光催化环己烷选择氧化合成环己酮/环己醇催化研究进展

doi:10.16085/j.issn.1000-6613.2019-1696

摘要/Abstract

摘要：

环己烷选择性氧化合成环己醇/酮具有重要工业价值，工业上热氧化路线反应温度高、副反应多、转化率低、选择性不高，亟需条件更温和、更环保的替代路线。以太阳光为驱动的光催化环己烷氧化路线可在常温常压下实现环己烷的选择性氧化，受到极大关注。本文综述了近10年来光催化环己烷选择性氧化催化体系、反应机理和反应影响因素的研究情况，对光催化环己烷选择性氧化催化循环中环己烷分子活化、环己酮/醇形成、活性自由基再生的基元过程和催化剂失活机理进行总结和分析；对影响光催化环己烷选择性氧化的反应参数进行深入分析和讨论；指出·OH为主要的活性自由基，环己基过氧化氢是重要的中间产物，环己酮/醇主要通过环己基过氧化氢的光催化分解形成，光辐射条件（光强和波长）、溶剂、催化剂结构和表面性质都是光催化环己烷选择性氧化的重要影响因素。最后指出光催化环己烷选择性氧化规模化应用的关键是进一步提高光催化剂的寿命和稳定性以及设计结构合理、高效利用光能的光催化反应装置。

关键词: 环己烷, 选择性, 催化剂, 活性自由基, 光化学

Abstract:

The selective oxidation of cyclohexane to cyclohexanone/ol is an industrially important process. The industrial thermal oxidation route has some disadvantages such as harsh reaction conditions, inevitable side reactions, low conversion of cyclohexane and low selectivity of cyclohexanone and cyclohexanol, which demands the development of alternative route that is more mild and environmentally friendly. The photocatalytic cyclohexane oxidation driven by sunlight can take place at normal temperature and pressure, and hence has attracted great attention. In this paper, the progress on the catalytic system, reaction mechanism and influencing factors of the photocatalytic selective oxidation of cyclohexane in last decade are reviewed. The research results on the element procedures of cyclohexane activation, cyclohexanone/ol formation and active radical regeneration as well as on the deactivation mechanism of catalysts were summarized and analyzed. In addition, the reaction parameters affecting the photocatalytic selective oxidation of cyclohexane were also analyzed and discussed in depth. It was found that ·OH was the main active radical, and cyclohexyl peroxide was the important intermediate. Cyclohexanone/alcohol was formed mainly through the photocatalytic decomposition of cyclohexyl peroxide. The light radiation parameters (incident light intensity and wavelength range), solvent and the structural and surficial properties of the catalysts are important factors affecting the reaction efficiency. Finally, it is pointed out that the key to the large-scale application of photocatalytic cyclohexane oxidation is to further improve the life and stability of the photocatalyst and to design a photocatalytic reaction device with reasonable structure and highly efficient utilization of light energy.

Key words: cyclohexane, selectivity, catalyst, active radical, photochemistry

中图分类号:

O643.31

佟占鑫, 石亮, 彭超, 李成宇, 秦弘宇, 陈丽娟, 向育君. 光催化环己烷选择氧化合成环己酮/环己醇催化研究进展[J]. 化工进展, 2020, 39(8): 3066-3076.

Zhanxin TONG, Liang SHI, Chao PENG, Chengyu LI, Hongyu QIN, Lijuan CHEN, Yujun XIANG. Progress in photocatalytic selective oxidation of cyclohexane to cyclohexanone/cyclohexanol[J]. Chemical Industry and Engineering Progress, 2020, 39(8): 3066-3076.

