石英砂粒径大小对甲烷水合物形成及分布的影响

doi:10.16085/j.issn.1000-6613.2019-1788

摘要/Abstract

摘要：

为了研究不同粒径多孔介质体系中甲烷水合物的形成，本文采用粒径分别为0.075~0.5mm、0.5~1mm、1~2mm和2~3mm的石英砂作为多孔介质，在初始压力7.0MPa、温度0.5℃条件下进行水合物形成实验并进行取样观察、分层分解，得出不同粒径大小石英砂中甲烷水合物形成及分布的特征。结果表明：随着石英砂粒径的增大，石英砂砂体中的水合物形成量和初始水合物形成速率在逐渐减小；在粒径为0.075~0.5mm、1~2mm和2~3mm石英砂中，充气过程中水合物便开始形成，且并未出现明显的水合物大量形成阶段，而在粒径为0.5~1mm石英砂体系中出现了水合物大量形成的阶段；通过计算发现，0.5~1mm石英砂体系的气体消耗量最大，为0.47mol，2~3mm石英砂体系的气体消耗量最小，仅为0.05mol；在这4种粒径的石英砂体表面的甲烷水合物主要以分散状均匀分布于颗粒之间或胶结成块，但这一观察结果与通过分解的方法所得到的石英砂上部水合物形成量大于下部的结果存在差异；重复实验也发现，仅在粒径为0.5~1mm石英砂顶部出现了水合物大量富集的现象，因此推断认为在一定粒径的介质体系同时上部存在较大空隙时，水合物有可能会在空隙中大量富集存在。这一实验结果对自然环境中水合物的赋存区域及形态的预测具有一定的参考价值。

关键词: 粒径大小, 石英砂, 甲烷水合物, 形成过程, 气体消耗量, 分解气体量, 分布

Abstract:

In order to study the formation of methane hydrate in porous media with different particle sizes, quartz sand with particle sizes of 0.075—0.5mm, 0.5—1mm, 1—2mm and 2—3mm were used as porous media. The hydrate formation experiment was carried out at an initial pressure of 7.0MPa and a temperature of 0.5℃, and then the sampling observation and delamination were performed. Results showed that with the increase of medium particle size, the initial rate of formation and the amount of hydrate formation in the pores of quartz sand were decreased gradually, the hydrate began to form during aeration process in three particle sizes of 0.075—0.5mm, 1—2mm and 2—3mm, and there was a large amount of hydrate formation in particle size of 0.5—1mm during the hydrate formation process. The particle size of 0.5—1mm had the maximum gas consumption of 0.47mol, and gas consumption in particle size of 2—3mm was the minimum of only 0.05mol. According to the sampling observation, the methane hydrate on the surface of these four quartz sand bodies was mainly distributed evenly among the particles with dispersed or cemented into blocks. However, it was different from the result that the amount of hydrate in the upper part of sand body was more than that in the lower part of sand body by decomposition method. There was only a large amount of hydrate accumulation occurred on the top of quartz sand with 0.5—1mm. Therefore, it was inferred that when there was a large void in the upper part of a medium system with a certain particle size, the hydrate may be enriched in the void. The experimental result had certain reference value for the prediction of hydrate occurrence area and morphology in natural environment.

Key words: particle size, quartz sand, methane hydrate, formation process, gas consumption, decomposed gas, distribution

中图分类号:

王英梅, 董世强, 展静, 吴青柏, 张鹏. 石英砂粒径大小对甲烷水合物形成及分布的影响[J]. 化工进展, 2020, 39(8): 3049-3056.

Yingmei WANG, Shiqiang DONG, Jing ZHAN, Qingbai WU, Peng ZHANG. Effect of quartz sand particle size on the formation and distribution of methane hydrate[J]. Chemical Industry and Engineering Progress, 2020, 39(8): 3049-3056.

