微细通道内CO2沸腾换热与干涸特性

doi:10.16085/j.issn.1000-6613.2015.08.009

化工进展 ›› 2015, Vol. 34 ›› Issue (08): 2961-2966.DOI: 10.16085/j.issn.1000-6613.2015.08.009

微细通道内CO₂沸腾换热与干涸特性

陆至羚¹, 柳建华^1,2, 张良¹, 张瑞¹, 吴昊¹, 祁良奎¹

1 上海理工大学能源与动力工程学院, 上海 200093;
2 上海市动力工程多相流动与传热重点实验室, 上海 200093

收稿日期:2015-01-04 修回日期:2015-02-15 出版日期:2015-08-05 发布日期:2015-08-05
作者简介:陆至羚(1991—),女,硕士研究生,研究方向为制冷与空调。E-mail lingling6243@hotmail.com。

Heat transfer and dry-out characteristics of CO₂ in mini-channel

LU Zhiling¹, LIU Jianhua^1,2, ZHANG Liang¹, ZHANG Rui¹, WU Hao¹, QI Liangkui¹

1 School of Energy and Power Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China;
2 Shanghai Key Laboratory of Multiphase Flow and Heat Transfer in Power Engineering, Shanghai 200093, China

Received:2015-01-04 Revised:2015-02-15 Online:2015-08-05 Published:2015-08-05

摘要/Abstract

摘要： CO₂作为一种天然制冷剂在微通道内应用具有很大的换热优势,然而由于微尺度效应及其物性,在低干度区容易发生干涸,严重影响换热效果。为研究微细通道内CO₂流动沸腾换热与干涸特性,搭建了相应实验装置,对内径分别为1mm、2mm、3mm以及内表面粗糙度为16μm的不锈钢管,在CO₂制冷剂热流密度2~34kW/m²、质量流率50~1350kg/(m²·s)、饱和温度-10~15℃下进行换热性能与干涸实验对比研究。结果表明:常规管径换热特性在微细通道内不再适用;热流密度的增加对于强化核态沸腾换热具有显著影响,高于临界热流密度(critical heat flux,CHF)则发生干涸;质量流率对于核态沸腾区换热系数的影响则较小;不同饱和温度时换热特性有所不同,高饱和温度下换热系数随其升高而提高,低饱和温度下则相反;干涸过程对总换热系数的影响占34%。研究结论为CO₂微通道换热器的研究开发提供理论依据。

关键词: 二氧化碳, 微通道, 沸腾换热, 临界热流密度, 干涸, 微尺度

Abstract: This paper reviewed the present membrane technologies in landfill leachate treatment. Compared with conventional treatment technologies, membrane separation technologies have the advantage of low-energy and high efficiency. Aiming at different treatment purposes, four membranes, including microfiltration(MF), ultrafiltration(UF), nanofiltration(NF) and reverse osmosis(RO) have been applied in complex landfill leachate treatment. MF and UF are used as pretreatment methods, whereas NF and RO are suitable for the deep treatment of the wastewater. However, membrane fouling is a great inhibition of the application of membrane technologies. Development of new membrane materials, effective pre-treatment technologies, and optimization of membrane process parameters should be the focus of membrane technologies to prevent membrane fouling.

Key words: carbon dioxide, microchannels, boiling heat transfer, critical heat flux(CHF), dryout, microscale

中图分类号:

TB69

陆至羚, 柳建华, 张良, 张瑞, 吴昊, 祁良奎. 微细通道内CO₂沸腾换热与干涸特性[J]. 化工进展, 2015, 34(08): 2961-2966.

LU Zhiling, LIU Jianhua, ZHANG Liang, ZHANG Rui, WU Hao, QI Liangkui. Heat transfer and dry-out characteristics of CO₂ in mini-channel[J]. Chemical Industry and Engineering Progree, 2015, 34(08): 2961-2966.

