Effect of pyrolysis temperature on microstructure and de-NOx reactivity of anthracite char

doi:10.16085/j.issn.1000-6613.2015.06.022

Abstract

Abstract: The Longping anthracite was pyrolyzed in the temperature range of 600—1000℃ under N₂ atmosphere for the preparation of char. The evolution of microstructure of anthracite char was characterized by Raman spectroscopy. The de-NO_x reactivity of anthracite char was investigated using a thermogravimetric analyzer (TGA) under programmed temperature conditions. The present work is focused on the impact of pyrolysis temperature on anthracite char microstructure and de-NO_x reactivity. The char microstructure was affected significantly by heat treatment temperature. The difference between G and D1 band position and all Raman band areas were found to decrease with increasing pyrolysis temperature. In addition, band area ratio, I_D1/I_G and I_D3/I_G, were shown to initially increase and then decrease with the increase of pyrolysis temperature, while with which I_G/I_All varied oppositely. As a result, the Longping anthracite was subjected to carbonization and subsequent preliminary graphitization during pyrolysis. It was found that the de-NO_x reactivity of anthracite char decreased with increasing pyrolysis temperature, largely due to the reduction of active structure and the increase of structural order, also leading to the gradual increase of reaction activation energy.

Key words: coal combustion, pyrolysis, Raman spectroscopy, de-NO_x, reaction kinetics

摘要： 在氮气气氛和600～1000℃条件下, 使用水平管式炉对龙坪无烟煤进行了热解制焦实验, 利用拉曼光谱分析了热解煤焦的微观结构变化, 使用热重分析仪(TGA)进行了无烟煤焦的程序升温脱硝实验, 研究了热解温度对无烟煤焦微观结构和脱硝特性的影响。研究结果表明:热解温度对无烟煤焦的微观结构有显著的影响, 随着热解温度升高, 煤焦的拉曼光谱G峰与D1峰的位置差逐渐减小, 谱峰积分面积逐渐缩小, 积分面积比值I_D1/I_G和I_D3/I_G先增大后减小, I_G/I_All先减小后增大。热解温度还对无烟煤焦的脱硝特性有明显的影响, 无烟煤随着热解温度升高由炭化向初步石墨化转变, 由于活性结构数量的减少和碳结构变得更加有序, 无烟煤焦的脱硝反应性不断降低, 脱硝反应活化能增大。

关键词: 煤燃烧, 热解, 拉曼光谱, 脱硝, 反应动力学

CLC Number:

TQ53

YIN Yanshan, WANG Zezhong, TIAN Hong, ZHANG Wei, YAN Xiaozhong, CHEN Donglin. Effect of pyrolysis temperature on microstructure and de-NO_x reactivity of anthracite char[J]. Chemical Industry and Engineering Progree, 2015, 34(06): 1636-1640.

尹艳山, 王泽忠, 田红, 张巍, 鄢晓忠, 陈冬林. 热解温度对无烟煤焦微观结构和脱硝特性的影响[J]. 化工进展, 2015, 34(06): 1636-1640.

