电晕放电喷雾荷电特性

doi:10.16085/j.issn.1000-6613.2020-0799

摘要/Abstract

摘要：

静电喷雾广泛应用于工业各个领域，如静电喷涂、静电雾化燃烧、静电雾化除尘等，其应用效果与喷雾荷电特性密切相关。为获得更佳荷电效果，本文探究了电晕荷电过程中感应电流对液滴真实荷电电流的影响，通过改变荷电电压、电极间距、电极环直径及液体流量等，实验研究了各因素变化对喷雾荷质比、电荷衰减及液滴粒径的影响。结果表明：相比于感应荷电，电晕荷电过程不稳定但能获得更佳的荷电效果，液滴荷质比随荷电电压的增加而先减小后增大，随电极环直径的增加而先增大后减小，随电极间距的增大而增大，电极环直径80mm，电极间距40mm能获得最佳荷电效果；荷电液滴带电量会随输运距离增加而泄漏衰减，相同距离下液滴通过电晕放电带有电荷后衰减更快；液滴带电后能够降低液体表面张力，随着液滴荷电量的增加，雾化液滴粒径有所降低。

关键词: 电晕荷电, 静电喷雾, 荷质比, 电荷衰减, 粒度分布

Abstract:

Electrostatic spray is widely used in industry, such as electrostatic spraying, electrostatic atomizing combustion, electrostatic atomization dust removal, etc. The application effect is closely related to spray charge characteristics. In order to obtain a better charge effect, the influence of the induced current on the true charge current of the droplet during the corona charging process was explored. The changes of spray charge-to-mass ratio, charge decay and droplet size were studied by changing the charge voltage, electrode spacing, electrode ring diameter and liquid flow rate. The results showed that the corona charging process is unstable but can obtain better charge effect. The charge-to-mass ratio of droplet decrease first then increases as the increase of charge voltage. It increases first and then decreases with the increase of the electrode ring diameter, and increases with the increase of the electrode spacing at the same voltage. The best charging effect is that the electrode ring diameter is 80mm and the electrode spacing is 40mm. When the droplet was charged, the charge amount would vary with the transport distance. The corona charge decayed faster than inductive charge at the same distance. Charged droplet could reduce the surface tension and the particle size of the droplet. As the charge capacity of the droplet increases, the droplet size decreases.

Key words: corona charge, electrostatic spray, charge-to-mass ratio, charge decay, size distribution

中图分类号:

O359

李金, 王军锋, 徐惠斌, 郑高杰, 孟新. 电晕放电喷雾荷电特性[J]. 化工进展, 2021, 40(3): 1300-1306.

LI Jin, WANG Junfeng, XU Huibin, ZHENG Gaojie, MENG Xin. Charge characteristics of corona discharge spray[J]. Chemical Industry and Engineering Progress, 2021, 40(3): 1300-1306.

