Effect of water content of fly ash on the performance of coupling reinforced electrostatic-fabric integrated precipitator

doi:10.16085/j.issn.1000-6613.2022-1031

Abstract

Abstract:

Coupling reinforced electrostatic-fabric integrated precipitator has a promising prospect in the field of coal-fired industrial boilers. The removal performance of coupling reinforced electrostatic-fabric integrated precipitator for different water content and its operational performance were experimentally investigated based on a pilot-scale experimental system. The experimental results showed that the bulk density first decreased and then increased with increasing water content, with valley value at water content of 0.65%. The penetration windows of bag filter distributed at different particle size with water content less than 0.65%, and disappeared with the water content higher than 0.65%. With the water content increasing to 0.65%, the total dust mass concentrations, final pressure drop and the total energy consumption decreased and the collection efficiency increased. The final pressure drop was reduced from 335Pa to 276Pa, with reduction of 17.61%, when the water content rose from 0.31% to 0.65%. However, the total performance became bad with the water content larger than 0.65%. Furthermore, the quality factor was used to comprehensively evaluate the total performance of the coupling reinforced electrostatic-fabric integrated precipitator. It was shown that the quality factor increased and decreased with the increase of water content, with the peak value reaching around 0.64%—0.65%. In summary, the performance of the coupling reinforced electrostatic-fabric integrated precipitator can be enhanced by increasing the water content of the fly ash within certain range, which can provide theoretical guidance for performance optimization of coupling reinforced electrostatic-fabric integrated precipitator.

Key words: coupling reinforced electrostatic-fabric integrated precipitator, water content, filtration efficiency, energy consumption, quality factor

摘要：

耦合电袋除尘器在燃煤工业锅炉领域中发展前景广阔。基于耦合电袋除尘器平台，实验研究了不同含湿量飞灰的脱除性能和除尘器运行性能。结果表明：含湿量上升，飞灰堆积密度呈现先减小后增大的趋势，含湿量为0.65%出现谷值。含湿量小于0.65%，除尘器对飞灰的穿透窗口不同，且含湿量增加，出口总尘浓度逐渐降低，整体脱除效率逐渐提高，最终压降和总能耗均逐渐降低，最终压降由含湿量0.31%时的335Pa降低到0.65%时的276Pa，减小了17.61%。除尘器对含湿量0.65%飞灰无穿透窗口，但含湿量高于0.65%，穿透窗口重新出现，且除尘器性能下降。利用质量因子对耦合电袋除尘器整体性能进行综合评价，其随含湿量增加而先增后降，峰值位于含湿量0.64%~0.65%附近。综上，一定范围内提高颗粒含湿量能优化除尘器性能。

关键词: 耦合电袋除尘器, 含湿量, 过滤效率, 能耗, 质量因子

CLC Number:

X701.2

XIA Shaobo, DUAN Lu, WANG Jianpeng, JI Renshan. Effect of water content of fly ash on the performance of coupling reinforced electrostatic-fabric integrated precipitator[J]. Chemical Industry and Engineering Progress, 2023, 42(4): 2101-2108.

夏少波, 段璐, 王建朋, 纪任山. 飞灰含湿量对耦合电袋除尘器性能影响规律[J]. 化工进展, 2023, 42(4): 2101-2108.

Figures/Tables 13

空气相对湿度/%	飞灰初始含湿量/%	除尘器进口			除尘器内飞灰含湿量/%	除尘器出口
空气相对湿度/%	飞灰初始含湿量/%	烟气相对湿度/%	飞灰含湿量/%	$d H 2 O$ /g·m^-3	除尘器内飞灰含湿量/%	烟气相对湿度/%	$d H 2 O$ /g·m^-3
27	2.42	29.0	1.10	0.773	0.69	23.0	0.761
27	2.90	31.3	1.21	0.806	0.72	25.8	0.791

空气相对湿度/%	飞灰初始含湿量/%	除尘器进口			除尘器内飞灰含湿量/%	除尘器出口
空气相对湿度/%	飞灰初始含湿量/%	烟气相对湿度/%	飞灰含湿量/%	$d H 2 O$ /g·m^-3	除尘器内飞灰含湿量/%	烟气相对湿度/%	$d H 2 O$ /g·m^-3
27	2.42	29.0	1.10	0.773	0.69	23.0	0.761
27	2.90	31.3	1.21	0.806	0.72	25.8	0.791

