DBU/甘油/CO2反应过程及动力学

doi:10.16085/j.issn.1000-6613.2016.10.010

化工进展 ›› 2016, Vol. 35 ›› Issue (10): 3078-3085.DOI: 10.16085/j.issn.1000-6613.2016.10.010

DBU/甘油/CO₂反应过程及动力学

张猛^1,2, 鲁厚芳^1,2, 梁斌^1,2, 刘颖颖², 郝晓刚³

1 四川大学化学工程学院, 四川成都 610065;
2 四川大学新能源与低碳技术研究院, 四川成都 610065;
3 太原理工大学化学工程系, 山西太原 030024

收稿日期:2016-02-01 修回日期:2016-03-01 出版日期:2016-10-05 发布日期:2016-10-05
通讯作者: 刘颖颖,博士,助理研究员,研究方向为化工过程新工艺开发。E-mail:liuyingying@scu.edu.cn
作者简介:张猛(1990-),男,硕士研究生。
基金资助:
国家自然科学基金重点项目（21336008）、国家自然科学基金面上项目（21476150）、教育部博士点基金（20130181130006）及山西省煤基重点科技攻关项目（MD2014-09）。

Reaction progress and kinetics of CO₂ with glycerol in the presence of DBU

ZHANG Meng^1,2, LU Houfang^1,2, LIANG Bin^1,2, LIU Yingying², HAO Xiaogang³

1 College of Chemical Engineering, Sichuan University, Chengdu 610065, Sichuan, China;
2 Institute of New Energy and Low-carbon Technology, Sichuan University, Chengdu 610065, Sichuan, China;
3 Taiyuan University of Technology, Taiyuan 030024, Shanxi, China

Received:2016-02-01 Revised:2016-03-01 Online:2016-10-05 Published:2016-10-05

摘要/Abstract

摘要： 1，8-二氮朵双环[5.4.0]十一碳-7-烯（DBU）-甘油溶液作为一种新型溶剂，具有低热容、高沸点等优点，目前被广泛研究应用于化学合成和产物分离等。本文考察了不同摩尔比的DBU-甘油溶液吸收CO₂效果，测定了不同摩尔比的DBU-甘油溶液吸收CO₂反应过程中体系的黏度变化，研究了DBU-甘油溶液吸收CO₂反应的动力学。结果表明，在反应温度25℃、CO₂气体流速为238mL/min的条件下，DBU与甘油摩尔比为0.49~1的溶液对CO₂的吸收量可在120min的反应时间内达到10.88g/100g溶液；DBU与甘油摩尔比为0.49∶1和1.12∶1的溶液在吸收CO₂后体系的黏度显著增大，而DBU与甘油摩尔比为0.11∶1和3.43∶1的溶液在吸收CO₂后体系的黏度变化较小。25℃、常压下，在消除扩散影响，甘油大大过量时，DBU/甘油/CO₂反应的速率方程为r=0.22C_DBUP_CO₂^0.5，反应的活化能为40.44kJ/mol。

关键词: 1,8-二氮朵双环[5.4.0]十一碳-7-烯, 甘油, 二氧化碳, 黏度, 反应动力学

Abstract: 1,8-diazabicyclo[5.4.0] undec-7-ene(DBU)/glycerol solution used as a new solvent,which has low heat capacity and high boiling point,has been widely studied in chemical synthesis and product separation. The absorption of CO₂ at different ratios of DBU/glycerol solutions was investigated. It is shown that the amount of CO₂ absorbed in this solution could reach 10.88g/100g within 120min at 25℃ under atmospheric pressure,0.49:1 of the molar ratio of DBU to glycerol and 238mL/min of the flow rate of CO₂. The viscosity of the solution at different ratios during reaction was also measured. It increased with the increase of time and the amount of DBU when the molar ratio of DBU and glycerol was 0.49:1 and 1.12:1. But, when the molar ratio of DBU to glycerol was 0.11:1 and 3.43:1,the viscosity of the solution changed a little. Furthermore,the kinetics of carbon dioxide binding by DBU/glycerol solution was studied. The reaction rate of DBU/glycerol/CO₂ can be expressed as r=0.22C_DBUP_CO₂^0.5 at 25℃ without the effect of agitation under atmospheric pressure when glycerol is excessive. The activation energy of the reaction is 40.44kJ/mol.