图/表 13

参考文献 22

1	HIGASHIYAMA Yoshio, TANAKA Shinichi, SUGIMOTO Toshiyuki, et al. Size distribution of the charged droplets in an axisymmetric shower[J]. Journal of Electrostatics, 1999, 47(3): 183-195.
2	DANIEL E Martin, MOHAMED Latheef, Lpoez JUAN D. Electrostatically charged aerial application improved spinosad deposition on early season cotton[J]. Journal of Electrostatics, 2019, 97: 121-125.
3	鲍重光. 静电技术原理[M]. 北京: 北京理工大学出版社, 1993: 96-99.
	BAO Chongguang. The principle of electrostatic technology[M]. Beijing: Beijing Institute of Technology Press, 1993: 96-99.
4	甘云华, 李海鸽, 张夏, 等. 组合电极小型燃烧器的电学及雾化特性研究[J]. 中国电机工程学报, 2017, 37(8): 162-171.
	GAN Yunhua, LI Haige, ZHANG Xia, et al. Study on the electrical and spraying characteristics of small-scale combustor with combined electrodes[J]. Proceedings of the CSEE, 2017, 37(8): 162-171.
5	甘云华, 李海鸽, 江政纬, 等. 组合电极荷电雾化的实验研究[J]. 工程热物理学报, 2018, 39(7): 1585-1591.
	GAN Yunhua, LI Haige, JIANG Zhengwei, et al. Experimental study on electrospray characteristics with combined electrodes[J]. Journal of Engineering Thermophysics, 2018, 39(7): 1585-1591.
6	叶宏程, 甘云华, 江政纬, 等. 乙醇荷电喷雾对冲燃烧的火焰特性[J].化工学报, 2019, 70(12): 4787-4794, 4514.
	YE Hongcheng, GAN Yunhua, JIANG Zhengwei, et al. Flame characteristics of alcohol electro-spraying in counter-flow combustor[J]. CIESC Journal, 2019, 70(12): 4787-4794, 4514.
7	ZHANG Shengchang, CAMPAGNE Christine, SALAUN Fabien. Preparation of n-alkane/polycaprolactone phase-change microcapsules via single nozzle electro-spraying: characterization on their formation, structures and properties[J]. Applied Science, 2020, 10(2): 1-19.
8	WANG Juan, LI Chao, CHEN Deliang, et al. Interlayered MoS₂/rGO thin film for efficient lithium storage produced by electrospray deposition and far-infrared reduction[J]. Applied Surface Science, 2020, 499: 143940.
9	JOSHI B, SAMUEL E, KIM M W, et al. Electrosprayed graphene films decorated with bimetallic (zinc-iron) oxide for lithium-ion battery anodes[J]. Journal of Alloys and Compounds, 2019, 782: 699-708.
10	王军锋, 张姚文, 孟令鹏. 静电喷雾旋风除尘器荷电特性及细颗粒物的脱除[J]. 高电压技术, 2019, 45(2): 637-642.
	WANG Junfeng, ZHANG Yaowen, MENG Lingpeng. Charged droplet characteristics and fine particle removal efficiency by electrostatic spray cyclone[J]. High Voltage Engineering, 2019, 45(2): 637-642.
11	王军锋, 李金, 徐惠斌, 等. 湿法脱硫协同去除细颗粒物的研究进展[J]. 化工进展, 2019, 38(7): 3402-3411.
	WANG Junfeng, LI Jin, XU Huibin, et al. Advances in research on wet desulfurization and synergistic removal of fine particles[J]. Chemical Industry and Engineering Progress, 2019, 38(7): 3402-3411.
12	李林, 董勇, 崔琳, 等.荷电水雾脱除超细颗粒物的研究进展[J].化工进展, 2010, 29(6): 1143-1147.
	LI Lin, DONG Yong, CUI Lin, et al. Removal of submicron particles by charged water droplets[J]. Chemical Industry and Engineering Progress, 2010, 29(6): 1143-1147.
13	SUNG J H, KIM M, KIM Y J, et al. Ultrafine particle cleaning performance of an ion spray electrostatic air cleaner emitting zero ozone with diffusion charging by carbon fiber[J]. Building and Environment, 2019, 166: 106422.
14	王军锋, 顾维锴, 王晓英, 等. 感应荷电喷雾荷电性能与喷雾特性试验研究[J]. 高电压技术, 2015, 41(2): 504-509.
	WANG Junfeng, GU Weikai, WANG Xiaoying, et al. Experimental study on charging performance and spray characteristics of induction charged spray[J]. High Voltage Engineering, 2015, 41(2): 504-509.
15	王军锋, 张仕超, 左子文. 感应荷电过程中喷雾荷电特性影响规律实验研究[J]. 高电压技术, 2017, 43(2): 184-189.
	WANG Junfeng, ZHANG Shichao, ZUO Ziwen. Experimental study of influence rules on spray charged characteristics in the induction charging process[J]. High Voltage Engineering, 2017, 43(2): 184-189.
16	崔琳, 李林, 孟凡腾, 等. 感应荷电过程中液滴雾化与荷电特性的相互影响[J]. 高电压技术, 2011, 37(10): 2536-2541.
	CUI Lin, LI Lin, MENG Fanteng, et al. Interrelationship of droplet atomization and charged characteristics in the induction charging process[J]. High Voltage Engineering, 2011, 37(10): 2536-2541.
17	陈志刚, 吴春笃, 孙英琨. 负高压电晕荷电喷雾沉积特性[J]. 高电压技术, 2008, 34(11): 2440-2446.
	CHEN Zhigang, WU Chundu, SUN Yingkun. Deposition characteristics of electrostatic spraying by negative high-voltage corona discharge[J]. High Voltage Engineering, 2008, 34(11): 2440-2446.
18	陈志刚, 周金木, 吴春笃, 等. 高压脉冲负电晕荷电喷雾试验研究[J]. 高电压技术, 2007, 33(2): 128-131.
	CHEN Zhigang, ZHOU Jinmu, WU Chundu, et al. Experimental study on electrostatic spraying of negative high-voltage pulse corona charge[J]. High Voltage Engineering, 2007, 33(2): 128-131.
19	PATEL Manoj Kumar, GHANSHYAM C, KAPUR Pawan. Characterization of electrode material for electrostatic spray charging: theoretical and engineering practices[J]. Journal of Electrostatics, 2013, 71(1): 55-60.
20	MARCHEWICZ Artur, SOBCZYK A T, KRUPA Andrzej, et al. Induction charging of water spray produced by pressure atomizer[J]. International Journal of Heat and Mass Transfer, 2019, 135: 631-648.
21	KIM S, JUN M, CHOI S, et al. Discharge current of water electrospray with electrical conductivity under high-voltage and high-flow-rate conditions[J]. Experimental Thermal and Fluid Science, 2020, 118: 110151.
22	王清亮, 张璐, 李舟, 等. 空气湿度对导线电晕起始电压的影响[J]. 电力建设, 2009(8): 66-69.
	WANG Qingliang, ZHANG Lu, LI Zhou, et al. Influence of humidity on conductor corona onset voltage[J]. Electric Power Construction, 2009(8): 66-69.