参考文献

1	薛晓金, 孙琼, 王妍, 等. 氟离子对二氧化钛选择性光催化氧化环己烷的影响[J]. 化学学报, 2010, 68(6): 471-475.
1	XUE Xiaojin, SUN Qiong, WANG Yan, et al. Effect of fluoride ions on the selective photocatalytic oxidatin of cyclohexane over TiO₂[J]. Acta Chimica Sinica, 2010, 68(6): 471-475.
2	乔涛. 四面体钛基光催化氧化环己烷与环己烯的研究[D]. 长沙: 湖南师范大学, 2016.
2	QIAO Tao. Study tetrahedral carbon-bsaed photocatalytic oxidation of cyclohexane and cyclohexanol[D]. Changsha: Hunan Normal University, 2016.
3	张利梅. 新型铬系催化剂的制备及可见光催化环己烷氧化性能研究[D]. 北京: 中国石油大学(北京), 2016.
3	ZHANG Limei. The preparation of new chromium catalysts and their catalytic performance of photocatalytic cyclohexane oxidation[D]. Beijing: China University of Petroleum(Beijing),2016.
4	SCHUCHARDT U, CARDOSO D, SERCHELI R, et al. Cyclohexane oxidation continues to be a challenge[J]. Applied Catallysis A: General, 2001, 211: 1-17.
5	穆金城, 谷晓庆, 宋华. 催化氧化环己烷合成环己酮最新进展[J]. 精细石油化工进展, 2010, 11(6): 9-14.
5	MU Jincheng, GU Xiaoqing, SONG Hua. The latest progress on catalytic oxidation of cyclohexane to cyclohexanone[J]. Advances in Fine Petrochemicals, 2010, 11(6): 9-14.
6	肖业鹏. 基于纳米银改性的两种新型二维材料催化环己烷氧化的研究[D]. 广州: 广东工业大学, 2018.
6	XIAO Yepeng. Oxideation of cyclohexane catayzed by two kind of novel 2D nano-materials based on nano silver modification[D]. Guangzhou: Guangdong University of Technology,2018.
7	ALMEIDA R A, MOULIJIN J A, MUL G. In situ ATR-FTIR study on the selective photo-oxidation of cyclohexane over anatase TiO₂[J]. Journal of Physical Chemistry C, 2008, 112(5): 1552-1561.
8	ALMEIDA A R, MOULIJIN J A, MUL G. Photocatalytic oxidation of cyclohexane over TiO₂: evidence for a Mar-Van Krevelen mechanism[J]. Journal of Physical Chemistry C, 2011, 115(4):1330-1338.
9	ALMEIDA A R, BERGER R, MOULIJIN J A, et al. Photo-catalytic oxidation of cyclohexane over TiO₂: a novel interpretation of temperature dependent performance[J]. Physical Chemistry Chemical Physics, 2011, 13(4):1345-1355.
10	CAMEIRO J T, ALMEIDA A R, MOULIJIN J A, et al. Cyclohexane selective photocatalytic oxidation by anatase TiO₂: influence of particle size and crystallinity[J]. Physical Chemistry Chemical Physics, 2010, 12(11): 2744-2750.
11	CARNEIRO J T, MOULIJIN J A, MUL G. Photocatalytic oxidation of cyclohexane by titanium dioxide: catalyst deactivation and regeneration[J]. Journal of Catalysis, 2010, 273(2):199-210.
12	HERNáNDEZ-ALONSO M D, ALMEIDA A R, MOULIJIN J A, et al. Identification of the role of surface acidity in the deactivation of TiO₂ in the selective photo-oxidation of cyclohexane[J]. Catalysis Today, 2009, 143(3): 326-333.
13	ALMEIDA A R, CARNEIRO J T, MOULIJIN J A, et al. Improved performance of TiO₂ in the selective photo-catalytic oxidation of cyclohexane by increasing the rate of desorption through surface silylation[J]. Journal of Catalysis, 2010, 273(2): 116-124.
14	DU P, MOULIJIN J A, MUL G. Selective photo(catalytic)-oxidation of cyclohexane: effect of wavelength and TiO₂ structure on product yields[J]. Journal of Catalysis, 2006, 238(2): 342-352.
15	HATTORI H, IDE Y, OGO S, et al. Efficient and selective photocatalytic cyclohexane oxidation on a layered titanate modified with iron oxide under sunlight and CO₂ atmosphere[J]. ACS Catalysis, 2012, 2(9): 1910-1915.
