多层喷雾洗涤塔对粉尘颗粒的脱除特性

doi:10.16085/j.issn.1000-6613.2016-2148

化工进展 ›› 2017, Vol. 36 ›› Issue (07): 2375-2380.DOI: 10.16085/j.issn.1000-6613.2016-2148

多层喷雾洗涤塔对粉尘颗粒的脱除特性

张立栋¹, 李晓博¹, 王擎¹, 秦宏¹, 崔达²

1 东北电力大学油页岩综合利用教育部工程研究中心, 吉林吉林 132012;
2 吉林吉顺油页岩开发有限公司, 吉林吉林 132012

收稿日期:2016-11-21 修回日期:2017-01-25 出版日期:2017-07-05 发布日期:2017-07-05
通讯作者: 张立栋(1980-),男,博士,副教授,主要研究方向为油页岩综合利用及回转装置混合与分离。
作者简介:张立栋(1980-),男,博士,副教授,主要研究方向为油页岩综合利用及回转装置混合与分离。E-mail:nedu1015@aliyun.com。
基金资助:
教育部长江学者和创新团队发展计划（IRT13052）、吉林省自然科学基金（20150101033JC）、吉林市科技计划（201464044）及吉教科合字2015-237项目。

Performance of dust removal in a multi-layer spray column scrubber

ZHANG Lidong¹, LI Xiaobo¹, WANG Qing¹, QIN Hong¹, CUI Da²

1 Engineering Research Center of Ministry of Education for Comprehensive Utilization of Oil Shale, Northeast Electric Power University, Jilin 132012, Jilin, China;
2 Jishun Oil Shale Development Co., Ltd., Jilin 132012, Jilin, China

Received:2016-11-21 Revised:2017-01-25 Online:2017-07-05 Published:2017-07-05

摘要/Abstract

摘要： 通过搭建多层喷雾洗涤塔实验台，研究了液气体积比、塔内气体平均流速、粉尘浓度、喷雾压力等操作参数对除尘效率的影响规律。研究结果表明：洗涤塔内喷雾层数对除尘效率的影响最为显著，与传统的单层相比，除尘效率可以提高15%以上，并且入口粉尘浓度的变化对其除尘效率的影响较小。增大喷雾压力可以有效提升除尘效率，当喷雾压力为0.5~0.6MPa时除尘效率变化趋于稳定。在相同操作参数下，适当降低气体在塔内平均流速有利于提高洗涤塔的除尘效率，对于三层喷雾洗涤，最佳的气体塔内平均流速为0.6~0.8m/s。当喷雾压力为0.6MPa、塔内气体平均气速为0.6m/s、液气体积比为5.27的条件下，三层喷雾除尘的效率可以达到98.3%。

关键词: 喷雾洗涤塔, 粉尘颗粒, 脱除, 湿法除尘

Abstract: An experimental device was built up to study the dust removal characteristics in multi-layer spray column scrubber.The operating parameters which influence dust removal efficiency were analyzed,such as volume ratio of liquid to gas,average velocity of gas in column,inlet dust loading and spray pressure.The results showed that the spray layer have most significant influence to dust removal.The efficiency of three-layer column scrubber increased by more than 15% compared with the traditional washing tower,and inlet dust loading have little impact on it.Increasing spray pressure can enhance the efficiency of dust removal obviously.When spray pressure is 0.5-0.6MPa,the dust removal efficiency will be stable.Under the same operating parameters,reducing the average velocity of gas in scrubber will help to improve dust removal efficiency.For the three-layer column scrubber,the best average velocity of gas is 0.6-0.8m/s.In this experiment,dust removal efficiency can reach 98.3% in three-layer spray column scrubber,when spray pressure is 0.6MPa,the average velocity of gas in column is 0.6m/s,and volume ratio of liquid to gas is 5.27.

Key words: sprayer column scrubber, fine particles, dust removal, wet scrubber

中图分类号:

TQ515

张立栋, 李晓博, 王擎, 秦宏, 崔达. 多层喷雾洗涤塔对粉尘颗粒的脱除特性[J]. 化工进展, 2017, 36(07): 2375-2380.

ZHANG Lidong, LI Xiaobo, WANG Qing, QIN Hong, CUI Da. Performance of dust removal in a multi-layer spray column scrubber[J]. Chemical Industry and Engineering Progress, 2017, 36(07): 2375-2380.

