Solubility and metastable zone of valsartan in ethyl acetate

doi:10.16085/j.issn.1000-6613.2016.08.04

Abstract

Abstract: The solubility of valsartan in ethyl acetate was measured by a static equilibrium method at temperatures from 278.15K to 323.15K. The solubility data were correlated by the modified Apelblat equation,the NRTL equation,and the λh equation. In addition,the thermodynamic parameters (including the enthalpy,entropy and Gibbs energy) were calculated by the van't Hoff analysis. The results showed that the solubility of valsartan obviously increased with an increase of temperature. The experimental data were well correlated with the above models because the mean deviation values of these three models were 1.03%,3.87%,and 1.7%,respectively. Therefore,the modified Apelblat equation was the best choice in the correlation of the solubility data of valsartan. The values of thermodynamic parameters proved that the dissolution process of valsartan in ethyl acetate was endothermic,spontaneous and entropy-driven. The main contributor to the standard molar Gibbs energy of solution was the enthalpy change during the dissolution process. Furthermore,the supersolubility of valsartan in ethyl acetate was measured at different stirring rates and cooling rates by the laser method. The results indicated that the metastable zone was wider under the condition of low stirring rate,high temperature and large cooling rate. Meanwhile,the temperature effect was remarkable but the cooling rate had little effect on the metastable zone.

Key words: valsartan, ethyl acetate, solubility, correlation, metastable zone

摘要： 采用静态平衡法测定缬沙坦在乙酸乙酯中278.15~323.15K的溶解度数据，利用Modified Apelblat、NRTL和λh方程分别对溶解度数据进行了关联，并通过van't Hoff分析计算了缬沙坦在溶解过程中的热力学参数（焓变、熵变和吉布斯自由能）。结果表明，缬沙坦在乙酸乙酯中的溶解度随着温度升高而显著增大，3个模型均具有较好的关联性，平均相对偏差分别为1.03%、3.87%、1.72%，Modified Apelblat方程对溶解度数据关联的效果最好；缬沙坦在乙酸乙酯中的溶解过程为自发吸热熵驱动过程，焓变在溶解过程中对吉布斯自由能贡献较大。利用激光法测定了缬沙坦在乙酸乙酯中的超溶解度，研究了不同搅拌速率、降温速率对结晶介稳区的影响。结果表明，随饱和温度的升高，介稳区显著变宽；搅拌速率越小、降温速率越快，介稳区越宽，降温速率的影响相对较小。

关键词: 缬沙坦, 乙酸乙酯, 溶解度, 超溶解度, 介稳区

CLC Number:

O795

WANG Qingqing, SUN Qin, YANG Asan, CHENG Rong, ZHENG Yanping. Solubility and metastable zone of valsartan in ethyl acetate[J]. Chemical Industry and Engineering Progree, 2016, 35(08): 2329-2333.

王清清, 孙勤, 杨阿三, 程榕, 郑燕萍. 缬沙坦在乙酸乙酯中的溶解度及介稳区[J]. 化工进展, 2016, 35(08): 2329-2333.

References

[1] NIXON R M,MULLER E,LOWY A,et al. Valsartan vs. other aongiotensinⅡ receptor blockers in the treatment of hypertension:a meta-analytical approach[J]. Int. J. Clin. Pract.,2009,63(5):766-775.
[2] NEUTEL J,WEBER M,POOL J,et al. Valsartan,a new angotensin Ⅱ antagonist:antihypertensive effects over 24 hours[J]. Clin. Ther.,1997,19(3):447-458.
[3] 马勇,朱家文,陈蔡,等. 磷酸结晶介稳区性质的研究[J]. 高校化学工程学报,2010,24(2):331-335.
[4] LIU Y,WANG J K,WANG X B,et al. Solubility of valsartan in ethyl acetate + hexane binary mixtures from(278.15 to 313.15)K[J]. J. Chem. Eng. Data,2009,54(4):1412-1414.
[5] 王小敏,汪全义,彭琦,等. 对乙酰氨基苯甲酸在甲醇+乙醇混合溶剂中溶解度测定及关联计算[J]. 化工进展,2015,34(3):647-651.
[6] TSONOPOULOS C. Thermodynamic analysis of the mutual solubilities of normal alkanes and water[J]. Fluid Phase Equilibr.,1999,156(1):21-33.
[7] MANZUROLA E,APELBLAT A. Solubilities of L-glutamic acid,3-nitrobenzoic acid,p-toluic acid,calcium-L-lactate,calcium gluconate,magnesium-DL-aspartate,and magnesium-L-lactate in water[J]. J. Chem. Thermodyn.,2002,34(7):127-136.
[8] HUANG C,XIE Z P,XU J C,et al. Experimental and modeling studies on the solubility of d-pantolactone in four pure solvents and ethanol-water mixtures[J]. J. Chem. Eng. Data,2015,60(3):870-875.
[9] MARTI E E. Crystalline salt forms of valsartan:US 6869970[P]. 2005-03-22.
[10] 宋微微,马沛生,相政乐. 丁二酸在五种有机溶剂中溶解度测定及关联[J]. 高校化学工程学报,2007,21(2):341-344.
[11] 李柏春,杜东雪,张文林,等. 氯化锂、氯化钠在NMP中溶解度的测定与关联[J]. 化工学报,2014,65(12):4664-4668.
[12] 张迪,肖清贵,张炳烛,等. 氯氧化铋在盐酸溶液中溶解度的测定和关联[J]. 化工学报,2014,65(6):1987-1992.
[13] SU J H,QIAN C,LUO N Z,et al. Experimental measurement and modeling of the solubility of biotin in six pure solvents at temperatures from 298.15 K to 333.85 K[J]. J. Chem. Eng. Data,2014,59(11):3894-3899.
[14] SHAKEEL F, HAQ N,SIDDIQUI N A,et al. Solubility and thermodynamic behavior of vanillin in propane-1,2-diol + water cosolvent mixtures at different temperatures[J]. Food Chem.,2015,188:57-61.
[15] YU C,ZENG Z X,XUE W L. Measurement and correlation of the solubility of hexaquonickel(Ⅱ) bis(ptoluenesul-fonate) in water + ethanol solvents within 288.15-333.15 K[J]. Ind. Eng. Chem. Res.,2015,54(15):3961-3967.