正弦波形管综合性能模拟及实验

doi:10.16085/j.issn.1000-6613.2017-0031

化工进展 ›› 2017, Vol. 36 ›› Issue (08): 2847-2853.DOI: 10.16085/j.issn.1000-6613.2017-0031

正弦波形管综合性能模拟及实验

吴金星, 杨禹坤, 倪硕, 李俊超

郑州大学化工与能源学院节能技术研究中心, 河南郑州 450001

收稿日期:2017-01-06 修回日期:2017-04-06 出版日期:2017-08-05 发布日期:2017-08-05
通讯作者: 吴金星(1968-),男,博士,教授,主要从事强化传热及节能技术研究。
作者简介:吴金星(1968-),男,博士,教授,主要从事强化传热及节能技术研究。E-mail:wujx@zzu.edu.cn。
基金资助:
河南省重点科技攻关项目（132102210406）及郑州市科技攻关项目（141PPTGG410）。

Experimental and numerical research on comprehensive characteristics of the sinusoidal tube

WU Jinxing, YANG Yukun, NI Shuo, LI Junchao

Research Center of Energy-saving Technology of School of Chemical and Energy Engineering, Zhengzhou University, Zhengzhou 450001, Henan, China

Received:2017-01-06 Revised:2017-04-06 Online:2017-08-05 Published:2017-08-05

摘要/Abstract

摘要： 为了提高换热管的综合性能，针对新型结构的正弦波形管，以水为换热介质，采用数值模拟的方法对其传热和阻力特性进行了研究，模拟云图表明，正弦波形管的周期性结构能够引发二次流，加强了管内流体的相互掺混，减薄了热边界层，使传热热阻减小，达到强化换热的目的。将测得的实验数据和模拟结果进行对比，结果表明：在5000 ≤ Re ≤ 28000的范围内，正弦波形管的总传热系数随着Re数的增大而增大，比直管提高了24.7%~58.4%；在相同的工况下正弦波形管中的压降略大于直管，二者的压降相差22%~38%；同时，二者的阻力系数随着Re数的增加而减小，且正弦波形管的阻力系数下降更迅速。当Re数>13000时，相同条件下波形管的阻力系数相比于直管增加幅度在20%以内。综合考虑总传热系数和压降，正弦波形管具有更好的综合性能。

关键词: 正弦波形管, 阻力特性, 传热, 数值模拟, 实验研究, 计算流体力学

Abstract: In order to improve the comprehensive performance of tube,heat transfer and resistance characteristics of a new type of sinusoidal tube were studied by numerical simulation using water as working fluid. The simulation indicated that secondary flow is caused by the periodic structure of the sinusoidal tube,which in turn strengthens fluid mixing,and reduces thermal boundary layer. As a result,heat transfer resistance is reduced and heat transfer enhanced. The measured data were compared with the simulation ones. Total heat transfer coefficient of the sinusoidal tube increased to 24.7%-58.4% than that of the straight tube, with the Re from 5000 to 28000. Under the same conditions,pressure drop in the sinusoidal tube was slightly larger than the straight tube. The difference between the two was 22%-38%. At the same time,resistance coefficient of the two tubes decreases as Re increases while the sinusoidal tube decreases more rapidly. When the Re number is larger than 13000,the resistance coefficient increment of sinusoidal tube is less than 20%. Considering the total heat transfer coefficient and pressure drop,heat transfer performance of the sinusoidal tube is better.

Key words: sinusoidal tube, resistance characteristic, heat transfer, numerical simulation, experimental research, CFD

中图分类号:

TK17

吴金星, 杨禹坤, 倪硕, 李俊超. 正弦波形管综合性能模拟及实验[J]. 化工进展, 2017, 36(08): 2847-2853.

WU Jinxing, YANG Yukun, NI Shuo, LI Junchao. Experimental and numerical research on comprehensive characteristics of the sinusoidal tube[J]. Chemical Industry and Engineering Progress, 2017, 36(08): 2847-2853.

