Adsorption performance of anionic azo dye by the modified MCM-41 mesoporous molecular sieve

doi:10.16085/j.issn.1000-6613.2016.01.044

Abstract

Abstract: The adsorption efficiency of the anionic azo dye (methyl red) on amino-modified ordered mesoporous silica (NH₃⁺-MCM-41) have been investigated. The research results indicate that the surface charge of MCM-41 are redistributed after the amino modification. By means of the electrostatic effect, the adsorption efficiency of methyl red on NH₃⁺-MCM-41 was 90.4% which was 1.1 times more than that on the unmodified MCM-41. The pH value of the solution determines the surface charge of NH₃⁺-MCM-41 and then affects the adsorption efficiency, and the optimal pH value is 4. The impurity ions in the methyl red solution also influence the adsorption efficiency through competitive adsorption. When the solution contains only Cl^- and NO₃^-, there is little effect on the adsorption efficiency. But when the solution contains the weak acid anion with high valence, such as CO₃^2- and HPO₄^2-, the adsorption efficiency is greatly reduced and there is no methyl red adsorbed. Through the adsorption kinetics study, the adsorption rate is quasi second order rather than quasi first order, indicating the presence of chemical adsorption, which involves electron sharing or electron transfer between the agent and the adsorbate.

Key words: adsorption, methyl red, moleclar sieves, surface charge

摘要： 制备了改性介孔分子筛NH₃⁺-MCM-41,研究了其对阴离子偶氮染料甲基红的吸附效果。研究表明,通过氨基改性使介孔分子筛MCM-41表面电荷发生改变,从而利用静电吸附作用改善了脱除效果,使甲基红吸附率提高了1.1倍,达到90.4%。溶液pH值的改变会影响NH₃⁺-MCM-41的表面电荷,从而影响吸附效率,其最佳pH值为4。溶液中的杂质离子均会对吸附产生影响,当溶液中含有Cl^-、NO₃^-时,对吸附效果影响不大;而当溶液中含有CO₃^2-和HPO₄^2-等高价弱酸根离子时,对吸附效果影响很大,基本不吸附染料。此外,通过其吸附动力学研究发现,吸附过程中不符合准一级动力学模型,而较好符合准二级动力学,说明在该过程中存在化学吸附,这种化学吸附涉及吸附剂与吸附质之间的电子共用或电子转移。

关键词: 吸附, 甲基红, 分子筛, 表面电荷

CLC Number:

QUAN Shanshan, ZHU Yuchan, REN Zhanhai, XI Teng, LU Mingzhu, REN Zhandong. Adsorption performance of anionic azo dye by the modified MCM-41 mesoporous molecular sieve[J]. Chemical Industry and Engineering Progree, 2016, 35(01): 320-326.

全姗姗, 朱玉婵, 任占海, 郗腾, 鲁明珠, 任占冬. 改性MCM-41分子筛对阴离子偶氮染料的吸附作用机理[J]. 化工进展, 2016, 35(01): 320-326.

