带压环境中CO2/H2O/N2气体稀释对合成气层流火焰速度的影响

doi:10.16085/j.issn.1000-6613.2020-0113

摘要/Abstract

摘要：

合成气稀释燃烧是燃气轮机高效低污染燃烧的重要运行方式。本文以CO₂、H₂O和N₂为稀释气体，利用数值模拟方法研究稀释比对不同压力下合成气（CO/H₂/CH₄）层流火焰速度（S_L）的影响规律，并从自由基浓度变化、敏感性数值和生成速率（rate of production，ROP）三个方面解析三种气体的物理和化学作用机理。结果表明，S_L随燃烧压力和稀释比的增大而不断减小，其中CO₂对层流火焰速度的抑制最为显著。稀释气体的物理效应对层流火焰速度的影响远大于化学效应，但CO₂和H₂O的化学效应不能忽略。化学效应则是通过改变H和OH自由基浓度影响S_L，其中CO₂稀释降低H和OH自由基浓度，H₂O稀释则是降低H自由基浓度，从而降低合成气的层流火焰速度。进一步反应动力学分析发现了H/OH浓度变化在低压、加压下的主要化学反应路径，且受H₂O稀释的化学反应速率对压力较CO₂更为敏感。

关键词: 合成气, 稀释燃烧, 层流火焰速度, 加压, 数值模拟, 反应动力学

Abstract:

Syngas dilution combustion is an important mode of operation for gas turbines with high efficiency and low pollution. CO₂, H₂O and N₂ were used as dilution gases to study the effect of dilution ratio on the laminar flame speed of syngas (CO/H₂/CH₄) at elevated pressures with numerical simulation, and the physical and chemical mechanisms of the three gases were also analyzed in radical concentration change, sensitivity value and ROP(rate of production) analysis. The results show that the laminar flame speed decreases with the increase of combustion pressure and dilution ratio, and the suppression of CO₂ on the laminar flame speed is the most significant. The physical effect of the diluent gas on the laminar flame velocity is far greater than the chemical effect, but the chemical effects of CO₂ and H₂O cannot be ignored. The chemical effect is to affect S_L by changing the concentration of H and OH radicals, where CO₂dilution reduces the H and OH radical concentration, and H₂O dilution decreases the H radical concentration, thereby reducing the laminar flame velocity of the syngas. Further reaction kinetics analysis finds the main path of change of H/OH concentration at low and high pressure, and the chemical reaction rate diluted by H₂O is more sensitive to pressure than CO₂.

Key words: syngas, dilution combustion, laminar flame speed, high pressure, numerical simulation, reaction kinetics

中图分类号:

TK16

朱晓宇, 杨卫娟, 张兴, 姚彦伊, 苏佳乐, 周俊虎. 带压环境中CO₂/H₂O/N₂气体稀释对合成气层流火焰速度的影响[J]. 化工进展, 2020, 39(11): 4357-4366.

Xiaoyu ZHU, Weijuan YANG, Xing ZHANG, Yanyi YAO, Jiale SU, Junhu ZHOU. Effect of CO₂/H₂O/N₂ gas dilution on laminar flame speeds of syngas at elevated pressure[J]. Chemical Industry and Engineering Progress, 2020, 39(11): 4357-4366.

