Fenton处理对污泥脱水性、重金属形态及生物淋滤效率影响

doi:10.16085/j.issn.1000-6613.2019-0844

摘要/Abstract

摘要：

为考察污泥预处理过程中重金属迁移转化规律，通过投加不同量的Fenton试剂对污泥进行处理，分析了Zn、Cd、Mn、Ni四种重金属的化学形态变化与后继生物淋滤过程的溶出行为。研究结果表明，污泥经Fenton处理后，毛细吸水时间在短时间内降低，但对生物淋滤后最终的污泥脱水性没有显著提升作用；重金属Zn、Cd、Mn的不稳定态（弱酸提取态、可还原态）比例不同程度提高，当投加Fe²⁺=1.00g/L、H₂O₂=9.00g/L时，其比例分别由37%、84%、79%上升至90%、93%、84%，但Ni无明显变化。此外，Fenton处理污泥中Zn、Cd、Mn、Ni四种重金属生物淋滤后含量分别由3451.52mg/kg、6.45mg/kg、443.40mg/kg、94.96mg/kg降至376.74mg/kg、1.10mg/kg、141.66mg/kg、21.77mg/kg，比单独生物淋滤处理污泥重金属残余量分别降低了36.20%、26.17%、30.92%和27.89%。利用动力学方程较好地描述了生物淋滤过程中Zn、Cd、Mn、Ni四种重金属的溶出速率的相对大小，排序为Mn＜Cd＜Zn＜Ni。

关键词: 污泥, Fenton, 脱水性, 重金属形态, 生物淋滤

Abstract:

To investigate the law of heavy metal migration and transformation during sludge pretreatment process, the sludge was treated with different amounts of Fenton reagents, and the chemical morphological changes of the heavy metals, including Zn, Cd, Mn and Ni, and the dissolution behavior in the subsequent bioleaching process were analyzed. The results showed that after Fenton treatment (Fe²⁺=1.00g/L, H₂O₂=9.00g/L), the capillary suction time decreased in a short time, but it had no significant effect on the final sludge dewatering after bioleaching. The proportion of the unstable states of heavy metals Zn, Cd and Mn increased from 37%, 84% and 79% to 90%, 93% and 84%, respectively. But there was no significant change in Ni. Furthermore, the contents of the four heavy metals Zn, Cd, Mn and Ni after bioleaching decreased from 3451.52mg/kg, 6.45mg/kg, 443.40mg/kg and 94.96mg/kg to 376.74mg/kg, 1.10mg/kg, 141.66mg/kg and 21.77mg/kg, respectively. Compared with the individual bioleaching treatment process, the residual content of these four heavy metals was decreased by 36.2%, 26.17%, 30.92% and 27.89%, respectively. The relative dissolution rates of the heavy metals in the bioleaching process were described by the kinetic equation, and the order was Mn＜Cd＜Zn＜Ni.

Key words: sewage sludge, Fenton, dewaterability, heavy metal speciation, bioleaching

中图分类号:

X705

郑金鑫,邱春生,王晨晨,刘楠楠,王栋,王少坡,孙力平,张轶凡. Fenton处理对污泥脱水性、重金属形态及生物淋滤效率影响[J]. 化工进展, 2020, 39(2): 805-811.

Jinxin ZHENG,Chunsheng QIU,Chenchen WANG,Nannan LIU,Dong WANG,Shaopo WANG,Liping SUN,Yifan ZHANG. Effects of Fenton treatment on sewage sludge dewaterability, heavy metal speciation and leaching efficiency[J]. Chemical Industry and Engineering Progress, 2020, 39(2): 805-811.

