热集成变压精馏分离乙二胺-水共沸体系的模拟优化

doi:10.16085/j.issn.1000-6613.2017-1697

化工进展 ›› 2018, Vol. 37 ›› Issue (06): 2426-2431.DOI: 10.16085/j.issn.1000-6613.2017-1697

热集成变压精馏分离乙二胺-水共沸体系的模拟优化

何晓旭, 钱欣瑞, 鄢烈祥, 史彬

武汉理工大学化学化工与生命科学学院, 湖北武汉 430070

收稿日期:2017-08-11 修回日期:2017-09-15 出版日期:2018-06-05 发布日期:2018-06-05
通讯作者: 史彬,副教授,研究方向为过程系统工程。
作者简介:何晓旭(1993-),女,硕士研究生。
基金资助:
国家自然科学基金项目（21376185）。

Simulation and optimization for azeotrope of ethylenediamine-water based on heat-integrated pressure-swing distillation

HE Xiaoxu, QIAN Xinrui, YAN Liexiang, SHI Bin

School of Chemistry, Chemical Engineering and Life Sciences, Wuhan University of Technology, Wuhan 430070, Hubei, China

Received:2017-08-11 Revised:2017-09-15 Online:2018-06-05 Published:2018-06-05

摘要/Abstract

摘要： 针对乙二胺-水共沸物组成对压力较为敏感的特性，采用部分热集成变压精馏工艺分离该共沸物。先利用Aspen Plus软件对该工艺进行稳态模拟，再以理论塔板数、进料位置、回流比为优化变量，水和乙二胺的纯度为约束，以年度总费用（total annual cost，TAC）为目标函数建立乙二胺-水共沸体系分离系统的优化设计模型。采用列队竞争算法对该分离过程主要工艺参数进行优化，得到了变压精馏分离乙二胺-水体系的最佳工艺操作参数及设备参数。模拟结果表明，利用算法对多变量进行同时优化可得到更具经济效益的分离系统，与传统优化结果相比，可降低TAC约7.31%。在此基础上，对高压塔的操作压力进行优化分析，将其由2atm提升至4atm（1atm=101325Pa），并对流程其他参数进行优化，可显著降低TAC约24.62%。进一步，采用部分热集成比普通变压双塔精馏降低TAC约21.87%

关键词: 变压精馏, 共沸物, 列队竞争算法, 热集成, 优化

Abstract: As the azeotropic composition of ethylenediamine-water system is sensitive to pressure, a pressure-swing distillation process with partial heat integrated was proposed to separate the azeotrope. First, the steady state simulation of this system was performed by Aspen Plus, and then the optimal design model of separation system for this azeotrope was established, where the total annual cost(TAC) was treated as objective function, the theoretical stage number of tower, feed stage and reflux ratio were adopted as variables, and the purity of products was used as constraint. The line-up competition algorithm was presented to obtain the optimum operation parameters and equipment parameters of the separation system. Simulation results showed that the simultaneous optimization of multiple variables can achieve a more economical separation system as compared with the traditional optimization results, where the TAC can be reduced by about 7.31%. On this basis, improving the operating pressure of the higher pressure column from 2 atm to 4 atm and optimizing the other parameters of the process can significantly reduce the TAC by about 24.62%. Moreover, through partial heat integration, the TAC is further reduced by about 21.87% compared with the one without heat integration.

Key words: pressure-swing distillation, azeotrope, line-up competition algorithm, heat-integrated, optimization

中图分类号:

TQ021.8

何晓旭, 钱欣瑞, 鄢烈祥, 史彬. 热集成变压精馏分离乙二胺-水共沸体系的模拟优化[J]. 化工进展, 2018, 37(06): 2426-2431.

HE Xiaoxu, QIAN Xinrui, YAN Liexiang, SHI Bin. Simulation and optimization for azeotrope of ethylenediamine-water based on heat-integrated pressure-swing distillation[J]. Chemical Industry and Engineering Progress, 2018, 37(06): 2426-2431.

