太阳集热管纳米流体的光热性能实验

doi:10.16085/j.issn.1000-6613.2016.05.008

化工进展 ›› 2016, Vol. 35 ›› Issue (05): 1314-1320.DOI: 10.16085/j.issn.1000-6613.2016.05.008

太阳集热管纳米流体的光热性能实验

宋景东, 孙娟, 孙斌

东北电力大学能源与动力工程学院, 吉林吉林 132012

收稿日期:2015-10-20 修回日期:2015-11-12 出版日期:2016-05-05 发布日期:2016-05-05
通讯作者: 宋景东(1968-),男,硕士,研究员,研究方向为多相流动与传热。E-mail 2356035718@qq.com。
作者简介:宋景东(1968-),男,硕士,研究员,研究方向为多相流动与传热。E-mail 2356035718@qq.com。

Experimental investigation on photo-thermal properties of nanofluid for the solar tube

SONG Jingdong, SUN Juan, SUN Bin

Energy and Power Engineering Institute, Northeast Dianli University, Jilin 132012, Jilin, China

Received:2015-10-20 Revised:2015-11-12 Online:2016-05-05 Published:2016-05-05

摘要/Abstract

摘要： 采用两步法制备SiC-H₂O、TiC-H₂O、Al₂O₃-H₂O(α和γ)4种纳米流体,通过闷晒实验研究了4种纳米流体的光热转换性能,分析了颗粒种类、质量分数、分散剂、pH值、颗粒形状对纳米流体光热转换性能的影响,并且对比了普通玻璃管内纳米流体与全玻璃真空管内水的集热性能。实验结果表明,纳米流体的光热转换性能优于去离子水和全玻璃真空管,其中TiC-H₂O纳米流体的光热转换性能最好,最高温度比水高出21.76%;分散剂能增强纳米流体的光热转换性能,并且不同纳米流体最适合的分散剂也不同;纳米流体存在其最佳的质量分数和pH值,其中SiC-H₂O最适宜的质量分数为0.1%,最佳pH值为9;粒子形状对光热转换性能有较大影响。在55℃以下,SiC-H₂O纳米流体直接吸收式集热效率高于全玻璃真空管内水的间接吸收集热效率,两者效率的最高差值可达30%。但在更高温度下,纳米流体集热效率迅速下降。

关键词: 纳米流体, 光热性能, 太阳能, 太阳集热管, 稳定性

Abstract: In this article, SiC-H₂O, TiC-H₂O, and Al₂O₃-H₂O (α and γ) nanofluid were prepared through a two-step method, and the photo-thermal properties of the four nanofluids were studied by an insolation experiment. The impacts of the types of the nanoparticle, mass fraction, dispersants, pH value and particle shapes on photo-thermal properties of nanofluid were investigated. This study also compared the photo-thermal properties of nanofluid in ordinary glass tube and water in all-glass vacuum tube. The results show that photo-thermal properties of nanofluid are better than those of deionized water and all-glass vacuum tube. Among the nanofulids, the performance of TiC-H₂O nanofluid is the best, with the peak temperature of 21.76% higher than that of deionized water. Dispersants can enhance the photo-thermal properties of nanofluid, but, each nanofluid has its own suitable dispersants. The optimal mass fraction and pH value are found in this experiment, and those for SiC-H₂O are 0.1%(mass fraction) and 9, respectively. The shape of particle also has a major impact on the photo-thermal properties of nanofluid.Under the 55℃, direct absorption collecting efficiency using SiC-H₂O nanofluid is higher than that of traditional all-glass vacuum tube using water, the maximal efficiency difference between the two collectors can be up to 30%, but the efficiency for nanofulids decreases rapidly at higher temperature.

Key words: nanofluid, photo-thermal property, solar energy, solar collector tube, stability

中图分类号:

TK121

宋景东, 孙娟, 孙斌. 太阳集热管纳米流体的光热性能实验[J]. 化工进展, 2016, 35(05): 1314-1320.

SONG Jingdong, SUN Juan, SUN Bin. Experimental investigation on photo-thermal properties of nanofluid for the solar tube[J]. Chemical Industry and Engineering Progree, 2016, 35(05): 1314-1320.

