环保型沥青研究进展

doi:10.16085/j.issn.1000-6613.2021-0859

化工进展 ›› 2021, Vol. 40 ›› Issue (S2): 226-231.DOI: 10.16085/j.issn.1000-6613.2021-0859

环保型沥青研究进展

丁佳瑛(), 薛永兵(), 刘振民, 李韬, 储一帆

太原科技大学化学与生物工程学院，山西太原 030021

收稿日期:2021-04-22 修回日期:2021-05-24 出版日期:2021-11-12 发布日期:2021-11-12
通讯作者: 薛永兵
作者简介:丁佳瑛（1996—），女，硕士研究生，研究方向为净味沥青。E-mail：365112260@qq.com。
基金资助:
山西省重点研发计划(201903D121025);山西省软科学研究项目(2018041043-1);2019年度山西省研究生教育改革课题(2019JG160)

Research progress of environmentally asphalt

DING Jiaying(), XUE Yongbing(), LIU Zhenmin, LI Tao, CHU Yifan

College of Chemistry and Bioengineering, Taiyuan University of Science and Technology, Taiyuan 030021, Shanxi, China

Received:2021-04-22 Revised:2021-05-24 Online:2021-11-12 Published:2021-11-12
Contact: XUE Yongbing

摘要/Abstract

摘要：

道路沥青在施工过程中产生的沥青烟无组织排放不仅会影响周围空气质量，还会对施工人员及周围居民造成健康隐患。为减少沥青烟污染，研究并使用较多的方法有工艺减排以及低排放沥青两种。工艺减排是采用一定的技术手段降低沥青体系的黏度，从而降低沥青混合料的拌合温度，以减少沥青烟排放。本文对温拌沥青技术研究进行了部分阐述，详细综述了研究较多的低排放沥青，即添加抑烟剂（阻燃剂、吸附剂、聚合物及一些新型材料等）通过物理或化学的方法将沥青烟气中的小分子加以固定，从而减少排放量。但单独使用某一抑烟剂会导致部分路用性能的下降，采用复配的方法从而克服这一缺点。本文对环保型沥青的研究及进展进行了总结并展望。

关键词: 沥青烟, 抑烟剂, 环保, 净味

Abstract:

During the construction of road asphalt, the disorganized emission of asphalt smoke will lead to the decline of the surrounding air quality, and affect the health of the construction personnel and the surrounding residents. In order to reduce asphalt smoke pollution, there are two methods: process emission reduction and low-emission asphalt research.Process emission reduction is to reduce the viscosity of asphalt system by certain technical means, so as to reduce the mixing temperature of asphalt mixture, and reduce asphalt smoke emission. In this paper, the research on warm-mix asphalt technology is partially described. Extensive research on low emission asphalt, which is adding smoke inhibitor (flame retardant, adsorbent, polymer and some new materials, etc.) to fix the small molecules in asphalt flue gas by physical or chemical methods to reduce emissions, is reviewed in detail. However, the use of a single smoke suppressant will lead to the decline of some road performance, so the compound method can overcome this shortcoming. In this paper, the research progress of environmentally asphalt is summarized and prospected.

Key words: asphalt smoke, smoke suppressant, environmental protection, taste purification

中图分类号:

TU535

丁佳瑛, 薛永兵, 刘振民, 李韬, 储一帆. 环保型沥青研究进展[J]. 化工进展, 2021, 40(S2): 226-231.

DING Jiaying, XUE Yongbing, LIU Zhenmin, LI Tao, CHU Yifan. Research progress of environmentally asphalt[J]. Chemical Industry and Engineering Progress, 2021, 40(S2): 226-231.

