好氧颗粒污泥的连续化研究进展

doi:10.16085/j.issn.1000-6613.2015.11.038

摘要/Abstract

摘要： 以泥水分离机制为分类标准,现有连续流好氧颗粒污泥反应器可分为沉淀区重力沉降分离型、三相分离器型、筛网过滤分离型及膜组件分离型。总结这些研究发现,好氧颗粒污泥的连续化所取得的研究成果还极其有限,且还存在着许多不足,包括:①现有连续流好氧颗粒污泥反应器的泥水分离器形式繁多,但很少有研究对泥水分离器的分离效果进行系统研究,导致难以评价这些分离器的可靠性;②缺乏对反应器内水力学流态的研究,而流态决定了微生物的存在形式及传质效果,进而影响好氧颗粒污泥的稳定性;③缺乏长期稳定运行的数据支撑,因而难以评价反应器的可靠性。对此,立足于序批式活性污泥工艺中所取得的研究成果并积极吸收工程上的成功经验与教训,无疑可大大减小连续流好氧颗粒污泥反应器研发的风险。

关键词: 好氧颗粒污泥, 连续流, 反应器

Abstract: Classified by liquid and sludge separation mechanisms, the existing continuous flow aerobic granular reactors(CFAGRs) are divided into four categories:gravity settling by settling tank or settling area, three phase separator, sieve filtration and membrane module separation. The research on CFAGR still has some disadvantages, including:①Although there are many kinds of three phase separators equipped by CFAGR, but their separation effectiveness is rarely investigated, thus, it is difficult to evaluate the reliability of these separators;②Hydraulic flow state of these reactors is rarely studied. However, hydraulic flow pattern determines the existence form of microbe and mass transfer effects, which eventually affects the stability of aerobic granular sludge;③As there is lack of long-term stable operational data, it is hard to evaluate the feasibility of these reactors. In summary, in order to reduce the risk, research and development of CFAGR should rely on the existing achievements obtained from SBR and absorb the successful experience and lessons from engineering.

Key words: aerobic granule sludge, continuous flow, reactor

中图分类号:

X703

闻香兰, 但昭和. 好氧颗粒污泥的连续化研究进展[J]. 化工进展, 2015, 34(11): 4059-4064.

WEN Xianglan, DAN Zhaohe. Advances in continuity of aerobic granular sludge[J]. Chemical Industry and Engineering Progree, 2015, 34(11): 4059-4064.

