy and Environment, Southeast University, Nanjing 210096, Jiangsu, China

Received:2017-03-07 Revised:2017-05-15 Online:2017-11-05 Published:2017-11-05

摘要/Abstract

摘要： 为了对复合热源热泵热水器进行变工况运行特性分析，采用变频压缩机与电子膨胀阀，搭建了直膨式太阳能-空气复合热源热泵热水器实验装置，建立了系统数学模型，并在相同工况下进行模拟计算和实验验证，比较发现，模拟结果与实验结果吻合良好。利用验证过的数学模型进一步分析了环境温度、太阳辐射强度和压缩机频率对系统性能的影响，并制定了压缩机变频控制策略，给出了不同工况下的推荐频率和加热时长，可以为用户提供变工况运行控制指导。利用南京地区典型年气象参数，对系统在不同模式下的全年逐月运行特性进行了模拟计算并作对比分析。结果表明，相比定容量模式，系统在变容量模式下的性能系数（COP）全年平均增长49.27%，耗电量全年平均下降29.73%，节能效果显著。

关键词: 直膨式热泵, 太阳能, 复合热源, 热水器, 变工况

Abstract: To analyze the operating characteristics of hybrid heat sources, heat pump water heater, under variable condition, the apparatus of the direct-expansion solar-air source water heat pump was established using a variable capacity compressor and an electronic expansion valve. The mathematical model of this system was developed and verified. The simulated results were in good agreement with the experimental results. The validated mathematical model was used to further analyze the effect of ambient temperature, solar radiation intensity and compressor frequency on the system performance. The frequency conversion control strategy of the compressor was developed, and the recommended frequency and heating time under different working conditions were obtained, which can provide guidance to operations under variable conditions. Based on the meteorological parameters of typical meteorological years in Nanjing, the annual operating characteristics of the system in different modes were simulated and compared. The results showed that, compared with the constant capacity mode, the COP of the system in the variable capacity mode annual increased by an average of 49.27%, while the power consumption decreased by 29.73%,and the energy saving was quite remarkable.

Key words: direct-expansion heat pump, solar energy, hybrid heat sources, water heater, variable condition

中图分类号:

TK519

赵伟强, 李舒宏, 张小松. 复合热源热泵热水器变工况运行特性分析[J]. 化工进展, 2017, 36(11): 3977-3985.

ZHAO Weiqiang, LI Shuhong, ZHANG Xiaosong. Analysis of the operating characteristics of hybrid heat sources:heat pump water heater under variable conditions[J]. Chemical Industry and Engineering Progress, 2017, 36(11): 3977-3985.