参考文献

[1] WANG W S,HUANG S D,ZOU J L. The present situation and policy suggestion of clean coal technology in China[J]. Advanced Materials Research,2013,616:1120-1123.
[2] 芮素生,成玉琪,叶显彬. 中国煤炭开发利用现状与发展清洁煤技术[J]. 煤炭学报,1994,19(4):333-342. RUI S S,CHENG Y Q,YE X B. Status of coal mining and utilization in China and development of clean coal technology[J]. Journal of China Coal Society,1994,19(4):333-342.
[3] LI A J,LI Z. General equilibrium analysis of development clean and low-carbonized coal-fired power technologies in China[J]. Advanced Materials Research,2012,347:1127-1131.
[4] 中华人民共和国国家统计局,中国环境保护局. 中国环境统计年鉴2007[M]. 北京:中国统计出版社,2007:29-31. NBSC,NBEC. Environmental statistical yearbook of China 2007[M]. Beijing:Statistics of China Press,2007:29-31.
[5] 詹水芬,张晓春,马春. 基于环境保护与燃烧品质双重考虑的煤炭分类研究[J]. 煤炭学报,2009,34(11):1535-1539. ZHAN S F,ZHANG X C,MA C. Coal classification based on environmental protection and burning quality[J]. Journal of China Coal Society,2009,34(11):1535-1539.
[6] 白志鹏,张文杰,韩斌,等. 我国环境空气颗粒物质量基准研究框架及研究体系的构建[J]. 环境科学研究,2015,28(5):667-675. BAI Z P,ZHANG W J,HAN B,et al. Framework and research system for determining air quality criteria for particulate matter in China[J]. Research of Environmental Sciences,2015,28(5):667-675.
[7] ZHANG X Y,WANG Y Q,NIU T,et al. Atmospheric aerosol compositions in China:spatial/temporal variability,chemical signature,regional haze distribution and comparisons withglobal aerosols[J]. Atmospheric Chemistry and Physics,2012,12:779-799.
[8] 宋国君,韩允垒,何雅琪,等. 中国污染物排放标准实施评估[J]. 环境工程技术学报,2011,1(3):275-280. SONG G J,HAN Y L,HE Y Q,et al. Evaluation on implementation of China's emission standards[J]. Journal of Environmental Engineering Technology,2011,1(3):275-280.
[9] 杨洪斌,邹旭东,汪宏宇,等. 大气环境中PM_2.5的研究进展与发展[J]. 气象与环境工程学报,2012,28(3):77-82. YANG H B,ZOU X D,WANG H Y,et al. Study progress on PM_2.5 in atmosphere environment[J]. Journal of Meteorology and Environment,2012,28(3):77-82.
[10] 王珲,宋蔷,姚强. 电厂湿法脱硫系统对烟气中细颗粒物脱除作用的实验研究[J]. 中国电机工程学报,2008,28(5):1-7. WANG H,SONG Q,YAO Q. Experimental study on removal effect of wet fluegas desulfurization system on fine particles from a coal-fired power plant[J]. Proceedings of the CESS,2008,28(5):1-7.
[11] 鲍静静,杨林军,颜金培,等. 湿法烟气脱硫系统对细颗粒脱除性能的实验研究[J]. 化工学报,2009,60(5):1260-1267. BAO J J,YANG L J,YAN J P,et al. Performance of removal of fine particles by WFGD system[J]. CIESC Journal,2009,60(5):1260-1267.
[12] 孙露娟,杨林军,张霞,等. 洗涤塔脱除燃烧源超细颗粒的实验研究[J]. 化工学报,2008,59(6):1508-1514. SUN L J,YANG L J,ZHANG X,et al. Removal of fine particles from combustion by condensation scrubbing[J]. CIESC Journal,2008,59(6):1508-1514.
[13] 王洁. 声波团聚及联合其他方法脱除燃煤飞灰细颗粒的研究[D]. 杭州:浙江大学,2012. WANG J. Study of combined acoustic agglomeration with other means to remove coal-fired fine particles[D]. Hangzhou:Zhejiang University,2012.
[14] 曾卓雄,姜培正,谢蔚明. 喷嘴雾化粒径的实验研究[J]. 西安交通大学学报,2000,34(4):75-77. ZENG Z X,JIANG P Z,XIE W M. Investigation of atomizer particle diameter[J]. Journal of Xi'anjiaotong University,2000,34(4):75-77.
[15] DULLIEN F A L,SPINK D R. Waste treatment and utilization:theory and practice of waste management[M]. Ontario:Pergamon Press,1978:487-508.
[16] MOHAN B R,BISWAS S,MEIKAP B C. Performance characteristics of the particulates scrubbing in a counter-current spray-column[J]. Separation and Purification Technology,2008,61(1):96-102.
