膨胀石墨/石蜡复合相变材料的导电及发热特性

doi:10.16085/j.issn.1000-6613.2021-0636

化工进展 ›› 2022, Vol. 41 ›› Issue (2): 892-900.DOI: 10.16085/j.issn.1000-6613.2021-0636

膨胀石墨/石蜡复合相变材料的导电及发热特性

周涛涛¹(), 熊志波¹(), 吴志根²^,³(), 李尚¹

^1.上海理工大学能源与动力工程学院，上海 200093
^2.同济大学环境与科学工程学院，上海 200092
^3.上海污染控制与生态安全研究院，上海 200092

收稿日期:2021-03-29 修回日期:2021-05-14 出版日期:2022-02-05 发布日期:2022-02-23
通讯作者: 熊志波,吴志根
作者简介:周涛涛（1996—），男，硕士研究生，研究方向为相变蓄热。E-mail：ztt1898@163.com。
基金资助:
国家自然科学基金(51106112);上海杨帆计划(18YF1418000);国家重点研发计划(2019YFC1805204);上海理工大学科技发展项目(2019KJFZ196)

Characters of electric resistance and heating of expanded graphite/paraffin composite phase change materials

ZHOU Taotao¹(), XIONG Zhibo¹(), WU Zhigen²^,³(), LI Shang¹

^1.School of Energy and Power Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China
^2.College of Environmental Science and Engineering, Tongji University, Shanghai 200092, China
^3.Shanghai Institute of Pollution Control and Ecological Security, Shanghai 200092, China

Received:2021-03-29 Revised:2021-05-14 Online:2022-02-05 Published:2022-02-23
Contact: XIONG Zhibo,WU Zhigen

摘要/Abstract

摘要：

采用混合搅拌方法制备膨胀石墨（EG）/石蜡复合相变材料，测试分析了EG含量、施加电压与EG/石蜡复合相变材料体积电阻率的关系，研究了直接自发热和正温度系数（PTC）电阻发热时复合相变蓄热单元的发热特性。结果表明，随着EG含量或施加电压的增大，复合相变材料体积电阻率逐渐减小；施加电压对样品体积电阻率的影响与复合相变材料中EG含量有关，EG含量越高，施加电压对复合相变材料体积电阻率的影响越明显。当施加电压为4.0V时，EG质量分数分别为4%、5%、8%的复合相变材料体积电阻率分别只有0.5V时的0.481倍、0.185倍、0.068倍。基于复合相变材料导电特性，直接负载电压可实现复合相变材料电热转化和相变蓄热；结合PTC电阻发热可灵活控制复合相变蓄热单元加热功率，实现其快速充热。

关键词: 复合相变材料, 相变蓄热, 膨胀石墨, 电阻率, 自发热

Abstract:

Expanded graphite/paraffin composite phase change materials were prepared by blending method using expanded graphite and paraffin. The effects of EG content and voltage on the volume resistivity of EG/paraffin composites were investigated. The electrothermal properties of EG/paraffin composites unit were also studied under direct heating and positive temperature coefficient (PTC) resistance heating. The results showed that volume resistivity of composite decreased with the increase of EG content and voltage. The effect of voltage on the volume resistivity of composite was related to EG content and the higher EG content was, the more obvious the effect was. The volume resistivity of 4%, 5% and 8% EG/paraffin composites at 4.0V voltage was 0.481 times, 0.185 times and 0.068 times of that at 0.5V voltage, respectively. Both direct load voltage and PTC resistance heating can realize electrothermal conversion and heat storage. The heating power of the composite unit can be controlled flexibly by combining PTC resistance heating, which can realize rapid heat charging.

Key words: composite phase change materials, phase change heat storage, expanded graphite, resistivity, direct heating

中图分类号:

TK02

周涛涛, 熊志波, 吴志根, 李尚. 膨胀石墨/石蜡复合相变材料的导电及发热特性[J]. 化工进展, 2022, 41(2): 892-900.

