变频滚动转子式压缩制冷系统的(火用)分析

doi:10.16085/j.issn.1000-6613.2017.02.008

化工进展 ›› 2017, Vol. 36 ›› Issue (02): 457-464.DOI: 10.16085/j.issn.1000-6613.2017.02.008

变频滚动转子式压缩制冷系统的(火用)分析

沈冰洁, 陶乐仁, 王超, 虞中旸

上海理工大学能源与动力工程学院, 上海 200093

收稿日期:2016-06-27 修回日期:2016-08-07 出版日期:2017-02-05 发布日期:2017-02-05
通讯作者: 陶乐仁,教授,博士生导师,研究方向为制冷及低温技术。E-mail:cryo307@usst.edu.cn。
作者简介:沈冰洁(1993-),女,硕士研究生。E-mail:bingbingjenny@163.com。
基金资助:
上海市动力工程多相流动与传热重点实验室资助项目（1N-15-301-101）。

The exergy analysis of variable frequency rolling rotor compression refrigeration system

SHEN Bingjie, TAO Leren, WANG Chao, YU Zhongyang

School of Energy and Power Engineering, University of Shanghai for Science and Technology, Shanghai 200093, China

Received:2016-06-27 Revised:2016-08-07 Online:2017-02-05 Published:2017-02-05

摘要/Abstract

摘要： 针对吸气带液状态下变频压缩机组（火用）分析对优化热力系统的运行有着很明确的指导价值，研究和分析了不同吸气状态和不同压缩机频率下（火用）损失、（火用）效率、（火用）损率、（火用）损系数、制冷量、制冷系数（COP）、总（火用）损失、总（火用）效率以及总（火用）损系数的变化趋势，并比较得出了吸气带液时哪个设备是系统最薄弱环节。结果表明：①当压缩机少量吸气带液时，冷凝器和蒸发器（火用）效率的提升大于压缩机（火用）效率的下降，也就是说少量吸气带液对蒸发器和冷凝器的有利影响大于对压缩机的不利影响；②系统的总（火用）损失和总（火用）损系数在x=0.95左右达到最小，而总（火用）效率在x=0.95左右达到峰值；③当压缩机在较高频率下工作时，冷凝器和蒸发器的（火用）损失将会明显增加；④当压缩机频率为50Hz且吸气带液时，蒸发器的（火用）损失、（火用）损率和（火用）损系数最大，（火用）效率最小，此时蒸发器为系统最薄弱环节。指出以上结论也适用于同型号的滚动转子式压缩机。

关键词: (火用)损失, (火用)效率, 吸气带液, 压缩机频率, 热力学

Abstract: Since the exergy analysis of variable frequency compressors has clear guidance values about optimizing the thermodynamic system operation under liquid-vapor mixture refrigerant suction,the changing trends of the exergy loss,exergy efficiency,exergy loss rate,exergy loss coefficient,refrigerating capacity,COP,total exergy loss,total exergy efficiency and total exergy loss coefficient under different suction states and compressor efficiencies have been analyzed and which equipment is the weakest link in the system under liquid-vapor mixture refrigerant suction has also been obtained. Results showed that:①when rolling rotor compressors suck vapor refrigerant mixed a little liquid refrigerant,the increase of exergy efficiency of condenser and evaporator is greater than the decrease of exergy efficiency of compressor;that is to say,the beneficial effects of liquid-vapor mixture refrigerant suction on condensers and evaporators are greater than the adverse impacts on compressors. ②The total exergy loss and total exergy loss coefficient are minimum at x=0.95,while the total exergy efficiency is maximun at x=0.95. ③When compressors are operated under high efficiencies,the exergy losses of condenser and evaporator will be increased significantly. ④When the compressor efficiency is 50Hz and compressor sucks vapor refrigerant mixed a little liquid refrigerant,the exergy loss,exergy loss rate and exergy loss coefficient of evaporator are maximun and the exergy efficiency of evaporator is minimum. Thus,the evaporator is the weakest link in the system at this moment. The conclusions mentioned above are the same with the same type of rolling rotor compressors.