参考文献

1	BABU P, YEE D, LINGA P, et al. Morphology of methane hydrate formation in porous media[J]. Energy & Fuels, 2013, 27(6): 3364-3372.
2	SLOAN E D. Fundamental principles and applications of natural gas hydrates[J]. Nature, 2003, 426: 353-359.
3	BAHK J J, KIM D H, CHUN J H, et al. Gas hydrate occurrences and their relation to host sediment properties: results from second ulleung basin gas hydrate drilling expedition, East Sea[J]. Marine and Petroleum Geology, 2013, 47: 21-29.
4	DALLIMORE S R, COLLETT T S. Intrapermafrost gas hydrates from a deep core-hole in the Mackenzie Delta, Northwest-Territories[J]. Canada Geology, 1995, 23: 527-530.
5	WANG Hongbin, YANG Shengxiong, WU Nengyou, et al. Controlling factors for gas hydrate occurrence in Shenhu area on the northern slope of the South China Sea[J]. Science China (Earth Sciences), 2013, 56: 513-520.
6	张辉, 卢海龙, 梁金强, 等．南海北部神狐海域沉积物颗粒对天然气水合物聚集的主要影响[J]. 中国科学: 地球科学, 2016, 61(3): 388-397.
6	ZHANG Hui, LU Hailong, LIANG Jinqiang, et al. The methane hydrate accumulation controlled compellingly by sediment grain at Shenhu, northern South China Sea[J]. Chinese Science Bulletin, 2016, 61(3): 388-397.
7	刘昌岭, 业渝光, 孙始财,等. 不同体系下天然气水合物P-T稳定条件及其影响因素的实验研究[J]. 中国科学: 地球科学, 2013, 43(3): 406-413.
7	LIU Changling, YE Yuguang, SUN Shicai, et al. Experimental study on the stability conditions of natural gas hydrate P-T and its influencing factors under different systems[J]. Scientia Sinica (Terrae), 2013, 43(3): 406-413.
8	张郁, 李小森, 陈朝阳, 等. 冰点下多孔介质中甲烷水合物的生成特性[J]. 现代地质, 2016, 30(4): 922-928.
8	ZHANG Yu, LI Xiaosen, CHEN Zhaoyang, et al. Formation behaviors of methane hydrate in porous media below freezing point[J]. Geoscience, 2016, 30(4): 922-928.
9	刘志明, 商丽艳, 潘振, 等. 多孔介质与 SDS 复配体系中天然气水合物生成过程分析[J]. 化工进展, 2018, 37(6): 2201-2213.
9	LIU Zhiming, SHANG Liyan, PAN Zhen, et al. Analysis of natural gas hydrate formation process in porous media and SDS complex system[J]. Chemical Industry and Engineering Progress, 2018, 37(6): 2201-2213.
10	张金华, 张郁, 魏伟. 石英砂介质中CO₂水合物形成影响研究[J].天然气化工, 2018, 43(2): 34-39.
10	ZHANG Jinhua, ZHANG Yu, WEI Wei. Influence factors of carbon dioxide hydrate formation in quartz sand media[J]. Natural Gas Chemical Industry, 2018, 43(2): 34-39.
11	BAGHERZADEH S A, MOUDRAKOVSKI I L, RIPMEESTER J A, et al. Magnetic resonance imaging of gas hydrate formation in a bed of silica sand particles[J]. Energy & Fuels, 2011, 25(7): 5496-5507.
12	ZHAO Jiafei, LV Qin, LI Yanghui, et al. In-situ visual observation for the formation and dissociation of methane hydrates in porous media by magnetic resonance imaging[J]. Magnetic Resonance Imaging, 2015, 33(4): 485-490.
13	CHONG Z R, YANG M, KHOO B C, et al. Size effect of porous media on methane hydrate formation and dissociation in an excess gas environment[J]. Industrial & Engineering Chemistry Research, 2015, 55(29): 7981-7991.
14	SUN Shicai, LIU Changling, YE Yuguang, et al. Phase behavior of methane hydrate in silica sand[J]. Journal of Chemical Thermodynamics, 2014, 69(2): 118-124.
15	潘振, 刘志明, 刘德俊, 等. 多孔介质中天然气水合物形成影响因素研究进展[J]. 化工进展, 2017, 36(12): 4403-4415.
15	PAN Zhen, LIU Zhiming, LIU Dejun, et al. Research progress on influence factors of natural gas hydrate formation in porous media[J]. Chemical Industry and Engineering Progress, 2017, 36(12): 4403-4415.
16	李滔, 李闽, 荆雪琪, 等. 孔隙尺度各向异性与孔隙分布非均质性对多孔介质渗透率的影响机理[J]. 石油勘探与开发, 2019, 46(3): 569-579.
16	LI Tao, LI Min, JING Xueqi, et al. Influence mechanism of pore-scale anisotropy and pore distribution heterogeneity on permeability of porous media[J]. Petroleum Exploration and Development, 2019, 46(3): 569-579.
