界面聚合在渗透汽化膜分离领域的应用进展

doi:10.16085/j.issn.1000-6613.2020-2018

摘要/Abstract

摘要：

蒸馏、萃取等传统分离方法能耗高，污染环境，而渗透汽化由于低能耗、高效、环保等优势，为共沸物、近沸点混合物的分离提供了新的思路，但渗透汽化膜制备过程中面临的最大问题是获得性能优异且稳定的膜材料。在众多制备方法中，界面聚合法具有反应活性高、常温下生成膜层稳定、制备活性层致密等特点而备受关注。通过对界面聚合过程的调控，可以优化活性层，从而制备出兼具高通量和高选择性的渗透汽化膜。本文综述了界面聚合的原理、在渗透汽化膜制备方面的优势和近年来国内外的研究进展，详细阐述了复合膜制备过程中底膜的选择与改性、界面聚合条件的调控对渗透汽化膜结构和分离性能的影响机制，并对界面聚合制备渗透汽化膜所面临的问题及前景进行了总结与展望。

关键词: 渗透汽化膜, 界面聚合, 底膜, 改性, 聚合条件

Abstract:

Compared with traditional separation methods such as distillation and extraction which cause high energy consumption and environmental pollution, pervaporation has attracted tremendous attention recently due to its superiorities including low cost, high efficiency, energy saving, safe operation and eco-friendliness in the separation of azeotrope and mixture near boiling point. However, the most prominent problem to prepare the pervaporation membranes is to balance the flux and selectivity under the condition of high stability. Interfacial polymerization is widely used in the preparation of pervaporation membranes, which has the advantages of high reactivity, stable formation of membrane layer at room temperature and the dense active layer. In this paper, the preparation principle and advantages of interfacial polymerization in the preparation of pervaporation membrane were described. The selection and modification of the substrates and the condition optimization of interfacial polymerization were analyzed and summarized in detail. Furthermore, the application prospect of interfacial polymerization in pervaporation field was looked forward.

Key words: pervaporation membrane, interfacial polymerization, support, modification, polymerization condition

中图分类号:

TQ028.8

刘娟, 陈宇昊, 叶海星, 孙海翔. 界面聚合在渗透汽化膜分离领域的应用进展[J]. 化工进展, 2021, 40(8): 4314-4326.

LIU Juan, CHEN Yuhao, YE Haixing, SUN Haixiang. Application development of interfacial polymerization in the fields of pervaporation membranes[J]. Chemical Industry and Engineering Progress, 2021, 40(8): 4314-4326.