参考文献

[1] KENAN YAKUT,BAYRAM SAHIN.The effects of vortex characteristics on performance of coiled wire turbulators used for heat transfer augmentation[J]. Applied Thermal Engineering,2004,24(16):2427-2438.
[2] YANG R,CHANG S F,WU W.Flow and heat transfer in a curved pipe with periodically varying curvature[J]. International Communications in Heat and Mass Transfer,2000,27(1):133-143.
[3] 朱升,孙中宁,范广铭.微波浪管传热与阻力特性实验研究[J].原子能科学技术,2011,45(12):1444-1448. ZHU Sheng,SUN Zhongning,FAN Guangming.Numerical study on flow and heat transfer characteristics with low-Reynolds number in Micro-wavy tubes[J].Unclear Power Engineering,2011,32(6):51-55.
[4] 朱升,孙中宁,范广铭.低流速时波浪管内流动与传热特性数值分析[J].核动力工程,2011,32(6):51-55. ZHU Sheng,SUN Zhongning,FAN Guangming.Numerical study on flow and heat transfer characteristics with low-Reynolds number in micro-wavy tubes[J].Unclear Power Engineering,2011,32(6):51-55.
[5] YANG Ru,CHIANG Fanping.An experimental heat transfer study for periodically varying curvature curved-pipe[J].International Journal of Heat and Mass transfer,2002,45(15):3199-3204.
[6] 胡志伟,李勤凌,苗永淼.三维强弯管内湍流场的数值分析[J].西安交通大学学报,1998(1):51-54. HU Zhiwei,LI Qinning,MIAO Yongmiao.Numerical analysis of the three-dimensional turbulent flow field in a ftrong curved duct[J]. Journal of Xi'an Jiaotong University,1998(1):51-54.
[7] ROSAGUTI N R,FLETCHER D F,HAYNES B S. Low-Reynolds number heat transfer enhancement in sinusoidal channels[J]. Chemical Engineering Science,2007,62:694-702.
[8] 李俊超.燃气真空锅炉中换热管束的强化换热研究[D].郑州:郑州大学,2013. LI Junchao.Research on heat transfer enhancement of heat transfer tubes in the gas-fired vacuum boiler[D]. Zhengzhou:Zhengzhou University,2013.
[9] 朱冬生,石仲璟,钱泰磊,等. 扭曲椭圆管换热器的数值模拟及场协同分析[J].高校化学工程学报,2015,29(1):64-71. ZHU Dongsheng,SHI Zhongjing,QIAN Tailei,et al.Numerical simulation and field synergy analysis of twisted oval tube heat exchanger[J].Journal of Chemical Engineering of Chinese Universities,2015,29(1):64-71.
[10] 汪淑奇,黄素逸.纵流式换热器壳侧支撑方式的数值研究[J].化工学报,2007,58(5):1097-1103. WANG Shuqi,HUANG Suyi.Numerical investigation on shell side support of longitudinal flow heat exchanger[J].CIESC Journal,2007,58(5):1097-1103.
[11] 陈庆光,徐忠,张永建.RNG κ-ε模式在工程湍流数值计算中的应用[J].力学季刊,2003,24(1):88-95. CHEN Qingguang,XU Zhong,ZHANG Yongjian.Application of RNG κ-ε models in numerical simulations of engineering turbulent flows[J].Chinese Quarterly of Mechanics,2003,24(1):88-95.
[12] ZHANG Cancan,WANG Dingbiao,ZHU Youjian.Numerical study on heat transfer and flow characteristics of a tube ftted with double spiral spring[J].International Journal of Thermal Sciences,2015,94:18-27.
[13] GNIELINSKI V.New equations for heat mass transfer in turbulent pipe and channel flows[J].International Journal of Chemical Reactor Engineering,1976,16:359-368.
[14] GUO Zengyuan,LI Zhixin,ZHOU Senquan,et al.Principle of uniformity of temperature difference field in heat exchanger[J]. Science in China(Series E:Technological Sciences),1996(1):68-75.
[15] GUO Zengyuan,TAO Wenquan,SHAH R K.The field synergy (coordination) principle and its applications in enhancing single phase convective heat transfer[J].International Journal of Heat and Mass Transfer,2005,48(9):1797-1807.
[16] 何长江,关昌峰,张震,等.内置开孔螺旋叶片转子换热管强化传热实验[J].化工进展,2014,33(12):3189-3193. HE Changjiang,GUAN Changfeng,ZHANG Zhen,et al. Experimental study on heat transfer enhancement of heat exchanger tubes with helical blades with internal openings[J]. Chemical Industry and Engineering Progress,2014,33(12):3189-3193.
[17] 陈颖,邓先和,丁小江,等.强化缩放管内湍流对流换热[J].化工学报,2004,55(9):1528-1531. CHEN Ying,DENG Xianhe,DING Xiaojiang,et al.Enhancement of turbulent convective heat transfer in a convergent tube[J].CIESC Journal,2004,55(9):1528-1531.