16	YANG D X, WU T B, CHEN C J, et al. The highly selective aerobic oxidation of cyclohexane to cyclohexanone and cyclohexanol over V₂O₅@TiO₂ under simulated solar light irradiation[J]. Green Chemistry, 2017, 18: 311-318.
17	ZHAO X X, ZHANG Y, WEN P, et al. NH₂-MIL-125(Ti)/TiO₂ composites as superior visible-light photocatalysts for selective oxidation of cyclohexane[J]. Molecular Catalysis, 2018, 452:175-183.
18	SHIRAISHI Y, SHIOTA S, HIRAKAWA H, et al. Titanium dioxide/reduced graphene oxide hybrid photocatalysts for efficient and selective partial oxidation of cyclohexane[J]. ACS Catalysis, 2017, 7: 293-300.
19	SHIRAISHI Y, OHARA H, HIRAI T. Visible light-induced partial oxidation of cyclohexane on hydrophobically modified chromium-containing mesoporous silica with molecular oxygen[J]. Journal of Catalysis, 2008, 254(2): 365-373.
20	SHIRAISHI Y, OHARA H, HIRAI T. Hydrophobic Cr-Si mixed oxides as catalyst for visible light-induced partial oxidation of cyclohexane[J]. New Journal of Chemistry, 2010, 34(12): 2841-2846.
21	TERAMURA K, TANAKA T, KANI M, et al. Selective photo-oxidation of neat cyclohexane in the liquid phase over V₂O₅ /Al₂O₃[J]. Journal of Molecular Catalysis A: Chemical, 2004, 208(1): 299-305.
22	TERAMURA K, TANAKA T, OHUCHI T, et al. Study of the reaction mechanism of selective photooxidation of cyclohexane over V₂O₅/Al₂O₃[J]. Journal of Physical Chemistry C, 2009, 113(39):17018-17024.
23	SHIRAISHI Y, TESHIMA Y, HIRAI T. Visible light-induced selective oxidation of cyclohexane to cyclohexanone on Cr-Si binary oxide with molecular oxygen[J]. Chemical Communications, 2005 (36):4569-4571.
24	TSUKAMOTO D, SHIRO A, SHIRAISHI Y, et al. Visible-light-induced partial oxidation of cyclohexane by Cr/Ti/Si ternary mixed oxides with molecular oxygen[J]. Journal of Physical Chemistry C, 2011, 115(40):19782-19788.
25	ZHONG W Z, QIAO T, DAI J, et al. Visible-light-responsive sulfated vanadium-doped TS-1 with hollow structure: enhanced photocatalytic activity in selective oxidation of cyclohexane[J]. Journal of Catalysis, 2015, 330: 208-221.
26	WANG H, ZHANG Y, ZHANG L, et al. Synthesis of C-N dual-doped Cr₂O₃ visible light-driven photocatalyst derived from metal organic framework (MOF) for cyclohexane oxidation[J]. RSC Advances, 2016, 6: 84871-84881.
27	IDE Y, IWATA M, YAGENJI Y, et al. Fe oxide nanoparticles/Ti-modified mesoporous silica as a photo-catalyst for efficient and selective cyclohexane conversion with O₂ and solar light[J]. Journal of Materials Chemistry A, 2016, 4(41):15829-15835.
28	TSUNOJI N, IDE Y, YAGENJI Y, et al. Design of layered silicate by grafting with metal acetylacetonate for high activity and chemoselectivity in photooxidation of cyclohexane[J]. ACS Applied Materials & Interfaces, 2014, 6(7):4616-21.
29	TANG S, WU W, FU Z, et al. Vanadium-substituted tungstophosphoric acids as efficient catalysts for visible-light-driven oxygenation of cyclohexane by dioxygen[J]. ChemCatChem, 2015, 7(17): 2637-2645.
30	TANG S, SHE J, FU Z, et al. Study on the formation of photoactive species in XPMo_12-_nV_nO₄₀-HCl system and its effect on photocatalysis oxidation of cyclohexane by dioxygens under visible light irradiation[J]. Applied Catalysis B: Environmental, 2017, 214:89-99.