设备名称	型号（规格）	实验参数
高压静电发生器	DW-N503-1ACDF	-50~0kV
激光粒度分析仪	Winner 318A	1~323μm
液体流量计	LZB-6WB	0.6L/min
空压机	ZBM-0.1/8	1MPa
压力罐	R-9363A	10L
微安表	SM3D-DA	0~20μA

设备名称	型号（规格）	实验参数
高压静电发生器	DW-N503-1ACDF	-50~0kV
激光粒度分析仪	Winner 318A	1~323μm
液体流量计	LZB-6WB	0.6L/min
空压机	ZBM-0.1/8	1MPa
压力罐	R-9363A	10L
微安表	SM3D-DA	0~20μA

实验条件	起晕电压U₁/kV	放电电压U₂/kV
A1	8.45	20.59
A2	7.48	25.64
A3	6.4	32.12
B1	9.54	24.74
B2	8.15	34.8
B3	7.53	36.44
C1	9.71	29.44
C2	8.48	36.77
C3	8.4	39.51

实验条件	起晕电压U₁/kV	放电电压U₂/kV
A1	8.45	20.59
A2	7.48	25.64
A3	6.4	32.12
B1	9.54	24.74
B2	8.15	34.8
B3	7.53	36.44
C1	9.71	29.44
C2	8.48	36.77
C3	8.4	39.51

[1]	王兰江, 梁瑜, 汤琼, 唐明兴, 李学宽, 刘雷, 董晋湘. 快速热解铂前体合成高分散的Pt/HY催化剂及其萘深度加氢性能[J]. 化工进展, 2023, 42(8): 4159-4166.
[2]	吴霞, 蒋勋涛, 张余晓, 吕慧园, 黄方, 于筱溪. 基于液滴微流控技术的蛋白质结晶[J]. 化工进展, 2023, 42(4): 2024-2030.
[3]	李娟娟, 张天永, 李祥高. 电泳显示用高质量铁锰黑纳米分散系的构建[J]. 化工进展, 2022, 41(6): 3178-3185.
[4]	于涵, 王宏, 朱恂, 丁玉栋, 陈蓉, 廖强. 静电喷雾沉积半径的预测模型[J]. 化工进展, 2022, 41(6): 2864-2870.
[5]	韩芬, 杨娜, 孙永利, 姜斌, 肖晓明, 张吕鸿. 玻璃纤维聚结器脱除油中乳化水[J]. 化工进展, 2022, 41(12): 6723-6732.
[6]	张爽, 赵立新, 刘洋, 宋民航, 刘琳. 脱气除油旋流系统流场分布及分离特性[J]. 化工进展, 2022, 41(1): 75-85.
[7]	尹微虹, 巨晓洁, 谢锐, 汪伟, 刘壮, 褚良银. 具有梯级释药性能的核壳型双重载药微球[J]. 化工进展, 2021, 40(2): 998-1007.
[8]	田昌, 苏明旭, 蒋瑜, 夏多兵. 超声法在线测量烟气脱硫浆液粒度分布、密度方法和装置[J]. 化工进展, 2021, 40(12): 6516-6522.
[9]	张超, 师旭军, 张国珍, 武福平, 晏雯雯, 黄星星. 弹性填料对ABR去除重金属及颗粒污泥的影响[J]. 化工进展, 2020, 39(7): 2858-2866.
[10]	王泽龙,王建军,刘宏宇. 两级组合式除雾器的分离性能分析[J]. 化工进展, 2020, 39(3): 890-897.
[11]	李爱英, 张文秀, 舒福昌, 李论, 李濛, 雷斌. BA原油沥青质性质及沉积抑制剂作用机理[J]. 化工进展, 2019, 38(s1): 110-115.
[12]	张亮,张玉明,张浩然,杨行,温宏炎,高士秋. 催化裂化油浆固含量测定及组成分析[J]. 化工进展, 2019, 38(9): 4052-4059.
[13]	朱桂华,张傲林,巴赛,陈勇,胡志坤. 卧螺离心机内盐析流场的CFD-PBM耦合计算[J]. 化工进展, 2019, 38(9): 3947-3955.
[14]	张军立, 龚俊波, 孙华, 段志钢, 胡卫国. 头孢氨苄连续结晶研究及应用[J]. 化工进展, 2019, 38(07): 3349-3354.
[15]	李丽, 刘宝树, 郑学明, 孙华. 舒巴坦钠溶析结晶工艺优化[J]. 化工进展, 2019, 38(06): 2905-2914.