Effect of O2/H2O/SO2 on the adsorption of PbCl2 by modified iron-rich attapulgite at high temperature

doi:10.16085/j.issn.1000-6613.2022-1188

Abstract

Abstract:

Modified iron-rich attapulgite was obtained by hydrochloric acid activation and Fe₃O₄ composite modification. The effect of O₂/H₂O/SO₂ on the adsorption of typical semi-volatile heavy metal PbCl₂ vapor was investigated in a high-temperature furnace. Meanwhile, the distribution and morphology of lead species in the adsorption products were analyzed. FTIR, BET, XRD and XPS were used to investigate the adsorption mechanism. The results showed that acid activation increased the proportion of surface-active sites by decomposing the impurities in raw ore. The dual active adsorption sites formed from the composite modification by iron-based oxides and attapulgite surface lattice oxygen significantly increased the adsorption capacity of PbCl₂. When the flue gas contained 20% O₂, 5% H₂O and 400mL/m³ SO₂, the PbCl₂ adsorption capacity of the modified attapulgite was significantly higher than that of the original attapulgite. The highest adsorption capacities of 70.42mg/g, 76.63mg/g and 86.21mg/g were achieved in Fe/HFP₂ sample with a loading mass ratio of 1∶2, respectively, better than kaolinite. Furthermore, the content of stable distributed Pb in the adsorption products using modified attapulgite under these atmospheres was higher than that of kaolinite, indicating the adsorption products were more stable.

Key words: lead chloride, adsorption, adsorbents, modification, iron-rich attapulgite, high temperature

摘要：

通过盐酸活化和负载Fe₃O₄复合改性方式获得改性富铁凹凸棒石，探究O₂/H₂O/SO₂对其吸附高温炉内典型半挥发性重金属PbCl₂蒸气的影响，同时分析了吸附产物中铅物种的分布形态，并结合FTIR、BET、XRD和XPS等表征手段深入探究其对PbCl₂蒸气的吸附机制。结果表明，酸活化通过分解原矿中杂质提高表面活性位点占比，复合改性后铁基氧化物与凹凸棒石表面晶格氧形成的双活性吸附位点显著增加其PbCl₂吸附容量。当高温烟气中含有体积分数20%O₂、5%H₂O和400mL/m³ SO₂时，复合改性凹凸棒石的PbCl₂吸附容量较原凹凸棒石有显著提升，在负载质量比为1∶2的Fe/HFP₂样品中吸附容量最高可分别达到70.42mg/g、76.63mg/g和86.21mg/g，吸附效果优于高岭土。此外，在这些氛围下改性凹凸棒石吸附产物中铅的稳定分布形态含量高于高岭土，吸附产物更为稳定。

关键词: 氯化铅, 吸附, 吸附剂, 改性, 富铁凹凸棒石, 高温

CLC Number:

X705

ZHAO Chongyang, ZHAO Lei, SHI Xiangwen, HUANG Jun, LI Zhiyao, SHEN Kai, ZHANG Yaping. Effect of O₂/H₂O/SO₂ on the adsorption of PbCl₂ by modified iron-rich attapulgite at high temperature[J]. Chemical Industry and Engineering Progress, 2023, 42(4): 2190-2200.

赵重阳, 赵磊, 石详文, 黄俊, 李治尧, 沈凯, 张亚平. O₂/H₂O/SO₂ 对改性富铁凹凸棒石高温吸附PbCl₂ 的影响[J]. 化工进展, 2023, 42(4): 2190-2200.

