氧对丙烷脱氢反应体系影响的热力学分析

doi:10.16085/j.issn.1000-6613.2015.04.012

化工进展 ›› 2015, Vol. 34 ›› Issue (04): 970-975,1006.DOI: 10.16085/j.issn.1000-6613.2015.04.012

氧对丙烷脱氢反应体系影响的热力学分析

林少波, 单玉领, 隋志军, 朱贻安, 李平, 周兴贵

华东理工大学化学工程联合国家重点实验室, 上海 200237

收稿日期:2014-09-02 修回日期:2014-12-10 出版日期:2015-04-05 发布日期:2015-04-05
通讯作者: 李平.E-mail lipingunilab@ecust.edu.cn.
作者简介:林少波(1989—),男,硕士研究生.
基金资助:
国家863计划(2012AA040306)、国家自然科学基金(21276077,21376076)及中央高校基本科研业务费专项资金(WG1213011,WA1313006)项目.

Thermodynamic analysis of effects of oxygen addition on dehydrogenation of propane

LIN Shaobo, SHAN Yuling, SUI Zhijun, ZHU Yian, LI Ping, ZHOU Xinggui

State Key Laboratory of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, China

Received:2014-09-02 Revised:2014-12-10 Online:2015-04-05 Published:2015-04-05

摘要/Abstract

摘要： 针对丙烷氧化脱氢和脱氢氧化两种反应体系进行了热力学分析,并与无氧丙烷脱氢体系进行了比较.考虑了丙烷裂解、部分氧化和深度氧化过程的27种产物,应用Aspen模拟软件,计算了体系压力为0.1MPa、温度范围为300～700℃的等温等压吉布斯平衡反应器内的各物质含量,讨论了进料氧气/丙烷摩尔比对目的产物丙烯产量及产物组成分布的影响.结果表明,无论先加氧脱氢,还是脱氢后再加氧反应,氧气加入对丙烯生成都非常不利,反应温度越高、氧气加入量越大,丙烯平衡生成量就越少,原料损耗也越严重;最主要的副产物是甲烷和一氧化碳,而非二氧化碳和水.

关键词: 烷烃, 氧化, 脱氢, 丙烯, 热力学

Abstract: The thermodynamics of both oxidative dehydrogenation and dehydrogenation-oxidation of propane were analyzed and compared with that of simple dehydrogenation of propane. Twenty seven products from the reactions of cracking,partial oxidation and deep oxidation of propane were taken into consideration. The molar fractions of the feed and the products in the Gibbs reactor under isotonic and isothermal conditions were calculated by using Aspen Plus simulation software. The effects of oxygen addition on the molar fraction of target product propylene and the composition of other products under pressure of 0.1MPa and in the temperature range of 300—700℃ were discussed. For whichever propane dehydrogenation system,i.e. adding oxygen before or after the dehydrogenation,addition of oxygen was extremely harmful to production of propylene. The higher the temperature and the larger the oxygen addition amount,the less the propylene production and the greater the feed loss. The major byproducts were CH₄ and CO rather than CO₂ and H₂O.

Key words: alkane, oxidation, dehydrogenation, propylene, thermodynamics

中图分类号:

TQ021.2

林少波, 单玉领, 隋志军, 朱贻安, 李平, 周兴贵. 氧对丙烷脱氢反应体系影响的热力学分析[J]. 化工进展, 2015, 34(04): 970-975,1006.

LIN Shaobo, SHAN Yuling, SUI Zhijun, ZHU Yian, LI Ping, ZHOU Xinggui. Thermodynamic analysis of effects of oxygen addition on dehydrogenation of propane[J]. Chemical Industry and Engineering Progree, 2015, 34(04): 970-975,1006.