参考文献

1	安江涛，蒋勇，邱榕，等. CO₂稀释及合成气构成对预混燃烧特性的影响[J].燃烧科学与技术, 2011, 17(5): 437-442.
1	AN J T, JIANG Y, QIU R, et al. Effects of CO₂ dilution and synthesis gas composition on premixed combustion characteristics[J]. Journal of Combustion Science and Technology, 2011, 17(5): 437-422.
2	NATARAJAN J, LIEUWEN T, SEITZMAN J. Laminar flame speeds of H₂/CO mixtures: effect of CO₂ dilution, preheat temperature, and pressure[J]. Combustion and Flame, 2007, 151(1): 104-119.
3	PRATHAP C, RAY A, RAVI M R. Investigation of nitrogen dilution effects on the laminar burning velocity and flame stability of syngas fuel at atmospheric condition[J]. Combustion and Flame, 2008, 155(1/2): 145-160.
4	SINGH D, NISHIIE T, TANVIR S, et al. An experimental and kinetic study of syngas/air combustion at elevated temperatures and the effect of water addition[J]. Fuel, 2012, 94: 448-456.
5	PRATHAP C, RAY A, RAVI M R. Effects of dilution with carbon dioxide on the laminar burning velocity and flame stability of H₂-CO mixtures at atmospheric condition[J]. Combustion and Flame, 2012, 159(2): 482-492.
6	DAVIS S G, JOSHI A V, WANG H, et al. An optimized kinetic model of H₂/CO combustion[J]. Proceedings of the Combustion Institute, 2005, 30(1): 1283-1292.
7	RANZI E, FRASSOLDATI A, STAGNI A, et al. Reduced kinetic schemes of complex reaction systems: Fossil and biomass-derived transportation fuels[J]. International Journal of Chemical Kinetics,2014, 46 (9): 512-542.
8	KéROMNèS A, METCALFE W K, et al. An experimental and detailed chemical kinetic modelling study of hydrogen and syngas mixtures at elevated pressures[J]. Combustion and Flame, 2013, 160(6): 995-1011.
9	ZHANG Y, SHEN W, ZHANG H, et al. Effects of inert dilution on the propagation and extinction of lean premixed syngas/air flames[J]. Fuel, 2015, 157: 115-121.
10	LI H M, LI G X, SUN Z Y, et al. Investigation on dilution effect on laminar burning velocity of syngas premixed flames[J]. Energy, 2016, 112: 146-152.
11	DAS A K, KUMAR K, SUNG C J. Laminar flame speeds of moist syngas mixtures[J]. Combustion and Flame, 2011, 158(2): 345-353.
12	谢永亮，王金华，张猛，等. CO₂和H₂O对合成气层流燃烧速度的影响[J]. 工程热物理学报, 2014, 35(6): 1248-1251.
12	XIE Y L, WANG J H, ZHANG M, et al. Effect of CO₂ and H₂O on laminar combustion velocity of syngas[J]. Journal of Engineering Thermophysics, 2014, 35(6): 1248-1251.
13	SHANG R X, ZHANG Y, ZHU M M, et al. Laminar flame speed of CO₂ and N₂ diluted H₂/CO/air flames[J]. International Journal of Hydrogen Energy, 2016, 41(33): 15056-15067.
14	SUN H Y, YANG S I, JOMAAS G, et al. High-pressure laminar flame speeds and kinetic modeling of carbon monoxide/hydrogen combustion[J]. Proceedings of the Combustion Institute, 2007, 31(1): 439-446.
15	周镇, 艾育华, 孔文俊. 加压下合成气层流火焰传播特性的实验研究[J]. 工程热物理学报, 2013(8):164-168.
15	ZHOU Z, AI Y H, KONG W J. Experimental study of laminar flame propagation characteristics of syngas under high pressure[J]. Journal of Engineering Thermophysics, 2013(8): 164-168.
16	AI Y H, ZHOU Z, CHEN Z, et al. Laminar flame speed and Markstein length of syngas at normal and elevated pressures and temperatures[J]. Fuel, 2014, 137: 339-345.
17	BURKE M P, CHAOS M, DRYER F L, et al. Negative pressure dependence of mass burning rates of H₂/CO/O₂/diluent flames at low flame temperatures[J]. Combustion and Flame, 2010, 157(4): 618-631.
18	NATARAJAN J, KOCHAR Y, LIEUWEN T, et al. Pressure and preheat dependence of laminar flame speeds of H₂/CO/CO₂/O₂/He mixtures[J]. Proceedings of the Combustion Institute, 2009, 32(1):1261-1268.
19	HAN Minchao, AI Yuhua, CHEN Zheng, et al. Laminar flame speeds of H₂/CO with CO₂ dilution at normal and elevated pressures and temperatures[J]. Fuel, 2015, 148: 32-38.
20	韩敏超. 稀释剂对高温加压下合成气层流预混火焰燃烧特性影响研究[D]. 北京：中国科学院研究生院（工程热物理研究所）, 2015.
20	HAN M C. Effect of diluents on combustion characteristics of syngas laminar premixed flame at high temperature and pressure[D].Beijing: Institute of Engineering Thermophysics, Chinese Academy of Sciences, 2015.
21	GREGORY P S, DAVID M G, MICHAEL F, et al. GRI Meth3.0[EB/OL]. .
22	WANG H, YOU X Q, JOSHI A V, et al. USC Mech Version II. High-temperature combustion reaction model of H₂/CO/C₁-C₄ Compounds[R]. http://ignis.usc.edu/USC_Mech_II.htm, 2007.
23	LI J, ZHAO Z W, KAZAKOV A, et al. An updated comprehensive kinetic model of hydrogen combustion[J]. International Journal of Chemical Kinetics, 2010, 36(10): 566-575.
24	LAPALME D, SEERS P. Influence of CO₂, CH₄and initial temperature on H₂/CO laminar flame speed[J]. International Journal of Hydrogen Energy, 2014, 39(7): 3477-3486.
25	ANDREWS G E, BRADLEY D. The burning velocity of methane-air mixtures[J]. Combustion and Flame, 1972, 19(2): 275-288.
26	GARFORTH A M, RALLIS C J. Laminar burning velocity of stoichiometric methane-air: pressure and temperature dependence[J]. Combustion and Flame, 1978, 31: 53-68.
27	IIJIMA T, TAKENO T. Effects of temperature and pressure on burning velocity[J]. Combustion and Flame, 1986, 65(1): 35-43.
28	EGOLFOPOULOS F N, CHO P, LAW C K. Laminar flame speeds of methane-air mixtures under reduced and elevated pressures[J]. Combustion and Flame, 1989, 76(3/4): 375-391.
29	许东灏, 穆延非, 陈新明, 等. 不同惰性组分稀释合成气对燃气-蒸汽联合循环的效益分析[J]. 中国电机工程学报, 2017(14):195-203, 350.
29	XU D Y, MU Y F, CHEN X M, et al. Benefit analysis of gas-steam combined cycle with dilute synthesis gas of different inert components[J]. Proceedings of the CSEE, 2017(14): 195-203, 350.
30	LI H M, LI G X, SUN Z Y, et al. Investigation on dilution effect on laminar burning velocity of syngas premixed flames[J]. Energy, 2016, 112: 146-152.
31	ZHOU Q, CHEUNG C S, LEUNG C W, et al. Effects of diluents on laminar burning characteristics of bio-syngas at elevated pressure[J]. Fuel, 2019, 248: 8-15.
32	张尊华，曾璇，梁俊杰，等. N₂、CO₂和H₂O稀释对天然气层流燃烧速度的影响[J]. 大连海事大学学报, 2019, 45(1): 120-131.
32	ZHANG Z H, ZENG X, LIANG J J, et al. Effect of N₂, CO₂ and H₂O dilution on laminar burning velocity of natural gas[J]. Journal of Dalian Maritime University, 2019, 45(1): 120-131.
33	WU B, PU G, ZHANG X, et al. Study on the laminar burning velocity of Medium-Btu syngas flame with N₂ dilution based on OH-PLIF technology[J]. Cogent Engineering, 2018, 5(1): 1536306.
34	WANG Z H, WENG W B, HE Y, et al. Effect of H₂/CO ratio and N₂/CO₂ dilution rate on laminar burning velocity of syngas investigated by direct measurement and simulation[J]. Fuel, 2015, 141: 285-292.

