水合物在静态脂肪醇聚氧乙烯醚硫酸钠溶液与纯水搅拌条件下生成分析

doi:10.16085/j.issn.1000-6613.2017.06.020

化工进展 ›› 2017, Vol. 36 ›› Issue (06): 2109-2114.DOI: 10.16085/j.issn.1000-6613.2017.06.020

水合物在静态脂肪醇聚氧乙烯醚硫酸钠溶液与纯水搅拌条件下生成分析

郝成名, 刘德俊, 李存磊, 李文昭

辽宁石油化工大学石油天然气工程学院, 辽宁抚顺 113001

收稿日期:2016-10-18 修回日期:2016-12-28 出版日期:2017-06-05 发布日期:2017-06-05
通讯作者: 刘德俊
作者简介:郝成名(1990—),女,硕士研究生。E-mail:595032995@qq.com。
基金资助:
国家自然科学基金项目（41502100）。

Analysis of hydrate formation in static AES solution and stirring with pure water

HAO Chengming, LIU Dejun, LI Cunlei, LI Wenzhao

Petroleum and Natural Gas Engineering, Liaoning Shihua University, Fushun 113001, Liaoning, China

Received:2016-10-18 Revised:2016-12-28 Online:2017-06-05 Published:2017-06-05

摘要/Abstract

摘要： 促进天然气水合物快速大量生成是天然气水合物技术产业化的关键，因此，对其动力学促进方法进行研究是十分必要的。本文在温度为（2±0.1）℃，压力为（6.6±0.1）MPa条件下研究了不同浓度（60～1350mg/L）脂肪醇聚氧乙烯醚硫酸钠（AES）以及不同搅拌转速0～800r/min对水合物生成的影响，对两种方式的促进效果进行了对比，并从水合物生成动力学角度对AES及搅拌的促进机理进行分析。实验结果表明：AES与搅拌都可以促进液相气过饱和，加速单核生长和多核聚结过程，显著缩短诱导期，提高水合物生成速率及气体消耗量，但不同的是在水合物生长阶段搅拌仅能促进气相向液相单向移动，AES能够使气液交叉移动，显著降低了气液传质阻力，增加了成核位置，因此AES比搅拌进一步提高了水合物生成速率及气体消耗量。

关键词: 天然气水合物, 脂肪醇聚氧乙烯醚硫酸钠, 搅拌, 生成速率, 气体消耗量, 成核

Abstract: Considering the key role of the rapid and abundant hydrate formation in the industrialization of natural gas hydrate,it is necessary to study the dynamic promoting approaches for hydrate formation. In this paper,the effects of AES concentration and stirring rate on hydrate formation were studied experimentally through AES solutions with concentrations from 60mg/L to 1350mg/L and stirring speeds from 0 to 800 r/min at 2℃ and 6.6MPa. The promoting effects were compared,and the promoting mechanisms were studied from the perspective of hydrate formation kinetics,respectively. Results show that both AES and stirring could promote the gas supersaturation in liquid phase and accelerate the growth and coalescence of crystal nucleus. This would significantly shorten the induction period,improve hydrate formation rate,and reduce gas consumption. However,in the hydrate growth stage,stirring could only promote the one-way movement of the gas phase into the liquid phase,whereas AES could improve the cross movements of both gas and liquid phases. This mechanism of AES could reduce the mass transfer resistance between gas and liquid,and significantly increase the nucleation sites. Therefore,AES could further improve the hydrate formation rate and gas consumption.

Key words: natural gas hydrate, AES, stirring, hydrate formation rate, gas consumption, nucleation

中图分类号:

TE89

郝成名, 刘德俊, 李存磊, 李文昭. 水合物在静态脂肪醇聚氧乙烯醚硫酸钠溶液与纯水搅拌条件下生成分析[J]. 化工进展, 2017, 36(06): 2109-2114.

HAO Chengming, LIU Dejun, LI Cunlei, LI Wenzhao. Analysis of hydrate formation in static AES solution and stirring with pure water[J]. Chemical Industry and Engineering Progress, 2017, 36(06): 2109-2114.

