水平管气液两相分层流界面剪切预测研究进展

doi:10.16085/j.issn.1000-6613.2016.05.004

摘要/Abstract

摘要： 水平管气液两相分层流虽流型简单,但由于界面存在复杂的动量和能量传递,分层流的界面剪切预测至今没有一致的结论。本文从理论模型、实验模型、数值计算3个角度出发,详细阐述水平管气液两相分层流界面剪切预测的研究现状,得出不同研究方法的优势和缺陷。针对3种研究方法,指出理论模型通过模型简化和经验关联式来建立封闭模型,实验模型则在封闭关系上修正经验关联式,但由于简化假设和实验条件的限制,使得这两种研究方法对界面剪切应力的预测具有一定的局限性;数值计算能够弥补机理模型在流场细节等方面的不足,但能够提供界面剪切预测或封闭关系的工作很少。此外,对比了5种不同形式的已有模型对气液两相分层流持液率和压降预测的结果。最后展望了水平管气液两相分层流界面剪切预测的研究趋势,提出理论和实验研究需要提出更详细的局部模型,并考虑工程实际工况进行研究,发展针对气液界面计算的新方法,并为分层流提供封闭关系则是数值计算研究面临的挑战。

关键词: 水平管, 气液两相流, 分层流, 界面剪切应力, 持液率, 压降

Abstract: The gas-liquid two-phase stratified flow has complex momentum and energy transmission phenomena at interface, although its pattern is simple. There are still no unified conclusions for interfacial shear stress in stratified flow. Current progress of interfacial shear stress in horizontal pipes were elaborated by theoretical models, experimental models and numerical simulations. As for theoretical models, closure models were established by models simplification and empirical correlations. Empirical correlations were corrected with closure relations in experiments. Due to simplifying assumptions and experimental conditions, there are some limitations in predicting the interfacial shear stress with theoretical and experimental ways. The detailed flow fields were studied by numerical simulations, but closure relations have been less obtained so far. Five existing models are compared according to liquid holdup and pressure drop. The future research trends of gas-liquid two-phase stratified flow interfacial shear stress in horizontal pipes were further discussed. More detailed local models are needed to be proposed and engineering practice should be taken into account. It is necessary to develop new methods of gas-liquid interface calculations and closure relations for numerical simulations.

Key words: horizontal pipe, gas-liquid flow, stratified flow, interfacial shear stress, liquid holdup, pressure drop

中图分类号:

O359.1

郑平, 赵梁. 水平管气液两相分层流界面剪切预测研究进展[J]. 化工进展, 2016, 35(05): 1289-1297.

ZHENG Ping, ZHAO Liang. Progress of interfacial shear stress in the gas-liquid stratified flow in horizontal pipes[J]. Chemical Industry and Engineering Progree, 2016, 35(05): 1289-1297.

