变频滚动转子式压缩机变吸气状态实验研究与模型建立

doi:10.16085/j.issn.1000-6613.2017.03.009

化工进展 ›› 2017, Vol. 36 ›› Issue (03): 832-838.DOI: 10.16085/j.issn.1000-6613.2017.03.009

变频滚动转子式压缩机变吸气状态实验研究与模型建立

虞中旸, 陶乐仁, 王超, 沈冰洁

上海理工大学制冷与低温工程研究所, 上海 200093

收稿日期:2016-07-29 修回日期:2016-08-15 出版日期:2017-03-05 发布日期:2017-03-05
通讯作者: 陶乐仁,教授,研究方向为制冷与低温技术。
作者简介:虞中旸(1994-),男,硕士研究生,研究方向为制冷系统仿真。
基金资助:
上海市动力工程多相流动与传热重点实验室项目（13DZ2260900）。

The experiment and modeling for variable frequency rotary compressor with different suction status

YU Zhongyang, TAO Leren, WANG Chao, SHEN Bingjie

Institute of Refrigeration and Cryogenics, University of Shanghai for Science and Technology, Shanghai 200093, China

Received:2016-07-29 Revised:2016-08-15 Online:2017-03-05 Published:2017-03-05

摘要/Abstract

摘要：

压缩机吸气带液可以有效降低排气温度，但也会对压缩机性能产生影响，需要对其深入研究。以R32变频滚动转子式压缩机实验系统为研究对象，通过分析相同频率不同压比和相同压比不同频率时压缩机容积效率随压缩机吸气状态的变化规律，建立了半经验压缩机模型。研究结果表明：①压缩机吸气过热时，过热度对压缩机容积效率基本无影响；少量吸气带液时，容积效率均随吸气干度的减小线性降低，各频率和各压比斜率基本相同。另外，系统COP与压缩机容积效率随吸气状态的变化趋势相似；②压缩机模型经实验验证，计算值与实验值最大相对误差为1.51%，最小相对误差为0.03%，具有较好的可靠性，可以减少试验次数，并能准确预测出压缩机性能；③压缩机运行性能在低频率、低吸气干度时迅速恶化，因此模型适用于压缩机频率高于额定频率、吸气干度大于0.90的运行工况。

关键词: 热力学, 变频压缩机, 模型, 两相

Abstract:

Although wet compression could decrease the compressor discharge temperature,it has effects on performance of compressor,which should be focused. The volumetric efficiency of R32 variable frequency rotary compressor with same frequency and different pressure ratios,then with same pressure ratio and different frequencies,varying with different compressor suction status is analyzed in this paper. According the conclusion and experimental data,the semi-empirical model was presented. Results showed that when the refrigerant status of compressor suction was superheated,the superheated temperature has less effect on the volumetric efficiency. When the status was at two phase,the volumetric efficiency decreased linearly with the suction vapor quality. The slopes at each frequency and pressure ratio were the same. The tendencies of the coefficient of performance varying with compressor suction state under experimental conditions were the same as that of the volumetric efficiency. In addition,by comparing theoretical value through the model with the experimental data,the maximum relative error is 1.51%,and the minimum is 0.03%,which demonstrates the precision of the model. The noteworthy phenomenon is that the performance of compressor is worsen when operating at lower frequency and suction vapor quality,which means the model is suitable for the operating condition with the frequency higher than the rated frequency and the suction vapor quality greater than 0.90.

Key words: thermodynamics, variable frequency compressor, model, two phase

中图分类号:

TK124

虞中旸, 陶乐仁, 王超, 沈冰洁. 变频滚动转子式压缩机变吸气状态实验研究与模型建立[J]. 化工进展, 2017, 36(03): 832-838.

YU Zhongyang, TAO Leren, WANG Chao, SHEN Bingjie. The experiment and modeling for variable frequency rotary compressor with different suction status[J]. Chemical Industry and Engineering Progress, 2017, 36(03): 832-838.