参考文献

[1] 杨溢,兰昭洪,田保亮,等.乙二胺合成工艺进展[J].石油化工, 2012, 41(5):603-608. YANG Y, LAN Z H, TIAN B L, et al. Progress in research of ethylenediamine synthesis[J]. Petrochemical Technology, 2012, 41(5):603-608.
[2] 王伟,毛伟,吕婧,等.萃取精馏法分离乙二胺和H₂O的共沸物[J].化学工程, 2014, 42(10):25-28. WANG W, MAO W, LV J, et al. Separation of EDA and H₂O azeotrope by extractive distillation[J]. Chemical Engineering, 2014, 42(10):25-28.
[3] WANG WW, JIA Q, DUAN J H, et al. Simulation and optimization for separation of ethylenediamine-waterazeotropic mixture[C]//International Conference on Materials, Environmental and Biological Engineering. France:Atlantis Press, 2015:371-374.
[4] JAKESLAND C, HYTOFT G, GANI R. Computer-aided process design and optimization with novel separation units[J]. Applied Thermal Engineering, 1997, 17(8/9/10):973-980.
[5] LUYBEN W L. Comparison of extractive distillation and pressure-swing distillation for acetone-methanol separation[J]. Computers & Chemical Engineering, 2013, 50(8):1-7.
[6] 杨德明,王新兵.采用双效变压精馏工艺分离甲苯-正丁醇的模拟[J].石油化工, 2009, 38(10):1081-1084. YANG D M, WANG X B. Simulation of separating toluene-butanol bydouble effect pressure swing distillation[J]. Petrochemical Technology, 2009, 38(10):1081-1084.
[7] 袁俊,杨建明,赵锋伟,等.热泵变压精馏分离乙二胺水溶液的模拟[J].化学工程, 2015, 43(4):75-78. YUAN J, YANG J M, ZHAO F W, et al. Simulation on separation of ethylenediamine and water by heat-pump pressure swing distillation[J]. Chemical Engineering, 2015, 43(4):75-78.
[8] 袁俊,杨建明,赵锋伟,等. 热集成变压精馏分离乙二胺水溶液的模拟[J]. 计算机与应用化学, 2015(2):235-238. YUAN J, YANG J M, ZHAO F W, et al. Simulation on separation of ethylenediamine and water by heat-integrated pressure swing distillation[J]. Computers and Applied Chemistry, 2015(2):235-238.
[9] 赵俊彤,李玲,许春建,等.热集成变压精馏分离乙醇-甲苯体系的过程模拟和优化[J].化工进展, 2013, 32(7):1495-1499. ZHAO J T, LI L, XU, C J, et al. Simulation and optimization of pressure swing distillation process with heat integration for the separation of ethanol-toluene mixture[J]. Chemical Industry and Engineering Progress, 2013, 32(7):1495-1499.
[10] 姜斌,吴菲,隋红,等.甲醇-丙酮共沸物分离的研究进展[J].化工进展, 2010, 29(3):397-402. JIANG B, WU F, SUI H, et al. Development in separation of acetone-methanol azeotrope[J]. Chemical Industry and Engineering Progress, 2010, 29(3):397-402.
[11] KNAPP J P, DOHERTY M F. A new pressure-swing-distillation process for separating homogeneous azeotropic mixtures[J]. Industrial & Engineering Chemistry Research,, 1992, 31(1):346-357.
[12] LI R,YE Q,SUO X,et al. Heat-integrated pressure-swing distillation process for separation of a maximum-boiling azeotropeethylenediamine/water[J]. Chemical Engineering Research & Design, 2016, 105:1-15.
[13] JANA A K. Heat integrated distillation operation[J]. Applied Energy, 2010, 87(5):1477-1494.
[14] REPKE J U, KLEIN A, BOGLE D, et al. Pressure swing batch distillation for homogeneous azeotropicseparation[J]. Chemical Engineering Research & Design, 2007, 85(4):492-501.
[15] YAN L X, MA D. Global optimization of non-convex nonlinear programs using line-up competition algorithm[J]. Computers & Chemical Engineering, 2001, 25(11/12):1601-1610.
[16] 林子雄,鄢烈祥,李骁淳,等.基于流程模拟器和列队竞争算法的精馏操作优化[J].化工进展, 2013, 32(1):54-58. LIN Z X, YAN L X, LI X C, et al. Distillation process operation optimization based on process simulatorand the line-up competition algorithm[J]. Chemical Industry and Engineering Progress, 2013, 32(1):54-58.
[17] 代红进,汪坤,史彬,等.催化裂化分离系统多产品方案的多目标优化[J].石油炼制与化工, 2016(2):93-97. DAI H J, WANG K, SHI B, et al. Multi-objective optimization of multi-product plan for fluid catalytic cracking separation system[J]. Petroleum Processing and Petrochemicals, 2016(2):93-97.
[18] 李振华,林子雄,罗艳玲,等.基于流程模拟器和列队竞争算法的蒸馏优化设计[J].化学工程, 2013(8):67-70. LI Z H, LIN Z X, LOU Y L, et al. Optimization design of distillation process based on processsimulator and line-up competition algorithm[J]. Chemical Engineering, 2013(8):67-70.
[19] 中华人民共和国国家质量监督检验检疫总局.固定式压力容器安全技术监察规程:TSG 21-2016[S].北京:新华出版社, 2016. General Administration of Quality Supervision, Inspection and Quarantine of the People's Republic of China. Supervision regulation on safety technology for stationary pressure vessel:TSG 21-2016[S]. Beijing:Xinhua Publishing House, 2016.