31	ZHANG Y L, HU L L, ZHAO S Y, et al. Ag₃PW₁₂O₄₀/C₃N₄ nanocomposites as an efficient photocatalyst for hydrocarbon selective oxidation[J]. RSC Advances, 2016, 6: 60394-60399.
32	FUKUZUMI S, KOTANI H, OHKUBO K, et al. Electron-transfer state of 9-mesityl-10-methylacridinium ion with a ucmh longer lifetime and higher energy than that of the natural photosynthetic reaction center[J]. Journal of the American Chemical Society, 2004, 126(6):1600-1601.
33	OHKUBO K, KOTANI H, FUKUZUMI S. Misleading effects of impurities derived from the extremely long-lived electron-transfer state of 9-mesityl-10-methylacridinium ion[J]. Chemical Communications, 2005(36): 4520-4522.
34	OHKUBO K, FUJIMOTO A, FUKUZUMI S. Metal-free oxygenation of cyclohexane with oxygen catalyzed by 9-mesityl-10-methylacridinium and hydrogen chloride under visible light irradiation[J]. Chemical Communications, 2011, 47(30): 8515-8517.
35	SHIMIZU K I, MURATA Y, SATSUMA A. Dicopper(II)-dioxygen complexes in Y zeolite for selective catalytic oxidation of cyclohexane under photoirradiation[J]. The Journal of Physical Chemistry C, 2007, 111(51):19043-19051.
36	ZHANG Y L, HU L L, ZHU C, et al. Air activation by metal-free photocatalyst for “total-green” hydrocarbon selective oxidation [J]. Catalysis Science ＆Technology, 2016, 6: 7252-7258.
37	龙丹, 周俊伶, 时洪民, 等. 氧化亚铜光催化剂性能提升及增强机制的研究进展[J]. 化工进展, 2019, 38(6): 2756-2767.
37	LONG Dan, ZHOU Junling, SHI Hongmin,et al. Research progress on the improved performance of cuprous oxide photocatalyst and its enhancement mechanism[J]. Chemical Industry and Engineering Progress, 2019, 38(6): 2756-2767.
38	黄文迪, 孙静, 申婷婷,等. Co-BiVO₄异质结光催化剂的制备及其性能[J]. 化工进展, 2017, 36(11): 4080-4086.
38	HUANG Wendi, SUN Jing, SHEN Tingting, et al. Preparation and properties of Co-doped BiVO₄ heterojunction photocatalysts fabricated by hydrothermal method[J]. Chemical Industry and Engineering Progress, 2017, 36(11): 4080-4086.
39	刘文芳, 周汝利, 王燕子. 光催化剂TiO₂改性的研究进展[J]. 化工进展, 2016, 35(8): 2446-2454.
39	LIU Wenfang, ZHOU Ruli, WANG Yanzi. Research progress on modification of TiO₂ photocatalyst[J]. Chemical Industry and Engineering Progress, 2016, 35(8): 2446-2454.
40	GOMATHI D L, KAVITHA R. A review on plasmonic metal-TiO₂ composite for generation, trapping, storing and dynamic vectorial transfer of photogenerated electrons across the Schottky junction in a photocatalytic system[J]. Applied Surface Science, 2016, 360: 601-622.
41	HOU W, CRONIN S B. A review of surface plasmon resonance-enhanced photocatalysis[J]. Advanced Functional Materials, 2013, 23(13):1612-1619.
42	KRAVETS V G, KABASHIN A V, BARNES W L, et al. Plasmonic surface lattice resonances: a review of properties and applications[J]. Chemical Reviews, 2018, 118(12): 5912-5951.
43	XIAO Y P, LIU J C, LIN Y T, et al. Novel graphene oxide-silver nanorod composites with enhanced photocatalytic performance under visible light irradiation[J]. Journal of Alloy and Compounds, 2017, 698: 170-177.
44	MAI J J, FANG Y X, LIU J C, et al. Simple synthesis of WO₃-Au composite and their improved photothermal synergistic catalytic performance for cyclohexane oxidation[J]. Molecular Catalysis, 2019, 473: 110389.
45	LIU J, LIU R, LI H, et al. Au nanoparticles in carbon nanotubes with high photocatalytic activity for hydrocarbon selective oxidation[J]. Dalton Transactions, 2014, 43(34):12982-12988.