参考文献 21

1	唐宁, 王弘晔, 符聃, 等. 沥青混合料温拌技术的研究进展[J]. 中国材料进展, 2020, 39(9): 653-660.
	TANG Ning, WANG Hongye, FU Dan, et al. Research progress on warm mix asphalt technologies[J]. Materials China, 2020, 39(9): 653-660.
2	DU J C, CHANG K C. Evaluation of asphalt emulsion for use in warm mix asphalt[J]. Advanced Materials Research, 2011, 255/256/257/258/259/260: 3180-3184.
3	赖智钦. 温拌沥青混合料路用性能与沥青烟成分特性[J]. 广东公路交通, 2020, 46(4): 23-28.
	LAI Zhiqin. Road performance and asphalt smoke composition characteristics of warm mix asphalt mixture[J]. Guangdong Highway Communications, 2020, 46(4): 23-28.
4	CALABI-FLOODY A T, VALDÉS-VIDAL G A, SANCHEZ-ALONSO E, et al. Evaluation of gas emissions, energy consumption and production costs of warm mix asphalt (WMA) involving natural zeolite and reclaimed asphalt pavement (RAP)[J]. Sustainability, 2020, 12(16): 6410.
5	李丹. 阻燃环氧沥青混合料性能研究[J]. 公路, 2020, 65(1): 217-220.
	LI Dan. Study on performance of flame retardant epoxy asphalt mixture [J]. Highway, 2020, 65(1): 217-220.
6	郭寅川, 王涵, 申爱琴, 等. ATH/OMMT复合改性沥青阻燃抑烟性能与机理分析[J]. 硅酸盐通报, 2020, 39(6): 1989-1997.
	GUO Yinchuan, WANG Han, SHEN Aiqin, et al. Analysis of flame-retarding and smoke suppressing performance and mechanism of ATH/OMMT modified asphalt[J]. Bulletin of the Chinese Ceramic Society, 2020, 39(6): 1989-1997.
7	郭进存, 廖克俭, 戴跃玲. 阻燃沥青的研制[J]. 辽宁石油化工大学学报, 2005, 25(2): 5-8.
	GUO Jincun, LIAO Kejian, DAI Yueling. Development of asphalt for flame retardancy[J]. Journal of Liaoning Shihua University, 2005, 25(2): 5-8.
8	付其林, 魏建国, 彭文举, 等. DBDPE-Sb₂O₃协同阻燃沥青的性能与机理[J]. 中国公路学报, 2020, 33(2): 44-55.
	FU Qilin, WEI Jianguo, PENG Wenju, et al. Performance and mechanism of DBDPE-Sb₂O₃ synergistic flame retardant asphalt [J]. China Journal of Highway and Transport, 2020, 33(2): 44-55.
9	XIAO Y, WAN M, JENKINS K J, et al. Using activated carbon to reduce the volatile organic compounds from bituminous materials[J]. Journal of Materials in Civil Engineering, 2017, 29(10): 04017166.
10	崔培强. 沥青VOC分析技术及抑制方法研究[D]. 武汉: 武汉理工大学, 2015.
	CUI Peiqiang. Research methodologies on the VOC emissions from bituminous materials and its inhibitor[D]. Wuhan: Wuhan University of Technology, 2015.
11	刘静. 高温条件下沥青烟尘评价系统与抑制技术研究[D]. 重庆: 重庆交通大学, 2012.
	LIU Jing. Research on the evaluation system and suppression technology of asphaltfume under the condition of high temperature[D]. Chongqing: Chongqing Jiaotong University, 2012.
12	黄刚. 高温条件下抑烟改性沥青开发及混合料性能研究[D]. 重庆: 重庆交通大学, 2013.
	HUANG Gang. Exploitation of modified asphalt of fume suppression and study on performance of its mixture under the elevated temperature[D]. Chongqing: Chongqing Jiaotong University, 2013.
13	黄刚, 何兆益, 周超, 等. 膨胀石墨抑制沥青烟机理与抑烟沥青混合料动态性能[J]. 中国公路学报, 2015, 28(10): 1-10.
	HUANG Gang, HE Zhaoyi, ZHOU Chao, et al. Suppression mechanism of expanded graphite for asphalt fume and dynamic performance of asphalt mixture of fume suppression[J]. China Journal of Highway and Transport, 2015, 28(10): 1-10.
14	刘文娟, 周婷, 孙杨, 等. 新型无机复合沥青阻燃剂的制备及其阻燃机理[J]. 实验室研究与探索, 2019, 38(12): 10-15, 64.
	LIU Wenjuan, ZHOU Ting, SUN Yang, et al. Preparation of new inorganic composite flame retardant modified asphalt and its flame retardant mechanism[J]. Research and Exploration in Laboratory, 2019, 38(12): 10-15, 64.
15	王浩轩, 黄玮, 丛玉凤, 等. 环保型道路沥青的制备[J]. 建筑材料学报, 2020, 23(3): 700-706.
	WANG Haoxuan, HUANG Wei, CONG Yufeng, et al. Preparation of environment-friendly road asphalt[J]. Journal of Building Materials, 2020, 23(3): 700-706.
16	杨锡武, 彭绪亚, 张兴雨, 等. 沥青烟气抑制剂及沥青混合料性能的试验[J]. 重庆大学学报, 2013, 36(12): 70-78.
	YANG Xiwu, PENG Xuya, ZHANG Xingyu, et al. Experiments on the asphalt fume suppression agents and properties of asphalt concrete with fume suppression agent[J]. Journal of Chongqing University, 2013, 36(12): 70-78.
17	杨锡武, 彭绪亚, 钱诗林. 路面施工沥青烟气抑制剂及现场应用试验研究[J]. 华中科技大学学报(自然科学版), 2012, 40(6): 122-127.
	YANG Xiwu, PENG Xuya, QIAN Shilin. Experimental study on suppression agents of asphalt fume from pavement construction and its application[J]. Journal of Huazhong University of Science and Technology (Natural Science Edition), 2012, 40(6): 122-127.
18	刘浪, 解伟, 金娇, 等. 纳米TiO₂基催化剂在环保功能路面应用的研究进展[J]. 中国材料进展, 2020, 39(1): 78-83.
	LIU Lang, XIE Wei, JIN Jiao, et al. Research progress on the application of nanoscale TiO₂-based catalysts in the environment-friendly pavement[J]. Materials China, 2020, 39(1): 78-83.
19	徐世法, 李思童, 李书飞, 等. 汽车尾气降解材料路用稳定剂开发及性能评价[J]. 中国公路学报, 2019, 32(4): 114-121.
	XU Shifa, LI Sitong, LI Shufei, et al. Development and evaluation of stabilizer for automobile exhaust gas degradation materials application in pavement[J]. China Journal of Highway and Transport, 2019, 32(4): 114-121.
20	鲍金奇. 光催化材料对道路沥青烟气抑制作用的研究[D]. 抚顺: 辽宁石油化工大学, 2020.
	BAO Jinqi. Study on the inhibition effect of photocatalytic materials on road asphalt fume[D]. Fushun: Liaoning Shihua University, 2020.
21	王朝辉, 李彦伟, 葛娟, 等. Tourmaline改性沥青及其混合料热拌减排性能[J]. 中国公路学报, 2014, 27(11): 17-24.
	WANG Chaohui, LI Yanwei, GE Juan, et al. Emission reduction effect of tourmaline modified asphalt and its mixtures under condition of hot-mix[J]. China Journal of Highway and Transport, 2014, 27(11): 17-24.