图/表 6

参考文献 32

33	闫瑾. 生物淋滤法去除污泥中重金属的工艺参数优选研究[D]. 太原: 太原理工大学, 2010.
	YAN J. Optimization of process parameters for removal of heavy metals from sludge by biological leaching [D]. Taiyuan: Taiyuan University of Technology, 2010.
34	肖凌鹏, 张盼月, 张玉璇, 等. 生物淋滤改善城市污泥的脱水性能[J]. 环境工程学报, 2012, 6(8): 2793-2797.
	XIAO L P, ZHANG P Y, ZHANG Y X, et al. Improvement of sewage sludge dewatering by bioleaching[J]. Chinese Journal of Environmental Engineering, 2012, 6(8): 2793-2797.
35	LI X Y, YANG S F. Influence of loosely bound extracellular polymeric substances (EPS) on the flocculation, sedimentation and dewaterability of activated sludge[J]. Water Research, 2007, 41(5): 1022-1030.
36	ZHANG W, YANG P, YANG X, et al. Insights into the respective role of acidification and oxidation for enhancing anaerobic digested sludge dewatering performance with Fenton process[J]. Bioresource Technology, 2015, 181: 247-253.
37	宋相国. 生物酸化联合类Fenton氧化去除城市污泥中重金属[D]. 长沙: 湖南大学, 2008.
	SONG X G. Heavy metal removal from sewage sludge by bioacidification and Fenton-like oxidation[D]. Changsha: Hunan University, 2008.
38	WEI X, HUANG W, LIU D, et al. Bioleaching of heavy metals from pig manure employing indigenous sulfur-oxidizing bacteria: effects of solid content[J]. Water, Air, & Soil Pollution, 2019, 230(2): 39.
1	解道雷, 孔慈明, 徐龙乾, 等. 城市污泥中重金属存在形态、去除及稳定化研究进展[J]. 化工进展, 2018, 37(1): 330-342.
	XIE D L, KONG C M, XU L Q, et al. Developments of the speciation, removal and stabilization of heavy metals in municipal sludge[J]. Chemical Industry and Engineering Progress, 2018, 37(1): 330-342.
2	DAVIS R D. Use of sewage sludge on land in the United Kingdom[J]. Water Sci. Technol., 1987, 19: 1-8.
3	CHAND S, YASEEN M, RAJKUMARI, et al. Application of heavy metal rich tannery sludge on sustainable growth, yield and metal accumulation by Clarysage (Salvia sclarea, L.)[J]. International Journal of Phytoremediation, 2015, 17(12): 1171-1176.
4	周邦智, 吕昕, 赵小辉. 剩余污泥中重金属的电动力学修复研究[J]. 环境工程学报, 2011, 5(6): 1401-1404.
	ZHOU B Z, LÜ X, ZHAO X H. Research on electrokinetic remediation of heavy metals in surplus sludge[J]. Chinese Journal of Environmental Engineering, 2011, 5(6): 1401-1404.
5	WANG J Y, ZHANG D S, STABNIKOVA O, et al. Evaluation of electrokinetic removal of heavy metals from sewage sludge[J]. Journal of Hazardous Materials, 2005, 124(1/2/3): 139-146.
6	YIP T C, YAN D Y, YUI M M, et al. Heavy metal extraction from an artificially contaminated sandy soil under EDDS deficiency: significance of humic acid and chelant mixture[J]. Chemosphere, 2010, 80(4): 416-421.
7	HUO J Z, WANG Z Z, ZHANG C. The speciation transformation of Cd, Pb in sludge biology leaching[J]. Advanced Materials Research, 2011, 356/357/358/359/360: 157-160.
