磷酸铵镁沉淀与沸石吸附组合工艺处理海水中的氨氮

doi:10.16085/j.issn.1000-6613.2015.07.042

化工进展 ›› 2015, Vol. 34 ›› Issue (07): 2060-2064.DOI: 10.16085/j.issn.1000-6613.2015.07.042

磷酸铵镁沉淀与沸石吸附组合工艺处理海水中的氨氮

王文华, 张晓青, 邱金泉, 司晓光, 成玉, 王静, 张雨山

国家海洋局天津海水淡化与综合利用研究所, 天津 300192

收稿日期:2014-12-04 修回日期:2015-01-04 出版日期:2015-07-05 发布日期:2015-07-05
通讯作者: 张雨山,教授级高级工程师,主要从事海水淡化与综合利用研究。E-mail:yushanzhang@hotmail.com。
作者简介:王文华(1985—),男,博士,工程师,主要从事海水净化与水再利用研究。
基金资助:
中央级公益性科研院所基本科研业务费专项资金(K- JBYWF-2013-G3)、海洋公益性行业科研专项(201105026)及国家海洋局青年海洋科学基金(2013542)项目。

Ammonia nitrogen removal from seawater by magnesium ammonium phosphate(MAP) precipitation combined with zeolite adsorption

WANG Wenhua, ZHANG Xiaoqing, QIU Jinquan, SI Xiaoguang, CHENG Yu, WANG Jing, ZHANG Yushan

Tianjin Institute of Seawater Desalination and Multipurpose Utilization, State Oceanic Administration, Tianjin 300192, China

Received:2014-12-04 Revised:2015-01-04 Online:2015-07-05 Published:2015-07-05

摘要/Abstract

摘要： 大量陆源营养物质的输入是导致我国近岸海域富营养化问题的主要原因, 传统生化法对海水中氮磷处理能力有限, 天然沸石凭借较强的选择性离子交换性能已成为一种较为经济和高效的水处理材料。本研究通过穿透实验考察了天然沸石对海水中氨氮的动态吸附性能, 采用磷酸铵镁(MAP)沉淀和沸石吸附组合工艺对海水中氨氮进行处理。实验结果表明, 天然沸石吸附氨氮达平衡时间随过滤速度的增大而减小, 随滤层高度的增加而增大, Logistic模型能较好反映天然沸石对海水中氨氮的动态吸附过程。MAP沉淀法与沸石吸附法联用可以将海水中氨氮含量降低至较低水平, 适宜的滤柱过滤条件为:滤速20L/h, 滤层高度100cm。通过焙烧或NaCl浸洗处理能够恢复天然沸石对海水中氨氮的吸附能力, 300℃焙烧2h和1.5mol/L NaCl溶液浸洗24h条件下的再生率分别为99.38%和122.22%。

关键词: 磷酸铵镁, 沸石, 海水, 氨氮, 去除效果

Abstract: The nutrients delivery from land usage and anthropogenic emissions in quantity is the main reason for euthrophication of coastal seawater in China. Nitrogen(N) and phosphorus(P) in seawater are hard to remove by conventional biological treatments. Due to its high ion exchange capacity and selectivity, natural zeolite has been one of the most efficient and economical water treatment materials. This paper studied the dynamic adsorption behavior of ammonium nitrogen from seawater, expressed as breakthrough curve, using natural zeolite bed filter. The magnesium ammonium phosphate(MAP) precipitation and zeolite adsorption combined process was performed to remove ammonia nitrogen from seawater. Experimental results showed that the adsorption reached equilibrium in a shorter period of time at higher flow rate lower and filter column height. It is indicated that the dynamic adsorption of ammonia nitrogen from seawater on zeolite filter was best represented by the Logistic model. The concentration of ammonium nitrogen in seawater dropped to a low level when treated with MAP precipitation combined with zeolite adsorption. The suitable filtration conditions of natural zeolite bed filter were as the following:The filter speed was 20L/h, and the filter column height was 100cm. The ammonia adsorption capacity of natural zeolite could be restored by using calcination or NaCl immersion. After treated by calcination at 300℃for 2h and immersed in 1.5mol/L NaCl solutions for 24h, the regeneration rate of natural zeolite was 99.38% and 122.22% respectively.

Key words: magnesium ammonium phosphate, zeolite, seawater, ammonium nitrogen, removal efficiency

中图分类号:

王文华, 张晓青, 邱金泉, 司晓光, 成玉, 王静, 张雨山. 磷酸铵镁沉淀与沸石吸附组合工艺处理海水中的氨氮[J]. 化工进展, 2015, 34(07): 2060-2064.

WANG Wenhua, ZHANG Xiaoqing, QIU Jinquan, SI Xiaoguang, CHENG Yu, WANG Jing, ZHANG Yushan. Ammonia nitrogen removal from seawater by magnesium ammonium phosphate(MAP) precipitation combined with zeolite adsorption[J]. Chemical Industry and Engineering Progree, 2015, 34(07): 2060-2064.