成分分析/%											工业分析/%
SiO₂	Al₂O₃	Fe₂O₃	CaO	MgO	K₂O	Na₂O	TiO₂	P₂O₅	MnO₂	SO₃	M_ad	A_d	V_d	FC_ad
42.42	13.10	7.22	25.51	1.30	1.31	1.73	0.55	0.069	0.23	5.30	0.12	98.04	1.55	0.40

References 36

1	王建朋, 段璐, 王乃继, 等. 燃煤锅炉烟气脱硫技术对颗粒物排放影响研究进展[J]. 洁净煤技术, 2020, 26(2): 34-42.
	WANG Jianpeng, DUAN Lu, WANG Naiji, et al. Research progress on the effect of flue gas desulfurization technology of coal-fired boiler on particulate matter emission[J]. Clean Coal Technology, 2020, 26(2): 34-42.
2	CHEN Chi-Hsien, WU Chih-Da, CHIANG Hung-Che, et al. The effects of fine and coarse particulate matter on lung function among the elderly[J]. Scientific Reports, 2019, 9(1): 14790.
3	KIM Hyunyoung, KIM Won-Ho, KIM Young-Youl, et al. Air pollution and central nervous system disease: A review of the impact of fine particulate matter on neurological disorders[J]. Frontiers in Public Health, 2020, 8: 575330.
4	国家质量监督检验检疫总局, 中国国家标准化管理委员会. 火电厂大气污染物排放标准: [S]. 北京: 中国环境科学出版社, 2012.
	General Administration of Quality Supervision, Inspection and Quarantine of the People’s Republic of China, Standardization Administration of the People’s Republic of China. Emission standard of air pollutants for thermal power plants: [S]. Beijing: China Environment Science Press, 2012.
5	环保部, 国家发改委, 国家能源局. 关于印发《全面实施燃煤电厂超低排放和节能改造工作方案》的通知[EB/OL]. [2022-06-02]．.
	Ministry of Environmental Protection, National Development and Reform Commission, National Energy Administration. Notice on the issuance of the Work Plan for Ultra-low Emission and Energy Saving Renovation of Coal-fired Power Plants[EB/OL]. [2022-06-02]．.
6	国务院关于印发打赢蓝天保卫战三年行动计划的通知[EB/OL]. [2022-06-02]. .
	Circular of The State Council on the issuance of the three-year action plan for winning the battle to protect the blue skies[EB/OL]. [2022-06-02]. .
7	GAO Qi, LI Shuiqing, XU Yang, et al. A general mechanistic model of fly ash formation during pulverized coal combustion[J]. Combustion and Flame, 2019, 200: 374-386.
8	胡燕. 探析我国燃煤工业锅炉大气污染物治理技术[J]. 环境与发展, 2020, 32(8): 87, 90.
	HU Yan. Discussion on air pollution control technology of coal-fired industrial boilers in China[J]. Environment and Development, 2020, 32(8): 87, 90.
9	LI Wei, SHEN Shengnan, LI Hui. Study and optimization of the filtration performance of multi-fiber filter[J]. Advanced Powder Technology, 2016, 27(2): 638-645.
10	PATNAIK Asis, ANANDJIWALA Rajesh D. Reasons for filter bag failure and method development to improve its life span[J]. Chemical Engineering & Technology, 2016, 39(3): 529-534.
11	李东梅, 田娱嘉, 郭阳, 等. 布袋除尘器滤袋使用寿命的影响因素分析[J]. 热力发电, 2013, 42(4): 104-106.
	LI Dongmei, TIAN Yujia, GUO Yang, et al. Factors affecting the service life of filter bag[J]. Thermal Power Generation, 2013, 42(4): 104-106.
12	YAO Yuping, ZHAO Xiyong. Application of electrostatic fabric hybrid particulate collector[M]//YAN K. Electrostatic Precipitation. Berlin, Heidelberg: Springer, 2009: 482-484.
13	段璐. 电袋除尘器颗粒物脱除理论和实验研究进展[J]. 粉煤灰综合利用, 2019, 32(4): 97-101.