8	CHAN L C. Comparison of bioleaching of heavy metals from sewage sludge using iron- and sulfur-oxidizing bacteria[J]. Advances in Environmental Research, 2002, 7(3): 603-607.
9	周普雄, 严勰, 余震, 等. 生物淋滤联合类Fenton反应去除污染土壤中重金属的效果[J]. 环境科学, 2016, 37(9): 3576-3581.
	ZHOU P X, YAN X, YU Z, et al. Performance of bioleaching combined with Fenton-like reaction in heavy metals removal from contaminated soil[J]. Environmental Science, 2016, 37(9): 3576-3581.
10	周顺桂, 周立祥, 黄焕忠. 生物淋滤技术在去除污泥中重金属的应用[J]. 生态学报, 2002, 22(1): 125-133.
	ZHOU S G, ZHOU L X, HUANG H Z. Removal of heavy metals from sewage sludge by bioleaching[J]. Acta Ecologica Sinica, 2002, 22 (1): 125-133.
11	ZHENG G D, GAO D, CHENG T B, et al. Stabilization of nickel and chromium in sewage sludge during aerobic composting[J]. Journal of Hazardous Materials, 2007, 142(1/2): 216-221.
12	QUEVAUVILLER P, RAURET G, GRIEPINK B. Single and sequential extraction in sediments and soils[J]. International Journal of Environmental Analytical Chemistry, 1993, 51(1/2/3/4): 231-235.
13	LIU Y G, ZHOU M, ZENG G M, et al. Bioleaching of heavy metals from mine tailings by indigenous sulfur-oxidizing bacteria: effects of substrate concentration[J]. Bioresource Technology, 2008, 99: 4124-4129.
14	廖天鹏, 祝星, 祁先进, 等. 铜污泥中重金属形态分布及浸出毒性分析[J]. 化工进展, 2014, 33(3): 762-768.
	LIAO T P, ZHU X, QI X J, et al. Chemical speciation of heavy metals and leaching toxicity analysis of sludge in copper metallurgy plan[J]. Chemical Industry and Engineering Progress, 2014, 33(3): 762-768.
15	PUEYO M, RAURET G, LVCK D, et al. Certification of the extractable contents of Cd, Cr, Cu, Ni, Pb and Zn in a freshwater sediment following a collaboratively tested and optimised three-step sequential extraction procedure[J]. Journal of Environmental Monitoring, 2001, 3(2): 243-250.
16	关若楠, 时亚飞, 梁莎, 等. 复合调理脱水污泥热解残渣中重金属形态分布[J]. 环境科学与技术, 2017(3): 74-78.
	GUAN R N, SHI Y F, LIANG S, et al. Speciation distribution of heavy metals in pyrolysis residue of dewatered sewage sludge after conditioned with the composite conditioners[J]. Environmental Science & Technology, 2017(3): 74-78.
17	王硕, 杨倩倩, 赵庆良, 等. 污泥重金属提取剂浸提效率及经济性比较[J]. 化工进展, 2015, 34(11): 4079-4083, 4088.
	WANG S, YANG Q Q, ZHAO Q L, et al. Comparative study on the extraction efficiency and economic performance by different agents in the extraction process of heavy metals in sewage sludge[J]. Chemical Industry and Engineering Progress, 2015, 34(11): 4079-4083, 4088.
18	LIU H, YANG J, SHI Y, et al. Conditioning of sewage sludge by Fenton’s reagent combined with skeleton builders[J]. Chemosphere, 2012, 88(2): 235-239.
19	NEYENS E, BAEYENS J. A review of classic Fenton’s peroxidation as an advanced oxidation technique[J]. Journal of Hazardous Materials, 2003, 98(1): 33-50.
20	徐大勇, 操沛沛, 乐王旭, 等. Fenton氧化剩余污泥过程重金属迁移及其形态变化[J]. 环境工程学报, 2016, 10(10): 5893-5900.
