Fe2+对厌氧氨氧化EGSB反应器运行性能的影响

doi:10.16085/j.issn.1000-6613.2022-1890

摘要/Abstract

摘要：

厌氧氨氧化（Anammox）在污水处理系统中越来越受到重视，Fe²⁺对Anammox系统具有重要作用。通过不断提升进水总氮（TN）浓度，本文研究Fe²⁺对Anammox膨胀颗粒污泥床反应器（EGSB）脱氮性能以及细菌生理变化的影响。当Fe²⁺浓度从1.00mg/L增加到7.50mg/L时，氮去除效果显著增加，抵抗氮负荷的能力明显增强。同时胞外聚合物（EPS）与血红素c浓度也逐渐增加到最大值分别为242mg/g VSS和3.76μmol/mg pro，细菌活性明显提高。随着Fe²⁺浓度继续增加到10.0mg/L，反应器脱氮性能下降，EPS与血红素c含量也随之减少，细菌活性降低。因此，7.50mg/L的Fe²⁺能最大程度增强反应器脱氮性能，提高细菌活性，使颗粒更加致密，促进Anammox污泥沉降和聚集。研究结果有助于深入探索Fe²⁺对Anammox系统的作用机制，对培育高性能Anammox污泥、保证EGSB反应器的高效稳定运行具有重要意义。

关键词: 厌氧氨氧化, 二价铁, 膨胀颗粒污泥床, 活性, 废水, 生物过程

Abstract:

Anaerobic ammonium oxidation (Anammox) has gained intensive attention in wastewater treatment. Fe²⁺ plays an important role in Anammox system. By continuously increasing the total nitrogen (TN) concentration in the influent, the effects of Fe²⁺ on the nitrogen removal performance and bacterial physiology of Anammox expanded granular sludge blanket reactor (EGSB) were studied. When the concentration of Fe²⁺ increased from 1.00mg/L to 7.50mg/L, the nitrogen removal efficiency and the ability to resist nitrogen load apparently increased. Meanwhile, the concentration of extracellular polymeric substances (EPS) and heme c also increased gradually, reaching the maximum value of 242mg/g VSS and 3.76μmol/mg pro, respectively. The bacterial activity obviously enhanced. When the concentration of Fe²⁺ increased to 10.0mg/L, the nitrogen removal performance of the reactor decreased, the concentration of EPS and heme c also declined, and the bacterial activity reduced. Therefore, addition of 7.50mg/L Fe²⁺ could maximize the nitrogen removal performance of the reactor, improve the bacterial activity, make the granule more compact, as well as promote Anammox sludge sedimentation and aggregation. This work helps the further exploration of the mechanism of Fe²⁺ addition on Anammox system, which is important to cultivate high-performance Anammox sludge and ensures the efficient and stable operation of EGSB reactor.

Key words: Anammox, Fe²⁺, expanded granular sludge blanket reactor（EGSB）, activity, wastewater, bioprocess

中图分类号:

史天茜, 石永辉, 武新颖, 张益豪, 秦哲, 赵春霞, 路达. Fe²⁺对厌氧氨氧化EGSB反应器运行性能的影响[J]. 化工进展, 2023, 42(9): 5003-5010.

SHI Tianxi, SHI Yonghui, WU Xinying, ZHANG Yihao, QIN Zhe, ZHAO Chunxia, LU Da. Effects of Fe²⁺ on the performance of Anammox EGSB reactor[J]. Chemical Industry and Engineering Progress, 2023, 42(9): 5003-5010.