图/表 1

参考文献 67

1	KAO S T, HUANG S H, LIAW D J, et al. Interfacially polymerized thin-film composite polyamide membrane: positron annihilation spectroscopic study, characterization and pervaporation performance[J]. Polymer Journal, 2010, 42(3): 242-248.
2	MUJIBUROHMAN M, MAHDI K A, ELKAMEL A. Predictive model of pervaporation performance based on physicochemical properties of permeant-membrane material and process conditions[J]. Journal of Membrane Science, 2011, 381: 1-9.
3	SHI G M, CHUNG T S. Thin film composite membranes on ceramic for pervaporation dehydration of isopropanol[J]. Journal of Membrane Science, 2013, 448: 34-43.
4	JIMENEZ S, SOLOMON M F, LIVINGSTON A G. High flux membranes for organic solvent nanofiltration (OSN)—interfacial polymerization with solvent activation[J]. Journal of Membrane Science, 2012, 423/424: 371-382.
5	LAU W J, LAI G S, LI J X, et al. Development of microporous substrates of polyamide thin film composite membranes for pressure-driven and osmotically-driven membrane processes: a review[J]. Journal of Industrial and Engineering Chemistry, 2019, 77: 25-59.
6	WANG J T, XU R Z, YANG F, et al. Probing influences of support layer on the morphology of polyamide selective layer of thin film composite membrane[J]. Journal of Membrane Science, 2018, 556: 374-383.
7	YANG W J, SHAO D D, ZHOU Z Z, et al. Carbon quantum dots (CQDs) nanofiltration membranes towards efficient biogas slurry valorization[J]. Chemical Engineering Journal, 2020, 385: 123993.
8	JIANG L Y, WANG Y, CHUNG T S, et al. Polyimides membranes for pervaporation and biofuels separation[J]. Progress in Polymer Science, 2009, 34(11): 1135-1160.
9	KORIKOV A P, KOSARAJU P B, SIRKAR K K. Interfacially polymerized hydrophilic microporous thin film composite membranes on porous polypropylene hollow fibers and flat films[J]. Journal of Membrane Science, 2006, 279(1/2): 588-600.
10	ALIBAKHSHIAN F, POURAFSHARI C, AAGHARI M. Thin film composite membranes with desirable support layer for MeOH/MTBE pervaporation[J]. Journal of Applied Polymer Science, 2019, 136(22): 47519.
11	LIU X W, CAO Y, LI Y X, et al. High-performance polyamide/ceramic hollow fiber TFC membranes with TiO₂ interlayer for pervaporation dehydration of isopropanol solution[J]. Journal of Membrane Science, 2019, 576: 26-35.
12	ZHANG Y, LE N L, CHUNG T S, et al. Thin-film composite membranes with modified polyvinylidene fluoride substrate for ethanol dehydration via pervaporation[J]. Chemical Engineering Science, 2014, 118: 173-183.
13	SUN H X, LUO X B, LIU J H, et al. Novel thin-film composite pervaporation membrane with controllable crosslinking degree for enhanced water/alcohol separation performance[J]. Separation and Purification Technology, 2020, 234: 116027.
14	VIATCHESLAV F. Kinetics of film formation by interfacial polycondensation[J]. Langmuir, 2005, 21(5): 1884-1894.
15	蒋超, 马文中, 李太雨, 等. 界面聚合法合成聚酰亚胺渗透汽化膜及表征[J]. 高校化学工程学报, 2019, 33(3): 724-731.
	JIANG Chao, MA Wenzhong, LI Taiyu, et al. Preparation and characterization of polyimide pervaporation membranes via interfacial polymerization[J]. Journal of Chemical Engineering of Chinese Universities, 2019, 33(3): 724-731.
16	曹阳, 任玉灵, 郭世伟, 等. 聚酰胺薄层复合膜的界面聚合制备过程调控研究进展[J]. 化工进展, 2020, 39(6): 2125-2134.
	CAO Yang, REN Yuling, GUO Shiwei, et al. Research progress on process optimization for preparation of polyamide thin-film composite membrane by interfacial polymerization[J]. Chemical Industry and Engineering Progress, 2020, 39(6): 2125-2134.
17	杨振生, 张磊, 张广厚, 等. 界面聚合法PI/PP耐溶剂复合纳滤膜的制备与表征[J]. 化工学报， 2012(8), 63: 2635-2641.
	YANG Z S, ZHANG L, ZHANG G Z, et al. Preparation and characterization of polyimide/polypropylene solvent resistant nanofiltration composite membrane via interfacial polymerization[J]. CIESC Journal, 2012, 63(8): 2635-2641.
18	LI X, WANG K Y, HELMER B, et al. Thin-film composite membranes and formation mechanism of thin-film layers on hydrophilic cellulose acetate propionate substrates for forward osmosis processes[J]. Industrial & Engineering Chemistry Research, 2012, 51(30): 10039-10050.
19	CHENG C, LI P, SHEN K, et al. Integrated polyamide thin-film nanofibrous composite membrane regulated by functionalized interlayer for efficient water/isopropanol separation[J]. Journal of Membrane Science, 2018, 553: 70-81.
20	LI C L, HUANG S H, LIAW D J, et al. Interfacial polymerized thin-film composite membranes for pervaporation separation of aqueous isopropanol solution[J]. Separation and Purification Technology, 2008, 62(3): 694-701.
21	ZHAO X Y, TONG Z Q, LIU X F, et al. Facile preparation of polyamide-graphene oxide composite membranes for upgrading pervaporation desalination performances of hypersaline solutions[J]. Industrial & Engineering Chemistry Research, 2020, 59(26): 12232-12238.
22	WU D H, MARTIN J, DU J, et al. Thin film composite membranes comprising of polyamide and polydopamine for dehydration of ethylene glycol by pervaporation[J]. Journal of Membrane Science, 2015, 493: 622-635.
