碱化度对聚合氯化铝混凝除硅的影响

doi:10.16085/j.issn.1000-6613.2015.12.040

化工进展 ›› 2015, Vol. 34 ›› Issue (12): 4375-4378,4397.DOI: 10.16085/j.issn.1000-6613.2015.12.040

碱化度对聚合氯化铝混凝除硅的影响

赵晓非¹, 张晓阳¹, 杨腾飞¹, 范蕾¹, 王顺武¹, 于庆龙²

1 东北石油大学化学化工学院石油与天然气化工省重点实验室, 黑龙江大庆 163318;
2 大庆油田有限责任公司第四采油厂试验大队试验一队, 黑龙江大庆 163511

收稿日期:2015-06-05 修回日期:2015-06-24 出版日期:2015-12-05 发布日期:2015-12-05
通讯作者: 赵晓非(1967—),男,教授,主要从事油田化学添加剂的开发及现场应用。E-maildqpifxz@163.com。
作者简介:赵晓非(1967—),男,教授,主要从事油田化学添加剂的开发及现场应用。E-maildqpifxz@163.com。
基金资助:
黑龙江省教育厅科学技术研究项目(12531061)。

Influence of basicity of polyaluminum chloride on removal of silicon

ZHAO Xiaofei¹, ZHANG Xiaoyang¹, YANG Tengfei¹, FAN Lei¹, WANG Shunwu¹, YU Qinglong²

1 Provincial Key Laboratory of Oil & Gas Chemical Technology, School of Chemistry & Chemical Engineering, Northeast Petroleum University, Daqing 163318, Heilongjiang, China;
2 The Fourth Production Experiment Group Team of Daqing Oilfield Company Ltd., Daqing 163511, Heilongjiang, China

Received:2015-06-05 Revised:2015-06-24 Online:2015-12-05 Published:2015-12-05

摘要/Abstract

摘要： 通过对实验室现有工业级聚合氯化铝进行碱化度分析,向多个化学试剂厂调研得出,现场常用聚合氯化铝的碱化度在1.5～2.7之间。通过合成不同碱化度(2.0～2.4)的聚合氯化铝,对模拟成垢水进行系统的混凝实验,考察碱化度对聚合氯化铝混凝除硅的影响。研究表明,碱化度会决定铝形态的分布,进而影响混凝除硅的效果。随着碱化度的升高,Al_a含量逐渐降低,Al_b含量先增大后减小,Al_c含量逐渐增加。对模拟污水处理后,残余硅酸形态有很大差异,用聚合氯化铝(2.0)除硅后Si_a含量变为32.1mg/L,Si_c含量变为15.3mg/L;聚合氯化铝(2.2)除硅后Si_a含量变为28.71mg/L,Si_c含量变为30.5mg/L;聚合氯化铝(2.4)除硅后Si_a含量变为22.4mg/L,Si_c含量变为41.2mg/L。聚合氯化铝(2.0)除硅后Si_a降低的比例最大,聚合氯化铝(2.4)除硅后Si_c降低的比例最大。随着碱化度的升高,全硅剩余含量依次为47.4mg/L、59.5mg/L、63.6mg/L,表明碱化度越低,除硅效果越好。

关键词: 聚合氯化铝, 碱化度, 铝形态, 硅形态, 混凝除硅

Abstract: By analyzing the alkalization degree of existing industrial-grade polymeric aluminum chloride in the laboratory and investigating several chemical reagent factories,we obtained that the alkalization degree of polymeric aluminum chloride commonly used on site is between 1.5—2.7. By synthesizing polymeric aluminum chloride with different alkalization degrees (2.0—2.4),we conducted a systematic coagulation experiment on the simulation of scale-forming water,and investigated the influence of alkalization degree on the coagulation silica removal of polymeric aluminum chloride. The results show that the alkalization degree will determine the distribution of aluminum speciation and therefore influence the effect of coagulation silicon removal. As the alkalization degree increases,the content of Al_a gradually decreases,the content of Al_b first increases and then decreases,while the content of Al_c gradually increases. After simulation of wastewater treatment,the residual silicate speciation is largely different. After silicon removal of polymeric aluminum chloride (2.0),the content of Si_a changes to 32.1mg/L,and the content of Si_c changes to 15.3mg/L;after silicon removal of polymeric aluminum chloride (2.2),the content of Si_a changes to 28.71mg/L,and the content of Si_c changes to 30.5mg/L;after silicon removal of polymeric aluminum chloride (2.4),the content of Si_a changes to 22.4mg/L,and the content of Si_c changes to 41.2mg/L. The proportion in the decrease of Si_a is the largest after silicon removal of polymeric aluminum chloride (2.0),and the proportion in the decrease of Si_c is the largest after silicon removal of polymeric aluminum chloride (2.4). With the increase of alkalization degree,the total residual silicon contents are respectively 47.4mg/L,59.5mg/L and 63.6mg/L. Within the author's scope of research,the lower the alkalization degree,the better the effect of silica removal.