图/表 9

图1 EGSB反应器结构图

图2 反应器脱氮性能

图3 反应器去除率变化

图4 反应器Anammox反应化学计量比变化

图5 反应器MLSS变化

图6 4个反应器NH4+-N和NO2--N浓度随时间变化的分布

图7 4个反应器中EPS含量变化情况

图8 4个反应器中血红素c浓度变化

图9 污泥SEM图

参考文献 32

1	MULDER A, VAN DE GRAAF A A, ROBERTSON L A, et al. Anaerobic ammonium oxidation discovered in a denitrifying fluidized bed reactor[J]. FEMS Microbiology Ecology, 1995, 16(3): 177-183.
2	ZHAO Jian, ZHANG Bowen, ZUO Jiane. Response of anammox granules to ZnO nanoparticles at ambient temperature[J]. Environmental Technology & Innovation, 2019, 13: 146-152.
3	LACKNER Susanne, GILBERT Eva M, VLAEMINCK Siegfried E, et al. Full-scale partial nitritation/anammox experiences—An application survey[J]. Water Research, 2014, 55: 292-303.
4	JETTEN Mike S M, VAN NIFTRIK Laura, STROUS Marc, et al. Biochemistry and molecular biology of anammox bacteria[J]. Critical Reviews in Biochemistry and Molecular Biology, 2009, 44(2/3): 65-84.
5	ZHANG Xiaojing, CHEN Zhao, ZHOU Yue, et al. Impacts of the heavy metals Cu(Ⅱ), Zn(Ⅱ) and Fe(Ⅱ) on an Anammox system treating synthetic wastewater in low ammonia nitrogen and low temperature: Fe(Ⅱ) makes a difference[J]. Science of the Total Environment, 2019, 648: 798-804.
6	WANG Jinxing, LIANG Jidong, SUN Li, et al. Enhancing anammox resistance to low operating temperatures with the use of PVA gel beads[J]. Science of the Total Environment, 2021, 774: 144826.
7	CARVAJAL-ARROYO José M, SUN Wenjie, Reyes SIERRA-ALVAREZ, et al. Inhibition of anaerobic ammonium oxidizing (anammox) enrichment cultures by substrates, metabolites and common wastewater constituents[J]. Chemosphere, 2013, 91(1): 22-27.
8	TANG Simin, XU Zehao, LIU Yalei, et al. Performance, kinetics characteristics and enhancement mechanisms in anammox process under Fe(Ⅱ) enhanced conditions[J]. Biodegradation, 2020, 31(4/5/6): 223-234.
9	DING Jing, SEOW Wanyi, ZHOU Jizhong, et al. Effects of Fe(Ⅱ) on anammox community activity and physiologic response[J]. Frontiers of Environmental Science & Engineering, 2021, 15(1): 7.
10	MAK C Y, LIN J G, CHEN W H, et al. The short- and long-term inhibitory effects of Fe( Ⅱ ) on anaerobic ammonium oxidizing (anammox) process[J]. Water Science and Technology, 2019, 79(10): 1860-1867.
11	ZHOU Biru, CHEN Guangjiao, DONG Chifei, et al. The short-term and long-term effects of Fe(Ⅱ) on the performance of anammox granules[J]. Water Environment Research, 2021, 93(9): 1651-1659.
12	国家环境保护总局《水和废水监测分析方法》编委会. 水和废水监测分析方法[M]. 4版. 北京: 中国环境科学出版社, 2002.
	Editorial Board of Water and Wastewater Monitoring and Analysis Method, State Environmental Protection Administration. Methods for monitoring and analysis of water and wastewater[M]. 4th ed. Beijing: China Environmental Science Press, 2002.
13	WANG Weigang, YAN Yuan, ZHAO Yuhao, et al. Characterization of stratified EPS and their role in the initial adhesion of anammox consortia[J]. Water Research, 2020, 169: 115223.
14	罗曦, 雷中方, 张振亚, 等. 好氧/厌氧污泥胞外聚合物(EPS)的提取方法研究[J]. 环境科学学报, 2005, 25(12): 1624-1629.
	LUO Xi, LEI Zhongfang, ZHANG Zhenya, et al. Study on the extraction of extracellular polymeric substances (EPS) from aerobic/anaerobic sludges[J]. Acta Scientiae Circumstantiae, 2005, 25(12): 1624-1629.
15	FR/OLUND B, GRIEBE T, NIELSEN P H. Enzymatic activity in the activated-sludge floc matrix[J]. Applied Microbiology and Biotechnology, 1995, 43(4): 755-761.
16	BERRY Edward A, TRUMPOWER Bernard L. Simultaneous determination of hemes a, b, and c from pyridine hemochrome spectra[J]. Analytical Biochemistry, 1987, 161(1): 1-15.