References

[1] 虞继舜. 煤化学[M]. 北京:冶金工业出版社, 2000.
[2] 石金明, 孙路石, 向军, 等. 兖州煤气化半焦表面官能团特征试验研究[J]. 中国电机工程学报, 2010, 30(5):17-22.
[3] 陈路, 周志杰, 刘鑫, 等. 煤快速热解焦的微观结构对其气化活性的影响[J]. 燃料化学学报, 2012, 40(6):648-654.
[4] Sheng C. Char structure characterised by Raman spectroscopy and its correlations with combustion reactivity[J]. Fuel, 2007, 86(15):2316-2324.
[5] 苏亚欣, 邓文义, 姜凡, 等. 废轮胎的燃料特性及用于燃煤锅炉再燃脱硝[J]. 化工进展, 2011, 30(3):642-648.
[6] Yang J, Sanchez-Cortezon E, Pfander N, et al. Reaction of NO with carbonaceous materials:III. Influence of the structure of the materials[J]. Carbon, 2000, 38(14):2029-2039.
[7] 陈旺, 焦娜, 徐樑华, 等. 碳纤维在石墨化处理过程中的sp²结构转变[J]. 宇航材料工艺, 2013(5):46-48.
[8] Jones S P, Fain C C, Edie D D. Structural development in mesophase pitch based carbon fibers produced from naphthalene[J]. Carbon, 1997, 35(10-11):1533-1543.
[9] Ishimaru K, Hata T, Bronsveld P, et al. Characterization of sp²- and sp³-bonded carbon in wood charcoal[J]. Journal of Wood Science, 2007, 53(5):442-448.
[10] Jawhari T, Roid A, Casado J. Raman spectroscopic characterization of some commercially available carbon black materials[J]. Carbon, 1995, 33(11):1561-1565.
[11] Morga R. Micro-Raman spectroscopy of carbonized semifusinite and fusinite[J]. International Journal of Coal Geology, 2011, 87(3-4):253-267.
[12] 柳晓飞, 尤静林, 王媛媛, 等. 澳大利亚烟煤热解的拉曼光谱研究[J]. 燃料化学学报, 2014, 42(3):270-276
[13] Cuesta A, Dhamelincourt P, Laureyns J, et al. Raman microprobe studies on carbon materials[J]. Carbon, 1994, 32(8):1523-1532.
[14] Li X, Hayashi J, Li C Z. FT-Raman spectroscopic study of the evolution of char structure during the pyrolysis of a Victorian brown coal[J]. Fuel, 2006, 85(12-13):1700-1707.
[15] Zickler G A, Smarsly B, Gierlinger N, et al. A reconsideration of the relationship between the crystallite size L_a of carbons determined by X-ray diffraction and Raman spectroscopy[J]. Carbon, 2006, 44(15):3239-3246.
[16] Zaida A, Bar-Ziv E, Radovic L R, et al. Further development of Raman Microprobe spectroscopy for characterization of char reactivity[J]. Proceedings of the Combustion Institute, 2007, 31(2):1881-1887.
[17] Xu L, Liu H, Jin Y, et al. Structural order and dielectric properties of coal chars[J]. Fuel, 2014, 137:164-171.
[18] Russell N V, Beeley T J, Man C K, et al. Development of TG measurements of intrinsic char combustion reactivity for industrial and research purposes[J]. Fuel Processing Technology, 1998, 57(2):113-130.
[19] Dong L, Gao S, Song W, et al. Experimental study of NO reduction over biomass char[J]. Fuel Processing Technology, 2007, 88(7):707-715.
[20] 徐朝芬, 向军, 孙路石, 等. 热解温度对淮南煤热解与CO₂气化特性的影响[J]. 华中科技大学学报:自然科学版, 2010, 38(11):100-107.
[21] Rhim Y R, Zhang D, Fairbrother D H, et al. Changes in electrical and microstructural properties of microcrystalline cellulose as function of carbonization temperature[J]. Carbon, 2010, 48(4):1012-1024.
[22] Xu M Z, Sheng C D. Influences of the heat-treatment temperature and inorganic matter on combustion characteristics of cornstalk biochars[J]. Energy & Fuels, 2012, 26(1):209-218.

Effect of pyrolysis temperature on microstructure and de-NO_x reactivity of anthracite char