Key words: polyaluminum chloride, basicity, aluminum speciation, silicon speciation, coagulation for silica removal

中图分类号:

赵晓非, 张晓阳, 杨腾飞, 范蕾, 王顺武, 于庆龙. 碱化度对聚合氯化铝混凝除硅的影响[J]. 化工进展, 2015, 34(12): 4375-4378,4397.

ZHAO Xiaofei, ZHANG Xiaoyang, YANG Tengfei, FAN Lei, WANG Shunwu, YU Qinglong. Influence of basicity of polyaluminum chloride on removal of silicon [J]. Chemical Industry and Engineering Progree, 2015, 34(12): 4375-4378,4397.

参考文献

[1] Shin J Y,Spinette R F,O'Melia C R. Stoichiometry of coagulation revisited[J]. Environmental Science and Technology,2008,7:2582-2589.
[2] Duffy S J,Vanlcon G W. Characterization of Al Hydroxide by ferron method[J]. Environmental Science and Technology,1994,28:1950-1956.
[3] 郭明红,叶天旭,李秀妹,等. Ferron逐时络合比色法在NFAC-PEM/AM复合絮凝剂[Al+Fe]形态分析中的应用[J]. 青岛科技大学学报:自然科学版,2011,32(3):256-260.
[4] 高宝平,李婧芳,武五爱. 铝形态分析的研究进展[J]. 理化检验:化学分册,2011,47(3):371-375.
[5] Fujiwara Kitao,Uchida Masayuki,Chen Minmin,et al. Ozone gas-phase chemiluminescence for silane and its application to the determination of silicate in natural waters[J]. Analytical Chemistry,1993,14:1814-1818.
[6] Yadav Abhay,Bhowmik Debdas,Sikder Nirmala. Direct determination of zirconium and silicon in zircon by flame atomic absorption spectrometry using two rapid decomposition methods[J].Analytical Methods,2012,8:2454-2461.
[7] Lacombe Marielle,Comtat Maurice,Oriol Louise,et al. Silicate determination in sea water:Toward a reagentless electrochemical method[J]. Marine Chemistry,2007,106:489-497.
[8] 隋欣,王宝辉,邵丽英,等. 硅钼黄光度法测定油田产出水中低聚硅[J]. 南京师大学报:自然科学版,2009,32(2):78-86.
[9] 《水和废水监测分析方法》编委会编. 水和废水监测分析方法[M]. 第3版. 中国环境科学出版社,1997:341-342.
[10] 田利,王广珠,孙巍伟,等.《SS-6-2-84全硅的测定》中存在的问题与改进[J]. 热力发电,2006(7):49-51.
[11] Iler Ralph K.,Isolation and characterization of particle nuclei during the polymerization of silicic acid to colloidal silica[J]. Journal of Colloid and Interface Science,1980,75:138-148.

碱化度对聚合氯化铝混凝除硅的影响

Influence of basicity of polyaluminum chloride on removal of silicon

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 4

编辑推荐

Metrics

本文评价

[1]	王敏, 毛玉红, 陈超, 白丹. 水处理工艺中铝盐水解物的毒性、形态及控制研究进展[J]. 化工进展, 2023, 42(S1): 479-488.
[2]	苏碧云, 黄鹤, 黄力, 郝蓉, 刘博, 李便琴, 李谦定. CMC-PAC复配絮凝剂的制备及其在含醇污水中的应用[J]. 化工进展, 2018, 37(S1): 219-222.
[3]	李静萍1，李超2，孔爱平1，韩迪1，郑李纯1. 复合絮凝剂PAFC-ST-AM的制备及其对模拟废水除磷率的试验 [J]. 化工进展, 2010, 29(10): 1999-.
[4]	刘桂萍，孙慎文，刘长风，王明杰. 聚合氯化铝镁絮凝剂的制备及处理印染废水 [J]. 化工进展, 2010, 29(10): 1990-.