活性黑5的生物脱色、复色现象及机理

doi:10.16085/j.issn.1000-6613.2016.09.048

摘要/Abstract

摘要： 印染废水问题形势依然严峻，目前常用生物法来治理，筛选高效降解染料的微生物是生物法处理印染废水的关键。本文利用梯度浓度压力驯化法，从印染废水水解酸化反应器中筛选出对染料活性黑5具有良好脱色性能的混合菌群DDMY1。利用该菌群在兼氧条件下对活性黑5进行脱色研究，首先采用拍照方式记录其反复脱色、复色的直观效果，其次运用紫外-可见光分光光度计检测其不同时间、不同状态下脱色液吸光值情况，最后运用气相色谱质谱联用仪和傅里叶变换红外光谱仪等检测方法分析脱色、复色过程中产物情况。结果表明，混合菌群DDMY1对活性黑5的脱色性能显著，24h脱色率能达到97.4%。同时，发现活性黑5的兼氧生物脱色反应可有效反复脱色、复色达17次之多，根据分析测试的结果，初步推测该现象可能是由活性黑5降解产物中的苯胺类物质或萘醌类物质造成的。

关键词: 混合菌群, 染料脱色, 活性黑5, 氧化还原反应

Abstract: Wastewater from printing and dyeing industrials is still a severe problem,and biological treatment is the most widely used method currently, for which screening high efficient dye biodegradation microorganisms is the key. In this paper,by using the concentration gradient pressure screening method,we selected a mixed bacterial flora DDMY1,which has good decolorization performance to reactive black 5(RB5),from the well-running hydrolytic acidification reactor for subsequent printing and dyeing wastewater treatment. The bacterial flora was used to study the RB5 decolorization under the facultative-aerobic condition. Firstly,photos were taken in the process of decolorization and repigmentation to record the repeated results visually. Secondly,ultraviolet-visible spectrophotometry was used to scan the decoloring liquid at different times and different states. At last, GC-MS (Gas Chromatography-Mass Spectrometer) and FTIR (Fourier Transform Infrared Spectroscopy) were employed to analyze the degradation products. Results indicated that,the mixed flora DDMY1 performed satisfatorily in decoloring of RB5,and with 400mg/L RB5 for 24h cultivation,the decolorization rate could reach 97.4%. At the same time,the study found that the biological oxygen decolorization reaction could effectively repeat the decolorization-repigmentation for 17 times. According to the analysis results of the tests,it could be speculated that RB5 degradation products such as aniline,naphthoquinones might be responsible.

Key words: bacterial consortium, biological decoloring, reactive black 5, redox

中图分类号:

X172

俞承志, 谢学辉, 郑秀林, 徐乐铱, 李然, 柳建设. 活性黑5的生物脱色、复色现象及机理[J]. 化工进展, 2016, 35(09): 2987-2996.

YU Chengzhi, XIE Xuehui, ZHENG Xiulin, XU Leyi, LI Ran, LIU Jianshe. Decolorization and repigmentation of reactive black 5 biodegradation and their mechanisms[J]. Chemical Industry and Engineering Progree, 2016, 35(09): 2987-2996.