	DUAN Lu. Progress of theoretical and experimental study of particle removal by hybrid electrostatic precipitators[J]. Fly Ash Comprehensive Utilization, 2019, 32(4): 97-101.
14	夏少波, 段璐, 王建朋, 等. 飞灰残碳量对除尘器性能影响规律[J]. 煤炭学报, 2022, 47(9): 3463-3471.
	XIA Shaobo, DUAN Lu, WANG Jianpeng, et al. Effect of residual carbon on precipitator performance[J]. Journal of China Coal Society, 2022, 47(9): 3463-3471.
15	熊桂龙, 李水清, 陈晟, 等. 增强PM_2.5脱除的新型电除尘技术的发展[J]. 中国电机工程学报, 2015, 35(9): 2217-2223.
	XIONG Guilong, LI Shuiqing, CHEN Sheng, et al. Development of advanced electrostatic precipitation technologies for reducing PM_2.5 emissions from coal-fired power plants[J]. Proceedings of the CSEE, 2015, 35(9): 2217-2223.
16	郭俊, 杨丁, 郭宝玉, 等. 低低温电除尘器实验与数值模拟研究进展[C]//第十七届中国电除尘学术会议论文集. 合肥, 2017: 84-100.
	GUO Jun, YANG Ding, GUO Baoyu, et al. Progress in experiment and numerical simulation of low temperature electrostatic precipitator[C]// Proceedings of the 17th China Academic Conference on Electrodust removal. Hefei, 2017: 84-100.
17	徐明厚, 王文煜, 温昶, 等. 燃煤电厂细微颗粒物脱除技术研究新进展[J]. 中国电机工程学报, 2019, 39(22): 6627-6640.
	XU Minghou, WANG Wenyu, WEN Chang, et al. Research development of precipitation technology to accomplish the ultra-low emission from coal-fired power plants[J]. Proceedings of the CSEE, 2019, 39(22): 6627-6640.
18	GAO Wenchao, ZHANG Hao, WU Zhicheng, et al. Low-temperature electrostatic precipitator with different electrode configurations under various operation conditions[J]. Powder Technology, 2021, 394: 1178-1185.
19	刘含笑, 郦建国, 姚宇平, 等. 低低温电除尘系统对SO₃脱除性能研究[J]. 发电技术, 2022, 43(1): 147-154.
	LIU Hanxiao, LI Jianguo, YAO Yuping, et al. Study on SO₃ removal performance of low-low temperature electrostatic precipitator system[J]. Power Generation Technology, 2022, 43(1): 147-154.
20	赵磊, 周洪光. 烟气调质技术在近零排放机组中的研究与应用[J]. 环境工程, 2016, 34(2): 83-86.
	ZHAO Lei, ZHOU Hongguang. Research and application of flue gas conditioning technology in near-zero emission of coal-fired power plant[J]. Environmental Engineering, 2016, 34(2): 83-86.
21	周家珍, 王丽萍, 王玉明, 等. SO₃烟气调质对粉尘导电性能的改善机制[J]. 环境工程, 2012, 30(5): 61-63, 95.
	ZHOU Jiazhen, WANG Liping, WANG Yuming, et al. The improvement mechanism of SO₃ flue gas conditioning on dust electric conduction[J]. Environmental Engineering, 2012, 30(5): 61-63, 95.
22	余海浩. 复合烟气调质技术研究[D]. 北京: 华北电力大学, 2015.
	YU Haihao. Study on dual flue gas conditioning[D]. Beijing: North China Electric Power University, 2015.
23	NAVARRETE Benito, Bernabé ALONSO-FARIÑAS, Mónica LUPIÓN, et al. Effect of flue gas conditioning on the cohesive forces in fly ash layers in electrostatic precipitation[J]. Environmental Progress & Sustainable Energy, 2015, 34(5): 1379-1383.
24	YAWOOTTI Artit, INTRA Panich, TIPPAYAWONG Nakorn, et al. An experimental study of relative humidity and air flow effects on positive and negative corona discharges in a corona-needle charger[J]. Journal of Electrostatics, 2015, 77: 116-122.
