化工进展 ›› 2020, Vol. 39 ›› Issue (2): 506-512.DOI: 10.16085/j.issn.1000-6613.2019-0659

• 能源加工与技术 • 上一篇    下一篇

基于紫外吸光度的生物柴油氧化降解程度分析

王霜1(),王友昊1,李法社1,2(),王文超1,隋猛1   

  1. 1.昆明理工大学冶金与能源工程学院,云南 昆明 650093
    2.冶金节能减排教育部工程研究中心,云南 昆明 650093
  • 收稿日期:2019-04-26 出版日期:2020-02-05 发布日期:2020-03-12
  • 通讯作者: 李法社
  • 作者简介:王霜(1978—),女,硕士,讲师,研究方向为生物质能利用。E-mail:364766529@qq.com
  • 基金资助:
    国家自然科学基金(51766007);云南省自然科学基金(2018FB092);NSFC 云南联合基金(U1602272);省部共建复杂有色金属资源清洁利用国家重点实验室自设项目(CNMRCUTS1704)

Analysis of oxidative degradation degree of biodiesel based on UV absorbance

Shuang WANG1(),Youhao WANG1,Fashe LI1,2(),Wenchao WANG1,Meng SUI1   

  1. 1.Faculty of Metallurgical and Energy Engineering, Kunming University of Science and Technology, Kunming 650093, Yunnan, China
    2.Engineering Research Center of Metallurgical Energy Conservation and Emission Reduction Ministry of Education, Kunming 650093, Yunnan, China
  • Received:2019-04-26 Online:2020-02-05 Published:2020-03-12
  • Contact: Fashe LI

摘要:

为快速检测出生物柴油的氧化降解程度,利用小桐子生物柴油在氧化过程中共轭二烯以及共轭三烯的变化致使230nm处吸光度随氧化时间延长逐渐增强、270nm处吸光度逐渐减弱的现象,建立了生物柴油酸值与紫外吸光度的线性、指数、对数和乘幂这4种模型。留一法交叉验证显示线型模型的预测均方根误差最小,预测值与实测值的相关性最高。利用最小二乘法建立酸值与吸光度线性方程,并对模型进行了验证。结果表明:该拟合方程的拟合优度R2为0.987,表明该预测模型的拟合效果较好;模型验证中实测值与预测值的拟合优度R2为0.980;样本的最大相对误差为5.27%,该模型具有较高的准确度与精确度,可以用该方法代替滴定法快速准确地预测出酸值来表征氧化降解程度。

关键词: 生物柴油, 紫外吸收光谱, 酸值预测, 共轭结构, 氧化降解

Abstract:

The change of conjugated diene and conjugated triene in the oxidation process of Jatropha biodiesel resulted in the increase of absorbance at 230nm and the decrease of absorbance at 270nm with increasing oxidation time. Four models of linearity, exponential, logarithm and power of biodiesel acid value and the UV absorbance were established in order to quickly detect the degree of oxidative degradation of biodiesel. The leave-one-out cross-validation showed that the predicted root mean square error of the linear model was the smallest, and the correlation between the predicted value and the measured value was the highest. The linear equations of acid value and absorbance were established by least squares method and the model was verified. The results showed that the fitting goodness R2 of the fitting equation was 0.987, which indicated that the fitting model had better fitting effect; the goodness of fit between the measured value and the predicted value in the model verification was 0.980; the maximum relative error of the sample was 5.27%, and the model had high accuracy and precision. This method can be used instead of titration to quickly and accurately predict the acid value to characterize the degree of oxidative degradation.

Key words: biodiesel, ultraviolet absorption spectrum, acid value prediction, conjugated structure, oxidative degradation

中图分类号: 

版权所有 © 《化工进展》编辑部


本系统由北京玛格泰克科技发展有限公司设计开发 技术支持:support@magtech.com.cn