[17] AMITAVA B,MANINDRA N B. Particulate scrubbing in high-velocity water sprays[J]. Journal of Chemical Engineering of Japan,2000,33(3):514-518.
[18] 程卫民,聂文,周刚,等. 煤矿高压喷雾雾化粒度的降尘性能研究[J]. 中国矿业大学学报,2011,40(2):185-189. CHENG W M,NIE W,ZHOU G,et al. Study of dust suppression by atomized water from high-pressure sprays in mines[J]. Journal of China University of Mining & Technology,2011,40(2):185-189.
[19] 程卫民,周刚,左前明,等. 喷嘴喷雾压力与雾化粒度关系的研究[J]. 煤炭学报,2010,35(8):1308-1313. CHENG W M,ZHOU G,ZUO Q M,et al. Experimental research on the relationship between nozzle spray pressure and atomization particle size[J]. Journal of China Coal Society,2010,35(8):1309-1313.
[20] 熊桂龙,杨桂林,颜金培,等. 对喷嘴协同蒸汽相变对燃煤细颗粒脱除性能的影响[J]. 中国电机工程学报,2011,31(32):39-45. XIONG G L,YANG G L,YAN J P,et al. Removal of fine particles from coal combustion by combined impinging streams and heterogeneous condensation[J]. Proceedings of the CESS,2011,31(32):39-45.
[21] 上官炬,常丽萍,苗茂谦. 气体净化分离技术[M]. 北京:化学工业出版社,1991. SHANGGUAN J,CHANG L P,MIAO M Q. Gas purification and separation technology[M]. Beijing:Chemical Industry Press,1991.
[22] 中华人民共和国国家质量监督检验检疫总局,中国国家标准化管理委员会. 火电厂大气污染物排放标准:GB 13223-2011[S]. 北京:中国环境科学出版社,2011. General Administration of Quality Supervision,Inspection and Quarantine of the People's Republic of China,Standardization Administration of the People's Republic of China. Emission standard of air pollutants for thermal power plants:GB 13223-2011[S]. Beijing:China Environmental Science Press,2011.
[23] 崔灵,笹辺修司,清水健司,等. 粉体流动性及喷流行测量方法及应用[J]. 中国粉体技术,2012,18(1):72-77. CUI L,SASABE S,SHIMIZU K,et al. Development and application for measuring method of powder flowability and floodability[J]. China Powder Science and Technology,2012,18(1):72-77.
[24] 颜金培,杨林军,沈湘林. 燃煤源PM_2.5微粒润湿性能[J]. 东南大学学报(自然科学版),2006,36(5):760-764. YAN J P,YANG L J,SHEN X L. Wettability of PM_2.5 from combustion[J]. Journal of Southeast University(Natural Science Edition),2006,36(5):760-764.
[25] ELPERIN I T,MELTSER V L,LEVENTAL L E,et al. Influence of solid particles concentration on their motion in impinging jets[J]. Proceedings of the Academy of BBSSR Senes of Physical-Energy Science,1971(4):66-74.
[26] BEIG S A,GONG M. Test of mathematical modeling for the design of high energy scrubbers[J]. Atomspheric Environment,1977,11:911-915.
[27] MEIKAP B C,KUNDU G. Prediction of the interfacial area of contact in a variable area multi-stage bubble column[J]. Industrial & Engineering Chemistry Research,2001,40(26):6194-6200.
[28] 张龙龙,安泽文,姜旭,等. 团聚液雾化气泡粒径分布特性的可视化研究[J]. 化工进展,2016,35(10):3086-3091. ZHANG L L,AN Z W,JIANG X,et al. Visualization study of reunion liquid atomization bubble size distribution characteristics[J]. Chemical Industry and Engineering Progress,2016,35(10):3086-3091.
[29] LI G B,CAO J M,LI M L,et al. Experimental study on the size distribution characteristics of spray droplets of DME/diesel blended fuels[J]. Fuel Processing Technology,2012,104:352-355.
[30] 李兆东,王世和,王晓明,等.湿法脱硫旋流喷嘴雾化粒径空间分布规律[J]. 化工学报,2007,58(4):1007-1012. LI Z D,WANG S H,WANG X M,et al. Atomized particle size spatial distribution of fluegas wet desulfurization swirl nozzle[J]. CIESC Journal,2007,58(4):1007-1012.