参考文献

[1] SLOAN E D,KOH C. Clathrate hydrates of natural gases[M]. 3rd ed. New York:CRC Press,2007.
[2] LU H,MATSUMOTO R. Experimental studies on the possible influences of composition changes of pore water on the stability conditions of methane hydrate in marine sediments[J]. Marine Chemistry,2005,93(s2):149-157.
[3] 李叔霞,李杰,靳玉蓉. 不同饱和度的天然气水合物降压分解实验[J]. 化工学报,2014,65(4):1411-1415. LI S X,LI J,JIN Y R. Depressurizing dissociation of natural gas hydrate with different saturation[J]. CIESC Journal,2014,65(4):1411-1415.
[4] SAW V K,AHMAD I,MANDAL A,et al. Methane hydrate formation and dissociation in synthetic seawater[J]. Journal of Natural Gas Chemistry,2012,21(6):625-632.
[5] 郝文峰,樊栓狮,王金渠. 搅拌对甲烷水合物生成的影响[J]. 天然气化工(C1化学与化工),2005,30(3):5-7. HAO W F,FAN S S,WANG J Q. Effects of stirrer on methane hydrate formation[J]. Natural Gas Chemical Industry,2005,30(3):5-7.
[6] ENGLEZOS P,JU D L. Gas hydrates:a cleaner source of energy and opportunity for innovative technologies[J]. Korean Journal of Chemical Engineering,2005,22(5):671-681.
[7] 吕秋楠,陈朝阳,李小森. 气体水合物快速生成强化技术与方法研究进展[J]. 化工进展,2011,30(1):74-79. LV Q N,CHEN C Y,LI X S. Advances in technology and method for promoting gas hydrate rapid formation[J]. Chemical Industry and Engineering Progress,2011,30(1):74-79.
[8] 王树立,饶永超,周诗岽,等. 水合物法天然气管道输送的实验研究[J]. 天然气工业,2014,34(11):101-107. WANG S L,RAO Y C,ZHOU S D,et al. An experimental study on deepwater natural gas transmission based on the hydrate slurry flow technology[J]. Natural Gas Industry,2014,34(11):101-107.
[9] WANG F,JIA Z Z,LUO S J,et al. Effects of different anionic surfactants on methane hydrate formation[J]. Chemical Engineering Science,2015,137:896-903.
[10] DU J,LI H,WANG L. Effects of ionic surfactants on methane hydrate formation kinetics in a static system[J]. Advanced Powder Technology,2014,25(4):1227-1233.
[11] ZHANG C S, FAN S S, LIANG D Q,et al. Effect of additives on formation of natural gas hydrate[J]. Fuel,2004, 83(16):2115-2121.
[12] KARAASLAN U,ULUNEYE E, PARLAKTUNA M. Effect of an anionic surfactant on different type of hydrate structures[J]. Journal of Petroleum Science & Engineering,2002,35(1):49-57.
[13] GANJI H,MANTEGHIAN M,ZADEH K S,et al. Effect of different surfactants on methane hydrate,formation rate,stability and storage capacity[J]. Fuel,2007,86(3):434-441.
[14] 林微. 水合物储存气体技术的相关基础研究[D]. 北京:中国石油大学(北京),2005. LIN W. Relevant fundamental research on technology of gas storage and transportation by hydrate[D]. Beijing :China University of Petroleum (Beijing),2005.
[15] WANG F,JIA Z Z,LUO S J,et al. Methane hydrate formation with surfactants fixed on the surface of polystyrene nanospheres[J].Journal of Materials Chemistry A,2015,3(16):8316-8323.
[16] 李刚森,蔡立芳,陈帅,等. AES与AEO₉复配体系表面活性的研究[J]. 精细与专用化学品,,2016,24(6):20-23. LI G S,CAI L F,CHEN S,et al. Study on surface activity and dynamic surface tension of AES and AEO₉complex system[J]. Fine and Specialty Chemicals,2016,24(6):20-23..
[17] 胡亚飞,蔡晶,徐纯刚,等. 气体水合物相变热研究进展[J]. 化工进展,2016,35(7):2021-2031. HU Y F,CAI J,XU C G,et al. Research progress on phase change heat of gas hydrates[J]. Chemical Industry and Engineering Progress,2016,35(7):2021-2031.
[18] 刘军,潘振,马贵阳,等. 降低“固封”对甲烷水合物生成的影响[J]. 化工进展,2016,35(5):1410-1417. LIU J,PAN Z,MA G Y,et al. Experimental study on decreasing the effect of the solid seal on methane hydrate[J]. Chemical Industry and Engineering Progress,2016,35(5):1410-1417.
[19] 李士凤,谭哲,申延明,等. 水合物溶液分离技术研究进展[J]. 化工进展,2014,33(6):1387-1391. LI S F,TAN Z,SHEN Y M,et al. Progress in aqueous solution concentration by forming clathrate hydrate[J]. Chemical Industry and Engineering Progress,2014,33(6):1387-1391.