17	LI Xiaosen, ZHANG Yu, LI Gang, et al. Gas hydrate equilibrium dissociation conditions in porous media using two thermodynamic approaches[J]. The Journal of Chemical Thermodynamics, 2008, 40: 1464-1474.
18	陈文胜, 李增华, 吴强. 甲烷水合物生成过程温度场分布与生长速率关系实验研究[J]. 煤炭学报, 2015, 40(5): 1065-1069.
18	CHEN Wensheng, LI Zenghua, WU Qiang. Experimental study of the relationship between temperature field distribution of methane hydrate formation process and the formation rate[J]. Journal of China Coal Society, 2015, 40(5): 1065-1069.
19	张郁, 吴慧杰, 李小森, 等. 多孔介质中甲烷水合物的生成特性的实验研究[J]. 化学学报, 2011, 69(19): 2221-2227.
19	ZHANG Yu, WU Huijie, LI Xiaosen, et al. Experimental study on formation behavior of methane hydrate in porous media[J]. Acta Chimica Sinica, 2011, 69(19): 2221-2227.
20	臧小亚, 梁德青, 吴能友. 细砂沉积物中水合物生成过程研究[J]. 中国科学: 地球科学, 2013, 43(3): 360-367.
20	ZANG Xiaoya, LIANG Deqing, WU Nengyou. Hydrate formation process in fine sand sediment[J]. Scientia Sinica(Terrae), 2013, 43(3): 360-367.
21	吴丹梅, 李刚, 李小森, 等. 不同水合物饱和度下渗透率变化特性的实验研究[J]. 化工进展, 2017, 36(8): 2916-2923.
21	WU Danmei, LI Gang, LI Xiaosen, et al. Experimental investigation of permeability characteristics under different hydrate saturation[J]. Chemical Industry and Engineering Progress, 2017, 36(8): 2916-2923.
22	邓帅, 胡高伟, 卜庆涛.粒径及孔径分布对天然气水合物形成影响的研究进展[J]. 地质科技情报, 2019, 38(4): 41-52.
22	DENG Shuai, HU Gaowei, PU Qingtao. Research progress on the effects of particle size and pore size distribution on natural gas hydrate formation[J]. Chinese Journal of Geophysics, 2019, 38(4): 41-52.
23	蒋观利, 吴青柏, 杨玉忠, 等. 砂土中不同产状甲烷水合物形成和分解过程研究[J]. 天然气地球科学, 2013, 24(6): 1305-1310.
23	JIANG Guanli, WU Qingbai, YANG Yuzhong, et al. Formation and dissociation of methane hydrate in different occurrences in sand[J]. Natural Gas Geoscience, 2013, 24(6): 1305-1310.
24	张鹏, 吴青柏, 蒋观利, 等. 不同颗粒介质内甲烷水合物形成反应特征[J]. 天然气地球科学, 2013, 24(2): 265-272.
24	ZHANG Peng, WU Qingbai, JIANG Guanli, et al. Formation reaction characteristic of methane hydrate in different granular media[J]. Natural Gas Geoscience, 2013, 24(2): 265-272.
25	李晨安, 李承峰, 刘昌岭, 等. CT图像法观测不同粒径多孔介质中水合物分布[J]. 核电子与探测技术，2018, 38(4): 545-551.
25	LI Chenan, LI Chengfeng, LIU Changling, et al. Research of xenon hydrate distribution in different particle sizes porous media during hydrate formation and dissociation based on X-CT[J]. Nuclear Electronics & Detection Technology, 2018, 38(4): 545-551.
26	胡高伟, 李承峰, 业渝光, 等. 沉积物孔隙空间天然气水合物微观分布观测[J]. 地球物理学报, 2014, 57(5): 1675-1682.
26	HU Gaowei, LI Chengfeng, YE Yuguang, et al. Observation of gas hydrate distribution in sediment pore space[J]. Chinese Journal of Geophysics, 2014, 57(5): 1675-1682.
27	SLOAN E D. Clathrate hydrate of natural gas[M]. 3rd ed. Boca Raton, Florida: Taylor & Francis Group, CRC Press, 2008:102.
28	张保勇, 周莉红, 刘昌岭, 等. 不同粒度沉积物介质对气体水合物成核的影响[J]. 天然气工业, 2018, 38(5): 148-155.
28	ZHANG Baoyong, ZHOU Lihong, LIU Changling, et al. Influence of sediment media with different particle sizes on the nucleation of gas hydrate[J]. Natural Gas Industry, 2018, 38(5):148-155.
29	刘伟. 多孔介质传热传质理论与应用[M]. 北京: 科学出版社, 2006: 45.
29	LIU Wei. Theory and application of heat and mass transfer in porous media[M]. Beijing: Science Press, 2006: 45.
30	陈光进，孙长宇，马庆兰. 气体水合物科学与技术[M]. 北京: 化学工业出版社, 2008: 23.
30	CHEN Guangjin， SUN Changyu, MA Qinglan. Gas hydrate science and technology[M]. Beijing: Chemical Industry Press, 2008: 23.
31	张鹏, 吴青柏, 王英梅. 非饱和介质中甲烷水合物形成与分解的水分变化特征[J]. 地球物理学进展, 2010, 25(4): 1339-1345.
31	ZHNAG Peng, WU Qingbai, WANG Yingmei. Water change characteristics of formation and dissociation of methane hydrate in non-saturated media[J]. Progress in Geophysics, 2010, 25(4): 1339-1345.