	XU D Y, CAO P P, LE W X, et al. Heavy metal migration and speciation changes of residual sludge during the Fenton oxidation processing[J]. Chinese Journal of Environmental Engineering, 2016, 10(10): 5893-5900.
21	洪晨, 邢奕, 司艳晓, 等. 芬顿试剂氧化对污泥脱水性能的影响[J]. 环境科学研究, 2014(6): 615-622.
	HONG C, XING Y, SI Y X, et al. Influence of Fenton’s reagent oxidation on sludge dewaterability[J]. Research of Environmental Sciences, 2014(6): 615-622.
22	于贺, 邱春生, 王晨晨, 等. Fenton预处理对城市污泥重金属形态及生物淋滤溶出影响[J]. 环境工程学报, 2019, 13(3): 725-731.
	YU H, QIU C S, WANG C C, et al. Influence of Fenton pretreatment on heavy metal speciation and bioleaching efficiency in municipal sludge[J]. Chinese Journal of Environmental Engineering, 2019, 13(3): 725-731.
23	国家环境保护总局《水和废水监测分析方法》编委会. 水和废水监测分析方法[M]. 4版. 北京: 中国环境科学出版社, 2002.
	SEPA, Water and wastewater monitoring analysis method[M]. 4th ed. Beijing: China Environmental Science Press, 2002.
24	刘甜田, 何滨, 王亚韩, 等. 改进BCR法在活性污泥样品重金属形态分析中的应用[J]. 分析试验室, 2007, 26(s1): 17-20.
	LIU T T, HE B, WANG Y H, et al. Application of improved BCR method in the morphological analysis of heavy metals in activated sludge samples[J]. Chinese Journal of Analysis Laboratory, 2007, 26(s1): 17-20.
25	BAYAT B, SARI B. Comparative evaluation of microbial and chemical leaching processes for heavy metal removal from dewatered metal plating sludge[J]. Journal of Hazardous Materials, 2010, 174(1/2/3): 763-769.
26	ZHU Y, ZENG G M, ZHANG P Y, et al. Feasibility of bioleaching combined with Fenton-like reaction to remove heavy metals from sewage sludge[J]. Bioresource Technology, 2013, 142(Complete): 530-534.
27	肖鑫. 土著氧化亚铁硫杆菌与土著氧化硫硫杆菌对尾矿重金属生物淋滤作用的研究[D]. 长沙: 湖南大学, 2011.
	XIAO X. Experimental research of bioleaching of heavy metals from minc tailing by indigenous thiobacillus ferrooxidans and indigenous thiobacillus[D]. Changsha: Hunan University, 2011.
28	BOSECKER K. Bioleaching: metal solubilization by microorganisms[J]. FEMS Microbiol. Rev., 1997, 20(3/4): 591-604.
29	李娟. Fenton氧化破解城市污泥及生物淋滤处理河道底泥[D]. 长沙: 湖南大学, 2008.
	LI J. Sewage sludge disintegration by fenton oxidation and river sediment disposal by bioleaching[D]. Changsha: Hunan University, 2008.
30	WONG J W C, XIANG L, GU X Y, et al. Bioleaching of heavy metals from anaerobically digested sewage sludge using FeS₂ as an energy source[J]. Chemosphere, 2004, 55(1): 101-107
31	ZHANG P, ZHU Y, ZHANG G, et al. Sewage sludge bioleaching by indigenous sulfur-oxidizing bacteria: effects of ratio of substrate dosage to solid content[J]. Bioresource Technology, 2009, 100(3): 1394-1398.
32	刘昌庚, 张盼月, 蒋娇娇, 等. 生物沥浸耦合类Fenton氧化调理城市污泥[J]. 环境科学, 2015(1): 333-337.
	LIU C G, ZHANG P Y, JIANG J J, et al. Sewage sludge conditioning by bioleaching combined with Fenton-like oxidation[J]. Environmental Science, 2015(1): 333-337.