正弦波形管综合性能模拟及实验

Experimental and numerical research on comprehensive characteristics of the sinusoidal tube

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	邵博识, 谭宏博. 锯齿波纹板对挥发性有机物低温脱除过程强化模拟分析[J]. 化工进展, 2023, 42(S1): 84-93.
[2]	郭强, 赵文凯, 肖永厚. 增强流体扰动强化变压吸附甲硫醚/氮气分离的数值模拟[J]. 化工进展, 2023, 42(S1): 64-72.
[3]	王云飞, 秦蕊, 郑利军, 李焱, 李清平. 旋转填充床CFD模拟研究进展[J]. 化工进展, 2023, 42(S1): 1-9.
[4]	肖辉, 张显均, 兰治科, 王苏豪, 王盛. 液态金属绕流管束流动传热进展[J]. 化工进展, 2023, 42(S1): 10-20.
[5]	王太, 苏硕, 李晟瑞, 马小龙, 刘春涛. 交流电场中贴壁气泡的动力学行为[J]. 化工进展, 2023, 42(S1): 133-141.
[6]	赵晨, 苗天泽, 张朝阳, 洪芳军, 汪大海. 负压状态窄缝通道乙二醇水溶液传热特性[J]. 化工进展, 2023, 42(S1): 148-157.
[7]	孙继鹏, 韩靖, 唐杨超, 闫汉博, 张杰瑶, 肖苹, 吴峰. 硫黄湿法成型过程数值模拟与操作参数优化[J]. 化工进展, 2023, 42(S1): 189-196.
[8]	陈匡胤, 李蕊兰, 童杨, 沈建华. 质子交换膜燃料电池气体扩散层结构与设计研究进展[J]. 化工进展, 2023, 42(S1): 246-259.
[9]	陈林, 徐培渊, 张晓慧, 陈杰, 徐振军, 陈嘉祥, 密晓光, 冯永昌, 梅德清. 液化天然气绕管式换热器壳侧混合工质流动及传热特性[J]. 化工进展, 2023, 42(9): 4496-4503.
[10]	刘炫麟, 王驿凯, 戴苏洲, 殷勇高. 热泵中氨基甲酸铵分解反应特性及反应器结构优化[J]. 化工进展, 2023, 42(9): 4522-4530.
[11]	罗成, 范晓勇, 朱永红, 田丰, 崔楼伟, 杜崇鹏, 王飞利, 李冬, 郑化安. 中低温煤焦油加氢反应器不同分配器中液体分布的CFD模拟[J]. 化工进展, 2023, 42(9): 4538-4549.
[12]	赵曦, 马浩然, 李平, 黄爱玲. 错位碰撞型微混合器混合性能的模拟分析与优化设计[J]. 化工进展, 2023, 42(9): 4559-4572.
[13]	汪健生, 张辉鹏, 刘雪玲, 傅煜郭, 朱剑啸. 多孔介质结构对储层内流动和换热特性的影响[J]. 化工进展, 2023, 42(8): 4212-4220.
[14]	卜治丞, 焦波, 林海花, 孙洪源. 脉动热管计算流体力学模型与研究进展[J]. 化工进展, 2023, 42(8): 4167-4181.
[15]	王云刚, 焦健, 邓世丰, 赵钦新, 邵怀爽. 冷凝换热与协同脱硫性能实验分析[J]. 化工进展, 2023, 42(8): 4230-4237.