参考文献

[1] 郑学鹏,高秀峰,黄允东,等. 变频滚动转子式压缩机热力性能分析[J]. 流体机械,1999,27(1):48-51. ZHENG X P,GAO X F,HUANG Y D,et al. The analysis for the thermal performance of frequency vibration of rolling piston inverter compressor[J]. Fluid Machinery,1999,27(1):48-51.
[2] 张华俊,袁秀玲,刘勇,等. 滚动转子式变频压缩机的实验研究[J]. 制冷与空调,2004,4(2):14-16. ZHANG H J,YUAN X L,LIU Y,et al. Experimental study of performance of rolling piston type rotary inverter compressor[J]. Refrigeration and Air-conditioning,2004,4(2):14-16.
[3] 丁国良,张春路,詹涛. 制冷压缩机热力性能的模糊建模方法[J]. 上海交通大学学报,2000,34(9):1298-1300. DING G L,ZHANG C L,ZHAN T. Fuzzy modeling method of thermodynamic performance of refrigeration compressor[J]. Journal of Shanghai Jiaotong University,2000,34(9):1298-1300.
[4] 丁国良,李灏,陈江平,等. 热力性能的神经网络模拟[J]. 上海交通大学学报,1999,33(3):265-267. DING G L,LI H,CHEN J P,et al. Neural network method for predicting refrigeration compressor performance[J]. Journal of Shanghai Jiaotong University,1999,33(3):265-267.
[5] 傅烈虎,李青东,徐荣吉. 汽车空调用压缩机变转速工况容积效率研究[J]. 制冷学报,2008,29(2):29-32. FU L H,LI Q D,XU R J. Research on volumetric efficiency of compressor at variable speed in automobile air-conditioning[J]. Journal of Refrigeration,2008,29(2):29-32.
[6] 傅烈虎,李青东,徐荣吉. 变转速制冷压缩机的实验研究[J]. 制冷与空调,2008,8(3):44-46. FU L H,LI Q D,XU R J. Experimental study of variable speed refrigerating compressor[J]. Refrigeration and Air-conditioning, 2008,8(3):44-46.
[7] 沈希,王晓燕,黄跃进,等. 制冷压缩机变工况运行的热力性能研究[J]. 制冷学报,2009,30(6):15-19. SHEN X,WANG X Y,HUANG Y J,et al. Thermodynamic performance of refrigeration compressor running at variable condition[J]. Journal of Refrigeration,2009,30(6):15-19.
[8] 矢岛龙三郎,吉见敦史,朴春成,等. 降低R32压缩机排气温度的方法[J]. 制冷与空调,2011,11(2):60-64. RUZABURO Y,ATUSHI Y,PIAO C C. Measures to reduce the discharge temperature of R32 compressor[J]. Refrigeration and Air-conditioning,2011,11(2):60-64.
[9] 杨丽辉,陶乐仁,陶宏,等. 滚动转子式压缩机吸气状态与排气温度的实验研究[J]. 制冷学报,2014,35(2):49-53. YANG L H,TAO L R,TAO H,et al. Experimental study on suction refrigerant state and discharge temperature for rolling piston compressor[J]. Journal of Refrigeration,2014,35(2):49-53.
[10] 张利,陆颖翀. 吸气干度对R32压缩机可靠性影响研究[C]//2013年中国家用电器技术大会,江苏无锡,2013. ZHANG L,LU Y C. Research on reliability of R32 compressor with wet suction[C]//2013 China Academic Journal Electronic Publishing House,Wuxi,Jiangsu Province,China,2013.
[11] 林恩新,丁国良,赵丹,等. 适用于制冷系统动态仿真的全封闭式压缩机准动态模型[J]. 制冷学报,2012,33(1):28-31. LIN E X,DING G L,ZHAO D,et al. Quasi-dynamic hermetical compressor model suitable for dynamic simulation of refrigeration system[J]. Journal of Refrigeration,2012,33(1):28-31.
[12] 孙帅辉,郭鹏程,孙龙刚,等. 变吸气工况R32涡旋压缩机湿压缩过程模拟研究[J]. 西安理工大学学报,2015,31(3):282-288. SUN S H,GUO P C,SUN L G,et al. Simulation research on wet compression process in R32 scroll compressor under different suction operational conditions[J]. Journal of Xi'an University of Technology, 2015,31(3):282-288.
[13] 陈华俊,马国远,石文星,等. 变频滚动转子压缩机容积效率的频率修正方法[J]. 流体机械,2001,29(10):12-19. CHEN H J,MA G Y,SHI W X,et al. Frequency correction method on volumetric efficiency of inverter rolling piston compressor[J]. Fluid Machinery,2001,29(10):12-19.
[14] 黄理浩,陶乐仁,王金峰,等. 电子膨胀阀对制冷量特性的实验研究[J]. 制冷技术,2010,38(5):41-43. HUANG L H,TAO L R,WANG J F,et al. Experiment study on refrigeration capacity characteristic with electronic expansion valve[J]. Refrigeration,2010,38(5):41-43.
[15] 缪道平. 活塞式制冷压缩机[M]. 2版. 北京:机械工业出版社,1992. MIAO Daoping. Piston type refrigeration compressor[M]. 2nd ed. Beijing:China Machine Press,1992.
[16] LI W H. Simplified steady state modeling for variable speed compressor[J]. Applied Thermal Engineering,2013,50(1):318-326.

