SnO2中空微球的制备与气敏性能

doi:10.16085/j.issn.1000-6613.2017-2702

化工进展 ›› 2018, Vol. 37 ›› Issue (11): 4364-4369.DOI: 10.16085/j.issn.1000-6613.2017-2702

SnO₂中空微球的制备与气敏性能

王晓冬^1,3, 周利星^1,3, 魏莹^1,3, 仪桂云^2,3, 曹建亮^2,3, 孙广^1,3, 孟哈日巴拉^1,3, 张战营^1,3

1 河南理工大学材料科学与工程学院, 河南焦作 454000;
2 河南理工大学化学化工学院, 河南焦作 454000;
3 河南理工大学环境友好型无机材料河南省高校重点实验室培育基地, 河南焦作 454000

收稿日期:2017-12-29 修回日期:2018-06-20 出版日期:2018-11-05 发布日期:2018-11-05
通讯作者: 王晓冬(1972-),男,副教授,研究方向为大孔气敏材料的制备与性能研究。E-mail:wangxd0863@aliyun.com。
作者简介:王晓冬(1972-),男,副教授,研究方向为大孔气敏材料的制备与性能研究。E-mail:wangxd0863@aliyun.com。
基金资助:
国家自然科学基金（U1704255，61474038，51404097）及河南省高等学校重点科研项目计划（19A530002）项目。

Synthesis of hollow SnO₂ microspheres and their enhanced sensing properties to ethanol

WANG Xiaodong^1,3, ZHOU Lixing^1,3, WEI Ying^1,3, YI Guiyun^2,3, CAO Jianliang^2,3, SUN Guang^1,3, MENG Haribala^1,3, ZHANG Zhanying^1,3

1 Institute of Materials Science and Engineering, Henan Polytechnic University, Jiaozuo 454000, Henan, China;
2 College of Chemistry and Chemical Engineering, Henan Polytechnic University, Jiaozuo 454000, Henan, China;
3 Key Laboratory Cultivation Base of Environment-Friendly Inorganic Materials in Henan Province, Henan Polytechnic University, Jiaozuo 454000, Henan, China

Received:2017-12-29 Revised:2018-06-20 Online:2018-11-05 Published:2018-11-05

摘要/Abstract

摘要： 在不加任何表面活性剂情况下，采用磺化的聚苯乙烯（PS）微球为模板，二水结晶二氯化锡（SnCl₂·2H₂O）为锡源，成功制得SnO₂中空微球。利用X射线衍射仪（XRD）、扫描电镜（SEM）、高分辨透射电镜（HRTEM）和氮气吸附脱附仪（BET）对材料的结构和形貌进行了表征，研究并讨论了温度、乙醇浓度等因素对SnO₂纳米颗粒及SnO₂中空微球气敏性能的影响。结果显示，SnO₂中空微球的比表面积为48.49m²/g，比SnO₂纳米颗粒的比表面积（21.94m²/g）提升了1.21倍。比表面积增加有助于SnO₂材料表面吸附更多被测气体以提升表面化学反应，进而提升气敏性能。在260℃下，SnO₂中空微球对200μL/L乙醇的灵敏度为66.26，与SnO₂纳米颗粒相比（51.34），气敏性能提高了0.29倍。

关键词: 中空微球, PS微球, 二氧化锡, 气敏性能

Abstract: SnO₂ hollow microspheres were successfully synthesized using sulfonated PS microspheres as a template and stannous chloride dihydrate (SnCl₂·2H₂O) as tin source, without using any surfactants. The structure and morphology of the obtained samples were characterized by XRD, SEM, HRTEM and BET. The effects of working temperature, ethanol concentration and other factors on the sensitivity were discussed. The results indicated that the SnO₂ hollow microspheres had high specific surface area of 48.49m²/g, which was 1.21 times higher than the specific surface area (21.94m²/g) of SnO₂ nanoparticles. The increase of specific surface area contributed to the adsorbtion of more target gases on the SnO₂ surface to enhance surface chemical reaction, and further improved the gas sensing properties. The sensor based on the SnO₂ hollow microspheres exhibited good gas-sensing properties, and the sensitivity to 200μL/L ethanol is 66.26 at the optimum operating temperature (260℃), which was 0.29 times higher than that of the SnO₂ nanoparticles (51.34).

Key words: hollow microspheres, PS microspheres, stannic oxide, gas-sensing properties

中图分类号:

TQ17

王晓冬, 周利星, 魏莹, 仪桂云, 曹建亮, 孙广, 孟哈日巴拉, 张战营. SnO₂中空微球的制备与气敏性能[J]. 化工进展, 2018, 37(11): 4364-4369.

WANG Xiaodong, ZHOU Lixing, WEI Ying, YI Guiyun, CAO Jianliang, SUN Guang, MENG Haribala, ZHANG Zhanying. Synthesis of hollow SnO₂ microspheres and their enhanced sensing properties to ethanol[J]. Chemical Industry and Engineering Progress, 2018, 37(11): 4364-4369.