Key words: DBU, glycerol, carbon dioxide, viscosity, reaction kinetics

中图分类号:

O643.12

张猛, 鲁厚芳, 梁斌, 刘颖颖, 郝晓刚. DBU/甘油/CO₂反应过程及动力学[J]. 化工进展, 2016, 35(10): 3078-3085.

ZHANG Meng, LU Houfang, LIANG Bin, LIU Yingying, HAO Xiaogang. Reaction progress and kinetics of CO₂ with glycerol in the presence of DBU[J]. Chemical Industry and Engineering Progree, 2016, 35(10): 3078-3085.

参考文献

[1] JESSOP P G.Switchable solvents as media for synthesis and separations[J].Aldrichimica Acta,2015,1:18.
[2] JESSOP P G,HELDEBRANT D J,LI X W,et al.Green chemistry:reversible nonpolar-to-polar solvent[J].Nature,2005,436(7054):1102-1102.
[3] HELDEBRANT D J,KOECH P K,ANG M T C,et al.Reversible zwitterionic liquids,the reaction of alkanol guanidines,alkanol amidines,and diamines with CO₂[J].Green Chemistry,2010,12(4):713-721.
[4] HELDEBRANT D J,KOECH P K,RAINBOLT J E,et al.10th International Conference on Greenhouse Gas Control Technologies[C].Amsterdam Netherlands:GALE J,HENDRIKS C,TURKENBERG W,2011:216-223.
[5] PHAN L,BROWN H,WHITE J,et al.Soybean oil extraction and separation using switchable or expanded solvents[J].Green Chemistry,2009,11(12):2061-2061.
[6] SALIU F,ORLANDI M.In situ alcoholysis of triacylglycerols by application of switchable-polarity solvents.A new derivatization procedure for the gas-chromatographic analysis of vegetable oils[J].Analytical and Bioanalytical Chemistry,2013,405(26):8677-8684.
[7] XUE D,MU Y,MAO Y,et al.Kinetics of DBU-catalyzed transesterification for biodiesel in the DBU-ethanol switchable-polarity solvent[J].Green Chemistry,2014,16(6):3218-3223.
[8] YANG Y,XIE H,LIU E.Acylation of cellulose in reversible ionic liquids[J].Green Chemistry,2014,16(6):3018-3023.
[9] PRIVALOVA E,NURMI M,MARNON M,et al.CO₂ removal with ‘switchable’ versus ‘classical’ ionic liquids[J].Separation and Purification Technology,2012,97:42-50.
[10] FENG X,SHEN L,WANG R,et al.Synthesis and application of DBU[J].Chemical Industry and Engineering Progress,2013,1:034.
[11] TAYLOR J E,BULL S D,WILLIAMS J M.Amidines,isothioureas,and guanidines as nucleophilic catalysts[J].Chemical Society Reviews,2012,41(6):2109-2121.
[12] 富丽娟,刘颖颖,鲁厚芳,等.醇羟基反应活性与DBU/C3-醇/CO₂离子化合物稳定性[J].化工学报,2015,66(10):4163-4169.
[13] ANUGWOM I,MAKI-ARVELA P,VIRTANEN P,et al.Switchable ionic liquids (SILs) based on glycerol and acid gases[J].RSC Advances,2011,1(3):452-457.
[14] OSTONEN A,SAPEI E,UUSI-KYYNY P,et al.Measurements and modeling of CO₂ solubility in 1,8-diazabicyclo-[5.4.0]-undec-7-ene-glycerol solutions[J].Fluid Phase Equilibria,2014,374:25-36.
[15] MUNSHI M K,GADE S M,MANE M V,et al.1,8-Diazabicyclo[5.4.0] undec-7-ene (DBU):a highly efficient catalyst in glycerol carbonate synthesis[J].Journal of Molecular Catalysis A:Chemical,2014,391:144-149.