[1]	李春利, 韩晓光, 刘加朋, 王亚涛, 王晨希, 王洪海, 彭胜. 填料塔液体分布器的研究进展[J]. 化工进展, 2023, 42(9): 4479-4495.
[2]	王兰江, 梁瑜, 汤琼, 唐明兴, 李学宽, 刘雷, 董晋湘. 快速热解铂前体合成高分散的Pt/HY催化剂及其萘深度加氢性能[J]. 化工进展, 2023, 42(8): 4159-4166.
[3]	薛凯, 王帅, 马金鹏, 胡晓阳, 种道彤, 王进仕, 严俊杰. 工业园区分布式综合能源系统的规划与调度[J]. 化工进展, 2023, 42(7): 3510-3519.
[4]	林海, 王彧斐. 考虑噪声约束的分布式风场布局优化[J]. 化工进展, 2023, 42(7): 3394-3403.
[5]	吴霞, 蒋勋涛, 张余晓, 吕慧园, 黄方, 于筱溪. 基于液滴微流控技术的蛋白质结晶[J]. 化工进展, 2023, 42(4): 2024-2030.
[6]	谢迎春, 王倩倩, 马永丽, 孙国强, 刘明言. 超声波与紫外线耦合脱气杀菌[J]. 化工进展, 2023, 42(3): 1629-1637.
[7]	胡亚飞, 冯自平, 田佳垚, 黄冲, 宋文吉. 燃料驱动无电热泵系统的节能模拟与运行经济性分析[J]. 化工进展, 2023, 42(3): 1217-1227.
[8]	彭德其, 冯源, 王依然, 谭卓伟, 俞天兰, 吴淑英. 立式缩放管内液固颗粒群浓度分布与汇聚特性[J]. 化工进展, 2022, 41(9): 4662-4672.
[9]	陈二军, 张玉玲, 路少磊, 段海洋, 靳文章. 空气纳米气泡的稳定性及理化特性[J]. 化工进展, 2022, 41(9): 4673-4681.
[10]	胡亚飞, 吕杰, 韩涛, 宋文吉, 冯自平. 基于余热回收的燃气热泵系统高温制热特性[J]. 化工进展, 2022, 41(7): 3553-3563.
[11]	李娟娟, 张天永, 李祥高. 电泳显示用高质量铁锰黑纳米分散系的构建[J]. 化工进展, 2022, 41(6): 3178-3185.
[12]	吕飞勇, 初茉, 易浩然, 郝焱, 杨彦博, 石旭, 孙星博. 磁性灰粒在不同粒级气化灰渣中的分布特性[J]. 化工进展, 2022, 41(5): 2372-2378.
[13]	李楠, 贾帅, 孙振峰, 孙长宇, 陈光进, 李璟明. 注CO₂+N₂混合气改造-开采CH₄水合物储层[J]. 化工进展, 2022, 41(5): 2356-2363.
[14]	马小娟, 王彧斐, 冯霄. 天然气水合物开采平台能量系统优化[J]. 化工进展, 2022, 41(3): 1667-1676.
[15]	施文博, 蔡淳名, 李德威, 小野圭, 张剑波. ISO/IEC、美日中氢能技术标准化体系比较与建议[J]. 化工进展, 2022, 41(12): 6275-6284.