46	QIAO S, FAN B H, YANG Y M, et al. Copper nanoparticle/carbon quantum dots hybrid as green photocatalyst for high-efficiency oxidation of cyclohexane[J]. RSC Advance, 2015, 172: 1782-1789.
47	LIU R, HUANG H, LI H, et al. Metal nanoparticle/carbon quantum dot composite as a photocatalyst for high-efficiency cyclohexane oxidation[J]. ACS Catalysis, 2014, 4(1): 328-336.
48	MURCIA J J, HIDALGO M C, NAVíO J A, et al. Cyclohexane photocatalytic oxidation on Pt/TiO₂ catalysts[J]. Catalysis Today, 2013, 209(15): 164-169.
49	LIU J, YANG Y M, LIU N Y, et al. Total photocatalysis conversion from cyclohexane to cyclohexanone by C₃N₄/Au nanocomposites[J]. Green Chemistry, 2014, 16(10): 4559-4565.
50	CARNEIRO J T, SAVENIJE T J, MOULIJIN J A, et al. The effect of Au on TiO₂ catalyzed selective photocatalytic oxidation of cyclohexane[J]. Journal of Photochemistry & Photobiology A: Chemistry, 2011, 217(2/3): 326-332.
51	MAYANI V J, MAYANI S V, SANG W K. Palladium, gold, and gold-palladium nanoparticle-supported carbon materials for cyclohexane oxidation[J]. Chemical Engineering Communications, 2016, 203(4):539-547.
52	MOHAMED M M. Gold loaded titanium dioxide-carbon nanotube composites as active photocatalysts for cyclohexane oxidation at ambient conditions[J]. RSC Advance, 2015, 5: 46405-46414.
53	SHIRAISHI Y, SUGANO Y, ICHIKAWA S, et al. Visible light-induced partial oxidation of cyclohexane on WO₃ loaded with Pt nanoparticles[J]. Catalysis Science & Technology, 2012, 2(2): 400-405.
54	ICHIHASHI Y, SAIJO S, TANIGUCHI M, et al. Study of cyclohexane photooxidation over Pt-WO₃ catalysts mixed with TiO₂ under visible light irradiation[J]. Materials Science Forum, 2010, 658: 149-152.
55	BOARINI P, CARASSITI V, MALDOTTI A, et al. Photocatalytic oxygenation of cyclohexane on titanium dioxide suspensions: effect of the solvent and of oxygen[J]. Langmuir, 1998, 14: 2080-2085.
56	XIANG L P, FAN J J, ZHONG W Z, et al. Heteroatom-induced band-reconstruction of metal vanadates for photocatalytic cyclohexane oxidation towards KA-oil selectivity[J]. Applied Catalysis A: General, 2019, 575: 120-131.
57	WU W F, HE X L, FU Z H, et al. Metal chlorides catalyzed selective oxidation of cyclohexane by molecular oxygen under visible irradiation[J]. Journal of Catalysis, 2012, 286: 6-12.
58	BRUSA M A, GRELA M A. Photon flux and wavelength effects on the selectivity and product yields of the photocatalytic air oxidation of neat cyclohexane on TiO₂particles[J]. The Journal of Physical Chemistry B, 2005, 109(5): 1914-1918.
59	SHE J, FU Z, LI J, et al. Visible light-triggered vanadium-substituted molybdophosphoric acids to catalyze liquid phase oxygenation of cyclohexane to KA oil by nitrous oxide[J]. Applied Catalysis B:Environmental, 2016, 182: 392-404.
60	CARNEIRO J T, YANG C C, MOULIJIN J A, et al. The effect of water on the performance of TiO₂ in photocatalytic selective alkane oxidation[J]. Journal of Catalysis, 2011, 277(2): 129-133.
61	DIJK V H A V, SIMMELINK G, MUL G. The influence of water vapour on the photocatalytic oxidation of cyclohexane in an internally illuminated monolith reactor[J]. Applied Catalysis A: General, 2014, 470: 63-71.

