冷凝条件对基于混合工质的内燃机余热有机朗肯循环热力性能的影响

doi:10.16085/j.issn.1000-6613.2017-2309

化工进展 ›› 2018, Vol. 37 ›› Issue (08): 2927-2934.DOI: 10.16085/j.issn.1000-6613.2017-2309

冷凝条件对基于混合工质的内燃机余热有机朗肯循环热力性能的影响

王明涛¹, 刘启一¹, 张百浩²

1 鲁东大学能源与动力工程系, 山东烟台 264025;
2 天津大学机械工程学院, 天津 300072

收稿日期:2017-11-08 修回日期:2018-03-13 出版日期:2018-08-05 发布日期:2018-08-05
通讯作者: 王明涛(1983-),男,博士,讲师,研究方向为新型热力循环及节能工程。
作者简介:王明涛(1983-),男,博士,讲师,研究方向为新型热力循环及节能工程。E-mail:wmtldu@163.com.cn。
基金资助:
山东省自然科学基金项目（ZR2014EEP026，ZR2016AP07）。

Effects of condensation condition on cycle performance of the organic Rankine cycle (ORC) for recovering waste heat of engine using zeotropic mixtures

WANG Mingtao¹, LIU Qiyi¹, ZHANG Baihao²

1 School of Energy and Power Engineering, Ludong University, Yantai 264025, Shandong, China;
2 School of Mechanical Engineering, Tianjin University, Tianjin 300072, China

Received:2017-11-08 Revised:2018-03-13 Online:2018-08-05 Published:2018-08-05

摘要/Abstract

摘要： 利用建立的内燃机余热有机朗肯循环模型，选取R245fa分别与环己烷、环戊烷组成非共沸混合工质，对3种冷凝条件下的有机朗肯循环进行热力学分析，研究了冷凝条件对非共沸混合工质有机朗肯循环性能的影响规律，提出了确定混合工质冷凝温度的方法。结果表明：冷凝条件是影响系统性能的重要因素，在定泡点冷凝温度工况下，纯工质的热力性能优于混合工质的热力性能；在定露点冷凝温度工况下，配比合适的混合工质的热力性能优于纯工质的热力性能。混合工质的冷凝温度应根据冷却介质进出口温度、混合工质的温度滑移和传热窄点温差进行优化；当冷却介质的温升小于混合工质的最大温度滑移时，随着R245质量分数的增加，系统输出净功出现两个极大值，但输出净功最大值出现在热力性能较优工质所占比例大的质量分数点；当冷却介质温升大于混合工质的最大温度滑移时，输出净功最大值出现在温度滑移最大的混合工质质量分数点。

关键词: 余热利用, 有机朗肯循环, 混合工质, 柴油机, 冷凝条件

Abstract: The effects of condensation conditions on the cycle performance of ORC (organic Rankine cycle) using zeotropic mixtures as working fluids for recovering exhaust heat of engine were analyzed in this paper. R245/cyclohexane and R245 fa/cyclopentane were selected as working fluids. Fixed condenser bubble temperature, fixed condenser dew temperature and optimized condensation temperature were considered as condensation conditions. The impacts of condensation conditions on the cycle performance were performed by establishing energy and exergy model of the ORC. Method determining condensation temperature was presented when using zeotropic mixtures as working fluids. Results showed that condensation condition is an important factor affecting the cycle performance. The cycle performance of pure component is better than that of mixture under the fixed condenser bubble temperature, however, the conclusion is opposite under the fixed condenser dew temperature. The condensation temperature of mixture should be optimized according to the inlet and outlet temperature of cooling air, temperature glide of mixture and pinch point temperature. Two optimal working fluids mass fractions maximize the net power output for cooling air increases less than the maximum condensation temperature glide, while the highest net power output appears at the higher mass fraction of the better cycle performance component. For the cooling air increases more than the maximum condensation temperature glide, the maximum net power output appears at the mass fraction of the maximum temperature glide.

Key words: waste heat recovery, organic Rankine cycle, zeotropic mixtures, engine, condensation condition

中图分类号:

TK123

王明涛, 刘启一, 张百浩. 冷凝条件对基于混合工质的内燃机余热有机朗肯循环热力性能的影响[J]. 化工进展, 2018, 37(08): 2927-2934.

WANG Mingtao, LIU Qiyi, ZHANG Baihao. Effects of condensation condition on cycle performance of the organic Rankine cycle (ORC) for recovering waste heat of engine using zeotropic mixtures[J]. Chemical Industry and Engineering Progress, 2018, 37(08): 2927-2934.