23	YANG G, XIE Z, CRAN M, et al. Enhanced desalination performance of poly(vinyl alcohol)/carbon nanotube composite pervaporation membranes via interfacial engineering[J]. Journal of Membrane Science, 2019, 579: 40-51.
24	JIRARATANANON R, CHANACHAI A, HUANG R Y M, et al. Pervaporation dehydration of ethanol-water mixtures with chitosan/hydroxyethyl cellulose (CS/HEC) composite membranes. Ⅱ. Effect of operating conditions[J]. Journal of Membrane Science, 2002, 195: 143-151.
25	LIU Y L, SU Y H, LAI J Y. In situ crosslinking of chitosan and formation of chitosan-silica hybrid membranes with using γ-glycidoxypropyltrimethoxysilane as a crosslinking agent[J]. Polymer, 2004, 45(20): 6831-6837.
26	YU T F, XU Z J, LIU S Y, et al. Enhanced hydrophilicity and water-permeating of functionalized graphene-oxide nanopores: molecular dynamics simulations[J]. Journal of Membrane Science, 2018, 550: 510-517.
27	JI Y L, ANG M B M Y, HUNG H C, et al. Bio-inspired deposition of polydopamine on PVDF followed by interfacial cross-linking with trimesoyl chloride as means of preparing composite membranes for isopropanol dehydration[J]. Journal of Membrane Science, 2018, 557: 58-66.
28	YU C H, KUSUMAWARDHANA I, LAI J, et al. PTFE/polyamide thin-film composite membranes using PTFE films modified with ethylene diamine polymer and interfacial polymerization: preparation and pervaporation application[J]. Journal of Colloid Interface Science, 2009, 336(1): 260-267.
29	AN Q F, CHEN J T, DE GUZMAN M, et al. Multilayered poly(vinylidene fluoride) composite membranes with improved interfacial compatibility: correlating pervaporation performance with free volume properties[J]. Langmuir， 2011, 27(17): 11062-11070.
30	LIU Y L, YU C H, LAI J Y. Poly(tetrafluoroethylene)/polyamide thin-film composite membranes via interfacial polymerization for pervaporation dehydration on an isopropanol aqueous solution[J]. Journal of Membrane Science, 2008, 315(1/2): 106-115.
31	LIU G P, WEI W, JIN W Q, et al. Polymer/ceramic composite membranes and their application in pervaporation process[J]. Chinese Journal of Chemical Engineering, 2012, 20(1): 62-70.
32	ZHU Y X, XIA S S, LIU G P, et al. Preparation of ceramic-supported poly(vinyl alcohol)-chitosan composite membranes and their applications in pervaporation dehydration of organic/water mixtures[J]. Journal of Membrane Science, 2010, 349(1/2): 341-348.
33	CHU L Y, WANG S, CHEN W M. Surface modification of ceramic-supported polyethersulfone membranes by interfacial polymerization for reduced membrane fouling[J]. Macromolecular Chemistry and Physics, 2005, 206(19): 1934-1940.
34	PETERS T A, FONTALVO J, VORSTMAN M A G, et al. Hollow fiber microporous silica membranes for gas separation and pervaporation[J]. Journal of Membrane Science, 2005, 248(1/2): 73-80.
35	TSAI H A, WANG T Y, HUANG S H, et al. The preparation of polyamide/polyacrylonitrile thin film composite hollow fiber membranes for dehydration of ethanol mixtures[J]. Separation and Purification Technology, 2017, 187:221-232.
36	SUKITPANEENIT P, CHUNG T S. Fabrication and use of hollow fiber thin film composite membranes for ethanol dehydration[J]. Journal of Membrane Science, 2014, 450: 124-137.
37	ANG M B M Y, HUANG S H, CHANG M W, et al. Ultraviolet-initiated graft polymerization of acrylic acid onto thin-film polyamide surface for improved ethanol dehydration performance of pervaporation membranes[J]. Separation and Purification Technology, 2020, 235: 116155.
38	LIU G, SHEN J, JI Y, et al. Two-dimensional Ti₂CT_x MXene membranes with integrated and ordered nanochannels for efficient solvent dehydration[J]. Journal of Materials Chemistry A, 2019, 7(19): 12095-12104.
39	FATHIZADEH M, AROUJALIAN A, RAISI A, et al. Preparation and characterization of thin film nanocomposite membrane for pervaporative dehydration of aqueous alcohol solutions[J]. Desalination, 2013, 314: 20-27.
40	AN Q F, ANG M B M Y, HUANG Y H, et al. Microstructural characterization and evaluation of pervaporation performance of thin-film composite membranes fabricated through interfacial polymerization on hydrolyzed polyacrylonitrile substrate[J]. Journal of Membrane Science, 2019, 583: 31-39.
41	ZHANG X, LI M P, HUANG Z H, et al. Fast surface crosslinking ceramic hollow fiber pervaporation composite membrane with outstanding separation performance for isopropanol dehydration[J]. Separation and Purification Technology, 2020, 234:116116.
42	HUANG S, LI C, HU C, et al. Polyamide thin-film composite membranes prepared by interfacial polymerization for pervaporation separation[J]. Desalination, 2006, 200(1/2/3): 387-389.
43	MARQUEZ J A D, ANGMB M Y, DOMA B T J, et al. Application of cosolvent-assisted interfacial polymerization technique to fabricate thin-film composite polyamide pervaporation membranes with PVDF hollow fiber as support[J]. Journal of Membrane Science, 2018, 564: 722-731.
44	ZUO J, LAI J Y, CHUNG T S. In-situ synthesis and cross-linking of polyamide thin film composite (TFC) membranes for bioethanol applications[J]. Journal of Membrane Science, 2014, 458: 47-57.