参考文献

[1] ULLMANN A, BRAUNER N. Closure relations for two-fluid models for two-phase stratified smooth and stratified wavy flows[J]. International Journal of Multiphase Flow, 2006, 32(1): 82-105.
[2] 郭烈锦. 两相与多相流动力学[M]. 西安: 西安交通大学出版社, 2002.
[3] MOUZA A A, PARAS S V, KARABELAS A J. CFD code application to wavy stratified gas-liquid flow[J]. Chemical Engineering Research and Design, 2001, 79(5): 561-568.
[4] LINÉ A, LOPEZ D. Two-fluid model of wavy separated two-phase flow[J]. International Journal of Multiphase Flow, 1997, 23(6): 1131-1146.
[5] LOCKHART R W, MARTINELLI R C. Proposed correlation of data for isothermal two phase, two component flow in pipes[J]. Chemical Engineering Progress, 1949, 45(1): 38-48
[6] TAITEL Y, DUKLER A E. A model for predicting flow regime transitions in horizontal and near horizontal gas-liquid flow[J]. AIChE Journal, 1976, 22(1): 47-55.
[7] TAITEL Y, DUKLER A E. A theoretical approach to the Lockhart-Martinelli correlation for stratified flow[J]. International Journal of Multiphase Flow, 1976, 2(4): 591-595.
[8] SHOHAM O, TAITEL Y. Stratified turbulent-turbulent gas-liquid flow in horizontal and inclined pipes[J]. AlChE Journal, 1984, 303(3): 377-385.
[9] HANSEN E A, VESTED H J. Liquid hold-up, pressure drop, and velocity profiles in steady uniform stratified flow[J]. Journal of Energy Resources Technology, 1991, 113(2): 87-93.
[10] Ullmann A, Zamir M, Gat S, et al. Multi-holdups in co-current stratified flow in inclined tubes[J]. International Journal of Multiphase Flow, 2003, 29(10): 1565-1581.
[11] Ullmann A, Goldstein A, Zamir M, et al. Closure relations for the shear stresses in two-fluid models for laminar stratified flow[J]. International Journal of Multiphase Flow, 2004, 30(7/8): 877-900.
[12] Kang H C, Kim M H. The relation between the interfacial shear stress and the wave motion in a stratified flow[J]. International Journal of Multiphase Flow, 1993, 19(1): 35- 49.
[13] 刘夷平, 王茹金, 陈超, 等.气液两相分层流剪切应力的不确定度分析[J]. 实验流体力学, 2012, 26(4): 43-47.
[14] Andritsos N, Hanratty T J. Influence of interfacial waves in stratified gas-liquid flows[J]. International Journal of Multiphase Flow, 1987, 13(5): 583-603.
[15] Hart J, Hamersma P J, Fortuin J M H. Correlations predicting frictional pressure drop and liquid holdup during horizontal gas-liquid pipe flow with a small liquid holdup[J]. International Journal of Multiphase Flow, 1989, 15(6): 947-964.
[16] Chen X T, Cai X D, Brill J P. Gas-liquid stratified-wavy flow in horizontal pipelines[J]. Journal of Energy Resources Technology, 1997, 119: 209-216.
[17] Vlachos N A, Paras S V, Karabelas A J. Prediction of holdup, axial pressure gradient and wall shear stress in wavy stratified and stratified/atomization gas/liquid flow[J]. International Journal of Multiphase Flow, 1999, 25(2): 365-376.
[18] Vlachos N A. Studies of stratified/atomization two-phase flow in a horizontal pipe[D]. Thessaloniki: Aristotle University of Thessaloniki, 1997
[19] Ng T S, Lawrence C J, Hewitt G F. Interface shapes for two-phase laminar stratified flow in a circular pipe[J]. International Journal of Multiphase Flow, 2000, 27(7): 1301-1311.
[20] Brauner N, Rovinsky J, Moalem M D. Determination of the interface curvature in stratified two-phase systems by energy considerations[J]. International Journal of Multiphase Flow, 1996, 22(6): 1167-1185.
[21] Brauner N, Rovinsky J, Moalem M D. Analytical solution for Laminar-Laminar two-phase flow in circular conduits[J]. Chemical Engineering Communication, 1996, 141/142(1): 103-143.
[22] Brauner N, Rovinsky J, Moalem M D. Analytical solution of laminar stratified flow with curved interfaces[C]// Proceedings of the NURETH-7 Meeting, ANS 1, 1995: 192-211.
[23] Brauner N, Rovinsky J, Moalem M D. Characteristics of annular and stratified two-phase flow in the limit of fully eccentric core annular configuration[C]// Proc. of the ExHFT 4, Brussels, 1997.
[24] Brauner N, Moalem M D, Rovinsky J. A two-fluid model for stratified flows with curved interfaces[J]. International Journal of Multiphase Flow, 1998, 24(6): 975-1004.
[25] ROVINSKY J, BRAUNER N, MOALEM M D. Analytical solution for laminar two-phase flow in a fully eccentric core-annular configuration[J]. International Journal of Multiphase Flow, 1997, 23(3): 523-543.
[26] SOLEIMANI A. Phase distribution and associated phenomena in oil-water flows in horizontal tubes[D]. London: Imperial College, University of London, 1999.
[27] BIRVALSKI M, TUMMERS M J, DELFOS R, et al. PIV measurements of waves and turbulence in stratified horizontal two-phase pipe flow[J]. International Journal of Multiphase Flow, 2014, 62: 161-173.
[28] FULLMER W D, RANSOM V H, LOPEZ de Bertodano M A. Linear and nonlinear analysis of an unstable, but well-posed, one-dimensional two-fluid model for two-phase flow based on the inviscid Kelvin-Helmholtz instability[J]. Nuclear Engineering and Design, 2014, 268: 173-184.