参考文献

[1] CONKIN J C, SZYBISTS J P. A highly efficient six-stroke internal combustion engine cycle with water injection for in-cylinder exhaust heat recovery[J]. Energy, 2010, 35:1658-1664.
[2] SAIDUR R, REZAEI M, MUZAMMIL W K, et al. Technologies to recover exhaust heat from internal combustion engines[J]. Renew Sustain Energy Rev., 2012, 16(8):5649-5659.
[4] 朱轶林, 李惟毅, 孙冠中, 等. 船舶烟气余热驱动有机朗肯循环的系统性能分析[J]. 化工进展, 2016, 35(12):3858-3865. ZHU Y L, LI W Y, SUN G Z, et al. Performance analysis for waste heat recovery system of ship diesel engine based on organic Rankine cycle[J]. Chemical Industry and Engineering Progress, 2016, 35(12):3858-3865.
[5] 杨凯, 张红光, 宋松松, 等. 变工况下车用柴油机排气余热有机朗肯循环回收系统[J]. 化工学报, 2015, 66(3):1097-1103. YANG K, ZHANG H G, SONG S S, et al. Waste heat organic Rankine cycle of vehicle diesel engine under variable working conditions[J]. CIESC Journal, 2015, 66(3):1097-1103.
[6] YU G P, SHU G Q, TIAN H, et al. Multi-approach evaluations of a cascade-organic Rankine cycle(CORC) system driven by diesel engine waste heat:Part B-Techno-economic evaluations[J]. Energy Conversion and Management, 2016, 108:596-608.
[7] WANG T, ZHANG Y, ZHANG J, et al. Comparisons of system benefits and thermo-economics for exhaust energy recovery applied on a heavy-duty diesel engine and a light-duty vehicle gasoline engine[J]. Energy Conversion and Manage, 2014, 84:97-107.
[8] HUANG H, ZHU J, YAN B. Comparison of the performance of two different dual loop organic Rankine cycles(DORC) with nano fluid for engine waste heat[J]. Energy Conversion and Management, 2016, 126:99-109.
[9] ZHANG H G, WANG E H, FAN B Y. A performance analysis of a novel system of a dual loop bottoming organic Rankine cycle(ORC) with a light-duty diesel engine[J]. Appl. Energy, 2013, 102:1504-1513.
[10] SHU G Q, LI X N, TIAN H, et al. Alkanes as working fluids for high-temperature exhaust heat recovery of diesel engine using organic Rankine cycle[J]. Appl. Energy, 2014, 119:204-217.
[11] 刘秀龙, 曹泷, 苗政, 等. 有机朗肯循环驱动反渗透海水淡化运行模式及工质选择[J]. 化工进展, 2016, 35(10):3639-3647. LIU X L, CAO S, MIAO Z, et al. Operation mode and working fluid selection for organic Rankine cycle coupled with reverse osmosis desatination[J]. Chemical Industry and Engineering Progress, 2016, 35(10):3639-3647.
[12] 倪渊, 赵良举, 刘朝, 等. 非共沸混合工质ORC低温烟气余热利用分析与优化[J]. 化工学报, 2013, 64(11):3985-3992. NI Y, ZHAO L J, LIU C, et al. Recovery of waste heat of low-temperature flue gas by parametric optimization on organic Rankine cycle with non-azeotropic mixures[J]. CIESC Journal, 2013, 64(11):3985-3992.
[13] 舒歌群, 高媛媛, 田华. 基于(火用)分析的内燃机排气余热ORC混合工质性能分析[J]. 天津大学学报, 2014, 47(3):218-223. SHU G Q, GAO Y Y, TIAN H. Performance analysis of mixtures used in ORC for engine exhaust gas waste heat recovery based on exergy analysis[J]. Journal of Tianjin University (Science and Technology), 2014, 47(3):218-223.
[14] TIAN H, CHANG L W, GAO Y Y, et al. Thermo-economic analysis of zeotropic mixtures based on siloxanes for engine waste heat recovery using a dual-loop organic Rankine cycle(DORC)[J]. Energy Conversion and Management, 2017, 136:11-26.
[15] PANESAR A S. An innovative organic Rankine cycle approach for high temperature applications[J]. Energy, 2016, 115:1436-1450.
[16] LIU Q, DUAN Y Y, YANG Z. Effect of condensation temperature glide on the performance of organic Rankine cycles with zeotropic mixture working fluids[J]. Applied Energy, 2014, 115:394-404.
[17] LU J L, ZHANG J, CHEN S L, et al. Analysis of organic Rankine cycles using zeotropic mixtures as woiking fluids under different restrictive conditions[J]. Energy Conversion and Management, 2016, 126:704-716.
[18] LI R Y, DU M T, WU C M, et al. Potential of organic Rankine cycle using zeotropic mixures as working fluids for watst heat recovery[J]. Energy, 2014, 77:509-519.
[19] TIAN H, SHU G Q, WEI H Q, et al. Fluids and parameters optimization for the organic Rankine cycles(ORCs) used in exhaust heat recovery of internal combustion engine(ICE)[J]. Energy, 2012, 47(1):125-136.
[20] 王明涛, 方筝, 刘启一. 涡轮增压柴油机余热利用的有机朗肯循环烃类高温工质热力学分析[J]. 化工进展, 2016, 35(9):2721-2727. WANG M T, FANG Z, LIU Q Y. Thermodynamics analysis of an organic Rankine cycle for waste heat recovery of a turbo-charged diesel engine based on working fluids of alkanes[J]. Chemical Industry and Engineering Progress, 2016, 35(9):2721-2727.