[1]	王太, 苏硕, 李晟瑞, 马小龙, 刘春涛. 交流电场中贴壁气泡的动力学行为[J]. 化工进展, 2023, 42(S1): 133-141.
[2]	陈匡胤, 李蕊兰, 童杨, 沈建华. 质子交换膜燃料电池气体扩散层结构与设计研究进展[J]. 化工进展, 2023, 42(S1): 246-259.
[3]	杨霞珍, 彭伊凡, 刘化章, 霍超. 熔铁催化剂活性相的调控及其费托反应性能[J]. 化工进展, 2023, 42(S1): 310-318.
[4]	郭强, 赵文凯, 肖永厚. 增强流体扰动强化变压吸附甲硫醚/氮气分离的数值模拟[J]. 化工进展, 2023, 42(S1): 64-72.
[5]	邵博识, 谭宏博. 锯齿波纹板对挥发性有机物低温脱除过程强化模拟分析[J]. 化工进展, 2023, 42(S1): 84-93.
[6]	刘炫麟, 王驿凯, 戴苏洲, 殷勇高. 热泵中氨基甲酸铵分解反应特性及反应器结构优化[J]. 化工进展, 2023, 42(9): 4522-4530.
[7]	赵曦, 马浩然, 李平, 黄爱玲. 错位碰撞型微混合器混合性能的模拟分析与优化设计[J]. 化工进展, 2023, 42(9): 4559-4572.
[8]	叶振东, 刘涵, 吕静, 张亚宁, 刘洪芝. 基于钙镁二元盐的热化学储能反应器的性能优化[J]. 化工进展, 2023, 42(8): 4307-4314.
[9]	陆洋, 周劲松, 周启昕, 王瑭, 刘壮, 李博昊, 周灵涛. CeO₂/TiO₂吸附剂煤气脱汞产物的浸出规律[J]. 化工进展, 2023, 42(7): 3875-3883.
[10]	俞俊楠, 俞建峰, 程洋, 齐一搏, 化春键, 蒋毅. 基于深度学习的变宽度浓度梯度芯片性能预测[J]. 化工进展, 2023, 42(7): 3383-3393.
[11]	王俊杰, 潘艳秋, 牛亚宾, 俞路. 分子水平催化重整装置模型构建及应用[J]. 化工进展, 2023, 42(7): 3404-3412.
[12]	单雪影, 张濛, 张家傅, 李玲玉, 宋艳, 李锦春. 阻燃型环氧树脂的燃烧数值模拟[J]. 化工进展, 2023, 42(7): 3413-3419.
[13]	王硕, 张亚新, 朱博韬. 基于灰色预测模型的水煤浆输送管道冲蚀磨损寿命预测[J]. 化工进展, 2023, 42(7): 3431-3442.
[14]	周龙大, 赵立新, 徐保蕊, 张爽, 刘琳. 电场-旋流耦合强化多相介质分离研究进展[J]. 化工进展, 2023, 42(7): 3443-3456.
[15]	李瑞东, 黄辉, 同国虎, 王跃社. 原油精馏塔中铵盐吸湿特性及其腐蚀行为[J]. 化工进展, 2023, 42(6): 2809-2818.

带压环境中CO₂/H₂O/N₂气体稀释对合成气层流火焰速度的影响

Effect of CO₂/H₂O/N₂ gas dilution on laminar flame speeds of syngas at elevated pressure

RichHTML

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价