参考文献

[1] 李郁武. 直膨式太阳能热泵热水装置的优化分析与变容量运行研究[D]. 上海:上海交通大学,2007. LI Y H. Study on optimum analysis and variable capacity operation of direct expansion solar assisted heat pump water heater[D]. Shanghai:Shanghai Jiao Tong University,2007.
[2] 高留花,赵军,高腾. 吸热板参数对平板太阳集热器热性能的影响[J]. 太阳能学报,2014(10):2054-2059. GAO L H,ZHAO J,GAO T. Effect of absorber plate parameter on thermal performance of flat plat solar collector[J]. Acta Energiae Solaris Sinica,2014(10):2054-2059.
[3] 李郁武,王如竹,王泰华,等. 直膨式太阳能热泵热水器热力性能分析及优化设计[J]. 太阳能学报,2007,28(5):464-471. LI Y W,WANG R Z,WANG T H,et al. Experimental performance analysis and optimization of a direct expansion solar assisted heat pump water heater[J]. Acta Energiae Solaris Sinica,2007,28(5):464-471.
[4] 梁子伟,简林桦,闫金州,等. PV/T集热器优化设计及实验[J]. 化工进展,2016,35(5):1326-1331. LIANG Z W,JIAN L H,YAN J Z,et al. Optimization design and experimental study on collector of photovoltaic/thermal[J]. Chemical Industry and Engineering Progress,2016,35(5):1326-1331.
[5] 徐国英,张小松,杨磊. 两种集热结构的太阳能光伏/光热一体化热泵性能分析[J]. 化工学报,2008,59(s2):224-229. XU G Y,ZHANG X S,YANG L. Performance evaluation of PV/T integrated heat pump using two different collector/evaporators[J]. CIESC Journal,2008,59(s2):224-229.
[6] HAWLADER M N A,CHOU S K,ULLAH M Z. The performance of a solar assisted heat pump water heating system[J]. Applied Thermal Engineering,2001,21(10):1049-1066.
[7] KONG X Q,ZHANG D,LI Y,et al. Thermal performance analysis of a direct-expansion solar-assisted heat pump water heater[J]. Energy,2011,36(12):6830-6838.
[8] XU G Y,ZHANG X S,DENG S M. A simulation study on the operating performance of a solar-air source heat pump water heater[J]. Applied Thermal Engineering,2006,26(11):1257-1265.
[9] 旷玉辉,王如竹. 直膨式太阳能热泵热水器的实验研究[J]. 工程热物理学报,2005,26(3):379-381. KUANG Y H,WANG R Z. Experimental study on the direct-expansion solar assisted heat-pump water heater[J]. Journal of Engineering Thermophysics,2005,26(3):379-381.
[10] 孔祥强,李俊枭,李瑛. 直膨式太阳能热泵热水器不同工质的性能分析[J]. 上海交通大学学报,2016,50(4):506-513. KONG X Q,LI J X,LI Y. Performance analysis of three different refrigerants in a direct-expansion solar-assisted heat pump water heater[J]. Journal of Shanghai Jiao Tong University,2016,50(4):506-513.
[11] 赵军,刘立平,李丽新,等. R134a应用于直接膨胀式太阳能热泵系统[J]. 天津大学学报,2000,33(3):302-305. ZHAO J,LIU L P,LI L X,et al. Investigation into the use of R134a in a direct expansion solar assisted heat pump[J]. Journal of Tianjin University,2000,33(3):302-305.
[12] CHATA F B G,CHATURVEDI S K,ALMOGBEL A. Analysis of a direct expansion solar assisted heat pump using different refrigerants[J]. Energy Conversion & Management,2005,46(15-16):2614-2624.
[13] LI S S,LI S H,ZHANG X S. Comparison analysis of different refrigerants in solar-air hybrid heat source heat pump water heater[J]. International Journal of Refrigeration,2015,57:138-146.
[14] LI S S,LI S H,ZHANG X S. Simulation research of a hybrid heat source heat pump using R134a,R744 instead of R22 for domestic water heating in residential buildings[J]. Energy & Buildings,2015,91:57-64.
[15] 李舒宏,张小松,杜凯,等. 太阳能与空气复合热源的储能型热泵装置:1580668[P]. 2005-02-16. LI S H,ZHANG X S,DU K,et al. Solar-air hybrid heat source energy storage heat pump device:1580668[P]. 2005-02-16.
[16] 徐国英,张小松. 太阳能-空气复合热源热泵热水器的性能模拟与分析[J]. 太阳能学报,2006,27(11):1148-1154. XU G Y,ZHANG X S. Analysis on the operating characteristics of solar-air source heat pump water heater[J]. Acta Energiae Solaris Sinica,2006,27(11):1148-1154.
[17] 张月红,徐国英,张小松. 太阳能与空气复合源热泵热水系统多模式运行实验特性[J]. 化工学报,2010,61(2):484-490. ZHANG Y H,XU G Y,ZHANG X S. Experimental characteristics of solar-air source heat pump water heating system operating in different modes[J]. CIESC Journal,2010,61(2):484-490.
[18] CHATURVEDI S K,CHEN D T,KHEIREDDINE A. Thermal performance of a variable capacity direct expansion solar-assisted heat pump[J]. Energy Conversion & Management,1998,39(3-4):181-191.
[19] 孙振华,王如竹,李郁武. 基于仿真与实验的直膨式太阳能热泵热水器变频策略[J]. 太阳能学报,2008,29(10):1235-1241. SUN Z H,WANG R Z,LI Y W. Variable frequency operation control strategy for DX-SAHPWH based on simulation and experiments[J]. Acta Energiae Solaris Sinica,2008,29(10):1235-1241.
[20] 徐国英,张小松. 复合热源热泵系统集热/蒸发器的模型[J].工程热物理学报,2006,27(s1):61-64. XU G Y,ZHANG X S. Simulation model of collector/evaporator for multi-source heat pump[J]. Journal of Engineering Thermophysics,2006,27(s1):61-64.

