低强度超声波对膨胀活性污泥沉降性能及污泥减量的影响

doi:10.16085/j.issn.1000-6613.2017.03.049

化工进展 ›› 2017, Vol. 36 ›› Issue (03): 1134-1139.DOI: 10.16085/j.issn.1000-6613.2017.03.049

低强度超声波对膨胀活性污泥沉降性能及污泥减量的影响

王梦杰^1,2, 员建^1,2, 马华继^1,2, 邓有学^1,2

1 天津城建大学环境与市政工程学院, 天津 300384;
2 天津市水质科学与技术重点实验室, 天津 300384

收稿日期:2016-07-22 修回日期:2016-09-12 出版日期:2017-03-05 发布日期:2017-03-05
通讯作者: 员建,教授,研究方向给水处理、饮用水水质安全保障。
作者简介:王梦杰(1991-),女,硕士研究生,研究方向污泥膨胀调控及污泥减量化。E-mail:752761830@qq.com。
基金资助:
天津市高等学校科技发展基金计划项目（20140518）。

Effects of low intensity ultrasonic treatment on settleability of bulking sludge and sludge reduction

WANG Mengjie^1,2, YUAN Jian^1,2, MA Huaji^1,2, DENG Youxue^1,2

1 School of Environmental and Municipal Engineering, Tianjin Chengjian University, Tianjin 300384, China;
2 Tianjin Key Laboratory of Aquatic Science and Technology, Tianjin 300384, China

Received:2016-07-22 Revised:2016-09-12 Online:2017-03-05 Published:2017-03-05

摘要/Abstract

摘要：

污泥膨胀和大量的剩余污泥是当前城市污水处理厂面临的重要问题。采用20kHz超声波，在不同的声能密度和超声时间下处理微膨胀活性污泥，研究低能量密度超声波处理对活性污泥的沉降性能及污泥减量的影响。结果表明：超声波处理可改善污泥沉降性能和实现污泥减量。适宜的超声处理时间为30～40s。超声处理后，泥水界面沉降速率可提高52%，污泥容积指数（SVI）可由202.9mL/g下降到151mL/g左右，污泥减量率为12.5%。在超声波处理40s时污泥减少已基本完成，而上清液的溶解性化学需氧量（SCOD）在40s之后还在大幅升高，从絮体中释放出来的污泥的溶解液化相对滞后。在一定范围内增加超声处理时间和提高超声能量密度有利于污泥减量效果的提升。活性污泥的初始pH对超声处理效果的影响不大。污泥初始浓度对污泥减量效果影响较大，采用超声波处理较高浓度的污泥时，污泥上清液SCOD增加值在25～29mg/gSS之间。

关键词: 活性污泥, 超声处理, 污泥膨胀, 污泥减量, 沉降性能

Abstract:

Sludge bulking and large amounts of excess sludge are the significant challenges for municipal wastewater treatment plant. The bulking activated sludge was treated by low intensity ultrasound with different ultrasonic densities and ultrasonic times under 20kHz. Effects of ultrasonication on the sludge settleability and sludge reduction were investigated. Results showed that the settleability of bulking sludge was improved by ultrasonication,and sludge reduction could also be achieved simultaneously. The desirable ultrasonic time was 30-40s. After ultrasonic treatment,the settle velocity of bulking sludge was increased by 52%,and its sludge volume index(SVI) was decreased from 209mL/g to 151mL/g. The sludge reduction rate amounted to 12.5%. With the 40s ultrasonication,sludge reduction was almost accomplished,while the soluble chemical oxygendemand (SCOD) concentration in the supernatant was still significantly increased. So the sludge solubilization was lagged behind its release from sludge floc. The increase of ultrasonic time and ultrasonic density within a certain range could improve the sludge reduction rate. There were little effects of initial pH of sludge on the results of ultrasonication. But the sludge reduction rate was significantly affected by initial sludge concentration. When the sludge with relatively high sludge concentration was ultrasonicated,the increase of SCOD in the supernatant amounted to 25-29mg/gSS.

