流化床内粉煤气固流动特性的实验研究

doi:10.16085/j.issn.1000-6613.2016-2290

化工进展 ›› 2017, Vol. 36 ›› Issue (S1): 180-186.DOI: 10.16085/j.issn.1000-6613.2016-2290

流化床内粉煤气固流动特性的实验研究

屠功毅¹, 宗弘元¹, 钟思青¹, 徐俊¹, 周靖¹, 辛忠²

1. 中国石油化工股份有限公司上海石油化工研究院, 上海 201208;
2. 华东理工大学化工学院, 上海 200237

收稿日期:2016-12-09 修回日期:2016-12-28 出版日期:2017-12-31 发布日期:2017-12-13
作者简介:屠功毅(1987-),男,博士,工程师,研究方向为化工流体力学。E-mail:tgy19870426@163.com。

Experimental study on flow characteristics of gas-solid of powdered coal in a fluidized-bed

TU Gongyi¹, ZONG Hongyuan¹, ZHONG Siqing¹, XU Jun¹, ZHOU Jing¹, XIN Zhong²

1. Shanghai Research Institute of Petrochemical Technology, SINOPEC, Shanghai 201208, China;
2. School of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, China

Received:2016-12-09 Revised:2016-12-28 Online:2017-12-31 Published:2017-12-13

摘要/Abstract

摘要： 采用5种不同粒径分布的粉煤对流化床内粉煤气固两相流动形态和压力波动进行了实验研究。确定了不同操作参数下的流动形态，考察了不同操作条件对压力分布和压力波动的影响，采用了一种新方法——通过流化床底部相邻两点压差关于流态化气速的曲线来分析临界流态化速度，通过压力标准偏差最大值对应的流态化速度来确定起始湍动流态化速度，提出了临界流态化和起始湍动流态化雷诺数关于粉煤粒径的关系式，揭示了压力变化与流态演变的内在联系。结果表明，粉煤颗粒粒径越小，各流动形态的临界速度越小；当床内出现节涌流态化或湍动流态化时，细颗粒粉煤的压力波动较小，而粗颗粒粉煤的压力波动比较剧烈；流化床底部相邻两点压差和压力标准偏差均随着流态化速度的增大先增加后减小。

关键词: 流化床, 流态化, 流域, 粉体, 流体动力学

Abstract: The flow regimes and pressure fluctuations of powdered coal gas-solid two-phase flow in a fluidized-bed are experimentally studied by using five different particle size distributions of powdered coal.The flow patterns under different operating parameters are determined.The effects of different operating conditions on the pressure distribution and the pressure fluctuation are investigated.The critical fluidization velocity was analyzed by a new method, which is based on the curve of the pressure difference between two adjacent points at the bottom of the fluidized-bed.The initial turbulent fluidization velocity is determined by the fluidization velocity of the maximum value of the pressure standard deviation.The relation formulas between the Reynolds numbers of the critical fluidization and the initial turbulent fluidization on the particle size of powdered coal are proposed.The internal relation between the pressure variations and the evolution of the flow regimes is revealed.The results show that the smaller particle size of powdered coal is, the smaller critical velocity of each flow regime is.When slugging fluidization or turbulent fluidization occurs in fluidized-bed, the pressure fluctuation of fine powdered coal is slight, while the pressure fluctuation of coarse powdered coal is severe.The pressure difference between two adjacent points and pressure standard deviation at the bottom of the fluidized-bed increase first and then decrease with the increase of fluidization velocity.

Key words: fluidized-bed, fluidization, flow regime, powders, hydrodynamics

中图分类号:

TQ051

屠功毅, 宗弘元, 钟思青, 徐俊, 周靖, 辛忠. 流化床内粉煤气固流动特性的实验研究[J]. 化工进展, 2017, 36(S1): 180-186.

TU Gongyi, ZONG Hongyuan, ZHONG Siqing, XU Jun, ZHOU Jing, XIN Zhong. Experimental study on flow characteristics of gas-solid of powdered coal in a fluidized-bed[J]. Chemical Industry and Engineering Progress, 2017, 36(S1): 180-186.