17	GUO Beibei, CHEN Yuanhao, Lu LYU, et al. Transformation of the zero valent iron dosage effect on anammox after long-term culture: From inhibition to promotion[J]. Process Biochemistry, 2019, 78: 132-139.
18	HE Shilong, CHEN Yi, QIN Meng, et al. Effects of temperature on anammox performance and community structure[J]. Bioresource Technology, 2018, 260: 186-195.
19	SINDHU Lara, NIU Kangle, LIU Xiaolin, et al. Effect of Fe²⁺ addition on anammox consortia, nitrogen removal performance and functional genes analysis during start-up of anammox process[J]. Journal of Water Process Engineering, 2021, 43: 102251.
20	GAO Fan, ZHANG Hanmin, YANG Fenglin, et al. The effects of zero-valent iron (ZVI) and ferroferric oxide (Fe₃O₄) on anammox activity and granulation in anaerobic continuously stirred tank reactors (CSTR)[J]. Process Biochemistry, 2014, 49(11): 1970-1978.
21	CHEN Yao, JIA Fangxu, LIU Yingjie, et al. The effects of Fe(Ⅲ) and Fe( Ⅱ ) on anammox process and the Fe-N metabolism[J]. Chemosphere, 2021, 285: 131322.
22	ZHANG Jianhua, MIAO Yuanyuan, ZHANG Qiong, et al. Mechanism of stable sewage nitrogen removal in a partial nitrification-anammox biofilm system at low temperatures: Microbial community and EPS analysis[J]. Bioresource Technology, 2020, 297: 122459.
23	LIU Lingjie, JI Min, WANG Fen, et al. Microbial community shift and functional genes in response to nitrogen loading variations in an anammox biofilm reactor[J]. International Biodeterioration & Biodegradation, 2020, 153: 105023.
24	XU Jiajia, CHENG Yafei, XU Lianzengji, et al. The performance and microbial community in response to MnO₂ nanoparticles in anammox granular sludge[J]. Chemosphere, 2019, 233: 625-632.
25	WANG Shuai, LI Hanxiang, ZHANG Aiyu, et al. Importance of exopolysaccharide branched chains in determining the aggregation ability of anammox sludge[J]. Science of the Total Environment, 2020, 734: 139470.
26	WANG Shuai, HUANG Xiaoxiao, LIU Lijuan, et al. Understanding the mechanism in aggregation ability between aerobic and anammox granular sludge from the perspective of exopolysaccharides[J]. Journal of Water Process Engineering, 2020, 38: 101629.
27	PENG Mengwen, QI Jing, YAN Peng, et al. Insight into the structure and metabolic function of iron-rich nanoparticles in anammox bacteria[J]. Science of the Total Environment, 2022, 806: 150879.
28	BI Zhen, QIAO Sen, ZHOU Jiti, et al. Fast start-up of Anammox process with appropriate ferrous iron concentration[J]. Bioresource Technology, 2014, 170: 506-512.
29	MA Haiyuan, ZHANG Yanlong, XUE Yi, et al. Relationship of heme c, nitrogen loading capacity and temperature in anammox reactor[J]. Science of the Total Environment, 2019, 659: 568-577.
30	XU Jiajia, CHENG Yafei, XU Lianzengji, et al. The revolution of performance, sludge characteristics and microbial community of anammox biogranules under long-term NiO NPs exposure[J]. Science of the Total Environment, 2019, 649: 440-447.
31	ZHANG Shaoqing, ZHANG Liqiu, YAO Hainan, et al. Responses of anammox process to elevated Fe(Ⅲ) stress: Reactor performance, microbial community and functional genes[J]. Journal of Hazardous Materials, 2021, 414: 125051.
32	WAN Kai, YU Ye, HU Jinggang, et al. Recovery of anammox process performance after substrate inhibition: Reactor performance, sludge morphology, and microbial community[J]. Bioresource Technology, 2022, 357: 127351.