Key words: activated sludge, ultrasonication, sludge bulking, sludge reduction, settleability

中图分类号:

X703

王梦杰, 员建, 马华继, 邓有学. 低强度超声波对膨胀活性污泥沉降性能及污泥减量的影响[J]. 化工进展, 2017, 36(03): 1134-1139.

WANG Mengjie, YUAN Jian, MA Huaji, DENG Youxue. Effects of low intensity ultrasonic treatment on settleability of bulking sludge and sludge reduction[J]. Chemical Industry and Engineering Progress, 2017, 36(03): 1134-1139.

参考文献

[1] MARTINS A M P, PAGILLA K, HEIJINEN J J,et al.Filamentous bulking sludge-a critical review[J]. Water Research, 2004,38(4):793-817.
[2] 龙腾锐,何强.排水工程[M].北京:中国建筑工业出版社,2015. LONG Tengrui,HE Qiang.Wasterwater engineering[M].Beijing:China Architecture & Building Press,2015.
[3] ZHENG Min,LIU Yanchen,XIN Jia,et al.Ultrasonic treatment enhanced ammonia-oxidizing bacterial(AOB)activity for nitritation process[J].Environmental Science & Technology,2016,50(2):864-871.
[4] YU Jinjin,CHEN Hui,ZHANG Jue,et al.Enhancement of ANAMMOX activity by low-intensity ultrasound irradiation at ambient temperature[J].Bioresource Technology,2013,142:693-696.
[5] PILILLI S,BHUNIA P,YAN S,et al.Ultrasonic pretreatment of sludge:a review[J].Ultrasonics Sonochemistry,2011,18(1):1-18.
[6] BRITTA Wünsch W H,UWE Neis.Combatting bulking sludge with ultrasound[J].Ultrasound in Environmental Engineering Ⅱ,2002, 35(1):201-212.
[7] GALLEGO-JUÁREZ J A, GRAFF K F. Power ultrasonics:applications of high-intensity ultrasound[M]. New York:Woodhead Publishing,Elserier,2015:973-996.
[8] MOHAMMADI A R,MEHRDADI N,BIDHENDI G N,et al.Excess sludge reduction using ultrasonic waves in biological wastewater treatment[J].Desalination,2011,275(1/2/3):67-73.
[9] SALSABIL M R, LAURENT J, CASELLAS M, et al.Techno-economic evaluation of thermal treatment,ozonation and sonication for the reduction of wastewater biomass volume before aerobic or anaerobic digestion[J].Journal of Hazardous Materials, 2010,174(1/2/3):323-333.
[10] 刘勇,郝赟,张书廷. 低强度超声波与酸、碱协同对污泥溶胞的影响[J].环境科学学报,2009,29(4):683-688. LIU Yong,HAO Yun,ZHANG Shuting. Effect of low intensity ultrasound/acid or alkaline combined treatment on activated sludge[J].Acta Scientiae Circumstantiae,2009,29(4):683-688.
[11] MA Haji,ZHANG Shuting,LU Xuebin,et al.Excess sludge reduction using pilot-scale lysis-cryptic growth system integrated ultrasonic/alkaline disintegration and hydrolysis/acidogenesis pretreatment[J].Bioresource Technology,2012,116:441-447.
[12] 国家环境保护总局《水和废水监测分析方法》编委会.水和废水监测分析方法[M]. 4版.北京:中国环境科学出版社,2002. The State Environmental Protection Administration 《Water and Wastewater Monitoring and Analysis Methods 》Editorial Committee.Water and wastewater monitoring and analysis method[M].4th ed.Beijing:Chinese Environmental Science Press,2002.
[13] 何志江,张源凯,王洪臣,等.活性污泥絮凝沉降速率计算方法研究[J].环境污染与防治,2015,37(12):35-40. HE Zhijiang,ZHANG Yuankai,WANG Hongchen,et al.Study on calculation method of flocculation sedimentation rate of activated sludge[J].Environmental Pollution & Control,2015,37(12):35-40.