ZHOU Taotao, XIONG Zhibo, WU Zhigen, LI Shang. Characters of electric resistance and heating of expanded graphite/paraffin composite phase change materials[J]. Chemical Industry and Engineering Progress, 2022, 41(2): 892-900.

图/表 1

参考文献 27

1	ZHANG S S, XU K, JOW T R. The low temperature performance of Li-ion batteries[J]. Journal of Power Sources, 2003, 115(1): 137-140.
2	郎春艳. 低温环境下锂离子电池组热管理系统研究[D]. 广州: 华南理工大学, 2016.
	LANG Chunyan. A study on the performance of lithium-ion battery pack thermal management system in case of low-temperature[D]. Guangzhou: South China University of Technology, 2016.
3	WU W X, YANG X Q, ZHANG G Q, et al. Experimental investigation on the thermal performance of heat pipe-assisted phase change material based battery thermal management system[J]. Energy Conversion and Management, 2017, 138: 486-492.
4	YAN J J, LI K, CHEN H D, et al. Experimental study on the application of phase change material in the dynamic cycling of battery pack system[J]. Energy Conversion and Management, 2016, 128: 12-19.
5	RAO Z H, WANG S F, ZHANG Y L. Thermal management with phase change material for a power battery under cold temperatures[J]. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 2014, 36(20): 2287-2295.
6	CHEN J W, KANG S Y, E J Q, et al. Effects of different phase change material thermal management strategies on the cooling performance of the power lithium ion batteries: a review[J]. Journal of Power Sources, 2019, 442: 227228.
7	邹得球, 马先锋, 刘小诗, 等. 石墨烯在相变材料中的研究进展[J]. 化工进展, 2017, 36(5): 1743-1754.
	ZOU Deqiu, MA Xianfeng, LIU Xiaoshi, et al. Research progress on graphene in phase change materials[J]. Chemical Industry and Engineering Progress, 2017, 36(5): 1743-1754.
8	ZHOU M, LIN T Q, HUANG F Q, et al. Highly conductive porous graphene/ceramic composites for heat transfer and thermal energy storage[J]. Advanced Functional Materials, 2013, 23(18): 2263-2269.
9	胡小冬, 高学农, 李得伦, 等. 石蜡/膨胀石墨定形相变材料的性能[J]. 化工学报, 2013, 64(10): 3831-3837.
	HU Xiaodong, GAO Xuenong, LI Delun, et al. Performance of paraffin/expanded graphite composite phase change materials[J]. CIESC Journal, 2013, 64(10): 3831-3837.
10	姜贵文, 黄菊花. 膨胀石墨/石蜡复合材料的制备及热管理性能[J]. 材料工程, 2017, 45(7): 41-47.
	JIANG Guiwen, HUANG Juhua. Preparation and thermal management of expanded graphite/paraffin composite for Li-ion battery[J]. Journal of Materials Engineering, 2017, 45(7): 41-47.
11	刘臣臻, 张国庆, 王子缘, 等. 膨胀石墨/石蜡复合材料的制备及其在动力电池热管理系统中的散热特性[J]. 新能源进展, 2014, 2(3): 233-238.
	LIU Chenzhen, ZHANG Guoqing, WANG Ziyuan, et al. Preparation of expanded graphite/paraffin composite materials and their heat dissipation characteristics in power battery thermal management system[J]. Advances in New and Renewable Energy, 2014, 2(3): 233-238.
12	HU X S, ZHENG Y S, HOWEY D A,et al. Battery warm-up methodologies at subzero temperatures for automotive applications: recent advances and perspectives[J]. Progress in Energy and Combustion Science, 2020, 77: 100806.
13	ZHONG G J, ZHANG G Q, YANG X Q, et al. Researches of composite phase change material cooling/resistance wire preheating coupling system of a designed 18650-type battery module[J]. Applied Thermal Engineering, 2017, 127: 176-183.
