煤炭地下气化残留物中微量元素分布及富集特性

doi:10.16085/j.issn.1000-6613.2017-1450

化工进展 ›› 2018, Vol. 37 ›› Issue (04): 1590-1598.DOI: 10.16085/j.issn.1000-6613.2017-1450

煤炭地下气化残留物中微量元素分布及富集特性

李玉龙^1,2, 梁栋宇^1,2, 盛训超^1,2, 王张卿^1,2, 梁杰^1,2

1 中国矿业大学(北京)化学与环境工程学院, 北京 100083;
2 中国矿业大学(北京)共伴生能源精准开采北京市重点实验室, 北京 100083

收稿日期:2017-07-14 修回日期:2017-11-13 出版日期:2018-04-05 发布日期:2018-04-05
通讯作者: 梁杰,教授,研究方向为煤炭地下气化。
作者简介:李玉龙(1988-),男,博士研究生。
基金资助:
中央高校基础科研业务费专项基金项目（2012YH01）。

Distribution and enrichment characteristics of trace elements during underground coal gasification

LI Yulong^1,2, LIANG Dongyu^1,2, SHENG Xunchao^1,2, WANG Zhangqing^1,2, LIANG Jie^1,2

1 School of Chemical and Environmental Engineering, China University of Mining & Technology(Beijing), Beijing 100083, China;
2 Beijing Key Laboratory for Precise Mining of Intergrown Energy and Resources, China University of Mining & Technology(Beijing), Beijing 100083, China

Received:2017-07-14 Revised:2017-11-13 Online:2018-04-05 Published:2018-04-05

摘要/Abstract

摘要： 煤炭地下气化是把残留物保留在地下的煤炭原位开采技术。本文通过地下气化富氧-水气化工艺模型实验，对不同工艺条件下气化区残留物进行网格采样，并通过离子体质谱仪（ICP-MS）和原子荧光形态分析仪对残留物中的Zn、Cu、As、Pb、Cr、Ni和Hg进行定量分析，最后采用迁移率和相对富集系数对微量元素进行迁移富集特性评价。结果表明，残留物中微量元素的总量随着工艺条件中氧气浓度的增加而减少。在氧化区中Cr、Ni含量最高，Cu、Pb在三区的残留量很少，Zn在三区的残留量最多，随着氧浓度的升高，在三区的残留物呈明显的递减趋势，易于在还原区内残留；As在三区都有富集的趋势，随着氧气浓度的升高，在三区残留物的残留量有递增的趋势；由于出口气温度较高，Hg在三区的残留量最少，没有明显的规律性。气化通道残留物中微量元素Hg、As、Zn、Cr的平均含量比原煤中的含量多，而Ni、Cu、Pb比原煤中的含量少。从相对富集系数与平均残留率综合分析，Cr、Ni、Zn、As、Hg的平均相对富集系数小于1，Zn、As、Hg的残留物大于100%；Cr、Ni残留率在50%~100%。Cu和Pb三区的相对富集系数小于1，残留率小于50%。

关键词: 煤炭地下气化, 残留物, 微量元素, 分布, 富集

Abstract: Underground coal gasification technology is a situ mining technology,leaving the produced pollutants in the ground. The grid-based sampling of gasification zone under different process conditions was carried out by oxygen-water gasification model test. The residue of content of zinc,arsenic,lead,chromium,nickel and mercury was analyzed by inductively coupled plasma mass spectrometry(ICP-MS) and atomic fluorescence spectrometry. Finally,the migration and enrichment coefficients were used to evaluate the migration and enrichment characteristics of trace elements. Results showed that the total amount of trace element residues decreases with the increase of oxygen concentration of the process conditions. In the oxidation zone,the residual amount of chromium and nickel was very high. The residual amount of copper and lead in the three regions was very low. The residual amount of zinc in the three regions was the highest,and the residual amount decreases with the increase of oxygen concentration in the three regions,and is easy to remain in the reducing area. Arsenic is enriched in three regions,and its residuals increase with the incresase of oxygen concentration in three regions. Due to the higer temperature at the outlet,the residual amount of mercury in the three areas was the least,and there was no obvious regularity. The average content of trace elements Hg,As,Zn and Cr in the residue of gasification channel was much higher than that in raw coal,while that of nickel,copper and lead was less than that of raw coal. By the method of the relative enrichment factor and the average residual ratio analysis,it is carried out that the relative enrichment factors of Cr,Ni,Zn,As,Hg are all less than 1. The residual rates of Zn,As and Hg are more than 100%. Cr and Ni are from 50% to 100%. The relative enrichment factors of Cu and Pb in three regions are less than 1. The residual rates are less than 50%.