复合热源热泵热水器变工况运行特性分析

Analysis of the operating characteristics of hybrid heat sources:heat pump water heater under variable conditions

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	叶振东, 刘涵, 吕静, 张亚宁, 刘洪芝. 基于钙镁二元盐的热化学储能反应器的性能优化[J]. 化工进展, 2023, 42(8): 4307-4314.
[2]	李吉焱, 景艳菊, 邢郭宇, 刘美辰, 龙永, 朱照琪. 耐盐型太阳能驱动界面光热材料及蒸发器的研究进展[J]. 化工进展, 2023, 42(7): 3611-3622.
[3]	符淑瑢, 王丽娜, 王东伟, 刘蕊, 张晓慧, 马占伟. 析氧助催化剂增强光阳极光电催化分解水性能研究进展[J]. 化工进展, 2023, 42(5): 2353-2370.
[4]	杜涛, 马进伟, 陈茜茜, 方浩, 陈秉章, 陈厚仁. PV/T模块复合冷却模式性能对比测试与数值模拟分析[J]. 化工进展, 2023, 42(2): 722-730.
[5]	张赫, 李小可, 熊颖, 文劲. 基于水凝胶界面光蒸发的压裂返排液脱盐降污处理[J]. 化工进展, 2023, 42(2): 1073-1079.
[6]	韩丽, 李望良, 李艳香, 安高军, 鲁长波. 纤维状钙钛矿太阳能电池研究进展[J]. 化工进展, 2023, 42(10): 5135-5146.
[7]	毛停停, 李双福, 黄李茗铭, 周川玲, 韩凯. 面向水处理与有机溶剂回收的太阳能界面蒸发系统与材料[J]. 化工进展, 2023, 42(1): 178-193.
[8]	白浩良, 王晨, 卢静, 康雪. 聚光光伏系统太阳能电池散热技术及发展现状[J]. 化工进展, 2023, 42(1): 159-177.
[9]	寇佳伟, 程淑艳, 程芳琴. 类水滑石基催化剂光催化二氧化碳还原研究进展[J]. 化工进展, 2022, 41(S1): 190-198.
[10]	王泽鹏, 苑中显, 王洁, 文鑫, 刘一默. 硅胶粒径对太阳能吸附制冷系统性能的影响[J]. 化工进展, 2022, 41(7): 3545-3552.
[11]	何美莹, 岳学杰, 张涛, 邱凤仙. 红外辐射调控原理及其在热管理应用中的材料研究进展[J]. 化工进展, 2022, 41(7): 3719-3730.
[12]	马进伟, 方浩, 陈茜茜, 陈海飞, 童维维. 基于焓-熵-㶲平衡的无盖板PV/T系统热力学分析与优化[J]. 化工进展, 2022, 41(4): 1840-1847.
[13]	朱乔虹, 邢明阳, 张金龙. 光催化分解水制氢中硫化物空心结构的研究进展[J]. 化工进展, 2021, 40(9): 4774-4781.
[14]	王雅君, 张文灿, 李宇明, 姜桂元, 姚文清. 碳点用于光催化分解水制氢的研究进展[J]. 化工进展, 2021, 40(6): 2952-2961.
[15]	凌祥, 宋丹阳, 陈晓轶, 张志浩, 靳晓刚, 王燕. 钙基热化学储能体系装备与系统研究进展[J]. 化工进展, 2021, 40(4): 1777-1796.