参考文献

[1] NIKAN E, KHODADADI A A, MORTAZAVI Y. Highly enhanced response and selectivity of electrospun ZnO-doped SnO? sensors to ethanol and CO in presence of CH?[J].Sensors & Actuators B:Chemical, 2013, 184(8):196-204.
[2] YANG Y, CHU Y, ZHANG Y P, et al. Polystyrene-ZnO core-shell microspheres and hollow ZnO structures synthesized with the sulfonated polystyrene templates[J]. Journal of Solid State Chemistry, 2006, 179(2):470-475.
[3] HWANG I S, CHOI J K, WOO H S, et al. Facile control of C₂H₅OH sensing characteristics by decorating discrete Ag nanoclusters on SnO₂ nanowire networks[J]. Acs Applied Materials & Interfaces, 2011, 3(8):3140-3145.
[4] YI Z, WANG Y Z, QIAO L, et al. Synthesis and the improved sensing properties of hierarchical SnO₂ hollow nanosheets with mesoporous and multilayered interiors[J]. Sensors & Actuators B:Chemical, 2016, 222:354-361.
[5] CHENG B, RUSSELL J M, SHI W, et al. Large-scale, solution-phase growth of single-crystalline SnO₂ nanorods[J]. Journal of the American Chemical Society, 2004, 126(19):5972-5973.
[6] SHAN H, LIU C B, LIU L, et al. Highly sensitive acetone sensors based on La-doped α-Fe₂O₃, nanotubes[J]. Sensors & Actuators B:Chemical, 2013, 184:243-247.
[7] CAO S K, ZENG W, ZHANG H, et al. Hydrothermal synthesis of SnO₂, nanocubes and nanospheres and their gas sensing properties[J]. Journal of Materials Science:Materials in Electronics, 2015, 26(5):2871-2878.
[8] ZHANG B W, FU W Y, LI H Y, et al. Synthesis and characterization of hierarchical porous SnO₂ for enhancing ethanol sensing properties[J]. Applied Surface Science, 2016, 363:560-565.
[9] 蔡宏敏, 任素贞, 王萌, 等. 单分散SnO₂中空微纳米球的制备和性质[J]. 物理化学学报, 2013, 29(4):881-888. CAI Hongmin, REN Suzhen, WANG Meng, et al. Preparation and properties of monodisperse SnO₂ hollow micro/nano spheres[J]. Acta Phys. -Chim. Sin., 2013, 29(4):881-888.
[10] WANG Y Z, SU T T, CHEN H Y, et al. Synthesis of hollow SnO₂, microspheres and its enhanced photocatalytic properties[J]. Materials Letters, 2014, 137:241-244.
[11] YANG J D, WANG S R, DONG R, et al. One-pot synthesis of SnO₂, hollow microspheres and their formaldehyde sensor application[J]. Materials Letters, 2016, 184:9-12.
[12] RAO A, HU L, HARLEY-TROCHIMCZYK A, et al. In situ localized growth of ordered metal oxide hollow sphere array on microheater platform for sensitive, ultra-fast gas sensing[J]. Acs Applied Materials & Interfaces, 2017, 9(3):2634-2641.

SnO₂中空微球的制备与气敏性能

Synthesis of hollow SnO₂ microspheres and their enhanced sensing properties to ethanol

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 11

编辑推荐

Metrics

本文评价

[1]	薛博, 杨婷婷, 王雪峰. 聚苯胺/碳纳米管气敏材料的研究进展[J]. 化工进展, 2023, 42(3): 1448-1456.
[2]	黄冠华, 刘序彦, 房晨曦, 顾庆峰, 雷浩. 生物模板法制备磁性中空微球的方法和应用[J]. 化工进展, 2021, 40(5): 2613-2623.
[3]	甄栋兴, 唐帅, 陈木森, 万磊, 吴雪梅, 贺高红. 硫酸化SnO₂/SPPESK复合质子交换膜的制备及燃料电池性能[J]. 化工进展, 2019, 38(01): 529-537.
[4]	魏莹, 仪桂云, 王晓冬, 许亚威, 周利星. ZnO负载SnO₂复合材料的制备及其气敏性能[J]. 化工进展, 2018, 37(02): 651-657.
[5]	王莹, 王晓冬, 许亚威, 周利星, 魏莹, 仪桂云. 贯通有序大孔SnO₂气敏材料的制备及气敏性能[J]. 化工进展, 2016, 35(11): 3570-3575.
[6]	张青. 溶胶-凝胶法与自模板法相结合制备SiO2中空微球[J]. 化工进展, 2014, 33(06): 1517-1520.
[7]	尹莉，陈德良，李涛，张毅，张锐. 贵金属/WO₃复合纳米晶的气敏与光催化研究进展[J]. 化工进展, 2012, 31(01 ): 133-143.
[8]	李振昊，李文乐，孔繁华，阎立军，任春晓. 掺杂二氧化锡的应用研究进展 [J]. 化工进展, 2010, 29(12): 2324-.
[9]	汪铁林，王博，周玉新，伍沅. 撞击流反应合成纳米二氧化锡 [J]. 化工进展, 2008, 27(11): 1832-.
[10]	龚圣，李明子，皮丕辉，杨卓如. 纳米锑掺杂氧化锡的研究进展 [J]. 化工进展, 2008, 27(10): 1516-.
[11]	娄向东，刘淑萍，师东阳，席国喜. H₂S气敏材料研究进展 [J]. 化工进展, 2006, 25(1): 43-.