Key words: underground coal gasification, residue, trace element, distribution, enrichment

中图分类号:

李玉龙, 梁栋宇, 盛训超, 王张卿, 梁杰. 煤炭地下气化残留物中微量元素分布及富集特性[J]. 化工进展, 2018, 37(04): 1590-1598.

LI Yulong, LIANG Dongyu, SHENG Xunchao, WANG Zhangqing, LIANG Jie. Distribution and enrichment characteristics of trace elements during underground coal gasification[J]. Chemical Industry and Engineering Progress, 2018, 37(04): 1590-1598.

参考文献

[1] 梁杰.煤炭地下气化过程稳定性及控制技术[M]. 徐州:中国矿业大学出版社,2002:1-15. LIANG Jie. Underground coal gasification stability and control technology[M]. Xuzhou:China University of Mining and Technology Press,2002:1-15.
[2] 杨兰和.煤炭地下气化火焰工作面移动速度研究[J].煤炭学报,2000,25(5):496-500. YANG Lanhe. Study on moving velocity of burning front in underground coal gasification[J]. Journal of China Coal Society,2000,25(5):496-500.
[3] 杨兰和.煤炭地下气化"三带"特征及影响变量的研究[J].南京理工大学学报(自然科学版),2001,25(5):534-537. YANG Lanhe. Characteristics of "Three Zones" in underground coal gasification and its study of influence variables[J]. Journal of Nanjing University of Science and Technology,2001,25(5):534-537.
[4] 王媛媛,刘洪涛,李金刚,等.煤炭地下气化"三带"痕量元素析出规律模拟试验研究[J].煤炭学报,2012,37(12):2092-2096. WANG Yuanyuan,LIU Hongtao,LI Jingang,et al. Experimental study on leaching behavior of trace elemenets in the residues of "Three Zones" from underground coal gasification[J]. Journal of China CoalSociety,2012,37(12):2092-2096.
[5] 杨兰和,余力.煤炭地下气化工业试验[J].化工学报,2001,52(11):1012-1016. YANG Lanhe,YU Li. Industrial test of underground coal gasification[J]. Journal of Chemical Industry and Engineering(China),2001,52(11):1012-1016.
[6] YANG Lanhe,LIANG Jie,YU Li. Study on model test on underground coal gasification technique[J]. Journal of China University of Mining &Technolog,1999,28(4):314-317.
[7] 李玉兰,刘鑫,邵素军,等. 煤炭地下气化灰渣浸泡实验及Zn、Cd、Pb、As环境效应分析[J]. 安全与环境学报,2008(2):80-82. LI Yulan,LIU Xin,SHAO Sujun,et al. Leaching test of Zn,Cd,Pb,As in UCG residues for the environmental impact assessment[J]. Journal of Safety and Environment,2008,8(2):80-82.
[8] 王勤辉,景妮洁,骆仲泱,等.灰成分影响煤灰烧结温度的实验研究[J].煤炭学报,2010(6):1015-1020. WANG Qinhui,JING Nijie,LUO Zhongyang,et al. Experiments on the effect of chemical components of coal ash onthe sintering temperature[J]. J. China Coal Soc.,2010,35(6):1015-1020.
[9] 高仲峰,王红. 浅谈煤炭地下气化的综合利用[J]. 城市燃气,2001(4):48-49. GAO Zhongfeng,WANG Hong. Analysis on the comprehensive utilization of the underground coal gasification[J]. Urban Gas,2001(4):48-49.
[10] 初茉,李华民,余力,等. 煤炭地下气化——回收报废矿井中煤炭资源的有效途径[J]. 中国煤炭,2001,27(1):22-23. CHU Mo,LI Huamin,YU Li,et al. Underground coal gasification:an effective way of recovering left-over resources in abandoned coal mines[J]. China Coal,2001,27(1):22-23.
[11] LOON A J V. Medical geology-effects of geological environments on human health[J]. Earth Science Reviews,2005,69(3/4):333-335.
[12] LIU S,WANG Y,LI Y,et al. Thermodynamic equilibrium study of trace element transformation during underground coal gasification[J]. Fuel Processing Technology,2006,87(3):209-215.
[13] DIAZ-SOMOANO M,MARTINEZ-TARAZONA M R. Trace element evaporation during coal gasification based on a thermodynamic equilibrium calculation approach[J]. Fuel,2003,82(2):137-145.
[14] 刘桂建,彭子成,杨萍玥,等.煤中微量元素在燃烧过程中的变化[J].燃料化学学报,2001,29(2):119-123. LIU Guijian,PENG Zicheng,YANG Pingyue,et al. Changes of trace elements in coal during combustion[J]. Journal of Fuel Chemistry and Technology,2001,29(2):119-123.
[15] 刘淑琴. 煤炭地下气化过程有害微量元素转化富集规律[M]. 北京:煤炭工业出版社,2009. LIU Shuqin.Harmful trace element transformation and enrichment of underground coal gasification process[M]. Beijing:Coal Industry Press,2009.
[16] 黄文辉,唐修义.煤燃烧过程中微量元素的迁移和富集[J].中国煤炭地质,2002,14(B07):75-87. HUANG Wenhui,TANG Xiuyi. Mobility and concentration of trace elements during coal combustion[J]. Coal Geology of China,2002,14(B07):75-87.
[17] 刘桂建,杨萍玥,余明高,等. 燃煤过程有害微量元素挥发与其赋存状态及燃烧温度的关系[J].燃烧科学与技术,2003,9(1):6-10. LIU Guijian,YANG Pingyue,YU Minggao,et al. Changes of trace elements in coal during combustion[J]. Journal of Fuel Chemistry and Technology,2003,9(1):6-10.
[18] 叶云娜,谌伦建,李金旺,等.大粒度煤块气化特性研究[J].化学工程,2015,43(12):47-52. YE Yunna,CHEN Lunjian,LI Jinwang,et al. Reaction characteristics of large coal particles[J]. Chemical Engineering(China),2015,43(12):47-52.
[19] 单晓梅,朱书全,李中和,等.煤中有害微量元素对环境的影响及控制[J]. 选煤技术,2003(3):3-6. SHAN Xiaomei,ZHU Shuquan,LI Zhonghe. Influence of harmful microelementin coal on environmentandits control[J]. Coal Preparation Technology,2003(3):3-6.