参考文献

[1] STOLZ A. Basic and applied aspects in the microbial degradation of azo dyes[J]. Appl. Microbiol Biotechnol,2001,56:69-80.
[2] PADMAVATHY S, SANDHYA S, SWAMINATHAN K, et al.Aerobic decolorization of reactive azo dyes in presence of various cosubstrates[J]. Chemical and Biochemical Engineering Quarterly, 2003,17:147-151.
[3] WANG Xingzu,CHENG Xiang,SUN Dezhi,et al. Biodecolorization and partial mineralization of Reactive Black 5 by a strain of Rhodopseudomonas palustris[J].Journal of Environmental Sciences, 2008,20:1218-1225.
[4] JADHAV S B,PATIL N S,WATHARKAR A D,et al.Batch and continuous biodegradation of Amaranth in plain distilled water by P. aeruginosa BCH and toxicological scrutiny using oxidative stress studies[J].Environ. Sci. Pollut. Res.,2013,20:2854-2866.
[5] RAFFI F,HALL J D,CERNIGLIA C E.Mutagenicity of azo dyes used in foods,drugs and cosmetics before and after reduction by Clostridium species from the human intestinal tract[J].Food Chem. Toxicol,1997,35:897-901.
[6] ZIMMERMANN T,KULLA H G,LEISINGER T. Properties of purified OrangeⅡ azoreductase,the enzyme initiating azo dye degradation by Pseudomonas KF46[J].Eur. J. Biochem.,1982,129:197-203.
[7] AHWANY El A M D.Decolorization of Fast red by metabolizing cells of Oenococcus oeni ML34[J].World Journal of Microbiology and Biotechnology,2008,24(8):1521-1527.
[8] PINHEIRO H,TOURAUD E,Thomas O.Aromatic amines from azo dye reduction:status review with emphasis on direct UV spectrophotometric detection in textile industry wastewaters[J].Dyes and Pigments,2004,61:121-139.
[9] ANLIKER R. Ecotoxicology of dyestuffs-a joint effort by industry[J].Ecotoxicol. Environ. Saf.,1979,3:59-74.
[10] AKSU Z,KILIC N K,ERTUGRUL S,et al.Inhibitory effects of chromium(Ⅵ) and Remazol Black B on chromium(Ⅵ) and dyestuff removals by Trametes versicolor[J]. Enzyme and Microbial Technology,2007,40:1167-1174.
[11] CHUNG K T.The significance of azo reduction in the mutagenesis and carcinogenesis of azo dyes[J].Mutat. Res.,1983,114:269-81.
[12] HUSAIN Q.Potential applications of the oxidoreductive enzymes in the decolorization and detoxification of textile and other synthetic dyes from polluted water:a review[J]. Critical Reviews in Biotechnology,2006,26(4):201-221.
[13] MOHANA S,SHRIVASTAVA S, DIVECHA J,et al.Response surface methodology for optimization of medium for decolorization of textile dye direct black 22 by a novel bacterial consortium. Bioresour[J]. Technol.,2008,99:562-569.
[14] NISHANT Dafale,SATISH Wate,SUDHIR Meshram,et al. Kinetic study approach of remazol black-B use for the development of two-stage anoxic-oxic reactor for decolorization/biodegradation of azo dyes by activated bacterial consortium[J].Journal of Hazardous Materials,2008,159:319-328.
[15] ARAVINDHAN R, RAO J R,NAIR B U. Removal of basic yellow dye from aqueous solution by sorption on green alga Caulerpa scalpelliformis[J]. Journal of Hazardous Materials,2007,142:68-76.
[16] JAIN K,SHAH V,CHAPLA D,et al. Decolorization and degradation of azo dye e reactive Violet 5R by an acclimatized indigenous bacterial mixed cultures-SB4 isolated from anthropogenic dye contaminated soil[J]. Journal of Hazardous Materials,2012,213/214:378-386.
[17] WANG X,CHENG X,SUN D,et al.Fate and transformation of naphthylaminesulfonic azo dye reactive black 5 during wastewater treatment process[J]. Environ. Sci. Pollut. Res,2014,21:5713-5723.
[18] CHAN Y,CHONG M,LIM law,et al. A review on anaerobic-aerobic treatment of industrial municipal wastewater[J].Chem. Eng. J.,2009, 155:1-18.
[19] WANG X Z,CHEN X,SUN D Z,et al. Biodecolorization and partial mineralization of Reactive Black 5 by a strain of Rhodopseudomonas palustris[J]. Journal of Environmental Sciences,2008,20:1218-1225.
[20] WANG Hui,XIAO Weizheng,JIAN Qiangsu,et al. Biological decolorization of the reactive dyes Reactive Black 5 by a novel isolated bacterial strain Enterobacter sp. EC3[J]. Journal of Hazardous Materials,2009,171:654-659.
[21] SINGH R L,SINGH P K,SINGH R P.Enzymatic decolorization and degradation of azo dyes-a review[J]. International Biodeterioration & Biodegradation,2015,104:21-31.
[22] SHAH P D,DAVE S R,RAO M S. Enzymatic degradation of textile dye Reactive Orange 13 by newly isolated bacterial strain Alcaligenes faecalis PMS-1[J]. International Biodeterioration & Biodegradation, 2012,69:41-50.
[23] GREKOVA Vasileva M,TOPALOVA Y. Enzyme activities and shifts in microbial populations associated with activated sludge treatment of textile effluents[J]. Biotechnology & Biotechnological Equipment, 2014,23(1):1136-1142.
[24] 范凤霞. 混合菌群FF对活性黑5的脱色降解研究[D]. 上海:东华大学,2013.