[29] LIU G, WANG Y S, ZANG G J, et al. Viscous Kelvin- Helmholtz instability analysis of liquid-vapor two-phase stratified flow for condensation in horizontal tubes[J]. International Journal of Heat and Mass Transfer, 2015, 84: 592-599.
[30] KOWALSKI J E. Wall and interfacial shear stress in stratified flow in a horizontal pipe[J]. AIChE Journal, 1987, 32(2): 274-281.
[31] HAGIWARA Y, ESMAEILZADEH E, TSUTSUI H, et al. Simultaneous measurements of liquid film thickness, wall shear stress and gas flow turbulence of horizontal wavy two-phase flow [J]. International Journal of Multiphase Flow, 1989, 15(3): 421- 431.
[32] TZOTZI C, ANDRITSOS N. Interfacial shear stress in wavy stratifed gas-liquid flow in horizontal pipes[J]. International Journal of Multiphase Flow, 2013, 54: 43-54.
[33] STRAND Ø. An experimental investigation of stratified two-phase flow in horizontal pipes[D]. Oslo: University of Oslo, 1993.
[34] HAALAND S E. Simple and explicit formulas for the friction factor in turbulent pipe flow[J]. Journal of Fluids Engineering, 1983, 105: 89-90.
[35] LI W D, SUN K X, ZHOU F D. Interfacial shear stress of stratified flow in a horizontal pipe[J]. Chinese Journal of Chemical Engineering, 1999, 7(3): 263-270.
[36] SIDI-ALI K, GATIGNOL R. Interfacial friction factor determination using CFD simulations in a horizontal stratified two-phase flow[J]. Chemical Engineering Science, 2010, 65(18): 5160- 5169.
[37] DOMINIQUE B. The difficult challenge of a two-phase CFD modelling for all flow regimes[J]. Nuclear Engineering and Design, 2014, 279: 116-125.
[38] AKAI M, INOUE A, AOKI S. The prediction of stratified two-phase flow with a two equation model of turbulence[J]. International Journal of Multiphase Flow, 1981, 7(1): 21-39.
[39] ISSA R I. Prediction of turbulent, stratified, two-phase flow in inclined pipes and channels[J]. International Journal of Multiphase Flow, 1988, 14(2): 141-154.
[40] MEKNASSI F, BENKIRANE R, LINÉ A, et al. Numerical modelling of wavy stratified two-phase flow in pipes[J]. Chemical Engineering Science, 2000, 55(20): 4681-4697.
[41] LOPEZ D. Ecoulements diphasiques a phases separees a faible contenu de liquide[D]. France: I.N.P. Toulouse, 1994.
[42] NEWTON C H, BEHNIA M. On the use of the stratified momentum balance for the deduction of shear stress in horizontal gas-liquid pipe flow[J]. International Journal of Multiphase Flow, 1998, 24(8): 1407-1423.
[43] NEWTON C H, BEHNIA M. Numerical calculation of turbulent stratified-gas-liquid pipe flows[J]. International Journal of Multiphase Flow, 2000, 26(2): 327-337.
[44] NEWTON C H, BEHNIA M. A numerical model of stratified-wavy gas-liquid pipe flow[J].Chemical Engineering Science, 2001, 56(24): 6851-6861.
[45] VLACHOS N A, PARAS S V, KARABELAS A J. Liquid-to-wall shear stress distribution in stratified/atomization flow[J]. International Journal of Multiphase Flow, 1997, 23(5): 845-863.
[46] BERTHELSEN P A, YTREHUS T. Calculations of stratified wavy two-phase flow in pipes[J]. International Journal of Multiphase Flow, 2005, 31(5): 571-592.
[47] Berthelsen P A, Ytrehus T. Stratified smooth two-phase flow using the immersed interface method[J]. Computers & Fluids, 2007, 36(7): 1273-1289.
[48] Ghorai S, Nigam K D P. CFD modelling of flow profiles and interfacial phenomena in two-phase flow in pipes[J]. Chemical Engineering and Processing, 2006, 45(1): 55-65.
[49] de Sampaio P A B, Faccini J L H, Su Jian. Modelling of stratified gas-liquid two-phase flow in horizontal circular pipes[J]. International Journal of Heat and Mass Transfer, 2008, 51: 2752-2761.
[50] Hand N P. Gas-liquid co-current flow in a horizontal pipeline[D]. Belfast: The Queen's University of Belfast, 1991.
[51] Srichai S. High pressure separated two-phase flow[D]. London: Imperial College, 1994.
[52] Barnea D, Taitel Y. Structural and interfacial stability of multiple solutions for stratified flow[J]. International Journal of Multiphase Flow, 1992, 18(6): 821-830.
[53] Newton C H, Behnia M. On the use of the stratified momentum balance for the deduction of shear stress in horizontal gas-liquid pipe flow[J]. International Journal of Multiphase Flow, 1998, 24(8):
1407-1423.
[54] Eck B. Technische Stromunglehre[M]. New York: Springer, 1973.
[55] Crowley C J, Wallis G B, Barry J J. Validation of a one-dimensional wave model for the stratified-to-slug flow regime transition, with consequences for wave growth and slug frequency[J]. International Journal of Multiphase Flow, 1992, 18(2): 249-271.
[56] Andritsos N. Statistical analysis of waves in horizontal stratified gas-liquid flow[J]. International Journal of Multiphase Flow, 1992, 18(3): 465-473.
[57] Ayati A J, Kolaas A, Jensen G W, et al. A PIV investigation of stratified gas-liquid flow in a horizontal pipe[J]. International Journal of Multiphase Flow, 2014, 61: 129- 143.