25	NOURI H, ZOUZOU N, DASCALESCU L, et al. Investigation of relative humidity effect on the particles velocity and collection efficiency of laboratory scale electrostatic precipitator[J]. Process Safety and Environmental Protection, 2016, 104: 225-232.
26	彭泽宏, 楼波, 孙超凡. 含湿量对电除尘器内PM_2.5除尘效率的影响规律研究[J]. 电站系统工程, 2015, 31(2): 41-43.
	PENG Zehong, LOU Bo, SUN Chaofan. Study on effect of moisture content on electric dust efficiency of PM_2.5 [J]. Power System Engineering, 2015, 31(2): 41-43.
27	WANG Xiaohua, YOU Changfu. Effects of thermophoresis, vapor, and water film on particle removal of electrostatic precipitator[J]. Journal of Aerosol Science, 2013, 63: 1-9.
28	胡斌, 周磊, 孙宗康, 等. 烟气温湿度对电除尘脱除细颗粒的影响[J]. 东南大学学报(自然科学版), 2017, 47(6): 1148-1153.
	HU Bin, ZHOU Lei, SUN Zongkang, et al. Effects of temperature and humidity on electrostatic precipitator removal of fine particles[J]. Journal of Southeast University (Natural Science Edition), 2017, 47(6): 1148-1153.
29	袁学玲, 陈晓春, 杨正羽, 等. 湿度对袋式除尘性能的强化研究[J]. 高校化学工程学报, 2019, 33(4): 965-971.
	YUAN Xueling, CHEN Xiaochun, YANG Zhengyu, et al. Effects of humidity on dust removal intensification of bag filters[J]. Journal of Chemical Engineering of Chinese Universities, 2019, 33(4): 965-971.
30	滕斌. 半干法烟气脱硫的实验及机理研究[D]. 杭州: 浙江大学, 2004.
	TENG Bin. Experimental and theoretical study on semi-dry flue gas desulfurization[D]. Hangzhou: Zhejiang University, 2004.
31	任育杰, 韩旭. 布袋除尘器在300MW机组干法脱硫中的应用[C]//第十七届二氧化硫氮氧化物、汞污染防治技术暨细颗粒物(PM2.5)控制与监测技术研讨会论文集. 杭州, 2013: 21-25.
	REN Yujie, HAN Xu. Application of bag dust collector in dry desulfurization of 300MW unit[C]// Proceedings of the 17th Seminar on Sulfur Dioxide nitrogen oxide and Mercury Pollution Prevention Technology and Fine Particulate matter (PM2.5) Control and Monitoring Technology. Hangzhou, 2013: 21-25.
32	许广林. 半干法脱硫后除尘器设计技术问题的探讨[C]//中国硅酸盐学会环保学术年会论文集. 北京: 中国建材工业出版社, 2012: 99-101, 112.
	XU Guanglin. Discussion on the design technology of dust collector after semi-dry method of desulfurization[C]//Proceedings of the Environmental Protection Academic Annual Conference of the Chinese Ceramics Society. Beijing: China Building Materials Press, 2012: 99-101, 112.
33	袁学玲. 环境湿度对PTFE覆膜滤料过滤性能影响研究[D]. 北京: 北京化工大学, 2015.
	YUAN Xueling. The effect of humidity on dust removal performance using PTFE membrane[D]. Beijing: Beijing University of Chemical Technology, 2015.
34	LI Mengqi, REN Jianxing. Study on the change characteristics of dust specific resistivity and electrostatic precipitation efficiency[J]. IOP Conference Series: Earth and Environmental Science, 2018, 108: 052115.
35	CHOI Ho-Kyung, PARK Seok-Joo, Jeong-Hwan LIM, et al. A study on the characteristics of improvement in filtration performance by dust precharging[J]. Korean Journal of Chemical Engineering, 2002, 19(2): 342-346.
36	FENG Zhuangbo, LONG Zhengwei, MO Jinhan. Experimental and theoretical study of a novel electrostatic enhanced air filter (EEAF) for fine particles[J]. Journal of Aerosol Science, 2016, 102: 41-54.