参考文献

[1] 国家海洋局. 2013年中国海洋环境状况公报[R]. 北京:2014.
[2] 唐文浩, 岳平, 葛成军, 等. 海水养殖废水光化学强化脱氮解毒的实验研究[J]. 农业环境科学学报, 2006, 25(5):1343-1346.
[3] 宋颖, 黄玉婷, 葛川, 等. 多介质土壤滤层系统(MSL)与潜流式人工湿地技术处理海水养殖废水的效能比较[J]. 环境科学, 2014, 35(9):3435-3442.
[4] 王文华, 张晓青, 邱金泉, 等. 磷酸铵镁(MAP)沉淀法处理低浓度氨氮污海水[J]. 化工进展, 2014, 33(1):228-232.
[5] 张美兰, 何圣兵, 陈雪初, 等. 天然沸石和硅酸钙滤床的脱氨除磷效能[J]. 水处理技术, 2007, 33(11):71-74.
[6] Weatherley L R, Miladinovic N D. Comparison of the ion exchange uptake of ammonium ion onto New Zealand clinoptilolite and mordenite[J]. Water Research, 2004, 38(20):4305-4312.
[7] 王大卫, 刘翔. 粉煤灰合成沸石去除城市暴雨径流中氨氮[J]. 环境工程学报, 2012, 6(1):195-200.
[8] Burgess R M, Perron M M, Cantwell M G, et al. Use of zeolite for removing ammonia and ammonia-caused toxicity in marine toxicity identification evaluations[J]. Archives of Environmental Contamination and Toxicology, 2004, 47(4):440-447.
[9] 刘转年, 刘源, 王贵荣. 超细粉煤灰基成型吸附剂的动态吸附实验[J]. 环境工程学报, 2009, 3(11):2109-2112.
[10] Farkaš A, Rožić M, Mikočević Z B. Ammonium exchange in leakage waters of waste dumps using natural zeolite from the Krapina region, Croatia[J]. Journal of Hazardous Materials, 2005, 117(1):25-33.
[11] Wang Y, Kmiya Y, Okuhara T. Removal of low-concentration ammonia in water by ion-exchange using Na-mordenite[J]. Water Research, 2007, 41(2):269-276.
[12] 赵丹, 王曙光, 栾兆坤. 改性斜发沸石吸附水中氨氮的研究[J]. 环境化学, 2003, 22(1):59-63.

[1]	潘宜昌, 周荣飞, 邢卫红. 高效分离同碳数烃的先进微孔膜：现状与挑战[J]. 化工进展, 2023, 42(8): 3926-3942.
[2]	王兰江, 梁瑜, 汤琼, 唐明兴, 李学宽, 刘雷, 董晋湘. 快速热解铂前体合成高分散的Pt/HY催化剂及其萘深度加氢性能[J]. 化工进展, 2023, 42(8): 4159-4166.
[3]	李吉焱, 景艳菊, 邢郭宇, 刘美辰, 龙永, 朱照琪. 耐盐型太阳能驱动界面光热材料及蒸发器的研究进展[J]. 化工进展, 2023, 42(7): 3611-3622.
[4]	朱雅静, 徐岩, 简美鹏, 李海燕, 王崇臣. 金属有机框架材料用于海水提铀的研究进展[J]. 化工进展, 2023, 42(6): 3029-3048.
[5]	殷成阳, 侯铭, 杨爽, 毛迪, 刘俊言. 过渡金属改性Cu-SSZ-13分子筛脱硝催化剂研究进展[J]. 化工进展, 2023, 42(6): 2963-2974.
[6]	任重远, 何金龙, 袁清. 分子筛膜晶间缺陷控制与修复技术研究进展[J]. 化工进展, 2023, 42(5): 2454-2463.
[7]	郭帅帅, 陈锦路, 金梁程龙, 陶醉, 陈小丽, 彭国文. 基于海水提铀的多孔芳香框架材料研究进展[J]. 化工进展, 2023, 42(3): 1426-1436.
[8]	陈昊, 张传浩, 于峰, 范彬彬, 李瑞丰. Y型沸石在异丁醇齐聚反应中的催化性能[J]. 化工进展, 2023, 42(2): 794-802.
[9]	高士超, 王树刚, 胡沛裕, 赵一铭, 王继红, 孙毅, 蒋爽. 沸石堆积高度对反应器蓄放热性能的影响[J]. 化工进展, 2023, 42(10): 5092-5100.
[10]	朱义浩, 赵白航, 王淳, 张雨晴, 杨海山. 改性煤矸石基沸石对水中腐殖酸的吸附性能[J]. 化工进展, 2023, 42(10): 5531-5537.
[11]	杨壮壮, 刘永军, 刘兴社, 刘喆, 杨璐, 张爱宁. 煤化工废水中油泥的聚结分离与水中有机物的去除效果[J]. 化工进展, 2023, 42(1): 538-545.
[12]	毛停停, 李双福, 黄李茗铭, 周川玲, 韩凯. 面向水处理与有机溶剂回收的太阳能界面蒸发系统与材料[J]. 化工进展, 2023, 42(1): 178-193.
[13]	王璐, 张磊, 都健. 机器学习高效筛选用于CO₂/N₂选择性吸附分离的沸石材料[J]. 化工进展, 2023, 42(1): 148-158.
[14]	邱琪丽, 蒋旭光. 垃圾焚烧飞灰在污染物控制领域中的应用探讨[J]. 化工进展, 2022, 41(7): 3855-3864.
[15]	杨韬, 王晓胜, 李然家, 余长春. 用于二甲醚羰基化反应的丝光沸石催化剂改性研究进展[J]. 化工进展, 2022, 41(5): 2451-2459.

磷酸铵镁沉淀与沸石吸附组合工艺处理海水中的氨氮

Ammonia nitrogen removal from seawater by magnesium ammonium phosphate(MAP) precipitation combined with zeolite adsorption

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价