参考文献

[1] In S, Jeong S. Flow boiling heat transfer characteristics of R123 and R134a in a micro-channel[J]. International Journal of Multiphase Flow, 2009, 35: 987-1000.
[2] Wei L, Zan W. A general correlation for evaporative heat transfer in micro/mini-channels[J]. International Journal of Heat and Mass Transfer, 2010, 53: 1778-1787.
[3] 马虎根, 胡自成. 非共沸混合物微通道内流动沸腾特性[J]. 化工学报, 2006, 57(3): 526-529.
[4] 郑亚锋, 赵阳, 辛峰. 微反应器研究及展望[J]. 化工进展, 2004, 23(5): 461-467.
[5] 付涛涛, 朱春英, 王东继. 微通道内气液传质特性[J]. 化工进展, 2011, 30(s2): 95-98.
[6] Ducoulombie M, Colasson S. Carbon dioxide flow boiling in a single microchannel-Part Ⅱ: Heat transfer[J]. Experimental Thermal and Fluid Science, 2011, 35: 597-611.
[7] Bredesen A M, Hafner A, Pettersen J, et al. Heat transfer and pressure drop for in-tube evaporation of CO₂[C]//Proceedings of the International Conference on Heat Transfer Issues in Natural Refrienrants, University of Maryland, 1997: 1-15.
[8] Jeong, S, Jeong D, Lee J J. Evaporating heat transfer and pressure drop inside helical coils with the refrigerant carbon dioxide[C]//ICR0260, 21st IIR International Congress of Refrigeration, Washington DC, USA, 2003.
[9] Pettersen J. Flow vaporization of CO₂ in microchannel tubes[J]. Experimental Thermal and Fluid Science, 2004, 28: 111-121.
[10] Yun R, Kim Y, Kim M S. Flow boiling heat transfer of carbon dioxide in horizontal mini tubes[J]. International Journal of Heat and Fluid Flow, 2005, 26: 801-809.
[11] Yun R, Kim Y, Kim M S. Convective boiling heat transfer characteristics of CO₂ in microchannels[J]. International Journal of Heat and Mass Transfer, 2005, 48: 235-242.
[12] Kew P A, Cornwell K. Correlations for prediction of flow boiling heat transfer in small-diameters channels[J]. Applied Thermal Engineering, 1997, 17: 705-715.

[1]	赵晨, 苗天泽, 张朝阳, 洪芳军, 汪大海. 负压状态窄缝通道乙二醇水溶液传热特性[J]. 化工进展, 2023, 42(S1): 148-157.
[2]	杨寒月, 孔令真, 陈家庆, 孙欢, 宋家恺, 王思诚, 孔标. 微气泡型下向流管式气液接触器脱碳性能[J]. 化工进展, 2023, 42(S1): 197-204.
[3]	王胜岩, 邓帅, 赵睿恺. 变电吸附二氧化碳捕集技术研究进展[J]. 化工进展, 2023, 42(S1): 233-245.
[4]	时永兴, 林刚, 孙晓航, 蒋韦庚, 乔大伟, 颜彬航. 二氧化碳加氢制甲醇过程中铜基催化剂活性位点研究进展[J]. 化工进展, 2023, 42(S1): 287-298.
[5]	郑谦, 官修帅, 靳山彪, 张长明, 张小超. 铈锆固溶体Ce_0.25Zr_0.75O₂光热协同催化CO₂与甲醇合成DMC[J]. 化工进展, 2023, 42(S1): 319-327.
[6]	戴欢涛, 曹苓玉, 游新秀, 徐浩亮, 汪涛, 项玮, 张学杨. 木质素浸渍柚子皮生物炭吸附CO₂特性[J]. 化工进展, 2023, 42(S1): 356-363.
[7]	孙玉玉, 蔡鑫磊, 汤吉海, 黄晶晶, 黄益平, 刘杰. 反应精馏合成甲基丙烯酸甲酯工艺优化及节能[J]. 化工进展, 2023, 42(S1): 56-63.
[8]	王耀刚, 韩子姗, 高嘉辰, 王新宇, 李思琪, 杨全红, 翁哲. 铜基催化剂电还原二氧化碳选择性的调控策略[J]. 化工进展, 2023, 42(8): 4043-4057.
[9]	刘毅, 房强, 钟达忠, 赵强, 李晋平. Ag/Cu耦合催化剂的Cu晶面调控用于电催化二氧化碳还原[J]. 化工进展, 2023, 42(8): 4136-4142.
[10]	黄玉飞, 李子怡, 黄杨强, 金波, 罗潇, 梁志武. 光催化CO₂和CH₄重整催化剂研究进展[J]. 化工进展, 2023, 42(8): 4247-4263.
[11]	娄宝辉, 吴贤豪, 张驰, 陈臻, 冯向东. 纳米流体用于二氧化碳吸收分离研究进展[J]. 化工进展, 2023, 42(7): 3802-3815.
[12]	白亚迪, 邓帅, 赵睿恺, 赵力, 杨英霞. 变温吸附碳捕集机组标准化测试方案探讨及性能实验[J]. 化工进展, 2023, 42(7): 3834-3846.
[13]	俞俊楠, 俞建峰, 程洋, 齐一搏, 化春键, 蒋毅. 基于深度学习的变宽度浓度梯度芯片性能预测[J]. 化工进展, 2023, 42(7): 3383-3393.
[14]	陈蔚阳, 宋欣, 殷亚然, 张先明, 朱春英, 付涛涛, 马友光. 矩形微通道内液相黏度对气泡界面的作用机制[J]. 化工进展, 2023, 42(7): 3468-3477.
[15]	吕超, 张习文, 金理健, 杨林军. 新型两相吸收剂-离子液体系统高效捕获CO₂[J]. 化工进展, 2023, 42(6): 3226-3232.

微细通道内CO₂沸腾换热与干涸特性

Heat transfer and dry-out characteristics of CO₂ in mini-channel

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价