水合物在静态脂肪醇聚氧乙烯醚硫酸钠溶液与纯水搅拌条件下生成分析

Analysis of hydrate formation in static AES solution and stirring with pure water

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	张杰, 白忠波, 冯宝鑫, 彭肖林, 任伟伟, 张菁丽, 刘二勇. PEG及其复合添加剂对电解铜箔后处理的影响[J]. 化工进展, 2023, 42(S1): 374-381.
[2]	董佳宇, 王斯民. 超声强化对二甲苯结晶特性及调控机理实验[J]. 化工进展, 2023, 42(9): 4504-4513.
[3]	尹新宇, 皮丕辉, 文秀芳, 钱宇. 特殊浸润性材料在防治油气管道中水合物成核与聚集的应用[J]. 化工进展, 2023, 42(8): 4076-4092.
[4]	王松松, 刘培乔, 陶长元, 王运东, 陈恩之, 苗迎彬, 赵风轩, 刘作华. 工业物联网技术在搅拌反应器领域的应用[J]. 化工进展, 2023, 42(7): 3331-3339.
[5]	张成松, 张静, 龚斌, 李明洋, 袁佳新, 李宏业. 自吸射流柔性搅拌桨振动特性[J]. 化工进展, 2023, 42(4): 1728-1738.
[6]	杨锋苓, 梁国林, 张翠勋, 王贵超. 疏水Rushton搅拌桨的减阻性能[J]. 化工进展, 2022, 41(9): 4682-4690.
[7]	孙德贇, 胡艳宏, 刘鹏, 唐茂, 胡泽, 柳召刚, 吴锦绣. 不同铈盐体系（硝酸盐、硫酸盐、氯化盐）中CTAB与Ce³⁺的相互作用机理[J]. 化工进展, 2022, 41(6): 3212-3220.
[8]	陈波, 刘爱贤, 孙强, 王逸伟, 郭绪强, 杨庆伟, 龙有, 肖树萌, 马绍坤. 柴油加氢尾气中氢气的水合物法回收工业侧线试验[J]. 化工进展, 2022, 41(6): 2924-2930.
[9]	来奎, 王仕博, 徐建新, 肖清泰, 王华, 李春林. 不连续扰流板强化搅拌的模拟仿真及机理分析[J]. 化工进展, 2022, 41(6): 2871-2883.
[10]	邹鹏程, 金光远, 李臻峰, 宋春芳, 韩太柏, 祝玉莲. 一种具有模式搅拌的微波反应釜内多物理场特性分析[J]. 化工进展, 2022, 41(5): 2301-2310.
[11]	马小娟, 王彧斐, 冯霄. 天然气水合物开采平台能量系统优化[J]. 化工进展, 2022, 41(3): 1667-1676.
[12]	张学民, 张山岭, 李鹏宇, 黄婷婷, 尹绍奇, 李金平, 王英梅. 多孔介质中CO₂-CH₄水合物置换的影响因素及强化机理研究进展[J]. 化工进展, 2022, 41(10): 5259-5271.
[13]	毛港涛, 李治平, 王凯, 丁垚. 全可视化反应釜内二氧化碳水合物的生成分解特征[J]. 化工进展, 2022, 41(10): 5363-5372.
[14]	隋金昊, 王智, 梁璇玑, 张烜玮, 朱羽墨, 宋尚飞, 史博会, 宫敬, LOU Xia. 动力学抑制剂与乙二醇协同作用下甲烷水合物再生成[J]. 化工进展, 2022, 41(10): 5373-5380.
[15]	王英梅, 牛爱丽, 张兆慧, 展静, 张学民. 二氧化碳水合物快速生成方法研究进展[J]. 化工进展, 2021, 40(S2): 117-125.