参考文献

[1] Adav S S,Lee D J,Show K Y,et al. Aerobic granular sludge:Recent advances[J]. Biotechnology Advances,2008,26(5):411-423.
[2] Mishima K,Nakamura M. Self-Immobilization of aerobic activated sludge—A pilot study of the aerobic upflow sludge blanket process in municipal sewage treatment[J]. Water Science and Technology,199l,23:981-990.
[3] Liu Y,Tay J H. State of the art of biogranulation technology for wastewater treatment[J]. Biotechnology Advances,2004,22(7):533-563.
[4] Lee D J,Chen Y Y,Show K Y,et al. Advances in aerobic granule formation and granule stability in the course of storage and reactor operation[J]. Biotechnology Advances,2010,28(6):919-934.
[5] Show K Y,Lee D J,Tay J H. Aerobic granulation:Advances and challenges[J]. Applied Biochemistry and Biotechnology,2012,167(6):1622-1640.
[6] Liu Y,Tay J H. The essential role of hydrodynamic shear force in the formation of biofilm and granular sludge[J]. Water Research,2002,36(7):1653-1665
[7] Liu Y,Wang Z W,Tay J H. A unified theory for upscaling aerobic granular sludge sequencing batch reactors[J]. Biotechnology Advances,2005,23(5):335-344.
[8] 张岩,王永胜,白玉华,等. 泳动床/好氧颗粒污泥新技术处理生活污水的特性研究[J]. 环境科学,2007,28(10):2249-2254.
[9] 鲁文娟,陈希,袁林江. 连续流传统活性污泥系统中好氧颗粒污泥的培养[J]. 环境工程学报,2013,7(6):2069-2073.
[10] 李媛,沈耀良,孙立柱. 采用CSTR反应器培养好氧颗粒污泥的研究[J]. 中国给水排水,2008,24(5):10-13.
[11] 沈耀良,李媛,孙立柱. 连续流反应器中培养好氧颗粒污泥的运行效能研究[J]. 环境污染与防治,2010,32(1):1-4,8.
[12] 张雯,邓风,何超群,等. 不同类型反应器好氧颗粒污泥培养过程研究[J]. 工业安全与环保,2010,36(9):23-25.
[13] 张雯,邓风,何超群. CSTR反应器好氧颗粒污泥脱氮影响因素研究[J]. 水处理技术,2011,37(1):116-120.
[14] Morales N,Figueroa M,Mosquera-Corral A,et al. Aerobic granular-type biomass development in a continuous stirred tank reactor[J]. Separation and Purification Technology,2012,89(22):199-205.
[15] 田永生,买文宁,代吉华. 连续流状态下好氧颗粒污泥培养及其脱氮除磷性能研究[J]. 广东化工,2012,39(7):26-28.
[16] 贾晓凤,孙长清,买文宁,等. 连续流态下好氧颗粒污泥的培养及处理制药废水的性能[J]. 中国地质大学学报:地球科学,2013,38(4):870-876.
[17] 周丹丹,刘孟媛,侯典训,等. 连续流气提式流化床启动过程中[J].吉林大学学报:地球科学版,2012,42(1):212-219.
[18] 牛姝,段百川,张祚黧,等. 连续流态下以城市污水培养好氧颗粒污泥及颗粒特性研究[J]. 环境科学,2013,34(3):986-992.
[19] Zhou D D,Liu M Y,Wang J,et al. Granulation of activated sludge in a continuous flow airlift reactor by strong drag force[J]. Biotechnology and Bioprocess Engineering,2013,18(2):289-299
[20] Zhou D D,Dong S S,Gao L L,et al. Distribution characteristics of extracellular polymeric substances and cells of aerobic granules cultivated in a continuous-flow airlift reactor[J]. Journal of Chemical Technology and Biotechnology,2013,88(5):942-947.
[21] Zhou D D,Liu M Y,Gao L L,et al. Calcium accumulation characterization in the aerobic granules cultivated in a continuous-flow airlift bioreactor[J]. Biotechnology Letters,2013,35(6):871-877.
[22] Yang Y,Zhou D D,Xu Z X,et al. Enhanced aerobic granulation,stabilization,and nitrification in a continuous-flow bioreactor by inoculating biofilms[J]. Applied Microbiology and Biotechnology,2014,98(12):5737-5745.
[23] Jemaat Z,Suárez-Ojeda M E,Pérez J,et al. Simultaneous nitritation and p-nitrophenol removal using aerobic granular biomass in a continuous airlift reactor[J]. Bioresource Technology,2013,150(4):307-313.
[24] Jemaat Z,Suárez-Ojeda M E,Pérez J,et al. Partial nitritation and o-cresol removal with aerobic granular biomass in a continuous airlift reactor[J]. Water Research,2014,48(1):354-362.
[25] Wan C,Yang X,Lee D,et al. Influence of hydraulic retention time on partial nitrification of continuous-flow aerobic granular-sludge reactor[J]. Environmental Technology,2014,35(14):1760-1765.
[26] Jin R,Zheng P,Mahmood Q,et al. Performance of a nitrifying airlift reactor using granular sludge[J]. Separation and Purification Technology,2008,63(3):670-675.
[27] Long B,Yang C Z,Pu W H,et al. Tolerance to organic loading rate by aerobic granular sludge in a cyclic aerobic granular reator[J]. Bioresource Technology,2015,182:314-322.
[28] Liu H B,Li Y J,Yang C Z,et al. Stable aerobic granules in continuous-flow bioreactor with self-forming dynamic membrane[J]. Bioresource Technology,2012,121(2):111-118.
[29] Liu H B,Xiao H,Huang S,et al. Aerobic granules cultivated and operated in continuous-flow bioreactor under particle-size selective pressure[J]. Journal of Environmental Sciences,2014,26(11):2215-2221.
[30] 邱光磊,宋永会,曾萍,等. 连续流膜生物反应器中好氧颗粒污泥的形成及机制探讨[J]. 环境科学学报,2011,31(3):476-484
[31] 刘爱萍,陈中颖,李开明,等. MBR中磁种好氧颗粒污泥的培养及对膜污染的影响[J]. 中国给水排水,2010,26(19):1-4.
[32] Juang Y C,Adav S S,Lee D J,et al. Stable aerobic granules for continuous-flow reactors:Precipitating calcium and iron salts in granular interiors[J]. Bioresource Technology,2010,101(21):8051-8057.
[33] Liu Y,Liu Q S. Causes and control of filamentous growth in aerobic granular sludge sequencing batch reactors[J]. Biotechnology Advances,2006,24(1):115-127.
[34] Qin L,Tay J H,Liu Y. Selection pressure is a driving force of aerobic granulation in sequencing batch reactors[J]. Process Biochemistry,2004,39(5):579-584.