Figures/Tables 14

References 28

1	SHI T R, MA J, ZHANG Y Y, et al. Status of lead accumulation in agricultural soils across China (1979—2016) [J]. Environment International, 2019, 129: 35-41.
2	ZHANG J K, HUANG X J, CHEN Y, et al. Characterization of lead-containing atmospheric particles in a typical basin city of China: Seasonal variations, potential source areas, and responses to fireworks[J]. Science of the Total Environment, 2019, 661: 354-363.
3	CHEN L, ZHOU S L, WU S H, et al. Concentration, fluxes, risks, and sources of heavy metals in atmospheric deposition in the Lihe River watershed, Taihu region, Eastern China[J]. Environmental Pollution, 2019, 255: 113301.
4	AWUAL M R, ISLAM A, HASAN M M, et al. Introducing an alternate conjugated material for enhanced lead(Ⅱ) capturing from wastewater[J]. Journal of Cleaner Production, 2019, 224: 920-929.
5	GEORGE A, SHEN B X, KANG D G, et al. Emission control strategies of hazardous trace elements from coal-fired power plants in China[J]. Journal of Environmental Sciences, 2020, 93: 66-90.
6	YU S H, ZHANG C, MA L, et al. Deep insight into the effect of NaCl/HCl/SO₂/CO₂ in simulated flue gas on gas-phase arsenic adsorption over mineral oxide sorbents[J]. Journal of Hazardous Materials, 2021, 403: 123617.
7	YU S H, ZHANG C, MA L, et al. Geochemical mechanism of lead vapors over fly ash cenospheres in simulated flue gas[J]. Fuel, 2021, 285: 119274.
8	WANG J W, ZHANG Y S, WANG T, et al. Effect of modified fly ash injection on As, Se, and Pb emissions in coal-fired power plant[J]. Chemical Engineering Journal, 2020, 380: 122561.
9	WENDT J O, LEE S J. High-temperature sorbents for Hg, Cd, Pb, and other trace metals: Mechanisms and applications[J]. Fuel, 2010, 89(4): 894-903.
10	樊聪慧, 黄亚继, 夏志鹏, 等. 改性高岭土捕集CdCl₂、PbCl₂蒸气[J]. 化工进展, 2020, 39(4): 1558-1566.
	FAN Conghui, HUANG Yaji, XIA Zhipeng, et al. Adsorption capacity of modified kaolin for gaseous CdCl₂ and PbCl₂ [J]. Chemical Industry and Engineering Progress, 2020, 39(4): 1558-1566.
11	XU L, LIU Y N, WANG J G, et al. Selective adsorption of Pb²⁺ and Cu²⁺ on amino-modified attapulgite: Kinetic, thermal dynamic and DFT studies[J]. Journal of Hazardous Materials, 2021, 404: 124140.
12	WANG H F, HU W Y, WU Q M, et al. Effectiveness evaluation of environmentally friendly stabilizers on remediation of Cd and Pb in agricultural soils by multi-scale experiments[J]. Journal of Cleaner Production, 2021, 311: 127673.
13	XU Y S, LIU X W, WANG H, et al. Influences of in-furnace kaolin addition on the formation and emission characteristics of PM_2.5 in a 1000MW coal-fired power station[J]. Environmental Science & Technology, 2018, 52(15): 8718-8724.
14	LIU J Y, ZENG J J, SUN S Y, et al. Combined effects of FeCl₃ and CaO conditioning on SO₂, HCl and heavy metals emissions during the DDSS incineration[J]. Chemical Engineering Journal, 2016, 299: 449-458.
15	WANG X Y, HUANG Y J, PAN Z G, et al. Theoretical investigation of lead vapor adsorption on kaolinite surfaces with DFT calculations[J]. Journal of Hazardous Materials, 2015, 295: 43-54.
16	WANG X Y, HUANG Y J, ZHONG Z P, et al. Control of inhalable particulate lead emission from incinerator using kaolin in two addition modes[J]. Fuel Processing Technology, 2014, 119: 228-235.
17	JIAO F C, ZHANG L, YAMADA N, et al. Effect of HCl, SO₂ and H₂O on the condensation of heavy metal vapors in flue gas cooling section[J]. Fuel Processing Technology, 2013, 105: 181-187.
18	CHENG H Q, HUANG Y J, ZHU Z C, et al. Enhanced PbCl₂ adsorption capacity of modified kaolin in the furnace using a combined method of thermal pre-activation and acid impregnation[J]. Chemical Engineering Journal, 2021, 414: 128672.
19	ZHANG W Y, QIAN L B, CHEN Y, et al. Nanoscale zero-valent iron supported by attapulgite produced at different acid modification: Synthesis mechanism and the role of silicon on Cr(Ⅵ) removal[J]. Chemosphere, 2021, 267: 129183.
20	ZHANG T T, WANG W, ZHAO Y L, et al. Removal of heavy metals and dyes by clay-based adsorbents: from natural clays to 1D and 2D nano-composites[J]. Chemical Engineering Journal, 2021, 420: 127574.
21	WANG X Y, SUN G Z, CHENG Y, et al. Insight into the high-temperature adsorption of PbO/PbCl₂ by kaolinite: An experimental and DFT study on the role of H₂O/-OH[J]. Fuel, 2021, 305: 121596.
22	MA J F, ZOU J, LI L Y, et al. Nanocomposite of attapulgite-Ag₃PO₄ for Orange Ⅱ photodegradation[J]. Applied Catalysis B: Environmental, 2014, 144: 36-40.
23	LIU Y S, LIU P, SU Z X, et al. Attapulgite-Fe₃O₄ magnetic nanoparticles via co-precipitation technique[J]. Applied Surface Science, 2008, 255(5): 2020-2025.
24	BOUDRICHE L, CALVET R, HAMDI B, et al. Effect of acid treatment on surface properties evolution of attapulgite clay: An application of inverse gas chromatography[J]. Colloids and Surfaces A: Physicochemical and Engineering Aspects, 2011, 392(1): 45-54.
25	ZHU L X, GUO J S, LIU P, et al. Novel strategy for palygorskite/poly(acrylic acid) nanocomposite hydrogels from bi-functionalized palygorskite nanorods as easily separable adsorbent for cationic basic dye[J]. Applied Clay Science, 2016, 121: 29-35.
26	GAO D G, ZHANG Y H, LYU B, et al. Nanocomposite based on poly(acrylic acid)/attapulgite towards flame retardant of cotton fabrics[J]. Carbohydrate Polymers, 2019, 206: 245-253.
27	TANG J, MU B, ZONG L, et al. One-step synthesis of magnetic attapulgite/carbon supported NiFe-LDHs by hydrothermal process of spent bleaching earth for pollutants removal[J]. Journal of Cleaner Production, 2018, 172: 673-685.
28	PAN J M, XU L C, DAI J D, et al. Magnetic molecularly imprinted polymers based on attapulgite/Fe₃O₄ particles for the selective recognition of 2,4-dichlorophenol[J]. Chemical Engineering Journal, 2011, 174(1): 68-75.