参数	数值
TS/g·L^-1	85.80
VS/g·L^-1	43.33
pH	6.80
Zn含量/mg·kg^-1	3451.52
Cd含量/mg·kg^-1	6.45
Mn含量/mg·kg^-1	443.40
Ni含量/mg·kg^-1	94.96

参数	数值
TS/g·L^-1	85.80
VS/g·L^-1	43.33
pH	6.80
Zn含量/mg·kg^-1	3451.52
Cd含量/mg·kg^-1	6.45
Mn含量/mg·kg^-1	443.40
Ni含量/mg·kg^-1	94.96

名称	Zn		Cd		Mn		Ni
名称	k/d^-1	R²	k/d^-1	R²	k/d^-1	R²	k/d^-1	R²
F0	0.0705	0.8116	0.0491	0.9119	0.0267	0.8389	0.0808	0.9233
F6	0.0921	0.8953	0.0603	0.8540	0.0485	0.9661	0.1045	0.9781
F9	0.1105	0.9641	0.0882	0.9209	0.0673	0.9203	0.1245	0.9575
F12	0.0218	0.8777	0.0393	0.9704	0.0200	0.8387	0.0392	0.9949

名称	Zn		Cd		Mn		Ni
名称	k/d^-1	R²	k/d^-1	R²	k/d^-1	R²	k/d^-1	R²
F0	0.0705	0.8116	0.0491	0.9119	0.0267	0.8389	0.0808	0.9233
F6	0.0921	0.8953	0.0603	0.8540	0.0485	0.9661	0.1045	0.9781
F9	0.1105	0.9641	0.0882	0.9209	0.0673	0.9203	0.1245	0.9575
F12	0.0218	0.8777	0.0393	0.9704	0.0200	0.8387	0.0392	0.9949

[1]	李志远, 黄亚继, 赵佳琪, 于梦竹, 朱志成, 程好强, 时浩, 王圣. 污泥与聚氯乙烯共热解重金属特性[J]. 化工进展, 2023, 42(9): 4947-4956.
[2]	史天茜, 石永辉, 武新颖, 张益豪, 秦哲, 赵春霞, 路达. Fe²⁺对厌氧氨氧化EGSB反应器运行性能的影响[J]. 化工进展, 2023, 42(9): 5003-5010.
[3]	杨子育, 朱玲, 王文龙, 于超凡, 桑义敏. 阴燃法处理含油污泥的研究及应用进展[J]. 化工进展, 2023, 42(7): 3760-3769.
[4]	郑昕, 贾里, 王彦霖, 张靖超, 陈世虎, 乔晓磊, 樊保国. 污泥与煤泥混烧对重金属固留特性的影响[J]. 化工进展, 2023, 42(6): 3233-3241.
[5]	修浩然, 王云刚, 白彦渊, 邹立, 刘阳. 准东煤/市政污泥混燃燃烧特性及灰熔融行为分析[J]. 化工进展, 2023, 42(6): 3242-3252.
[6]	詹咏, 王慧, 韦婷婷, 朱星宇, 王先恺, 陈思思, 董滨. Mn²⁺强化臭氧调理对生物处理工艺的污泥原位减量效果[J]. 化工进展, 2023, 42(6): 3253-3260.
[7]	庄捷, 薛锦辉, 赵斌成, 张文艺. 猪粪厌氧消化进程中重金属与腐殖质的有机结合机制[J]. 化工进展, 2023, 42(6): 3281-3291.
[8]	常占坤, 张弛, 苏冰琴, 张聪政, 王健, 权晓慧. H₂S气态基质对污泥生物沥滤处理效能的影响[J]. 化工进展, 2023, 42(5): 2733-2743.
[9]	杨自强, 李风海, 郭卫杰, 马名杰, 赵薇. 市政污泥热处理过程中磷迁移转化的研究进展[J]. 化工进展, 2023, 42(4): 2081-2090.
[10]	赵佳琪, 黄亚继, 李志远, 丁雪宇, 祁帅杰, 张煜尧, 刘俊, 高嘉炜. 污泥和聚氯乙烯共热解三相产物特性[J]. 化工进展, 2023, 42(4): 2122-2129.
[11]	王毅斌, 冯敬武, 谭厚章, 李良钰. 市政污泥热化学处置中磷元素形态转变与回收利用研究进展[J]. 化工进展, 2023, 42(2): 985-999.
[12]	王玉, 余广炜, 林佳佳, 黎长江, 江汝清, 邢贞娇, 余铖. 沼渣、飞灰和污泥生物炭制备建筑陶粒[J]. 化工进展, 2023, 42(2): 1039-1050.
[13]	张涵, 张肖静, 马冰冰, 佴灿, 刘烁烁, 马永鹏, 宋亚丽. 以城市废弃污泥为种泥启动厌氧氨氧化工艺的可行性[J]. 化工进展, 2023, 42(2): 1080-1088.
[14]	郭宇晨, 刘庆林, 蒋金洋, 宗永忠, 王金伟, 李臻, 吕树祥. 含铬污泥资源化方法研究进展[J]. 化工进展, 2023, 42(2): 575-584.
[15]	孙千千, 刘阵, 李瑞, 张溪, 杨明德, 吴玉龙. 低温水热耦合亚铁离子活化过硫酸盐提高剩余污泥的脱水性能[J]. 化工进展, 2023, 42(2): 595-602.