[1]	杨志强, 曾纪珺, 马义丁, 尉涛, 赵波, 刘英哲, 张伟, 吕剑, 李兴文, 张博雅, 唐念, 李丽, 孙东伟. 六氟化硫替代气体的研究现状及未来发展趋势[J]. 化工进展, 2023, 42(8): 4093-4107.
[2]	卢德庆, 辛靖, 朱元宝, 苏梦军. 流化催化裂化油浆综合利用的分析[J]. 化工进展, 2021, 40(S1): 142-149.
[3]	马双忱, 林宸雨, 周权, 吴忠胜, 刘琦, 陈文通, 樊帅军, 要亚坤, 马采妮. 基于深度神经网络的脱硫系统预测模型及应用[J]. 化工进展, 2021, 40(3): 1689-1698.
[4]	刘祚人, 许传龙, 汤光华. 基于ASPEN Plus的燃煤机组环保岛系统仿真与敏感性分析[J]. 化工进展, 2021, 40(12): 6564-6573.
[5]	王凡, 谷佳泽, 胡兵, 谈继淮, 朱新宝. 邻苯二甲酸二(乙二醇醚)酯绿色合成及增塑PVC性能[J]. 化工进展, 2021, 40(11): 6315-6322.
[6]	李丹丹, 谈继淮, 胡丁根, 陈建斌, 刘祝兰, 曹云峰. 水性聚氨酯表面施胶剂的制备、改性及应用研究进展[J]. 化工进展, 2021, 40(1): 366-377.
[7]	张虹, 罗莹, 崔朋蕾, 杨军. 离子液体在纳米材料合成中的应用[J]. 化工进展, 2020, 39(5): 1803-1811.
[8]	王成鸿,孟凡宁,魏昕,曹田田,栾金义. 金属-有机框架材料在石化环保领域的应用[J]. 化工进展, 2020, 39(2): 429-438.
[9]	张华, 沈一丁, 杨凯, 段望望. 自交联阳离子丙烯酰胺共聚物合成及应用[J]. 化工进展, 2020, 39(11): 4581-4588.
[10]	孙国方, 郑修新, 于海斌, 赵甲, 高鹏, 费亚南, 刘有鹏. 邻苯二甲酸二异丁酯脱硫-加氢工艺[J]. 化工进展, 2017, 36(01): 203-209.
[11]	费亚南，赵甲，李孝国，孙国方，高鹏，郑修新，刘有鹏，于海斌. 加氢法生产环己烷1,2-二甲酸二(2-乙基己)酯工艺[J]. 化工进展, 2014, 33(11): 3057-3060.
[12]	陈燕敏，孙彩霞，吴晋英，黄长山. 一种环保型阻垢缓蚀剂的性能[J]. 化工进展, 2014, 33(01): 204-208.
[13]	蒋平平，张书源，冷炎，董玉明，张萍波. 催化合成环保增塑剂的研究及其应用进展[J]. 化工进展, 2012, 31(05): 953-964.
[14]	宋航，姚舜，李新莹，杨莹莹，贾春梅. 基于构建集约环保型社会的天然植物化工的研究进展 [J]. 化工进展, 2011, 30(4): 691-.
[15]	辛寅昌，周世光，康峰，许东彬，安骏. 核磁共振处理稀土活性复合物用于燃油节能环保 [J]. 化工进展, 2007, 26(4): 594-.

环保型沥青研究进展

Research progress of environmentally asphalt

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献 21

相关文章 15

编辑推荐

Metrics

本文评价