热解温度对无烟煤焦微观结构和脱硝特性的影响

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 15

Recommended Articles

Metrics

Comments

[1]	LAI Shini, JIANG Lixia, LI Jun, HUANG Hongyu, KOBAYASHI Noriyuki. Research progress of ammonia blended fossil fuel [J]. Chemical Industry and Engineering Progress, 2023, 42(9): 4603-4615.
[2]	LI Zhiyuan, HUANG Yaji, ZHAO Jiaqi, YU Mengzhu, ZHU Zhicheng, CHENG Haoqiang, SHI Hao, WANG Sheng. Characterization of heavy metals during co-pyrolysis of sludge with PVC [J]. Chemical Industry and Engineering Progress, 2023, 42(9): 4947-4956.
[3]	LI Haidong, YANG Yuankun, GUO Shushu, WANG Benjin, YUE Tingting, FU Kaibin, WANG Zhe, HE Shouqin, YAO Jun, CHEN Shu. Effect of carbonization and calcination temperature on As(Ⅲ) removal performance of plant-based Fe-C microelectrolytic materials [J]. Chemical Industry and Engineering Progress, 2023, 42(7): 3652-3663.
[4]	YAO Liming, WANG Yazhuo, FAN Honggang, GU Qing, YUAN Haoran, CHEN Yong. Treatment status of kitchen waste and its research progress of pyrolysis technology [J]. Chemical Industry and Engineering Progress, 2023, 42(7): 3791-3801.
[5]	ZHANG Shan, ZHONG Zhaoping, YANG Yuxuan, DU Haoran, LI Qian. Enrichment of heavy metals in pyrolysis of municipal solid waste by phosphate modified kaolin [J]. Chemical Industry and Engineering Progress, 2023, 42(7): 3893-3903.
[6]	WANG Junjie, PAN Yanqiu, NIU Yabin, YU Lu. Molecular level catalytic reforming model construction and application [J]. Chemical Industry and Engineering Progress, 2023, 42(7): 3404-3412.
[7]	XIU Haoran, WANG Yungang, BAI Yanyuan, ZOU Li, LIU Yang. Combustion characteristics and ash melting behavior of Zhundong coal/municipal sludge blended combustion [J]. Chemical Industry and Engineering Progress, 2023, 42(6): 3242-3252.
[8]	LI Ruolin, HE Shaolin, YUAN Hongying, LIU Boyue, JI Dongli, SONG Yang, LIU Bo, YU Jiqing, XU Yingjun. Effect of in-situ pyrolysis on physical properties of oil shale and groundwater quality [J]. Chemical Industry and Engineering Progress, 2023, 42(6): 3309-3318.
[9]	LI Dongxian, WANG Jia, JIANG Jianchun. Producing biofuels from soapstock via pyrolysis and subsequent catalytic vapor-phase hydrotreating process [J]. Chemical Industry and Engineering Progress, 2023, 42(6): 2874-2883.
[10]	WANG Zhiwei, GUO Shuaihua, WU Mengge, CHEN Yan, ZHAO Junting, LI Hui, LEI Tingzhou. Recent advances on catalytic co-pyrolysis of biomass and plastic [J]. Chemical Industry and Engineering Progress, 2023, 42(5): 2655-2665.
[11]	LIANG Yijing, MA Yan, LU Zhanfeng, QIN Fusheng, WAN Junjie, WANG Zhiyuan. Experimental investigation on the anti-coking performance of La_1-_x Sr _x MnO₃ perovskite coating [J]. Chemical Industry and Engineering Progress, 2023, 42(4): 1769-1778.
[12]	GE Weitong, LIAO Yalong, LI Mingyuan, JI Guangxiong, XI Jiajun. Preparation and dechlorination kinetics of Pd-Fe/MWCNTs bimetallic catalyst [J]. Chemical Industry and Engineering Progress, 2023, 42(4): 1885-1894.
[13]	LIU Jing, LIN Lin, ZHANG Jian, ZHAO Feng. Research progress in pore size regulation and electrochemical performance of biomass-based carbon materials [J]. Chemical Industry and Engineering Progress, 2023, 42(4): 1907-1916.
[14]	YANG Ziqiang, LI Fenghai, GUO Weijie, MA Mingjie, ZHAO Wei. Review on phosphorus migration and transformation during municipal sewage sludge heat treatment [J]. Chemical Industry and Engineering Progress, 2023, 42(4): 2081-2090.
[15]	ZHAO Jiaqi, HUANG Yaji, LI Zhiyuan, DING Xueyu, QI Shuaijie, ZHANG Yuyao, LIU Jun, GAO Jiawei. Characteristics of three-phase products from co-pyrolysis of sewage sludge and PVC [J]. Chemical Industry and Engineering Progress, 2023, 42(4): 2122-2129.