样品	SiO₂	Al₂O₃	Na₂O	Fe₂O₃	TiO₂	MgO	CaO	K₂O	P₂O₅
高岭土	49.52	39.91	0.06	0.92	0.61	0.35	0.06	1.82	0.09
富铁凹凸棒石	48.31	15.39	1.54	7.31	1.13	3.83	11.20	4.16	0.28

样品	SiO₂	Al₂O₃	Na₂O	Fe₂O₃	TiO₂	MgO	CaO	K₂O	P₂O₅
高岭土	49.52	39.91	0.06	0.92	0.61	0.35	0.06	1.82	0.09
富铁凹凸棒石	48.31	15.39	1.54	7.31	1.13	3.83	11.20	4.16	0.28

样品	Fe(Ⅱ)/Fe(Ⅲ)（原子比）
Fe/HFP₂ - fresh	0.68
无O₂-Fe/HFP₂- adsorbed	0.47
10% O₂-Fe/HFP₂- adsorbed	0.42
20% O₂-Fe/HFP₂ - adsorbed	0.32
5% H₂O-Fe/HFP₂ - adsorbed	0.65
10% H₂O-Fe/HFP₂ - adsorbed	0.35

样品	Fe(Ⅱ)/Fe(Ⅲ)（原子比）
Fe/HFP₂ - fresh	0.68
无O₂-Fe/HFP₂- adsorbed	0.47
10% O₂-Fe/HFP₂- adsorbed	0.42
20% O₂-Fe/HFP₂ - adsorbed	0.32
5% H₂O-Fe/HFP₂ - adsorbed	0.65
10% H₂O-Fe/HFP₂ - adsorbed	0.35

样品	比表面积/m²·g^-1	孔体积/cm³·g^-1	平均孔径/nm
FP	86.49	0.15	8.21
HFP	187.78	0.27	6.68
Fe/HFP₄	168.97	0.43	11.81
Fe/HFP₃	160.22	0.43	12.70
Fe/HFP₂	144.48	0.49	14.15
Fe/HFP₁	133.75	0.43	14.83

Effect of O₂/H₂O/SO₂ on the adsorption of PbCl₂ by modified iron-rich attapulgite at high temperature