Key words: exergy loss, exergy efficiency, liquid-vapor mixture refrigerant suction, compressor efficiency, thermodynamic

中图分类号:

TK123

沈冰洁, 陶乐仁, 王超, 虞中旸. 变频滚动转子式压缩制冷系统的(火用)分析[J]. 化工进展, 2017, 36(02): 457-464.

SHEN Bingjie, TAO Leren, WANG Chao, YU Zhongyang. The exergy analysis of variable frequency rolling rotor compression refrigeration system[J]. Chemical Industry and Engineering Progree, 2017, 36(02): 457-464.

参考文献

[1] 牛国庆,王海波. 制冷系统的(火用)分析计算[J]. 焦作工学院学报(自然科学版),2002,21(4):244-247. NIU G Q,WANG H B. Analysis and calculation of exergy in a refrigeration system[J]. Journal of Jiaozuo Institute of Technology(Natural Science),2002,21(4):244-247.
[2] 高志宏. 制冷系统的(火用)效率分析[J]. 辽宁师专学报,2003,5(3):17-18. GAO Z H. Analysis of exergy efficiency in a refrigeration system[J]. Journal of Liaoning Teachers College,2003,5(3):17-18.
[3] 高洪亮,于守强. (火用)分析法在制冷循环中的应用[J]. 山东轻工业学院学报,1999,13(2):15-17. GAO H L,YU S Q. The applications of exergy in refrigeration cycle[J]. Journal of Shandong Institute of Light Industry,1999,13(2):15-17.
[4] 杨开明. (火用)分析应用初探[J]. 四川电力技术,1993(2):26-31. YANG K M. The preliminary study of the applications of exergy analysis[J]. Sichuan Electric Power Technology,1993(2):26-31.
[5] 高洪亮. 制冷装置的(火用)效率分析[J]. 冷藏技术,1999(3):13-15. GAO H L. Analysis of exergy efficiency in refrigeration equipments[J]. Cold Storage Technology,1999(3):13-15.
[6] 王军,张定才,周光辉. 实际制冷循环的(火用)分析[J]. 郑州纺织工学院学报,2000,11(3):53-55. WANG J,ZHANG D C,ZHOU G H. The exergy analysis of practical refrigerative circle[J]. Journal of Zhengzhou Textile Institute,2000,11(3):53-55.
[7] 姚立为. 制冷与热泵系统的(火用)分析[J]. 应用能源技术,2000(2):1-3. YAO L W. Analysis of exergy in refrigeration system and heat pump system[J]. Applied Energy Technology,2000(2):1-3.
[8] 马娟丽,刘昌海,周骞,等. 膨胀阀开度对跨临界CO₂制冷系统(火用)损失影响的实验研究[J]. 西安交通大学学报,2014,48(3):12-16. MA J L,LIU C H,ZHOU Q,et al. Experimental investigation for effects of electronic expansion valve opening on exergy loss in transcritical CO₂ system[J]. Journal of Xi'an Jiaotong University,2014,48(3):12-16.
[9] 王建强,王文红,任晓芬,等. 蒸气压缩式制冷系统的能耗分析[J]. 河北工程大学学报(自然科学版),2008,25(1):71-73. WANG J Q,WANG W H,REN X F,et al. Exergy analysis of the vapor compression refrigeration[J]. Journal of Hebei University of Engineering(Natural Science Edition),2008,25(1):71-73.
[10] AHAMED J U,SAIDUR R,MASJUKI H H. A review on exergy analysis of vapor compression refrigeration system[J]. Renewable and Sustainable Energy Reviews,2011,15(3):1593-1600.
[11] 杨丽辉,陶乐仁,李芳芹,等. 压缩机少量吸气带液对制冷系统性能的影响[J]. 制冷学报,2014,35(5):83-87. YANG L H,TAO L R,LI F Q,et al. Influence of a little liquid entrainment into compressors on refrigerating system performance[J]. Journal of Refrigeration,2014,35(5):83-87.
[12] 韩磊,陶乐仁,郑志皋,等. 回气带液对滚动转子压缩制冷系统性能影响实验研究[J]. 制冷学报,2010,31(4):22-25. HAN L,TAO L R,ZHENG Z G,et al. Experiment on effect of liquid-refrigerant return on performance of refrigerant system with rolling rotor compressor[J]. Journal of Refrigeration,2010,31(4):22-25.
[13] 卫宇. ARI空调工况与中国空调工况的差异对水冷冷水机组满负荷效率的影响[J]. 暖通空调,2000,30(4):67-69. WEI Y. Impacts of actual air conditioning condition differing from ARI standard on full-load efficiency of a water-cooled liquid chiller[J]. Journal of HV&AC,2000,30(4):67-69.
[14] 朱明善. 能量系统的(火用)分析[M]. 北京:清华大学出版社,1988:180-192. ZHU M S. Exergy analysis of energy system[M]. Beijing:Tsinghua University Press,1988:180-192.