[1]	张明焱, 刘燕, 张雪婷, 刘亚科, 李从举, 张秀玲. 非贵金属双功能催化剂在锌空气电池研究进展[J]. 化工进展, 2023, 42(S1): 276-286.
[2]	时永兴, 林刚, 孙晓航, 蒋韦庚, 乔大伟, 颜彬航. 二氧化碳加氢制甲醇过程中铜基催化剂活性位点研究进展[J]. 化工进展, 2023, 42(S1): 287-298.
[3]	谢璐垚, 陈崧哲, 王来军, 张平. 用于SO₂去极化电解制氢的铂基催化剂[J]. 化工进展, 2023, 42(S1): 299-309.
[4]	杨霞珍, 彭伊凡, 刘化章, 霍超. 熔铁催化剂活性相的调控及其费托反应性能[J]. 化工进展, 2023, 42(S1): 310-318.
[5]	王乐乐, 杨万荣, 姚燕, 刘涛, 何川, 刘逍, 苏胜, 孔凡海, 朱仓海, 向军. SCR脱硝催化剂掺废特性及性能影响[J]. 化工进展, 2023, 42(S1): 489-497.
[6]	李化全, 王明华, 邱贵宝. 硫酸酸解钙钛矿相精矿的行为[J]. 化工进展, 2023, 42(S1): 536-541.
[7]	邓丽萍, 时好雨, 刘霄龙, 陈瑶姬, 严晶颖. 非贵金属改性钒钛基催化剂NH₃-SCR脱硝协同控制VOCs[J]. 化工进展, 2023, 42(S1): 542-548.
[8]	程涛, 崔瑞利, 宋俊男, 张天琪, 张耘赫, 梁世杰, 朴实. 渣油加氢装置杂质沉积规律与压降升高机理分析[J]. 化工进展, 2023, 42(9): 4616-4627.
[9]	王晋刚, 张剑波, 唐雪娇, 刘金鹏, 鞠美庭. 机动车尾气脱硝催化剂Cu-SSZ-13的改性研究进展[J]. 化工进展, 2023, 42(9): 4636-4648.
[10]	王鹏, 史会兵, 赵德明, 冯保林, 陈倩, 杨妲. 过渡金属催化氯代物的羰基化反应研究进展[J]. 化工进展, 2023, 42(9): 4649-4666.
[11]	张启, 赵红, 荣峻峰. 质子交换膜燃料电池中氧还原反应抗毒性电催化剂研究进展[J]. 化工进展, 2023, 42(9): 4677-4691.
[12]	王伟涛, 鲍婷玉, 姜旭禄, 何珍红, 王宽, 杨阳, 刘昭铁. 醛酮树脂基非金属催化剂催化氧气氧化苯制备苯酚[J]. 化工进展, 2023, 42(9): 4706-4715.
[13]	葛亚粉, 孙宇, 肖鹏, 刘琦, 刘波, 孙成蓥, 巩雁军. 分子筛去除VOCs的研究进展[J]. 化工进展, 2023, 42(9): 4716-4730.
[14]	朱传强, 茹晋波, 孙亭亭, 谢兴旺, 李长明, 高士秋. 固体高分子脱硝剂选择性非催化还原NO _x 特性[J]. 化工进展, 2023, 42(9): 4939-4946.
[15]	毛善俊, 王哲, 王勇. 基团辨识加氢：从概念到应用[J]. 化工进展, 2023, 42(8): 3917-3922.