O₂/H₂O/SO₂ 对改性富铁凹凸棒石高温吸附PbCl₂ 的影响

RichHTML

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

Figures/Tables 14

References 28

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	WANG Jiaqing, SONG Guangwei, LI Qiang, GUO Shuaicheng, DAI Qingli. Rubber-concrete interface modification method and performance enhancement path [J]. Chemical Industry and Engineering Progress, 2023, 42(S1): 328-343.
[2]	CUI Shoucheng, XU Hongbo, PENG Nan. Simulation analysis of two MOFs materials for O₂/He adsorption separation [J]. Chemical Industry and Engineering Progress, 2023, 42(S1): 382-390.
[3]	CHEN Chongming, CHEN Qiu, GONG Yunqian, CHE Kai, YU Jinxing, SUN Nannan. Research progresses on zeolite-based CO₂ adsorbents [J]. Chemical Industry and Engineering Progress, 2023, 42(S1): 411-419.
[4]	XU Chunshu, YAO Qingda, LIANG Yongxian, ZHOU Hualong. Research progress on functionalization strategies of covalent organic frame materials and its adsorption properties for Hg(Ⅱ) and Cr(Ⅵ) [J]. Chemical Industry and Engineering Progress, 2023, 42(S1): 461-478.
[5]	GU Yongzheng, ZHANG Yongsheng. Dynamic behavior and kinetic model of Hg⁰ adsorption by HBr-modified fly ash [J]. Chemical Industry and Engineering Progress, 2023, 42(S1): 498-509.
[6]	GUO Qiang, ZHAO Wenkai, XIAO Yonghou. Numerical simulation of enhancing fluid perturbation to improve separation of dimethyl sulfide/nitrogen via pressure swing adsorption [J]. Chemical Industry and Engineering Progress, 2023, 42(S1): 64-72.
[7]	WANG Shengyan, DENG Shuai, ZHAO Ruikai. Research progress on carbon dioxide capture technology based on electric swing adsorption [J]. Chemical Industry and Engineering Progress, 2023, 42(S1): 233-245.
[8]	ZHU Jie, JIN Jing, DING Zhenghao, YANG Huipan, HOU Fengxiao. Modification of CaSO₄ oxygen carrier by Zhundong coal ash in chemical looping gasification and its mechanism [J]. Chemical Industry and Engineering Progress, 2023, 42(9): 4628-4635.
[9]	WANG Jingang, ZHANG Jianbo, TANG Xuejiao, LIU Jinpeng, JU Meiting. Research progress on modification of Cu-SSZ-13 catalyst for denitration of automobile exhaust gas [J]. Chemical Industry and Engineering Progress, 2023, 42(9): 4636-4648.
[10]	GE Yafen, SUN Yu, XIAO Peng, LIU Qi, LIU Bo, SUN Chengying, GONG Yanjun. Research progress of zeolite for VOCs removal [J]. Chemical Industry and Engineering Progress, 2023, 42(9): 4716-4730.
[11]	YANG Ying, HOU Haojie, HUANG Rui, CUI Yu, WANG Bing, LIU Jian, BAO Weiren, CHANG Liping, WANG Jiancheng, HAN Lina. Coal tar phenol-based carbon nanosphere prepared by Stöber method for adsorption of CO₂ [J]. Chemical Industry and Engineering Progress, 2023, 42(9): 5011-5018.
[12]	LI Xuejia, LI Peng, LI Zhixia, JIN Dunshang, GUO Qiang, SONG Xufeng, SONG Peng, PENG Yuelian. Experimental comparation on anti-scaling and anti-wetting ability of hydrophilic and hydrophobic modified membranes [J]. Chemical Industry and Engineering Progress, 2023, 42(8): 4458-4464.
[13]	CHEN Junjun, FEI Chang’en, DUAN Jintang, GU Xueping, FENG Lianfang, ZHANG Cailiang. Research progress on chemical modification of polyether ether ketone for the high bioactivity [J]. Chemical Industry and Engineering Progress, 2023, 42(8): 4015-4028.
[14]	JIANG Jing, CHEN Xiaoyu, ZHANG Ruiyan, SHENG Guangyao. Research progress of manganese-loaded biochar preparation and its application in environmental remediation [J]. Chemical Industry and Engineering Progress, 2023, 42(8): 4385-4397.
[15]	ZHANG Zhen, LI Dan, CHEN Chen, WU Jinglan, YING Hanjie, QIAO Hao. Separation and purification of salivary acids with adsorption resin [J]. Chemical Industry and Engineering Progress, 2023, 42(8): 4153-4158.