煤炭地下气化残留物中微量元素分布及富集特性

Distribution and enrichment characteristics of trace elements during underground coal gasification

PDF (PC)

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	李春利, 韩晓光, 刘加朋, 王亚涛, 王晨希, 王洪海, 彭胜. 填料塔液体分布器的研究进展[J]. 化工进展, 2023, 42(9): 4479-4495.
[2]	王兰江, 梁瑜, 汤琼, 唐明兴, 李学宽, 刘雷, 董晋湘. 快速热解铂前体合成高分散的Pt/HY催化剂及其萘深度加氢性能[J]. 化工进展, 2023, 42(8): 4159-4166.
[3]	林海, 王彧斐. 考虑噪声约束的分布式风场布局优化[J]. 化工进展, 2023, 42(7): 3394-3403.
[4]	薛凯, 王帅, 马金鹏, 胡晓阳, 种道彤, 王进仕, 严俊杰. 工业园区分布式综合能源系统的规划与调度[J]. 化工进展, 2023, 42(7): 3510-3519.
[5]	吴霞, 蒋勋涛, 张余晓, 吕慧园, 黄方, 于筱溪. 基于液滴微流控技术的蛋白质结晶[J]. 化工进展, 2023, 42(4): 2024-2030.
[6]	谢迎春, 王倩倩, 马永丽, 孙国强, 刘明言. 超声波与紫外线耦合脱气杀菌[J]. 化工进展, 2023, 42(3): 1629-1637.
[7]	胡亚飞, 冯自平, 田佳垚, 黄冲, 宋文吉. 燃料驱动无电热泵系统的节能模拟与运行经济性分析[J]. 化工进展, 2023, 42(3): 1217-1227.
[8]	陈二军, 张玉玲, 路少磊, 段海洋, 靳文章. 空气纳米气泡的稳定性及理化特性[J]. 化工进展, 2022, 41(9): 4673-4681.
[9]	彭德其, 冯源, 王依然, 谭卓伟, 俞天兰, 吴淑英. 立式缩放管内液固颗粒群浓度分布与汇聚特性[J]. 化工进展, 2022, 41(9): 4662-4672.
[10]	胡亚飞, 吕杰, 韩涛, 宋文吉, 冯自平. 基于余热回收的燃气热泵系统高温制热特性[J]. 化工进展, 2022, 41(7): 3553-3563.
[11]	李娟娟, 张天永, 李祥高. 电泳显示用高质量铁锰黑纳米分散系的构建[J]. 化工进展, 2022, 41(6): 3178-3185.
[12]	吕飞勇, 初茉, 易浩然, 郝焱, 杨彦博, 石旭, 孙星博. 磁性灰粒在不同粒级气化灰渣中的分布特性[J]. 化工进展, 2022, 41(5): 2372-2378.
[13]	马小娟, 王彧斐, 冯霄. 天然气水合物开采平台能量系统优化[J]. 化工进展, 2022, 41(3): 1667-1676.
[14]	韩芬, 杨娜, 孙永利, 姜斌, 肖晓明, 张吕鸿. 玻璃纤维聚结器脱除油中乳化水[J]. 化工进展, 2022, 41(12): 6723-6732.
[15]	施文博, 蔡淳名, 李德威, 小野圭, 张剑波. ISO/IEC、美日中氢能技术标准化体系比较与建议[J]. 化工进展, 2022, 41(12): 6275-6284.