夹点对超临界二氧化碳布雷顿再压缩循环性能的影响

doi:10.16085/j.issn.1000-6613.2017-0323

化工进展 ›› 2017, Vol. 36 ›› Issue (11): 3986-3992.DOI: 10.16085/j.issn.1000-6613.2017-0323

夹点对超临界二氧化碳布雷顿再压缩循环性能的影响

曹春辉, 李惟毅

中低温热能高效利用教育部重点实验室(天津大学), 天津 300350

收稿日期:2017-02-28 修回日期:2017-03-20 出版日期:2017-11-05 发布日期:2017-11-05
通讯作者: 李惟毅,男,教授,从事可再生能源利用与节能、能源与环境工程、传热与传质等方面的研究。
作者简介:曹春辉(1992-),男,硕士研究生,研究方向为可再生能源利用与节能、超临界二氧化碳动力循环研究。

Effect of pinch point on thermal and exergetic performance of supercritical carbon dioxide Brayton recompression cycle

CAO Chunhui, LI Weiyi

Key Laboratory of Efficient Utilization of Low and Medium Grade Energy, Ministry of Education(Tianjin University), Tianjin 300350, China

Received:2017-02-28 Revised:2017-03-20 Online:2017-11-05 Published:2017-11-05

摘要/Abstract

摘要： 研究了超临界二氧化碳（supercritical carbon dioxide，SCO₂）布雷顿再压缩循环回热器的夹点问题，分析了换热器夹点对SCO₂布雷顿再压缩循环热效率、净输出功、不可逆损失和（火+用）效率等性能的影响，阐述了膨胀机进口温度和循环压比对SCO₂布雷顿再压缩循环的影响，并比较了再压缩循环和简单回热循环的性能。结果表明：夹点的位置随着分流比的增大，先出现在低温回热器低温侧的出口，然后出现在低温回热器内部，最后出现在低温回热器低温侧进口；在给定的初始条件下，分流比存在最小值，随着分流比的增大，循环的热效率和（火+用）效率先增大后减小；分流比对加热器、低温回热器、冷却器和高温回热器的（火+用）损失有较大影响；压比的增大和膨胀机进口温度的升高都会使再压缩循环最小分流比减小；在一定分流比下，再压缩循环的热效率比简单回热循环要高。

关键词: 夹点, 超临界二氧化碳, 布雷顿循环, 优化, 热力学

Abstract: The pinch point problem of recuperator on supercritical carbon dioxide Brayton recompression cycle was studied. Then,the effect of the pinch point on the thermal efficiency,specific work output,irreversible exergy losses,and exergy efficiency of supercritical carbon dioxide Brayton recompression cycle was analyzed; and the effect of the inlet temperature of turbine and pressure ratio on supercritical carbon dioxide brayton recompression cycle was discussed. The simple regenerative cycle and the recompression cycle was coampared. The results showed that,with the increase of the spilt ratio,the pinch point first appeared at the outlet of low temperature side of the low temperature recuperator,then at the inside,finally at the inlet. A minimum split ratio existed for the given initial conditions. The thermal efficiency and the exergy efficiency first increased with the rise of split ratio, and then decreased. The split ratio had a great effect on the exergy losses of heater,low temperature recuperator,cooler,and high temperature recuperator. Increasing of the pressure ratio and the inlet temperature of turbine decreased the minimum split ratio of recompression cycle. Furthermore,within a certain range of split ratios,the thermal efficiency of recompression cycle was higher than that of the simple regenerative cycle.

Key words: pinch point, supercritical carbon dioxide, brayton cycle, optimization, thermodynamics

中图分类号:

TK12

曹春辉, 李惟毅. 夹点对超临界二氧化碳布雷顿再压缩循环性能的影响[J]. 化工进展, 2017, 36(11): 3986-3992.

CAO Chunhui, LI Weiyi. Effect of pinch point on thermal and exergetic performance of supercritical carbon dioxide Brayton recompression cycle[J]. Chemical Industry and Engineering Progress, 2017, 36(11): 3986-3992.