变频滚动转子式压缩机变吸气状态实验研究与模型建立

The experiment and modeling for variable frequency rotary compressor with different suction status

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	徐若思, 谭蔚. C形管池沸腾两相流流场模拟与流固耦合分析[J]. 化工进展, 2023, 42(S1): 47-55.
[2]	赵晨, 苗天泽, 张朝阳, 洪芳军, 汪大海. 负压状态窄缝通道乙二醇水溶液传热特性[J]. 化工进展, 2023, 42(S1): 148-157.
[3]	徐晨阳, 都健, 张磊. 基于图神经网络的化学反应优劣评价[J]. 化工进展, 2023, 42(S1): 205-212.
[4]	王胜岩, 邓帅, 赵睿恺. 变电吸附二氧化碳捕集技术研究进展[J]. 化工进展, 2023, 42(S1): 233-245.
[5]	陈匡胤, 李蕊兰, 童杨, 沈建华. 质子交换膜燃料电池气体扩散层结构与设计研究进展[J]. 化工进展, 2023, 42(S1): 246-259.
[6]	陈林, 徐培渊, 张晓慧, 陈杰, 徐振军, 陈嘉祥, 密晓光, 冯永昌, 梅德清. 液化天然气绕管式换热器壳侧混合工质流动及传热特性[J]. 化工进展, 2023, 42(9): 4496-4503.
[7]	董佳宇, 王斯民. 超声强化对二甲苯结晶特性及调控机理实验[J]. 化工进展, 2023, 42(9): 4504-4513.
[8]	罗成, 范晓勇, 朱永红, 田丰, 崔楼伟, 杜崇鹏, 王飞利, 李冬, 郑化安. 中低温煤焦油加氢反应器不同分配器中液体分布的CFD模拟[J]. 化工进展, 2023, 42(9): 4538-4549.
[9]	张帆, 陶少辉, 陈玉石, 项曙光. 基于改进恒热传输模型的精馏模拟初始化[J]. 化工进展, 2023, 42(9): 4550-4558.
[10]	张智琛, 朱云峰, 成卫戍, 马守涛, 姜杰, 孙冰, 周子辰, 徐伟. 高压聚乙烯失控分解研究进展：反应机理、引发体系与模型[J]. 化工进展, 2023, 42(8): 3979-3989.
[11]	卜治丞, 焦波, 林海花, 孙洪源. 脉动热管计算流体力学模型与研究进展[J]. 化工进展, 2023, 42(8): 4167-4181.
[12]	张振, 李丹, 陈辰, 吴菁岚, 应汉杰, 乔浩. 吸附树脂对唾液酸的分离纯化[J]. 化工进展, 2023, 42(8): 4153-4158.
[13]	王硕, 张亚新, 朱博韬. 基于灰色预测模型的水煤浆输送管道冲蚀磨损寿命预测[J]. 化工进展, 2023, 42(7): 3431-3442.
[14]	陈蔚阳, 宋欣, 殷亚然, 张先明, 朱春英, 付涛涛, 马友光. 矩形微通道内液相黏度对气泡界面的作用机制[J]. 化工进展, 2023, 42(7): 3468-3477.
[15]	杨许召, 李庆, 袁康康, 张盈盈, 韩敬莉, 吴诗德. 含Gemini离子液体低共熔溶剂热力学性质[J]. 化工进展, 2023, 42(6): 3123-3129.