14	HE F Q, LI X X, ZHANG G Q, et al. Experimental investigation of thermal management system for lithium ion batteries module with coupling effect by heat sheets and phase change materials[J]. International Journal of Energy Research, 2018, 42(10): 3279-3288.
15	张叶龙, 宋鹏飞, 周伟, 等. 基于复合相变储热材料的电热储能系统[J]. 储能科学与技术, 2017, 6(6): 1250-1256.
	ZHANG Yelong, SONG Pengfei, ZHOU Wei, et al. Electrical heating systems with heat storage using composite phase change materials[J]. Energy Storage Science and Technology, 2017, 6(6): 1250-1256.
16	WU W H, HUANG X Y, LI K, et al. A functional form-stable phase change composite with high efficiency electro-to-thermal energy conversion[J]. Applied Energy, 2017, 190: 474-480.
17	LI C C, ZHANG B, LIU Q X. N-eicosane/expanded graphite as composite phase change materials for electro-driven thermal energy storage[J]. Journal of Energy Storage, 2020, 29: 101339.
18	TABASSUM H, HUANG X Y, CHEN R J, et al. Tailoring thermal properties via synergistic effect in a multifunctional phase change composite based on methyl stearate[J]. Journal of Materiomics, 2015, 1(3): 229-235.
19	LI Z, SUN W G, WANG G, et al. Experimental and numerical study on the effective thermal conductivity of paraffin/expanded graphite composite[J]. Solar Energy Materials and Solar Cells, 2014, 128: 447-455.
20	WANG Q Q, ZHOU D, CHEN Y M, et al. Characterization and effects of thermal cycling on the properties of paraffin/expanded graphite composites[J]. Renewable Energy, 2020, 147: 1131-1138.
21	曹庆超, 黄安平, 张维, 等. 碳基材料掺杂聚合物导电特性研究进展[J]. 高分子材料科学与工程, 2012, 28(4): 177-181.
	CAO Qingchao, HUANG Anping, ZHANG Wei, et al. Progress in conductive properties of carbon-based doped polymer[J]. Polymer Materials Science & Engineering, 2012, 28(4): 177-181.
22	李大军, 严长浩, 鲁萍, 等. 膨胀石墨/聚酯导电复合材料的制备与导电行为[J]. 复合材料学报, 2008, 25(1): 35-39.
	LI Dajun, YAN Changhao, LU Ping, et al. Preparation and conductive behavior of expanded graphite/poly(ethylene terephthalate) conductive composites[J]. Acta Materiae Compositae Sinica, 2008, 25(1): 35-39.
23	郭文敏. 聚乙烯/无机填料复合材料非线性电导特性及机理研究[D]. 哈尔滨: 哈尔滨理工大学, 2010.
	GUO Wenmin. Research on non-linear conductive characteristics and mechanisms of polymer composites filled with inorganic filler[D]. Harbin: Harbin University of Science and Technology, 2010.
24	WU K, XUE Y, YANG W X, et al. Largely enhanced thermal and electrical conductivity via constructing double percolated filler network in polypropylene/expanded graphite—Multi-wall carbon nanotubes ternary composites[J]. Composites Science and Technology, 2016, 130: 28-35.
25	ZHANG Y A, UMAIR M M, ZHANG S F, et al. Phase change materials for electron-triggered energy conversion and storage: a review[J]. Journal of Materials Chemistry A, 2019, 7(39): 22218-22228.
26	JI H X, SELLAN D P, PETTES M T, et al. Enhanced thermal conductivity of phase change materials with ultrathin-graphite foams for thermal energy storage[J]. Energy & Environmental Science, 2014, 7(3): 1185-1192.
27	王青青, 范鹏远, 陈玉明, 等. 膨胀石墨/石蜡复合相变材料热-电特性实验研究[J]. 塑料工业, 2018, 46(9): 129-133, 137.
	WANG Qingqing，FAN Pengyuan, CHEN Yuming, et al. Experimental study on the thermo-physical and electrical properties of paraffin/expanded graphite composite phase change materials[J]. China Plastics Industry, 2018, 46(9): 129-133, 137.