45	ZUO J, WANG Y, SUN S P, et al. Molecular design of thin film composite (TFC) hollow fiber membranes for isopropanol dehydration via pervaporation[J]. Journal of Membrane Science, 2012, 405/406: 123-133.
46	TSAI H A, YE Y L, LEE K R, et al. Characterization and pervaporation dehydration of heat-treatment PAN hollow fiber membranes[J]. Journal of Membrane Science, 2011, 368(1/2): 254-263.
47	CAO Y, WANG M, XU Z, et al. A novel seeding method of interfacial polymerization-assisted dip coating for the preparation of zeolite NaA membranes on ceramic hollow fiber supports[J]. ACS Applied Materials & Interfaces, 2016, 8(38): 25386-25395.
48	OKUMUȘ E, GÜRKAN T, YILMAZ L. Effect of fabrication and process parameters on the morphology and performance of a PAN-based zeolite-filled pervaporation membrane[J]. Journal of Membrane Science, 2003, 223(1/2): 23-38.
49	POLOTSKAYA G A, MELESHKO T K, SUSHCHENKO I G, et al. Membranes based on polyimide-polyaniline nanocomposites for pervaporation of organic mixtures[J]. Journal of Applied Polymer Science, 2010, 117(4): 2175-2182.
50	SOROUSH A, BARZIN J, BARIKANI M, et al. Interfacially polymerized polyamide thin film composite membranes: preparation, characterization and performance evaluation[J]. Desalination, 2012, 287: 310-316.
51	RABIEE F, AROUJALIAN A, RAISI A, et al. Effect of fabrication parameters on the performance zeolite filled composite pervaporation membranes[C]//7th International Chemical Engineering Congress & Exihibition, 2011.
52	KIM H, ABDALA A A, MACOSKO C W. Graphene/polymer nanocomposites[J]. Macromolecules, 2010, 43(16): 6515-6530.
53	LI B F, CUI Y, JAPIP S, et al. Graphene oxide (GO) laminar membranes for concentrating pharmaceuticals and food additives in organic solvents[J]. Carbon, 2018, 130: 503-514.
54	MA W Z, ZHAO Y C, LI Y X, et al. Synthesis of hydrophilic carbon nanotubes by grafting poly(methyl methacrylate) via click reaction and its effect on poly(vinylidene fluoride)-carbon nanotube composite membrane properties [J]. Applied Surface Science, 2018, 435: 79-90.
55	ŞENER T, OKUMUS E, GURKAN T, et al. The effect of different solvents on the performance of zeolite-filled composite pervaporation membranes[J]. Desalination, 2010, 261(1/2): 181-185.
56	ZUO J, CHUNG T. Design and synthesis of a fluoro-silane amine monomer for novel thin film composite membranes to dehydrate ethanol via pervaporation[J]. Journal of Materials Chemistry A, 2013, 1(34): 9814–9826.
57	LI S S, DAI J, GENG X, et al. Highly selective sodium alginate mixed-matrix membrane incorporating multi-layered MXene for ethanol dehydration[J]. Separation and Purification Technology, 2020, 235: 116206.
58	CHAO W C, HUANG Y H, LIAW D J, et al. Correlating the microstructure of novel polyamide thin-film composite membranes with ethanol dehydration performances[J]. Polymer, 2013, 54(4): 1381-1387.
59	CHAO W C, HUANG S H, AN Q F, et al. Novel interfacially-polymerized polyamide thin-film composite membranes: studies on characterization, pervaporation, and positron annihilation spectroscopy[J]. Polymer, 2011, 52(11): 2414-2421.
60	HUANG Y H, HUANG S H, CHAO W C, et al. A study on the characteristics and pervaporation performance of polyamide thin-film composite membranes with modified polyacrylonitrile as substrate for bioethanol dehydration[J]. Polymer International, 2014, 63(8): 1478-1486.
61	CUI K J, LI P, ZHANG R, et al. Preparation of pervaporation membranes by interfacial polymerization for acid wastewater purification[J]. Chemical Engineering Research and Design, 2020, 156: 171–179.
62	秘一芳, 安全福. 界面聚合聚酰胺纳滤膜渗透选择性能优化的研究进展[J]. 化工进展, 2020, 39(6): 2093-2104.
	MI Yifang, AN Quanfu. Progress in optimization of polyamide nanofiltration membranes prepared by interfacial polymerization for perm-selectivity[J]. Chemical Industry and Engineering Progress, 2020, 39(6): 2093-2104.
63	AHMAD A L, OOI B S. Properties-performance of thin film composites membrane: study on trimesoyl chloride content and polymerization time[J]. Journal of Membrane Science, 2005, 255(1/2): 67-77.
64	SAHA N K, JOSHI S V. Performance evaluation of thin film composite polyamide nanofiltration membrane with variation in monomer type[J]. Journal of Membrane Science, 2009, 342(1/2): 60-69.
65	JUSOH W A Z W, RAHMAN S A, AHMAD A L, et al. Fabrication and characterisation of a polyamide thin-film composite membrane on a nylon 6,6 substrate for isopropanol dehydration[J]. Comptes Rendus Chimie, 2019, 22(11/12): 755-760.
66	CHENG Q B, ZHENG Y P, YU S C, et al. Surface modification of a commercial thin-film composite polyamide reverse osmosis membrane through graft polymerization of N-isopropylacrylamide followed by acrylic acid[J]. Journal of Membrane Science, 2013, 447: 236-245.
67	MANSOURPANAH Y, MADAENI S, RAHIMPOUR A. Fabrication and development of interfacial polymerized thin-film composite nanofiltration membrane using different surfactants in organic phase; study of morphology and performance[J]. Journal of Membrane Science, 2009, 343(1/2): 219-228.