热集成变压精馏分离乙二胺-水共沸体系的模拟优化

Simulation and optimization for azeotrope of ethylenediamine-water based on heat-integrated pressure-swing distillation

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	王正坤, 黎四芳. 双子表面活性剂癸炔二醇的绿色合成[J]. 化工进展, 2023, 42(S1): 400-410.
[2]	孙玉玉, 蔡鑫磊, 汤吉海, 黄晶晶, 黄益平, 刘杰. 反应精馏合成甲基丙烯酸甲酯工艺优化及节能[J]. 化工进展, 2023, 42(S1): 56-63.
[3]	李梦圆, 郭凡, 李群生. 聚乙烯醇生产中回收工段第三、第四精馏塔的模拟与优化[J]. 化工进展, 2023, 42(S1): 113-123.
[4]	张瑞杰, 刘志林, 王俊文, 张玮, 韩德求, 李婷, 邹雄. 水冷式复叠制冷系统的在线动态模拟与优化[J]. 化工进展, 2023, 42(S1): 124-132.
[5]	王福安. 300kt/a环氧丙烷工艺反应器降耗减排分析[J]. 化工进展, 2023, 42(S1): 213-218.
[6]	陈匡胤, 李蕊兰, 童杨, 沈建华. 质子交换膜燃料电池气体扩散层结构与设计研究进展[J]. 化工进展, 2023, 42(S1): 246-259.
[7]	李春利, 韩晓光, 刘加朋, 王亚涛, 王晨希, 王洪海, 彭胜. 填料塔液体分布器的研究进展[J]. 化工进展, 2023, 42(9): 4479-4495.
[8]	刘炫麟, 王驿凯, 戴苏洲, 殷勇高. 热泵中氨基甲酸铵分解反应特性及反应器结构优化[J]. 化工进展, 2023, 42(9): 4522-4530.
[9]	王晨, 白浩良, 康雪. 大功率UV-LED散热与纳米TiO₂光催化酸性红26耦合系统性能[J]. 化工进展, 2023, 42(9): 4905-4916.
[10]	李海东, 杨远坤, 郭姝姝, 汪本金, 岳婷婷, 傅开彬, 王哲, 何守琴, 姚俊, 谌书. 炭化与焙烧温度对植物基铁碳微电解材料去除As(Ⅲ)性能的影响[J]. 化工进展, 2023, 42(7): 3652-3663.
[11]	李蓝宇, 黄新烨, 王笑楠, 邱彤. 化工科研范式智能化转型的思考与展望[J]. 化工进展, 2023, 42(7): 3325-3330.
[12]	林海, 王彧斐. 考虑噪声约束的分布式风场布局优化[J]. 化工进展, 2023, 42(7): 3394-3403.
[13]	周龙大, 赵立新, 徐保蕊, 张爽, 刘琳. 电场-旋流耦合强化多相介质分离研究进展[J]. 化工进展, 2023, 42(7): 3443-3456.
[14]	薛凯, 王帅, 马金鹏, 胡晓阳, 种道彤, 王进仕, 严俊杰. 工业园区分布式综合能源系统的规划与调度[J]. 化工进展, 2023, 42(7): 3510-3519.
[15]	侯殿保, 贺茂勇, 陈育刚, 杨海云, 李海民. 资源优化配置与循环经济在钾资源开发利用中的应用[J]. 化工进展, 2023, 42(6): 3197-3208.