参考文献

[1] Bhasin M M,McCain J H,Vora B V,et al. Dehydrogenation and oxydehydrogenation of paraffins to olefins[J]. Applied Catalysis A:General,2001,221:397-419.
[2] 王红秋,郑轶丹. 丙烷脱氢生产丙烯技术进展[J]. 石化技术,2011,18(2):63-66.
[3] 周巍. 丙烷脱氢制丙烯技术浅析[J]. 石油化工设计,2013,30(3):36-38.
[4] 余长林,葛庆杰,徐恒泳,等. 丙烷脱氢制丙烯研究新进展[J]. 化工进展,2006,25(9):977-982.
[5] 上官荣昌,葛欣,王健锋,等. 二氧化碳氧化丙烷制丙烯的热力学分析[J]. 石油与天然气化工,2002,31(1):5-7.
[6] 刘淑鹤,方向晨,张喜文,等. 丙烷脱氢催化反应机理及动力学研究进展[J]. 化工进展,2009,28(2):259-266,282.
[7] 叶敏,李贤. 丙烷脱氢氧化制丙烯热力学分析[J]. 化学工业与工程技术,2011,32(6):18-21.
[8] Burch R,Crabb E M. Homogeneous and heterogeneous contributions to the oxidative dehydrogenation of propane on oxide catalysts[J]. Applied Catalysis A:General,1993,100:111-130.
[9] Beretta A,Forzatti P,Ranzi E. Production of olefins via oxidative dehydrogenation of propane[J]. Journal of Catalysis,1999,184:469-478.
[10] Fathi M,Lødeng R,Nilsen E S,et al.Short contact time oxidative dehydrogenation of propane[J]. Catalysis Today,2001,64:113-120.
[11] Layokun S K. Oxidative pyrolysis of propane[J]. Ind. Eng. Chem. Process Des. Dev.,1979,18(2):241-245.
[12] Satterfield C N,Wilson R E. Partial oxidation of propane[J]. Industrial and Engineering Chemistry,1954,46(5):1001-1007.
[13] 张海娟,张舒冬,李江红,等. 丙烷脱氢反应的热力学分析[J]. 石油化工,2012,41(s1):86-88.
[14] 熊刚华,李平,张世渊,等. 小分子烃类及含氧有机物蒸汽重整制氢反应热力学[J]. 化学反应工程与工艺,2010,26(2):104-111.
[15] Pease R N,Munro W P. The slow oxidation of propane[J]. J. Am. Chem. Soc.,1934,56(10):2034-2038.
[16] The Uhde STAR process:Oxydehydrogenation of light paraffins to olefins[EB/OL]. www. uhde. eu,2014.
[17] Liu R D,Zhu Y A,Sui Z J,et al. Support effects on catalytic performance for selective combustion of hydrogen in the presence of propene[J]. Fuel Processing Technology,2013,108(35):82-88.
[18] Hayashi T,Han L B,Tsubota S,et al. Formation of propylene oxide by the gas-phase reaction of propane and propene mixture with oxygen[J]. Ind. Eng. Chem. Res.,1995,34:2298-2304.

氧对丙烷脱氢反应体系影响的热力学分析

Thermodynamic analysis of effects of oxygen addition on dehydrogenation of propane

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	杨寒月, 孔令真, 陈家庆, 孙欢, 宋家恺, 王思诚, 孔标. 微气泡型下向流管式气液接触器脱碳性能[J]. 化工进展, 2023, 42(S1): 197-204.
[2]	杨建平. 降低HPPO装置反应系统原料消耗的PSE[J]. 化工进展, 2023, 42(S1): 21-32.
[3]	王福安. 300kt/a环氧丙烷工艺反应器降耗减排分析[J]. 化工进展, 2023, 42(S1): 213-218.
[4]	王胜岩, 邓帅, 赵睿恺. 变电吸附二氧化碳捕集技术研究进展[J]. 化工进展, 2023, 42(S1): 233-245.
[5]	张明焱, 刘燕, 张雪婷, 刘亚科, 李从举, 张秀玲. 非贵金属双功能催化剂在锌空气电池研究进展[J]. 化工进展, 2023, 42(S1): 276-286.
[6]	时永兴, 林刚, 孙晓航, 蒋韦庚, 乔大伟, 颜彬航. 二氧化碳加氢制甲醇过程中铜基催化剂活性位点研究进展[J]. 化工进展, 2023, 42(S1): 287-298.
[7]	谢璐垚, 陈崧哲, 王来军, 张平. 用于SO₂去极化电解制氢的铂基催化剂[J]. 化工进展, 2023, 42(S1): 299-309.
[8]	杨霞珍, 彭伊凡, 刘化章, 霍超. 熔铁催化剂活性相的调控及其费托反应性能[J]. 化工进展, 2023, 42(S1): 310-318.
[9]	郑谦, 官修帅, 靳山彪, 张长明, 张小超. 铈锆固溶体Ce_0.25Zr_0.75O₂光热协同催化CO₂与甲醇合成DMC[J]. 化工进展, 2023, 42(S1): 319-327.
[10]	戴欢涛, 曹苓玉, 游新秀, 徐浩亮, 汪涛, 项玮, 张学杨. 木质素浸渍柚子皮生物炭吸附CO₂特性[J]. 化工进展, 2023, 42(S1): 356-363.
[11]	高雨飞, 鲁金凤. 非均相催化臭氧氧化作用机理研究进展[J]. 化工进展, 2023, 42(S1): 430-438.
[12]	顾永正, 张永生. HBr改性飞灰对Hg⁰的动态吸附及动力学模型[J]. 化工进展, 2023, 42(S1): 498-509.
[13]	孙玉玉, 蔡鑫磊, 汤吉海, 黄晶晶, 黄益平, 刘杰. 反应精馏合成甲基丙烯酸甲酯工艺优化及节能[J]. 化工进展, 2023, 42(S1): 56-63.
[14]	许友好, 王维, 鲁波娜, 徐惠, 何鸣元. 中国炼油创新技术MIP的开发策略及启示[J]. 化工进展, 2023, 42(9): 4465-4470.
[15]	董佳宇, 王斯民. 超声强化对二甲苯结晶特性及调控机理实验[J]. 化工进展, 2023, 42(9): 4504-4513.