Extractive denitrification of coal tar diesel fraction using phosphate-based alkylimidazolium ionic liquids

doi:10.16085/j.issn.1000-6613.2016.04.018

Abstract

Abstract: Two series phosphate-based alkylimidazolium ionic liquids (ILs), dialkyl and dihydrogen phosphate alkylimidazolium ILs were prepared and used to remove nitrogen compounds in the coal tar diesel fraction by extraction. The denitrification effect were studied under different conditions. The results indicate that dihydrogen phosphate alkylimidazolium ILs have a higher denitrification rate for both basic and non-basic nitrogen compounds than dialkyl phosphate alkylimidazolium ILs due to the complexation. The best denitrification rate can reach 92.3% using 1-butyl-3-methylimidazolium dihydrogen phosphate ([BMim]H₂PO₄) ILs as the extraction agent under the optimum conditions, with which the mass ratio of ILs to oil is 0.2, temperature is 40℃, reaction and stratification time are both 30min. [BMim]H₂PO₄ ILs performed stably in nitrogen removal of coal tar diesel fraction, and the denitrification rate remained almost no change even after five times reuse.

Key words: phosphate, ionic liquids, coal tar diesel fraction, denitrification

摘要： 研究了不同磷酸基咪唑离子液体对煤焦油柴油馏分中氮化物的脱除效果.分别以磷酸酯和磷酸二氢根为阴离子合成了烷基碳链长度不同的咪唑磷酸酯和咪唑磷酸二氢盐离子液体,考察了不同条件下离子液体对煤焦油柴油馏分的脱氮效果.结果表明,酸性咪唑磷酸二氢盐离子液体脱氮效果优于咪唑磷酸酯离子液体,1-丁基-3-甲基咪唑磷酸二氢盐([BMim]H₂PO₄)离子液体的脱氮效果最佳.在剂油质量比为0.2、反应温度为40℃、反应时间和静置时间均为30min的条件下,[BMim]H₂PO₄对煤焦油柴油馏分的脱氮率为92.3%,循环使用5次后仍具有稳定的脱氮效果.

关键词: 磷酸基, 离子液体, 煤焦油柴油馏分, 脱氮

CLC Number:

TE664

SU Xiaolin, SONG Jun, YANG Jingyi, XU Xinru. Extractive denitrification of coal tar diesel fraction using phosphate-based alkylimidazolium ionic liquids[J]. Chemical Industry and Engineering Progree, 2016, 35(04): 1081-1086.

苏晓琳, 宋军, 杨敬一, 徐心茹. 磷酸基咪唑离子液体脱除煤焦油柴油馏分中的氮化物[J]. 化工进展, 2016, 35(04): 1081-1086.

References

[1] 姚春雷,全辉,张忠清.中、低温煤焦油加氢生产清洁燃料油技术[J].化工进展,2013,32(3):501-507.
[2] JIAO T T,LI C S,ZHANG X L,et al.The new liquid-liquid extraction method for separation of phenolic compounds from coal tar[J].Chemical Engineering Journal,2015,266:148-155.
[3] 张军民,刘弓.低温煤焦油的综合利用[J].煤炭转化,2010,33(3):92-96.
[4] DA SILVA J M,MACHADO M E,MACIEL G P S,et al.Speciation of nitrogen-containing compounds in an unfractionated coal tar sample by comprehensive two-dimensional gas chromatography coupled to time-of-flight mass spectrometry[J].Journal of Chromatography A,2014,1373:159-168.
[5] HANSMEIER A R,MEINDERSMA G W,DE HAAN A B.Desulfurization and denitrogenation of gasoline and diesel fuels by means of ionic liquids[J].Green Chemistry,2011,13(7):1907-1913.
[6] 李贵贤,曹彦伟,李梦晨,等.煤焦油加氢脱氮反应网络及催化剂研究进展[J].化工进展,2015,34(5):1283-1290.
[7] HUH E S,ZAZYBIN A,PALGUNADI J,et al.Zn-containing ionic liquids for the extractive denitrogenation of a model oil:a mechanistic consideration[J].Energy & Fuels,2009,23(6):3032-3038.
[8] 唐晓东,胡涛,李晶晶,等.柴油络合脱氮技术的研究进展[J].石油化工,2014,43(7):843-847.
[9] ANANTHARAJ R,BANERJEE T.Aromatic sulfur-nitrogen extraction using ionic liquids:experiments and predictions using an a priori model[J].AIChE Journal,2013,59(12):4806-4815.
[10] 王辉,解从霞,于世涛,等.功能化酸性离子液体脱除模拟油品中的非碱性氮[J].燃料化学学报,2014,42(1):55-60.
[11] LAREDO G C,LIKHANOVA N V,LIJANOVA I V,et al.Synthesis of ionic liquids and their use for extracting nitrogen compounds from gas oil feeds towards diesel fuel production[J].Fuel Processing Technology,2015,130:38-45.
[12] RAVILLA U K,BANERJEE T.Liquid liquid equilibria of imidazolium based ionic liquid+ pyridine+ hydrocarbon at 298.15 K:experiments and correlations[J].Fluid Phase Equilibria,2012,324:17-27.
[13] 冯锦锋,袁军,杨梅,等.酸性离子液体脱除焦化柴油中碱性氮[J].武汉工程大学学报,2011,33(10):17-21.
[14] SHAO B B,SHI L,MENG X.Deep desulfurization of 4,6-dimethyldienzothiophene by an ionic liquids extraction coupled with catalytic oxidation with a molybdic compound[J].Industrial & Engineering Chemistry Research,2014,53(16):6655-6663.
[15] FRAGA-DUBREUIL J,BOURAHLA K,RAHMOUNI M,et al.Catalysed esterifications in room temperature ionic liquids with acidic counteranion as recyclable reaction media[J].Catalysis Communications,2002,3(5):185-190.
[16] 杨敬一,周秀欢,蔡海军,等.煤焦油和石油基柴油馏分中含氮化合物的分离鉴定[J].石油炼制与化工,2015,46(7):107-113.
[17] 林燕,王芳,张志庆,等.离子液体绿色脱硫机理及应用进展[J].化工进展,2013,32(3):549-557.
[18] XIE L L,FAVRE-REGUILLON A,PELLET-ROSTAING S,et al.Selective extraction and identification of neutral nitrogen compounds contained in straight-run diesel feed using chloride based ionic liquid[J].Industrial & Engineering Chemistry Research,2008,47(22):8801-8807.
[19] GAO P,CAO Z B,ZHAO D Z,et al.Extraction of basic nitrides from FCC diesel using ionic liquids at room temperature[J].Petroleum Science and Technology,2005,23(9/10):1023-1031.
[20] ZHANG S G,ZHANG Q L,ZHANG Z C.Extractive desulfurization and denitrogenation of fuels using ionic liquids[J].Industrial & Engineering Chemistry Research,2004,43(2):614-622.
[21] GABRIC B,SANDER A,BUBALO M C,et al.Extraction of S-and N-compounds from the mixture of hydrocarbons by ionic liquids as selective solvents[J].The Scientific World Journal,2013,2013:512953.
[22] ASUMANA C,YU G,GUAN Y,et al.Extractive denitrogenation of fuel oils with dicyanamide-based ionic liquids[J].Green Chemistry,2011,13(11):3300-3305.