[1]	王胜岩, 邓帅, 赵睿恺. 变电吸附二氧化碳捕集技术研究进展[J]. 化工进展, 2023, 42(S1): 233-245.
[2]	董佳宇, 王斯民. 超声强化对二甲苯结晶特性及调控机理实验[J]. 化工进展, 2023, 42(9): 4504-4513.
[3]	杨许召, 李庆, 袁康康, 张盈盈, 韩敬莉, 吴诗德. 含Gemini离子液体低共熔溶剂热力学性质[J]. 化工进展, 2023, 42(6): 3123-3129.
[4]	马润梅, 杨海超, 李正大, 李双喜, 赵祥, 章国庆. 表面强化镀层对高速轴承腔密封端面变形及摩擦磨损影响分析[J]. 化工进展, 2023, 42(4): 1688-1697.
[5]	贺山明, 潘界昌, 徐国钻, 李文君, 梁勇. 粗钨酸钠溶液亚铁盐沉淀法除铬、钒的热力学分析及实验验证[J]. 化工进展, 2023, 42(4): 2171-2179.
[6]	王晓月, 张伟敏, 姚正阳, 郭晓宏, 李聪明. 逆水煤气变换反应研究进展[J]. 化工进展, 2023, 42(3): 1583-1594.
[7]	孙潇, 朱光涛, 裴爱国. 氢液化装置产业化与研究进展[J]. 化工进展, 2023, 42(3): 1103-1117.
[8]	陈钰, 刘冲, 邱于荟, 贲梓欣, 牟天成. 离子液体和低共熔溶剂绿色回收废旧锂离子电池的研究进展[J]. 化工进展, 2022, 41(S1): 485-496.
[9]	王宇晶, 张楠, 刘涉江, 苗辰, 刘秀丽. 热化学清洗含油污泥的效果评价及机理[J]. 化工进展, 2022, 41(6): 3333-3340.
[10]	张凝凝, 丁华, 高燕, 白向飞, 张昀朋, 孙南翔. 新疆淖毛湖煤中钠在CO₂气化过程的迁移行为[J]. 化工进展, 2022, 41(5): 2348-2355.
[11]	马进伟, 方浩, 陈茜茜, 陈海飞, 童维维. 基于焓-熵-㶲平衡的无盖板PV/T系统热力学分析与优化[J]. 化工进展, 2022, 41(4): 1840-1847.
[12]	任首龙, 陆庭中, 唐波, 高颖, 戴远哲, 吉利, 赵胜悟. 辐射冷却材料研究进展[J]. 化工进展, 2022, 41(4): 1982-1993.
[13]	陈磊, 闫兴清, 胡延伟, 于帅, 杨凯, 陈绍云, 关辉, 喻健良, HMAHGEREFTE Haroun, MARTYNOV Sergey. 二氧化碳管道意外泄漏减压过程的断裂控制研究进展[J]. 化工进展, 2022, 41(3): 1241-1255.
[14]	谷志攀, 阳季春, 张叶, 陶乐仁, 刘泛函. 市政污泥吸附等温线模型和热力学性质[J]. 化工进展, 2022, 41(2): 998-1008.
[15]	隋金昊, 王智, 梁璇玑, 张烜玮, 朱羽墨, 宋尚飞, 史博会, 宫敬, LOU Xia. 动力学抑制剂与乙二醇协同作用下甲烷水合物再生成[J]. 化工进展, 2022, 41(10): 5373-5380.

变频滚动转子式压缩制冷系统的(火用)分析

The exergy analysis of variable frequency rolling rotor compression refrigeration system

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价