参考文献

[1] ZHANG K,ZHANG J Y,ZHANG B J.Experimental and numerical study of fluid dynamic parameters in a jetting fluidized bed of a binary mixture[J].Powder Technology,2003,132(1):30-38.
[2] GUO Q J,YUE G X,ZHANG J Y,et al.Hydrodynamic characteristics of a two-dimensional jetting fluidized bed with binary mixtures[J].Chemical Engineering Science,2001,56(15):4685-4694.
[3] GUO Q J,ZHANG J Y,WERTHER J.Jetting transition velocity in a jetting fluidized bed with two nozzles[J]. Chemical Engineering Journal,2003,92(1):63-67.
[4] 朱治平.加压循环流化床的实验与模型研究[D].北京:中国科学院研究生院(工程热物理研究所),2008.
[5] 祝小龙,刘代俊,陈建钧.锥形流化床水平射流条件下的流化特性[J].化工进展,2014,33(2):328-332.
[6] 金保升,董长青,朱传宝,等.喷动流化床流动形态变化的试验研究[J].煤炭转化,2000,23(4):69-73.
[7] 付伍岭.煤的粒度对循环流化床工业锅炉运行的影响[J].化工进展,2009,28(6):1096-1097.
[8] 赵贵兵,陈纪忠,阳永荣.流化床压力脉动信号时间延迟相关性[J].化工学报,2002,53(12):1281-1286.
[9] BI H T.A critical review of the complex pressure fluctuation phenomenon in gas-solids fluidized beds[J].Chemical Engineering Science,2007,62(13):3473-3493.
[10] FAN L T,HO T C,HIROKA S,et al.Pressure fluctuations in a fluidized bed[J].AIChE Journal,1981,27(3):388-396.
[11] BI X T.Flow regime transitions in gas-solid fluidization and transport[D].Columbia:The University of British Columbia,1994.
[12] 付芝杰,赵跃民,骆振福,等.-0.5mm煤粉对空气重介质流化床流态化特性的影响[J].煤炭科学技术,2013,41(1):125-128.
[13] 金涌.流态化工程原理[M].北京:清华大学出版社,2001:39-40.
[14] 郭慕孙,李洪钟.流态化手册[M].北京:化学工业出版社,2008:150-173.
[15] YERUSHALMI J,CANKURT N T.Further studies of the regimes of fluidization[J].Powder Technology,1979,24(2):187-205.

流化床内粉煤气固流动特性的实验研究

Experimental study on flow characteristics of gas-solid of powdered coal in a fluidized-bed

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	黄益平, 李婷, 郑龙云, 戚傲, 陈政霖, 史天昊, 张新宇, 郭凯, 胡猛, 倪泽雨, 刘辉, 夏苗, 主凯, 刘春江. 三级环流反应器中气液流动与传质规律[J]. 化工进展, 2023, 42(S1): 175-188.
[2]	金涌, 程易, 白丁荣, 张晨曦, 魏飞. 中国流态化技术研发史略[J]. 化工进展, 2023, 42(6): 2761-2780.
[3]	章凯, 金捍宇, 刘思宇, 王帅. 鼓泡流态化气泡间相互作用下相间传质过程的模拟[J]. 化工进展, 2023, 42(6): 2828-2835.
[4]	袁守正, 陈啸, 蒋鸣, 余亚雄, 周强. 气固下行床中壁面对介尺度曳力的影响规律[J]. 化工进展, 2023, 42(5): 2272-2281.
[5]	张成松, 张静, 龚斌, 李明洋, 袁佳新, 李宏业. 自吸射流柔性搅拌桨振动特性[J]. 化工进展, 2023, 42(4): 1728-1738.
[6]	范昀培, 金晶, 刘敦禹, 王静杰, 刘秋祺, 许开龙. CaSO₄载氧体在煤气化化学链燃烧中的脱汞[J]. 化工进展, 2023, 42(3): 1638-1648.
[7]	闫兴清, 戴行涛, 喻健良, 李岳, 韩冰, 胡军. 高压氢气泄漏射流研究进展[J]. 化工进展, 2023, 42(3): 1118-1128.
[8]	邱沫凡, 蒋琳, 刘荣正, 刘兵, 唐亚平, 刘马林. 气固流化床化学反应数值模拟中颗粒尺度模型研究进展[J]. 化工进展, 2023, 42(10): 5047-5058.
[9]	刘美佳, 王刚, 张忠东, 何盛宝, 高金森. 石蜡基原油直接催化裂解制低碳烯烃新型炼化工艺的开发[J]. 化工进展, 2023, 42(10): 5191-5199.
[10]	范旭阳, 陈延信, 赵博, 张蕾蕾. 气体硫黄还原磷石膏制酸新工艺预还原数值模拟[J]. 化工进展, 2023, 42(10): 5414-5426.
[11]	沈天绪, 沈来宏. 基于3kW塔式串行流化床差异燃料的化学链燃烧解析[J]. 化工进展, 2023, 42(1): 138-147.
[12]	邓权龙, 丁厚成, 徐远迪, 蒋仲安, 杨岚, 孙雪霏. 表面活性雾滴联合金属网栅增效除尘[J]. 化工进展, 2023, 42(1): 546-552.
[13]	曹正凯, 米晓斌, 吴子明, 孙士可, 曹均丰, 彭德强, 梁相程. 煤合成气净化除尘装置压降问题分析及应用优化[J]. 化工进展, 2022, 41(S1): 15-21.
[14]	房科靖, 熊祖鸿, 鲁敏, 黎涛, 陈勇. 垃圾衍生燃料的制备、热转化特性及应用研究进展[J]. 化工进展, 2022, 41(S1): 132-140.
[15]	杨锋苓, 梁国林, 张翠勋, 王贵超. 疏水Rushton搅拌桨的减阻性能[J]. 化工进展, 2022, 41(9): 4682-4690.