[25] 陈刚,陈晔,黄满红,等. 活性黑5脱色菌的分离鉴定及其脱色特性[J]. 环境污染与防治,2010,32(12):63-66.
[26] MOHANTY S,RAO N N,KAUL S N. Preliminary decolorization of H-acid based azo dye-Reactive black 5[J]. Annali. Chem.,2003,93:771-775.
[27] YU J,WANG X W,YUE P L.Optimal decolorization and kinetic modeling of synthetic dyes by Pseudomonas strains[J]. Water Research,2001,35(15):3579-3586.
[28] KALYANI D C,TELKE A A,DHANVE R S,et al. Ecofriendly biodegradation and detoxification of Reactive Red 2 textile dye by newly isolated Pseudomonas sp. SUK1[J]. Journal of Hazardous Materials,2009,163:735-742.
[29] ALI Ryan,CHAN Ju wang,NICOLA Laurieri,et al. Reaction mechanism of azoreductases suggests convergent evolution with quinone oxidoreductases[J]. Protein Cell,2010,1(8):780-790.
[30] FRANCISCON E,ZILLE A,FANTINATTI Garboggini F,et al. Microaerophilic-aerobic sequential decolourization/biodegradation of textile azo dyes by a facultative Klebsiella sp. strain VN-31[J]. Process Biochem,2009,44:446-452.
[31] ARIF Al-Hamad1,MATHEW Upton1,JAMES Burnie. Molecular cloning and characterization of SmrA,a novel ABC multidrug efflux pump from Stenotrophomonas maltophilia[J]. Journal of Antimicrobial Chemotherapy,2009,64:731-734.
[32] 赵晓祥,张小凡. 环境微生物技术[M]. 北京:化学工业出版社, 2015.
[33] 陈刚. 偶氮染料废水生物脱色及典型产物好氧降解性能研究[D]. 上海:东华大学,2012.
[34] 傅献彩,沈文霞,姚天扬,等. 物理化学[M]. 北京:高等教育出版社,2005.
[35] SAGARIKA Mohanty,NISHANT Dafale,NAGESWARA Neti Rao. Microbial decolorization of reactive black-5 in a two-stage anaerobic-aerobic reactor using acclimatized activated textile sludge[J]. Biodegradation,2006,17:403-413.
[36] KHANDARE R V,RANE N R,WAGJMODE T R,et al. Bacterial assisted phytoremediation for enhanced degradation of highly sulfonated diazo reactive dye degradation of highly sulfonated diazo reactive dye[J].Environ. Sci. Pollut. Res.,2012,19:1709-1718.
[37] KSHAMA Balapure, NIKHIL Bhatt,DATTA Madamwar. Mineralization of reactive azo dyes present in simulated textile waste water using down flow microaerophilic fixed film bioreactor[J]. Bioresource Technology,2015,175:1-7.
[38] ANJALI Pandey,POONAM Singh,LEELA Iyengar. Bacterial decolorization and degradation of azo dyes[J]. International Biodeterioration & Biodegradation,2007,59:73-84
[39] KSHAMA Balapure,KUNAL Jain,NIKHIL Bhatt,et al. Exploring bioremediation strategies to enhance the mineralization of textile industrial wastewater through sequential anaerobic-microaerophilic process[J]. International Biodeterioration & Biodegradation,2016, 106:97-105.
[40] MUSTAFA Isık,DELIA Teresa Sponza. A batch kinetic study on decolorization and inhibition of Reactive Black 5 and Direct Brown 2 in an anaerobic mixed culture[J]. Chemosphere,2004,55:119-128.
[41] ANDRE B,DOS Santos,FRANCISCO J,et al. Review paper on current technologies for decolourisation of textile wastewaters. Perspectives for anaerobic biotechnology[J]. Bioresource Technology, 2007,98:2369-2385.
[42] SIBYLLE Bürger, ANDREAS Stolz. Characterisation of the flavin-free oxygen-tolerant azoreductase from Xenophilus azovorans KF46F in comparison to flavin-containing azoreductases[J]. Appl. Microbiol. Biotechnol.,2010,87:2067-2076.
[43] FRANK P,ZEE V D,GATZE Lettinga,et al. Azo dye decolourisation by anaerobic granular sludge[J]. Chemosphere,2001,44:1169-1176.
[44] CUI Daizong,LI Guofang,ZHAO Dan,et al. Effect of quinoid redox mediators on the aerobic decolorization of azo dyes by cells and cell extracts from Escherichia coli[J]. Environ. Sci. Pollut. Res.,2015,22:4621-4630.
[45] ALEXANDER Plum,ASTRID Rehorek. Strategies for continuous on-line high performance liquid chromatography coupled with diode array detection and electrospray tandem mass spectrometry for process monitoring of sulphonated azo dyes and their intermediates in anaerobic-aerobic bioreactors[J]. Journal of Chromatography A, 2005,1084:119-133.
[46] WANG Xingzu,CHENG Xiang,SUN Dezhi,et al. Fate and transformation of naphthylaminesulfonic azo dye Reactive Black 5 during wastewater treatment process[J]. Environ Sci. Pollut. Res., 2014,21:5713-5723.
[47] ANDREAS Keck,JÖRG Rau,THORSTEN Reemtsma,et al. Identification of quinoide redox mediators that are formed during the degradation of naphthalene-2-sulfonate by Sphingomonas xenophaga BN6[J]. Applied and Environmental Microbiology,2002,68(9):4341-4349.
[48] KUDLICH M,HETHERIDGE M J,KNACKMUSS H J,et al. Autoxidation reactions of different aromatic o-amino hydroxy naphthalenes that are formed during the anaerobic reduction of sulfonated azo dyes[J]. Environ. Sci. Technol.,1999,33:896-901.
[49] 陈刚,陈亮,黄满红. 偶氮染料的微生物脱色研究进展[J]. 微生物学通报,2009,36(7):1046-1051.