[1]	FU Le, YANG Yang, XU Wenqing, GENG Zanbu, ZHU Tingyu, HAO Runlong. Research progress in CO₂ capture technology using novel biphasic organic amine absorbent [J]. Chemical Industry and Engineering Progress, 2023, 42(4): 2068-2080.
[2]	JIANG Hua, ZHANG Zihui, GONG Wuqi, CHANG Yueyong. Design and performance analysis of mechanical vapor recompression salt fractionation evaporation crystallization system [J]. Chemical Industry and Engineering Progress, 2022, 41(7): 3947-3956.
[3]	TANG Siyang, LI Xingyu, LU Houfang, ZHONG Shan, LIANG Bin. Perspective on low-energy chemical absorption for CO₂ capture [J]. Chemical Industry and Engineering Progress, 2022, 41(3): 1102-1106.
[4]	ZHANG Weifeng, XU Yuanlong, WANG Qiuhua. Progress of research on regeneration of rich alkanolamine solution with low energy consumption [J]. Chemical Industry and Engineering Progress, 2021, 40(8): 4497-4507.
[5]	WANG Jiajun, DENG Shuai, ZHAO Ruikai, ZHAO Li. Analysis of energy and consumption reduction in adsorption recovery of electronic HF [J]. Chemical Industry and Engineering Progress, 2021, 40(7): 3645-3655.
[6]	Jianfeng TANG, Yujuan WANG, Yue WANG, Yihuai HUA, Jie CHU, Wei SANG, Jing CHEN. Applicability of Aspen HYSYS for simulation of amine decarbonization regeneration process [J]. Chemical Industry and Engineering Progress, 2021, 40(2): 747-754.
[7]	Yangyang ZHENG, Xiaosan SONG, Sanfan WANG, Zhihua ZHANG, Zhengping SONG, Lin MA. Influence of additives on the electrowinning process of single membrane and double chamber in the same cell [J]. Chemical Industry and Engineering Progress, 2020, 39(S2): 440-446.
[8]	Hongtao ZHAO, Shumin WANG. Key parameters and energy consumption analysis of amine decarburization regeneration system with MVR for coal-fired flue gas [J]. Chemical Industry and Engineering Progress, 2020, 39(S1): 256-262.
[9]	Jie CHEN,Yuanyuan ZHANG,Yihuai HUA,Jianfeng TANG,Hao GUO,Rufeng TIAN,Qingjun ZENG. Screening of ternary amine solution for natural gas semi-lean liquid decarburization process [J]. Chemical Industry and Engineering Progress, 2020, 39(3): 975-983.
[10]	Shijian LU,Lijuan GAO,Jiafeng WANG,Dongya ZHAO,Xin WANG,Quanmin ZHU. Coupling optimization of energy-saving technology for cascade utilization of flue gas CO₂ capture system [J]. Chemical Industry and Engineering Progress, 2020, 39(2): 728-737.
[11]	Sheng CHEN, Xinbo CAO, Meng ZHAO, Cenfan LIU, Haoyuan KANG, Yong WANG, Wei WANG, Guoshan XIE. Simulation and optimization of MTO front-end depropanizer separation process [J]. Chemical Industry and Engineering Progress, 2019, 38(07): 3473-3481.
[12]	Hong JIANG, Shijian ZHANG, Jiaqiang JING, Cong ZHU. Comparison of conventional and novel high-pressure NGL recovery processes [J]. Chemical Industry and Engineering Progress, 2019, 38(06): 2581-2589.
[13]	LIN Haizhou, PEI Aiguo, FANG Mengxiang. Progress of research on process modifications for amine solvent-based post combustion CO₂ capture from coal-fired power plant [J]. Chemical Industry and Engineering Progress, 2018, 37(12): 4874-4886.
[14]	YU Jie, DONG Yuping, CHANG Jiafu, DONG Lei. Pilot experiment of gasification of corn straw in circulating fluidized bed [J]. Chemical Industry and Engineering Progress, 2018, 37(08): 2970-2975.
[15]	XIE Xinshuo, YANG Weijuan, SHI Wei, ZHANG Shengsheng, WANG Zhihua, ZHOU Junhu. Life cycle assessment of technologies for hydrogen production-a review [J]. Chemical Industry and Engineering Progress, 2018, 37(06): 2147-2158.