[1]	高婷婷, 蒋振, 吴晓毅, 郝婷婷, 马学虎, 温荣福. 微乳液脉动热管应用于锂离子电池的散热性能[J]. 化工进展, 2023, 42(3): 1167-1177.
[2]	李丹, 杨思宇, 钱宇. 耦合溴化锂吸收式制冷与有机朗肯循环的合成气深冷分离工艺[J]. 化工进展, 2022, 41(10): 5236-5246.
[3]	曾成, 卢苇, 蒙仕达, 覃日帅. 基于热流逸效应的燃煤电厂烟气二氧化碳分离系统[J]. 化工进展, 2022, 41(10): 5214-5220.
[4]	张春伟, 张学军, 赵阳. 应用于空分纯化系统的相变储热器建模及分析[J]. 化工进展, 2021, 40(6): 3099-3106.
[5]	李新国, 弭慧惠, 吴晓松, 高冠怡. 调节传热窄点以提升有机朗肯循环性能的分析[J]. 化工进展, 2021, 40(5): 2517-2525.
[6]	刘广林, 徐进良, 苗政. 共冷凝器双循环有机朗肯发电系统㶲分析[J]. 化工进展, 2021, 40(12): 6656-6662.
[7]	王东亮, 孟文亮, 杨勇, 董鹏, 李春强. 热泵耦合甲醇多效精馏节能新工艺[J]. 化工进展, 2020, 39(9): 3550-3555.
[8]	谢玮祎,陈晓平,马吉亮,刘道银,梁财,吴烨,蔡天意. 基于钠基吸附剂的烟气脱碳系统余热利用研究[J]. 化工进展, 2020, 39(2): 720-727.
[9]	张超,徐荣吉,陈静妍,吴青平. 非共沸不互溶混合工质脉动热管启动特性分析[J]. 化工进展, 2019, 38(12): 5279-5286.
[10]	汪宗御,邝海浪,张继锋,褚李林,纪玉龙. 低温等离子体用于柴油机尾气脱硝的实验[J]. 化工进展, 2019, 38(10): 4755-4766.
[11]	刘广林, 曹泷, 刘欢, 苗政, 徐进良. 基于单螺杆膨胀机有机朗肯循环有无回热系统性能分析[J]. 化工进展, 2019, 38(06): 2626-2632.
[12]	王治红, 丁晓明, 吴明鸥, 沈晓燕. 有机朗肯循环在多品位余热发电中的应用[J]. 化工进展, 2019, 38(05): 2189-2196.
[13]	杨宇鑫, 张红光, 赵蕊, 李健, 赵腾龙, 张梦茹. 工质泵变运行工况对有机朗肯循环系统性能的影响[J]. 化工进展, 2019, 38(02): 851-857.
[14]	姚玉婷, 李士雨. 高通量换热器用于低温发电系统的研究[J]. 化工进展, 2018, 37(10): 3737-3743.
[15]	陈光辉, 李升大, 陶少辉, 李建隆. 焦炉余热综合利用研究进展[J]. 化工进展, 2018, 37(10): 3799-3805.

冷凝条件对基于混合工质的内燃机余热有机朗肯循环热力性能的影响

Effects of condensation condition on cycle performance of the organic Rankine cycle (ORC) for recovering waste heat of engine using zeotropic mixtures

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价