DBU/甘油/CO₂反应过程及动力学

Reaction progress and kinetics of CO₂ with glycerol in the presence of DBU

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	时永兴, 林刚, 孙晓航, 蒋韦庚, 乔大伟, 颜彬航. 二氧化碳加氢制甲醇过程中铜基催化剂活性位点研究进展[J]. 化工进展, 2023, 42(S1): 287-298.
[2]	郑谦, 官修帅, 靳山彪, 张长明, 张小超. 铈锆固溶体Ce_0.25Zr_0.75O₂光热协同催化CO₂与甲醇合成DMC[J]. 化工进展, 2023, 42(S1): 319-327.
[3]	戴欢涛, 曹苓玉, 游新秀, 徐浩亮, 汪涛, 项玮, 张学杨. 木质素浸渍柚子皮生物炭吸附CO₂特性[J]. 化工进展, 2023, 42(S1): 356-363.
[4]	孙玉玉, 蔡鑫磊, 汤吉海, 黄晶晶, 黄益平, 刘杰. 反应精馏合成甲基丙烯酸甲酯工艺优化及节能[J]. 化工进展, 2023, 42(S1): 56-63.
[5]	杨寒月, 孔令真, 陈家庆, 孙欢, 宋家恺, 王思诚, 孔标. 微气泡型下向流管式气液接触器脱碳性能[J]. 化工进展, 2023, 42(S1): 197-204.
[6]	王胜岩, 邓帅, 赵睿恺. 变电吸附二氧化碳捕集技术研究进展[J]. 化工进展, 2023, 42(S1): 233-245.
[7]	王耀刚, 韩子姗, 高嘉辰, 王新宇, 李思琪, 杨全红, 翁哲. 铜基催化剂电还原二氧化碳选择性的调控策略[J]. 化工进展, 2023, 42(8): 4043-4057.
[8]	刘毅, 房强, 钟达忠, 赵强, 李晋平. Ag/Cu耦合催化剂的Cu晶面调控用于电催化二氧化碳还原[J]. 化工进展, 2023, 42(8): 4136-4142.
[9]	黄玉飞, 李子怡, 黄杨强, 金波, 罗潇, 梁志武. 光催化CO₂和CH₄重整催化剂研究进展[J]. 化工进展, 2023, 42(8): 4247-4263.
[10]	娄宝辉, 吴贤豪, 张驰, 陈臻, 冯向东. 纳米流体用于二氧化碳吸收分离研究进展[J]. 化工进展, 2023, 42(7): 3802-3815.
[11]	白亚迪, 邓帅, 赵睿恺, 赵力, 杨英霞. 变温吸附碳捕集机组标准化测试方案探讨及性能实验[J]. 化工进展, 2023, 42(7): 3834-3846.
[12]	王俊杰, 潘艳秋, 牛亚宾, 俞路. 分子水平催化重整装置模型构建及应用[J]. 化工进展, 2023, 42(7): 3404-3412.
[13]	陈蔚阳, 宋欣, 殷亚然, 张先明, 朱春英, 付涛涛, 马友光. 矩形微通道内液相黏度对气泡界面的作用机制[J]. 化工进展, 2023, 42(7): 3468-3477.
[14]	谢志伟, 吴张永, 朱启晨, 蒋佳骏, 梁天祥, 刘振阳. 植物油基Ni_0.5Zn_0.5Fe₂O₄磁流体的黏度特性及磁黏特性[J]. 化工进展, 2023, 42(7): 3623-3633.
[15]	孙征楠, 李洪晶, 荆国林, 张福宁, 颜飚, 刘晓燕. EVA及其改性聚合物在原油降凝剂领域的应用[J]. 化工进展, 2023, 42(6): 2987-2998.