Feasibility research on the performance improvement of sludge protein solution by 60Coγ ray synergia H2O2

doi:10.16085/j.issn.1000-6613.2015.02.041

Chemical Industry and Engineering Progree ›› 2015, Vol. 34 ›› Issue (02): 561-564.DOI: 10.16085/j.issn.1000-6613.2015.02.041

Previous Articles Next Articles

Feasibility research on the performance improvement of sludge protein solution by ⁶⁰Coγ ray synergia H₂O₂

XIANG Yulin, WANG Lipeng, JIAO Yurong

College of Chemistry and Chemical Engineering, Yulin University, Yulin 719000, Shaanxi, China

Received:2014-06-05 Revised:2014-08-10 Online:2015-02-05 Published:2015-02-05

⁶⁰Coγ射线协同H₂O₂改善污泥蛋白液性能的可行性

相玉琳, 王立鹏, 焦玉荣

榆林学院化学与化工学院, 陕西榆林 719000

通讯作者: 相玉琳(1982-),女,博士,讲师,主要从事污泥蛋白质的研究。E-mail:xianglin@tju.edu.cn
基金资助:
陕西省教育厅自然科学专项(2013JK0880)及榆林学院高层次人才科研基金(12GK04)项目

Abstract

Abstract: The effect of ⁶⁰Coγ-ray/H₂O₂ on the performance of sludge protein solution was investigated. The results showed that the sludge protein solution exhibited abundant fine foam,homogeneous texture and good sensory quality after ⁶⁰Coγ-ray/H₂O₂ synergia treatment. Foam fire extinguishing agent and foam concrete were developed by using the sludge protein solution after treatment,both products could meet correspondent quality standard. Cost analysis showed that the ⁶⁰Coγ-ray/H₂O₂ synergia treatment cost was lower and more feasible than chemical methods.

Key words: 60Co, H₂O₂, sludge protein solution

摘要： 实验以污泥蛋白液为研究对象,考察了⁶⁰Coγ射线协同H₂O₂对污泥蛋白液性能的影响。结果表明,⁶⁰Coγ射线协同H₂O₂处理后,污泥蛋白液的泡沫细腻丰富、质地均匀、感官品质好。用处理后的污泥蛋白液研制泡沫灭火剂和泡沫混凝土,所得产品均能满足相应的质量标准。成本分析显示,⁶⁰Coγ射线协同H₂O₂法处理成本低于化学法,工艺流程简洁,可行性较强。

关键词: 钴60, 过氧化氢, 污泥蛋白液

CLC Number:

TQ949

XIANG Yulin, WANG Lipeng, JIAO Yurong. Feasibility research on the performance improvement of sludge protein solution by ⁶⁰Coγ ray synergia H₂O₂[J]. Chemical Industry and Engineering Progree, 2015, 34(02): 561-564.

相玉琳, 王立鹏, 焦玉荣. ⁶⁰Coγ射线协同H₂O₂改善污泥蛋白液性能的可行性[J]. 化工进展, 2015, 34(02): 561-564.