参考文献

[1] CHOI S U S.Enhancing thermal conductivity of fluids with nanoparticles[J].ASME, 1995, 231: 99-106.
[2] XIE H, WANG J, XI T, et al.Thermal conductivity of suspensions containing nanosized SiC particles[J].International Journal of Thermophysics, 2002, 23(2): 571-580.
[3] 毛凌波, 张仁元, 柯秀芳, 等.纳米流体太阳集热器的光热性能研究[J].太阳能学报, 2009, 30(12): 1647-1652.
[4] YOUSEFI T, VEISY F, SHOJAEIZADEH E, et al.An experimental investigation on the effect of MWCNT-H₂O nanofluid on the efficiency of flat-plate solar collectors[J].Experimental Thermal and Fluid Science, 2012, 39: 207-212.
[5] YOUSEFI T, SHOJAEIZADEH E, VEYSI F, et al.An experimental investigation on the effect of pH variation of MWCNT-H₂O nanofluid on the efficiency of a flat-plate solar collector[J].Solar Energy, 2012, 86(2): 771-779.
[6] 何钦波, 汪双凤, 曾社铨, 等.直接吸收式太阳能集热纳米流体辐射特性实验研究[J].制冷学报, 2014, 35(1): 109-113.
[7] YU W, XIE H, CHEN L, et al.Investigation of thermal conductivity and viscosity of ethylene glycol based ZnO nanofluid[J].Thermochimica Acta, 2009, 491(1): 92-96.
[8] 凌智勇, 邹涛, 丁建宁, 等.纳米流体黏度特性[J].化工学报, 2012, 63(5): 1409-1414.
[9] 李强, 宣益民.纳米流体热导率的测量[J].化工学报, 2003, 54(1): 42-46.
[10] 王良虎, 向军, 李菊香.纳米流体的稳定性研究[J].材料导报, 2011, 17(5): 17-20.
[11] LI X, ZHU D, WANG X.Evaluation on dispersion behavior of the aqueous copper nano-suspensions[J].Journal of Colloid and Interface Science, 2007, 310(2): 456-463.
[12] 全国能源基础与管理标准化技术委员会.真空管型太阳能集热器: GB/T 17581-2007[S].北京: 中国标准出版社, 2008: 6-9.
[13] 徐国英, 李凌志, 张小松, 等.添加不同纳米颗粒的导热油直接吸收集热实验性能[J].化工学报, 2014, 65(s2): 293-298.

[1]	张岱凌, 丁玉梅, 左夏华, 黎昊为, 杨卫民, 阎华, 安瑛. 废弃墨粉纳米流体的光热特性[J]. 化工进展, 2023, 42(9): 4791-4798.
[2]	叶振东, 刘涵, 吕静, 张亚宁, 刘洪芝. 基于钙镁二元盐的热化学储能反应器的性能优化[J]. 化工进展, 2023, 42(8): 4307-4314.
[3]	王鑫, 王兵兵, 杨威, 徐志明. 金属表面PDA/PTFE超疏水涂层抑垢与耐腐蚀性能[J]. 化工进展, 2023, 42(8): 4315-4321.
[4]	娄宝辉, 吴贤豪, 张驰, 陈臻, 冯向东. 纳米流体用于二氧化碳吸收分离研究进展[J]. 化工进展, 2023, 42(7): 3802-3815.
[5]	陆洋, 周劲松, 周启昕, 王瑭, 刘壮, 李博昊, 周灵涛. CeO₂/TiO₂吸附剂煤气脱汞产物的浸出规律[J]. 化工进展, 2023, 42(7): 3875-3883.
[6]	吴展华, 盛敏. 绝热加速量热仪在反应安全风险评估应用中的常见问题[J]. 化工进展, 2023, 42(7): 3374-3382.
[7]	李吉焱, 景艳菊, 邢郭宇, 刘美辰, 龙永, 朱照琪. 耐盐型太阳能驱动界面光热材料及蒸发器的研究进展[J]. 化工进展, 2023, 42(7): 3611-3622.
[8]	谢志伟, 吴张永, 朱启晨, 蒋佳骏, 梁天祥, 刘振阳. 植物油基Ni_0.5Zn_0.5Fe₂O₄磁流体的黏度特性及磁黏特性[J]. 化工进展, 2023, 42(7): 3623-3633.
[9]	杨竞莹, 施万胜, 黄振兴, 谢利娟, 赵明星, 阮文权. 改性纳米零价铁材料制备的研究进展[J]. 化工进展, 2023, 42(6): 2975-2986.
[10]	杨扬, 孙志高, 李翠敏, 李娟, 黄海峰. 静态条件下表面活性剂OP-13促进HCFC-141b水合物生成[J]. 化工进展, 2023, 42(6): 2854-2859.
[11]	符淑瑢, 王丽娜, 王东伟, 刘蕊, 张晓慧, 马占伟. 析氧助催化剂增强光阳极光电催化分解水性能研究进展[J]. 化工进展, 2023, 42(5): 2353-2370.
[12]	郭文杰, 翟玉玲, 陈文哲, 申鑫, 邢明. Al₂O₃-CuO/水混合纳米流体对流传热性能及热经济性分析[J]. 化工进展, 2023, 42(5): 2315-2324.
[13]	李玲, 马超峰, 卢春山, 于万金, 石能富, 金佳敏, 张建君, 刘武灿, 李小年. 新型含氟替代品1,1,2-三氟乙烯的合成工艺与催化剂研究进展[J]. 化工进展, 2023, 42(4): 1822-1831.
[14]	殷铭, 郭晋, 庞纪峰, 吴鹏飞, 郑明远. 铜催化剂在涉氢反应中的失活机制和稳定策略[J]. 化工进展, 2023, 42(4): 1860-1868.
[15]	李云闯, 谢方明, 席亚男, 万新月, 孙玉虎, 赵永峰, 李根, 刘宏海, 高雄厚, 刘洪涛. 高水热稳定性介孔分子筛的低成本合成研究进展[J]. 化工进展, 2023, 42(4): 1877-1884.

太阳集热管纳米流体的光热性能实验

Experimental investigation on photo-thermal properties of nanofluid for the solar tube

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价