参考文献

[1] HEJZLAR P,DOSTAL V,DRISCOLL M J,et al. Assessment of gas cooled fast reactor with indirect supercritical CO₂ cycle[J]. Nuclear Engineering and Technology,2006,38(2):443-445.
[2] DOSTAL V,HEJZLAR P,DRISCOLL M J. The supercritical carbon dioxide power cycle:comparison to other advanced power cCycles[J]. Nuclear Technology,2006,154(3):283-301
[3] CHACARTEGUI R,ESCALONA J M M D,SANCHEZ D,et al. Alternative cycles based on carbon dioxide for central receiver solar power plants[J]. Applied Thermal Engineering,2011,31(5):872-879.
[4] GARG P,KUMAR P,SRINIVASAN K. Supercritical carbon dioxide Brayton cycle for concentrated solar power[J]. Journal of Supercritical Fluids,2013,76(4):54-60.
[5] JEONG W S,LEE J I,YONG H J. Potential improvements of supercritical recompression CO₂ Brayton cycle by mixing other gases for power conversion system of a SFR[J]. Nuclear Engineering and Design,2011,241(6):2128-2137.
[6] 段承杰,王捷,杨小勇. 反应堆超临界CO₂ Brayton循环特性[J]. 原子能科学技术,2010,44(11):1341-1348. DUAN C J,WANG J,YANG X Y. Features of supercritical carbon dioxide Brayton cycle coupled with reactor[J]. Atomic Energy Science and Technology,2010,44(11):1341-1348.
[7] 廖吉香,刘兴业,郑群,等. 超临界CO₂发电循环特性分析[J]. 热能动力工程,2016,31(5):40-46. LIAO J X,LIU X Y,ZHANG Q,et al. Analysis of the power generation cycle characteristics of supercritical carbon dioxide[J]. Journal of Engineering for Thermal Energy and Power,2016,31(5):40-46.
[8] 段承杰,杨小勇,王捷. 超临界二氧化碳布雷顿循环的参数优化[J]. 原子能科学技术,2011,45(12):1489-1494. DUAN C J,YANG X Y,WANG J. Parameters optimization of supercritical carbon dioxide Brayton cycle[J]. Atomic Energy Science and Technology,2011,45(12):1489-1494.
[9] SARKAR J. Second law analysis of supercritical CO₂ recompression Brayton cycle[J]. Energy,2009,34(9):1172-1178.
[10] ZHAO H,DENG Q,HUANG W,et al. Thermodynamic and economic analysis and multi-objective optimization of supercritical CO₂ Brayton cycles[C]//ASME Turbo Expo 2015:Turbine Technical Conference and Exposition. American Society of Mechanical Engineers,2015:15-19.
[11] AKBARI A D,MAHMOUDI S M S. Thermoeconomic analysis and optimization of the combined supercritical CO₂ recompression Brayton/organic Rankine cycle[J]. Energy,2014,78:501-512.
[12] 吴毅,王佳莹,王明坤,等. 基于超临界CO₂布雷顿循环的塔式太阳能集热发电系统[J]. 西安交通大学学报,2016,50(5):108-113. WU Y,WANG J Y,WANG M K,et al. A towered solar thermal power plant based on supercritical CO₂ Brayton cycle[J]. Journal of Xi'an Jiaotong University,2016,50(5):108-113.
[13] REYES-BELMONTE M A,SEBASTIAN A,ROMERO M,et al. Optimization of a recompression supercritical carbon dioxide cycle for an innovative central receiver solar power plant[J]. Energy,2016,112:17-27.
[14] PADILLA R V,TOO Y C S,BENITO R,et al. Exergetic analysis of supercritical CO₂ Brayton cycles integrated with solar central receivers[J]. Applied Energy,2015,148:348-365.
[15] AL-SULAIMAN F A,ATIF M. Performance comparison of different supercritical carbon dioxide Brayton cycles integrated with a solar power tower[J]. Energy,2015,82:61-71.

夹点对超临界二氧化碳布雷顿再压缩循环性能的影响

Effect of pinch point on thermal and exergetic performance of supercritical carbon dioxide Brayton recompression cycle

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	李梦圆, 郭凡, 李群生. 聚乙烯醇生产中回收工段第三、第四精馏塔的模拟与优化[J]. 化工进展, 2023, 42(S1): 113-123.
[2]	张瑞杰, 刘志林, 王俊文, 张玮, 韩德求, 李婷, 邹雄. 水冷式复叠制冷系统的在线动态模拟与优化[J]. 化工进展, 2023, 42(S1): 124-132.
[3]	王福安. 300kt/a环氧丙烷工艺反应器降耗减排分析[J]. 化工进展, 2023, 42(S1): 213-218.
[4]	王胜岩, 邓帅, 赵睿恺. 变电吸附二氧化碳捕集技术研究进展[J]. 化工进展, 2023, 42(S1): 233-245.
[5]	陈匡胤, 李蕊兰, 童杨, 沈建华. 质子交换膜燃料电池气体扩散层结构与设计研究进展[J]. 化工进展, 2023, 42(S1): 246-259.
[6]	王正坤, 黎四芳. 双子表面活性剂癸炔二醇的绿色合成[J]. 化工进展, 2023, 42(S1): 400-410.
[7]	孙玉玉, 蔡鑫磊, 汤吉海, 黄晶晶, 黄益平, 刘杰. 反应精馏合成甲基丙烯酸甲酯工艺优化及节能[J]. 化工进展, 2023, 42(S1): 56-63.
[8]	李春利, 韩晓光, 刘加朋, 王亚涛, 王晨希, 王洪海, 彭胜. 填料塔液体分布器的研究进展[J]. 化工进展, 2023, 42(9): 4479-4495.
[9]	董佳宇, 王斯民. 超声强化对二甲苯结晶特性及调控机理实验[J]. 化工进展, 2023, 42(9): 4504-4513.
[10]	刘炫麟, 王驿凯, 戴苏洲, 殷勇高. 热泵中氨基甲酸铵分解反应特性及反应器结构优化[J]. 化工进展, 2023, 42(9): 4522-4530.
[11]	王晨, 白浩良, 康雪. 大功率UV-LED散热与纳米TiO₂光催化酸性红26耦合系统性能[J]. 化工进展, 2023, 42(9): 4905-4916.
[12]	李海东, 杨远坤, 郭姝姝, 汪本金, 岳婷婷, 傅开彬, 王哲, 何守琴, 姚俊, 谌书. 炭化与焙烧温度对植物基铁碳微电解材料去除As(Ⅲ)性能的影响[J]. 化工进展, 2023, 42(7): 3652-3663.
[13]	李蓝宇, 黄新烨, 王笑楠, 邱彤. 化工科研范式智能化转型的思考与展望[J]. 化工进展, 2023, 42(7): 3325-3330.
[14]	林海, 王彧斐. 考虑噪声约束的分布式风场布局优化[J]. 化工进展, 2023, 42(7): 3394-3403.
[15]	周龙大, 赵立新, 徐保蕊, 张爽, 刘琳. 电场-旋流耦合强化多相介质分离研究进展[J]. 化工进展, 2023, 42(7): 3443-3456.