References

[1] Wilson C A,Novak J T. Hydrolysis of macromolecular components of primary and secondary wastewater sludge by thermal hydrolytic pretreatment[J]. Water Res.,2009,43(18):4489-4498.
[2] Mottet A,Francois E,Latrille E,et al. Estimating anaerobic biodegradability indicators for waste activated sludge[J].Chemical Engineering Journal,2010,160(2):488-496.
[3] Jimenez J,Vedrenne F,Denis C,et al. A statistical comparison of protein and carbohydrate characterisation methodology applied on sewage sludge samples[J]. Water Res.,2013,47(5):1751-1762.
[4] 华佳,陈玉辉,霍苗,等. 正交优化制备污泥水解蛋白质的实验研究[J]. 环境科学与技术,2006,29(12):28-30.
[5] 华佳,陈玉辉,李亚东,等. 制备剩余污泥水解蛋白质实验条件的初步研究[J]. 湖北大学学报:自然科学版,2006,28(1):87-90.
[6] 崔健,董岸杰,张卫江,等. 热碱水解提取污泥蛋白质的实验研究[J].环境工程学报,2009,3(10):1889-1892.
[7] 陈玉辉,华佳,霍苗,等. 酸循环水解制备剩余污泥水解蛋白质的试验研究[J]. 湖北大学学报:自然科学版,2006,28(4):417-419.
[8] 华佳,李亚东,张林生. 改进污泥水解制取蛋白质工艺的研究[J]. 中国给水排水,2008,24(1):17-21.
[9] 庞金钊,张淑玲,刘忠,等. 用超滤膜法浓缩剩余污泥中蛋白提取液的实验研究[J]. 天津工业大学学报,2009,28(6):7-10.
[10] Hwang Jiyeon,Zhang Lei,Seo Sunkeun,et al. Protein recovery from excess sludge for its use as animal feed[J]. Bioresource Technology,2008,99(18):8949-8954.
[11] 李军. 活性污泥蛋白质混凝土发泡剂的泡沫稳定性研究[J]. 新型建筑材料,2010(12):63-66.
[12] 相玉琳,张卫江. 污泥蛋白液的除臭研究[J]. 化学工程,2012,40(2):7-11.
[13] Xiang Yulin,Zhang Weijiang,Zheng Hao. Synergetic decolorization and deodorization of sludge protein foaming solution by ⁶⁰Coγ-ray irradiation/H₂O₂ oxidation[J]. Process Safety and Environmental Protection,2010,88:285-291.
[14] Xiang Yulin,ZhangWeijiang,Zheng Hao. Decoloration kinetics of sludge protein solution by ⁶⁰Coγ-ray/H₂O₂[J]. Transactions of Tianjin University,2011,17(1):45-50.
[15] 相玉琳,张卫江,徐姣,等. 超声波辐射强化污泥蛋白质的提取[J]. 化学工程,2011,39(3):63-66.
[16] 寿崇琦,康杰分,宋南京,等. 一种动物蛋白水泥发泡剂的研制及其复合应用[J]. 化工建材,2007,23(2):35-37.
[17] 尹冰,刘才林,霍冀川,等. 动物蛋白类泡沫混凝土发泡剂的制备与发泡性能测试[J]. 新型建筑材料,2007(7):8-11.
[18] Erkan Y,SÜeda C,Esra I. Foaming properties of barley protein isolates and hydrolysates[J]. Eur. Food Res. Technol.,2008,226(5):967-974.
[19] 王武祥. 泡沫混凝土砌块[J]. 建筑砌块与砌块建筑,2007(2):42-45.
[20] 施培新. 食品辐照加工原理与技术[M]. 北京:农业科技出版社,2004.

Feasibility research on the performance improvement of sludge protein solution by ⁶⁰Coγ ray synergia H₂O₂

⁶⁰Coγ射线协同H₂O₂改善污泥蛋白液性能的可行性

PDF (PC)

Knowledge

Abstract

Cite this article

share this article

References

Related Articles 7

Recommended Articles

Metrics

Comments

[1]	LIAO Bing, XU Wen, YE Qiuyue. A review of activated percarbonate and peroxymonocarbonate in the field of water treatment [J]. Chemical Industry and Engineering Progress, 2022, 41(6): 3235-3248.
[2]	YAN Wenjie, XIONG Yuanquan, YANG Siyuan, HE Shanshan. NO preoxidation by gas phase Fenton reaction with Fe₂O₃ over rice husk-based silica carrier [J]. Chemical Industry and Engineering Progress, 2021, 40(7): 4027-4035.
[3]	Hua ZHANG, Zipeng ZHANG, Lanlan ZHANG, Xiaofei ZHANG, Yiying LIU. In situ test of aniline wastewater degradation by photocatalytic treatment combined with H₂O₂ [J]. Chemical Industry and Engineering Progress, 2020, 39(12): 5299-5308.
[4]	XU Yanhui, YIN Xianhong, QIU Jiangyuan, HUANG Zaiyin, TAN Chunping, HU Yuping. Application and mechanism of azo dye wastewater treatment using Cu₃(BTB)₂ and H₂O₂ [J]. Chemical Industry and Engineering Progress, 2017, 36(12): 4700-4707.
[5]	JIN Fuya, YU Lin, LAN Bang, CHENG Gao, SUN Ming, ZHENG Xiaoying. Preparation of MnO₂ nanomaterials in hydrothermal method and applied in hydrogen peroxide sensing [J]. Chemical Industry and Engineering Progress, 2017, 36(09): 3380-3387.
[6]	CAO Xiaohua, LI Shuigen, ZHOU Dezhi, LEI Yanhong, ZHAN Changchao. Preparation,characterization of AlH₃P₂W₁₈O₆₂·nH₂O and its catalytic performance in synthesis of adipic acid [J]. Chemical Industry and Engineering Progree, 2015, 34(04): 1014-1018.
[7]	YE Zhaolian1，ZHANG Renxi 2，CHEN Xian1，XI Zhinan1. Oxidative degradation of nitrogen-heterocyclic compounds（NHCs）under microwave electrodeless excilamp in the presence of H₂O₂ [J]. Chemical Industry and Engineering Progree, 2012, 31(02 ): 440-447.