References

[1] ALOTHMAN Z A,UNSAL Y E,HABILA M,et al. Membrane filtration of Sudan orange G on a cellulose acetate membrane filter for separation-preconcentration and spectrophotometric determination in water,chili powder,chili sauce and tomato sauce samples[J]. Food Chem. Toxicol.,2012,50(8):2709-2713.
[2] SAHOO C,GUPTA A K,ANJALI P. Photocatalytic degradation of Methyl Red dye in aqueous solutions under UV irradiation using Ag⁺ doped TiO₂[J]. Desalination,2005,181(1/3):91-100.
[3] LACHHEB H,PUZENAT E,HOUAS A,et al. Photocatalytic degradation of various types of dyes (Alizarin S,Crocein Orange G, Methyl Red,Congo Red,Methylene Blue) in water by UV-irradiated titania[J]. Appl. Catal. B,2002,39(1):75-90.
[4] EMILIA RIOS-DEL TORO E.,CELIS L B,CERVANTES F J,et al. Enhanced microbial decolorization of methyl red with oxidized carbon fiber as redox mediator[J]. J. Hazard. Mater.,2013,260:967-974.
[5] AYED L,MAHDHI A,CHEREF A,et al. Decolorization and degradation of azo dye Methyl Red by an isolated Sphingomonas paucimobilis:biotoxicity and metabolites characterization[J]. Desalination,2011,274(1/3):272-277.
[6] ANJANYEULU Y,SREEDHARA CHARY N,SAMUEL SUMAN RAJ D. Decolourization of industrial effluents-available methods and emerging technologies——a review[J]. Rev. Environ. Sci. Biotechnol.,2005,4(4):245-273.
[7] RAI H S,BHATTACHARYYA M S,SINGH J,et al. Removal of dyes from the effluent of textile and dyestuff manufacturing industry:a review of emerging techniques with reference to biological treatment[J]. Crit. Rev. Environ. Sci. Technol.,2005,35(3):219-238.
[8] GALENDA A,CROCIANI L,EL HABRA N,et al. Effect of reaction conditions on methyl red degradation mediated by boron and nitrogen doped TiO₂[J]. Appl. Surf. Sci.,2014,314:919-930.
[9] BADR Y,ABD EI-WAHED M G,MAHMOUD M A. Photocatalytic degradation of methyl red dye by silica nanoparticles[J]. J. Hazard. Mater.,2008,154:245-253.
[10] SINGH N K,SAHA S,PAL A. Solar light-induced photocatalytic degradation of methyl red in an aqueous suspension of commercial ZnO:a green approach[J]. Desalination and Water Treatment,2015, 53(2):501-514.
[11] XIAN T,YANG H,WANG Y F,et al. Visible-light photocatalysis of LSMO-graphene nanocomposites toward degradation of methyl red[J]. Mater. Trans.,2014,55(2):245-248.
[12] HANKARE P P,PATIL R P,JADHAV A V,et al. Enhanced photocatalytic degradation of methyl red and thymol blue using titania-alumina-zinc ferrite nanocomposite[J]. Appl. Catal. B-Environ.,2011,107(3/4):333-339.
[13] CHEBLI D,FOURCADE F,BROSILLON S,et al. Supported photocatalysis as a pre-treatment prior to biological degradation for the removal of some dyes from aqueous solutions; Acid Red 183, Biebrich Scarlet,Methyl Red Sodium Salt,Orange II[J]. J. Chem. Technol. Biotechnol.,2010,85(4):555-563.
[14] GHAEDI M,SHOKROLLAHI A,TAVALLALI H,et al. Activated carbon and multiwalled carbon nanotubes as efficient adsorbents for removal of arsenazo(Ⅲ) and methyl red from waste water[J]. Toxicological & Environmental Chemistry,2011,93(3):438-449.
[15] HALDORAI Y,SHIM J J. An efficient removal of methyl orange dye from aqueous solution by adsorption onto chitosan/MgO composite:a novel reusable adsorbent[J]. Appl. Surf. Sci.,2014,292:447-453.
[16] TAVARES M G,V.A. DA SILVA L,SALES SOLANO A M,et al. Electrochemical oxidation of Methyl Red using Ti/Ru_0.3Ti_0.7O₂ and Ti/Pt anodes[J]. Chem. Eng. J.,2012,204-206:141-150.
[17] DADFARNIA S,SHABANI A M H,MORADI S E,et al. Methyl red removal from water by iron based metal-organic frameworks loaded onto iron oxide nanoparticle adsorbent[J]. Appl. Surf. Sci.,2015, 330:85-93.
[18] IOANNOU Z,KARASAVVIDIS C,DIMIRKOU A,et al. Adsorption of methylene blue and methyl red dyes from aqueous solutions onto modified zeolites[J]. Water Sci. Technol.,2013,67(5):1129-1136.
[19] SANTHI T,MANONMANI S,SMITHA T. Removal of methyl red from aqueous solution by activated carbon prepared from the Annona squmosa seed by adsorption[J]. Chem. Eng. Res. Bull.,2010,14(1):11-18.
[20] KAUR S,RANI S,MAHAJANA R K,et al. Synthesis and adsorption properties of mesoporous material for the removal of dye safranin:kinetics,equilibrium,and thermodynamics[J]. J. Ind. Eng. Chem., 2015,22:19-27.
[21] XIAO X C,ZHANG F,FENG Z P,et al. Adsorptive removal and kinetics of methylene blue from aqueous solution using NiO/MCM-41 composite[J]. Physica E:Low-dimensional Systems and Nanostructures,2015,65:4-12.
[22] SHAO Y M,WANG X,KANG Y,et al. Application of Mn/MCM-41 as an adsorbent to remove methyl blue from aqueous solution[J]. J. Colloid Interf. Sci.,2014,429:25-33.
[23] HAN B Q,ZHANG F,FENG Z P,et al. A designed Mn₂O₃/MCM-41 nanoporous composite for methylene blue and rhodamine B removal with high efficiency[J]. Ceram. Int.,2014,40(6):8093-8101.
[24] YANG S X,WU Y H,WU Y Y,et al. Optimizing decolorization of Acid Fuchsin and Acid Orange II solution by MnO₂ loaded MCM-41[J]. J. Taiwan Inst. Chem. E.,2015,50:205-214
[25] QIN Q D, MA J, LIU K. Adsorption of anionic dyes on ammonium-functionalized MCM-41[J]. J. Hazard. Mater.,2009,162(1):133-139.
[26] YOKOI T,TATSUMI T,YOSHITAKE H. Fe³⁺ coordinated to amino-functionalized MCM-41:an adsorbent for the toxic oxyanions with high capacity,resistibility to inhibiting anions,and reusability after a simple treatment[J]. J. Colloid Interf. Sci.,2004,274:451-457.