多层喷雾洗涤塔对粉尘颗粒的脱除特性

Performance of dust removal in a multi-layer spray column scrubber

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	邵博识, 谭宏博. 锯齿波纹板对挥发性有机物低温脱除过程强化模拟分析[J]. 化工进展, 2023, 42(S1): 84-93.
[2]	贺山明, 潘界昌, 徐国钻, 李文君, 梁勇. 粗钨酸钠溶液亚铁盐沉淀法除铬、钒的热力学分析及实验验证[J]. 化工进展, 2023, 42(4): 2171-2179.
[3]	袁礼, 王学谦, 李翔, 王郎郎, 马懿星, 宁平, 熊亦然. 催化脱除钢铁副产煤气中COS和H₂S的研究进展[J]. 化工进展, 2023, 42(10): 5147-5161.
[4]	张辛亥, 赵思琛, 朱辉, 王凯, 张首石. 活性碳纤维负载型脱硫剂在矿井气体环境条件下的应用[J]. 化工进展, 2022, 41(S1): 415-423.
[5]	李兴, 黄宏宇, 大坂侑吾, 呼和涛力, 肖林发, 李军. 碳材料吸附脱除二氧化硫性能的影响因素[J]. 化工进展, 2022, 41(9): 4963-4972.
[6]	高天, 张伊黎, 熊卓, 赵永椿, 张军营. 改性氧化钛光催化氧化单质汞性能及其影响因素研究进展[J]. 化工进展, 2022, 41(2): 690-700.
[7]	陈沛坤, 张袁斌, 崔希利, 邢华斌. 氨气深度脱除材料与技术研究进展[J]. 化工进展, 2021, 40(7): 3957-3975.
[8]	宋峥元, 孙国刚, 祖泽辉, 王中原. 耦合热泵的FCC脱硫湿烟气脱白净化及余热回收系统设计分析[J]. 化工进展, 2021, 40(12): 6934-6940.
[9]	许浩洁, 王军锋, 王东保, 张伟, 姚江. 新型湿法除尘系统内气液两相流动的数值模拟[J]. 化工进展, 2020, 39(9): 3590-3599.
[10]	李歌, 王宝冬, 马子然, 赵春林, 周佳丽, 王红妍. 烟气多污染物协同处理催化陶瓷过滤管的研究进展[J]. 化工进展, 2020, 39(8): 3307-3319.
[11]	赵珂, 宁平, 李凯, 孙鑫, 宋辛, 王驰. Mn/Cu-BTC催化剂同时脱硫脱硝实验研究[J]. 化工进展, 2020, 39(5): 1784-1791.
[12]	王龙, 刘会娥, 于云飞, 王娩, 刘宇童, 陈爽, 王彬. 槐糖脂用于含油砂质土壤处理及石油资源回收[J]. 化工进展, 2020, 39(5): 1930-1937.
[13]	魏永久,张月,郭雨生,王春波,白涛. 喷淋鼓泡塔内氨水对烟气中As₂O₃的吸收特性[J]. 化工进展, 2020, 39(3): 834-841.
[14]	顾慧劼, 李磊, 叶丽萍, 黄河, 罗勇, 金政伟. 低温深度脱除液相丙烯中微量CO的CuO(y)/Cu_xCe_1-_xO_δ催化剂表征分析及性能实验[J]. 化工进展, 2020, 39(12): 5104-5111.
[15]	刘露, 骆嘉钦, 阚青, 马晓迅. 乙醇胺对介质阻挡耦合电晕放电同时脱除NO、SO₂的影响[J]. 化工进展, 2020, 39(11): 4685-4692.