[1]	时永兴, 林刚, 孙晓航, 蒋韦庚, 乔大伟, 颜彬航. 二氧化碳加氢制甲醇过程中铜基催化剂活性位点研究进展[J]. 化工进展, 2023, 42(S1): 287-298.
[2]	高雨飞, 鲁金凤. 非均相催化臭氧氧化作用机理研究进展[J]. 化工进展, 2023, 42(S1): 430-438.
[3]	许春树, 姚庆达, 梁永贤, 周华龙. 共价有机框架材料功能化策略及其对Hg(Ⅱ)和Cr(Ⅵ)的吸附性能研究进展[J]. 化工进展, 2023, 42(S1): 461-478.
[4]	王乐乐, 杨万荣, 姚燕, 刘涛, 何川, 刘逍, 苏胜, 孔凡海, 朱仓海, 向军. SCR脱硝催化剂掺废特性及性能影响[J]. 化工进展, 2023, 42(S1): 489-497.
[5]	赵景超, 谭明. 表面活性剂对电渗析减量化工业含盐废水的影响[J]. 化工进展, 2023, 42(S1): 529-535.
[6]	王谨航, 何勇, 史伶俐, 龙臻, 梁德青. 气体水合物阻聚剂研究进展[J]. 化工进展, 2023, 42(9): 4587-4602.
[7]	林晓鹏, 肖友华, 管奕琛, 鲁晓东, 宗文杰, 傅深渊. 离子聚合物-金属复合材料（IPMC）柔性电极的研究进展[J]. 化工进展, 2023, 42(9): 4770-4782.
[8]	王晨, 白浩良, 康雪. 大功率UV-LED散热与纳米TiO₂光催化酸性红26耦合系统性能[J]. 化工进展, 2023, 42(9): 4905-4916.
[9]	王琦, 寇丽红, 王冠宇, 王吉坤, 刘敏, 李兰廷, 王昊. 焦化废水生物出水中可溶解性有机物的分子识别[J]. 化工进展, 2023, 42(9): 4984-4993.
[10]	张丽宏, 金要茹, 程芳琴. 煤气化渣资源化利用[J]. 化工进展, 2023, 42(8): 4447-4457.
[11]	毛善俊, 王哲, 王勇. 基团辨识加氢：从概念到应用[J]. 化工进展, 2023, 42(8): 3917-3922.
[12]	向阳, 黄寻, 魏子栋. 电催化有机合成反应的活性和选择性调控研究进展[J]. 化工进展, 2023, 42(8): 4005-4014.
[13]	陈俊俊, 费昌恩, 段金汤, 顾雪萍, 冯连芳, 张才亮. 高生物活性聚醚醚酮化学改性研究进展[J]. 化工进展, 2023, 42(8): 4015-4028.
[14]	张耀杰, 张传祥, 孙悦, 曾会会, 贾建波, 蒋振东. 煤基石墨烯量子点在超级电容器中的应用[J]. 化工进展, 2023, 42(8): 4340-4350.
[15]	郑梦启, 王成业, 汪炎, 王伟, 袁守军, 胡真虎, 何春华, 王杰, 梅红. 菌藻共生技术在工业废水零排放中的应用与展望[J]. 化工进展, 2023, 42(8): 4424-4431.

Fe²⁺对厌氧氨氧化EGSB反应器运行性能的影响

Effects of Fe²⁺ on the performance of Anammox EGSB reactor

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

图/表 9

参考文献 32

相关文章 15

编辑推荐

Metrics

本文评价