[1]	汤磊, 曾德森, 凌子夜, 张正国, 方晓明. 相变蓄冷材料及系统应用研究进展[J]. 化工进展, 2023, 42(8): 4322-4339.
[2]	杨喆, 刘飞, 张涛, 邓兴, 张正文. TPMS多孔铝-石蜡复合相变材料蓄热过程数值模拟及实验[J]. 化工进展, 2022, 41(9): 4918-4927.
[3]	熊鑫, 苏庆宗, 农增耀, 王亚雄. 加热方式对管壳式相变蓄热单元强化传热的可视化及数值模拟[J]. 化工进展, 2022, 41(9): 4635-4643.
[4]	朱孟帅, 王子龙, 孙向昕, 周翔. 高孔密度下泡沫铜的填充率对石蜡融化传热机理的影响[J]. 化工进展, 2022, 41(6): 3203-3211.
[5]	罗明昀, 凌子夜, 方晓明, 张正国. 基于相变储热技术的电池热管理系统研究进展[J]. 化工进展, 2022, 41(3): 1594-1607.
[6]	禹兴海, 唐海慰, 李艳安, 韩玉琦, 闵雪梅. 一种光、电驱动的生物炭/硬脂酸复合相变材料的制备及其性能[J]. 化工进展, 2022, 41(11): 5936-5945.
[7]	尹少武, 康鹏, 韩嘉维, 张朝, 王立, 童莉葛. 基于相变材料的锂离子电池热管理性能[J]. 化工进展, 2022, 41(10): 5518-5529.
[8]	舒钊, 钟珂, 肖鑫, 贾洪伟, 吕凤勇, 常沙. 多孔纳米基复合相变材料在建筑节能中的应用进展[J]. 化工进展, 2021, 40(S2): 265-278.
[9]	蒯子函, 闫霆, 吴韶飞, 周宇翔, 潘卫国. 硬脂醇/膨胀石墨复合相变材料的制备及储热性能[J]. 化工进展, 2021, 40(S1): 301-310.
[10]	唐志伟, 刘静, 石英, 陆颖, 肖荣晖, 王昊. 低碳供热技术节能指标与经济效益综合分析[J]. 化工进展, 2021, 40(S1): 156-162.
[11]	秦煜, 唐元鑫, 阮鹏臻, 王威娜, 陈斌. 碳纳米管水泥基复合材料压阻效应的多尺度研究进展[J]. 化工进展, 2021, 40(8): 4278-4289.
[12]	张润霞, 顾兆林, 王赞社, 康彦青, 白梦梦. 空气能蓄冷用相变材料研制及热物性表征[J]. 化工进展, 2021, 40(7): 3892-3899.
[13]	徐众, 侯静, 吴恩辉, 李军, 黄平, 唐亚兰. 石墨对活性炭/脂肪酸复合相变材料潜热和导电性能的影响[J]. 化工进展, 2021, 40(7): 3878-3891.
[14]	于楠, 陈超, 蔺洁, 韩枫涛, 邹平, 贺祎鹏, 胡庆玲. 应用于太阳能相变蓄热PC构件升温养护建筑的复合相变材料热物性[J]. 化工进展, 2021, 40(1): 297-304.
[15]	徐众, 侯静, 李军, 吴恩辉, 黄平, 刘黔蜀, 胥大伟. 膨胀石墨/有机质复合相变材料的制备及性能[J]. 化工进展, 2020, 39(7): 2758-2767.

膨胀石墨/石蜡复合相变材料的导电及发热特性

Characters of electric resistance and heating of expanded graphite/paraffin composite phase change materials

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

图/表 1

参考文献 27

相关文章 15

编辑推荐

Metrics

本文评价