[1]	詹咏, 王慧, 韦婷婷, 朱星宇, 王先恺, 陈思思, 董滨. Mn²⁺强化臭氧调理对生物处理工艺的污泥原位减量效果[J]. 化工进展, 2023, 42(6): 3253-3260.
[2]	王大为, 毕春梦, 秦永丽, 蒋永荣, 谢华宾, 毛宇昆, 苗雪岩. 硫酸盐还原活性污泥矿化固定酸性矿山废水中的镉[J]. 化工进展, 2023, 42(10): 5509-5519.
[3]	张瑞瑞, 王宁, 高志, 于晓慧, 杨宾. 赤藻糖醇/甘露醇过冷特性分析[J]. 化工进展, 2022, 41(6): 2959-2966.
[4]	韦婷婷, 王先恺, 詹咏, 陈思思, 董滨. Mn²⁺催化臭氧氧化活性污泥强化溶胞[J]. 化工进展, 2022, 41(2): 1009-1016.
[5]	郭超然, 黄勇, 朱文娟, 陈丽媛, 王灵芝, 张悦, 徐楚天, 李大鹏. 城市污水有机物回收——捕获技术研究进展[J]. 化工进展, 2021, 40(3): 1619-1633.
[6]	李石, 邢亚彬, 孙慧, 杜改平, 戴安国, 赵东风. 污泥基活性炭制备改性及其吸附甲苯性能[J]. 化工进展, 2020, 39(6): 2463-2471.
[7]	韦朝海, 汝旋, 杨兴舟, 冯春华, 魏永芬, 李富生. 污水生物处理基于氧调控的节能策略[J]. 化工进展, 2018, 37(11): 4121-4134.
[8]	董姗燕, 李咏梅, 池春榕, 刘祖文. 基于活性污泥数学模型(ASM_s)的污水处理系统不确定性分析研究进展[J]. 化工进展, 2017, 36(12): 4651-4657.
[9]	陈瑶, 徐愿坚, 陈玉成, 徐贵华. 自养、异养和混合营养污泥沉降性能差异原因探讨[J]. 化工进展, 2015, 34(05): 1466-1471,1498.
[10]	杨倩1，蒋阳月1，王小军1，陈英文1，沈树宝1，石利利2，刘济宁2. 不同区域污水处理厂活性污泥中微生物菌落结构分析[J]. 化工进展, 2014, 33(12): 3329-3336.
[11]	闫立龙1，郝国馨1，刘玉1，文艳1，伍祖静1，陈艺洋1，张英民2. 以稻壳为载体的SBR对农村生活污水去除效能分析[J]. 化工进展, 2014, 33(09): 2484-2488.
[12]	郭静波1，陈微1，王亮2，马放3. SBR共代谢工艺深度处理石化废水[J]. 化工进展, 2013, 32(11): 2768-2772.
[13]	沈春花，曾庆玲，郭义海. 以微生物燃料电池技术资源化利用剩余污泥的研究进展 [J]. 化工进展, 2011, 30(9): 2075-.
[14]	贾艳萍1，2，王莹1，张兰河1，李军1 . SBR工艺同步去除屠宰废水高浓度氮磷 [J]. 化工进展, 2011, 30(7): 1627-.
[15]	李金娟，赵林，谭欣，黄宇，柳听义. 利用淀粉酸化废水驯化活性污泥合成聚-?-羟基脂肪酸酯及其表征 [J]. 化工进展, 2011, 30(7): 1618-.

低强度超声波对膨胀活性污泥沉降性能及污泥减量的影响

Effects of low intensity ultrasonic treatment on settleability of bulking sludge and sludge reduction

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价