[1]	王家庆, 宋广伟, 李强, 郭帅成, DAI Qingli. 橡胶混凝土界面改性方法及性能提升路径[J]. 化工进展, 2023, 42(S1): 328-343.
[2]	陈崇明, 陈秋, 宫云茜, 车凯, 郁金星, 孙楠楠. 分子筛基CO₂吸附剂研究进展[J]. 化工进展, 2023, 42(S1): 411-419.
[3]	顾永正, 张永生. HBr改性飞灰对Hg⁰的动态吸附及动力学模型[J]. 化工进展, 2023, 42(S1): 498-509.
[4]	朱杰, 金晶, 丁正浩, 杨会盼, 侯封校. 化学链气化中准东煤灰对CaSO₄载氧体改性及其作用机理[J]. 化工进展, 2023, 42(9): 4628-4635.
[5]	王晋刚, 张剑波, 唐雪娇, 刘金鹏, 鞠美庭. 机动车尾气脱硝催化剂Cu-SSZ-13的改性研究进展[J]. 化工进展, 2023, 42(9): 4636-4648.
[6]	李雪佳, 李鹏, 李志霞, 晋墩尚, 郭强, 宋旭锋, 宋芃, 彭跃莲. 亲水和疏水改性膜的抗结垢和润湿能力的对比[J]. 化工进展, 2023, 42(8): 4458-4464.
[7]	陈俊俊, 费昌恩, 段金汤, 顾雪萍, 冯连芳, 张才亮. 高生物活性聚醚醚酮化学改性研究进展[J]. 化工进展, 2023, 42(8): 4015-4028.
[8]	谭利鹏, 申峻, 王玉高, 刘刚, 徐青柏. 煤沥青和石油沥青共混改性的研究进展[J]. 化工进展, 2023, 42(7): 3749-3759.
[9]	殷成阳, 侯铭, 杨爽, 毛迪, 刘俊言. 过渡金属改性Cu-SSZ-13分子筛脱硝催化剂研究进展[J]. 化工进展, 2023, 42(6): 2963-2974.
[10]	陈明星, 王新亚, 张威, 肖长发. 纤维基耐高温空气过滤材料研究进展[J]. 化工进展, 2023, 42(5): 2439-2453.
[11]	于捷, 张文龙. 锂离子电池隔膜的发展现状与进展[J]. 化工进展, 2023, 42(4): 1760-1768.
[12]	田园, 娄舒洁, 孟闪茹, 闫敬如, 肖海成. 合成气制高碳醇钴基催化剂研究进展[J]. 化工进展, 2023, 42(4): 1869-1876.
[13]	赵珍珍, 郑喜, 王雪琪, 王涛, 冯英楠, 任永胜, 赵之平. 聚酰胺复合膜微孔支撑基底的研究进展[J]. 化工进展, 2023, 42(4): 1917-1933.
[14]	叶海星, 陈宇昊, 陈仪, 孙海翔, 牛青山. 镁锂分离复合纳滤膜研究进展[J]. 化工进展, 2023, 42(4): 1934-1943.
[15]	范思涵, 于国熙, 来超超, 何欢, 黄斌, 潘学军. 非生物改性对厌氧微生物产物光化学活性影响[J]. 化工进展, 2023, 42(4): 2180-2189.