换热网络的热流均匀性因子

化工进展

换热网络的热流均匀性因子

万义群，崔国民，方大俊，彭富裕

上海理工大学新能源科学与工程研究所，上海 200093

出版日期:2013-09-05 发布日期:2013-09-05

Uniformity factor of heat flux in heat exchanger networks

WAN Yiqun，CUI Guomin，FANG Dajun，PENG Fuyu

Institute of New Energy Science and Engineering，University of Shanghai for Science and Technology，Shanghai 200093，China

Online:2013-09-05 Published:2013-09-05

摘要/Abstract

摘要： 提出并建立了能够评价换热网络换热效能的热流均匀性因子，在两个条件下对该因子进行验证和分析。首先，在相同结构上保持换热器单元总面积之和不变的条件下模拟计算，考察热流均匀性因子与总换热量之间的对应关系，并与温差均匀性因子进行比较；其次，在改变换热网络结构的条件下优化计算，考察各优化结构的热流均匀性因子与总换热量之间的对应关系。通过两个具体的换热网络实例验证该因子，结果表明：热流均匀性因子越小则对应的换热网络总体换热效能越好。由此说明本研究建立的换热网络的热流均匀性因子能够从总体上反应换热网络的换热效能，能够作为其换热效能的一种新的评价指标，并能为换热网络的综合及优化提供新的思路。

关键词: 换热网络, 换热效能, 温差均匀性因子, 热流均匀性因子

Abstract: This paper presented the uniformity factor of heat flux，which can evaluate the heat transfer efficiency of heat exchanger networks. The uniformity factor was analyzed under two conditions. Simulation was conducted under the condition of constant total heat transfer areas in the same structure，the corresponding relationship between the uniformity factor of heat flux and the heat transfer rate was investigated，and compared with the uniformity factor of temperature difference. Simulation was optimized under the condition of changing structures of heat exchanger networks，the corresponding relationship between the uniformity factor of heat flux and the heat transfer rate was investigated. The factor was validated in two specific heat exchanger networks. The results showed that the heat transfer efficiency of heat exchanger networks increased when the uniformity factor of heat flux decreased. The uniformity factor of heat flux in heat exchanger networks established in this paper could reflect the heat transfer efficiency of heat exchanger networks，it could also be a new evaluation index for the heat transfer efficiency，and a new idea for the synthesis and optimization of heat exchanger networks.

Key words: heat exchanger networks, heat transfer performance, the uniformity factor of temperature difference, the uniformity factor of heat flux

万义群，崔国民，方大俊，彭富裕. 换热网络的热流均匀性因子[J]. 化工进展.

WAN Yiqun，CUI Guomin，FANG Dajun，PENG Fuyu. Uniformity factor of heat flux in heat exchanger networks[J]. Chemical Industry and Engineering Progree.

[1]	朱添宇, 孙琳, 任超, 罗雄麟. 基于全周期持续节能的换热网络滑动窗口分析与裕量缓释优化控制[J]. 化工进展, 2023, 42(3): 1195-1205.
[2]	蒋宁, 张元毅, 范伟, 赵世超, 徐新杰, 徐英杰. 基于智能预测和机理模型的换热网络清洗决策[J]. 化工进展, 2022, 41(4): 1781-1792.
[3]	刘洪彬, 崔国民, 周志强, 肖媛, 张冠华, 杨其国. 应用于换热网络优化的并行双层RWCE算法[J]. 化工进展, 2022, 41(10): 5247-5258.
[4]	徐玥, 崔国民. 基于节点配置策略的有分流换热网络优化性能探析[J]. 化工进展, 2021, 40(7): 3608-3616.
[5]	蒋宁, 赵世超, 谢小东, 范伟, 徐新杰, 徐英杰. 利用余热回收多能互补技术的原油蒸馏装置热集成系统的优化改造[J]. 化工进展, 2021, 40(2): 652-663.
[6]	邵缨迪, 胡建杭, 刘慧利, 蔡正达. 异丁烯提纯装置换热网络的能效分析[J]. 化工进展, 2020, 39(S2): 57-65.
[7]	蒋宁, 范伟, 谢小东, 郭风元, 李恩腾, 赵世超. NSGA-Ⅱ和NSGA-Ⅲ应用于换热网络多目标优化的对比[J]. 化工进展, 2020, 39(7): 2534-2547.
[8]	孙琳, 杨明达, 罗雄麟. 基于持续节能的换热网络缓释优化[J]. 化工进展, 2020, 39(10): 3941-3948.
[9]	苏戈曼, 崔国民, 肖媛, 赵倩倩. 换热网络优化中换热单元生成频次的影响分析及策略改进[J]. 化工进展, 2020, 39(10): 3879-3891.
[10]	刘昶,李士雨,谢晓兰. 考虑间接换热额外换热温差的间歇过程储热集成[J]. 化工进展, 2020, 39(1): 72-79.
[11]	苏戈曼,崔国民,鲍中凯,肖媛,蒋奥炜. RWCE优化换热网络的不可行解影响分析及强化策略[J]. 化工进展, 2020, 39(1): 14-25.
[12]	蒋宁,谢小东,范伟,徐英杰. 数据驱动的固定拓扑结构换热网络优化改造方法[J]. 化工进展, 2019, 38(10): 4452-4460.
[13]	董云青, 王政, 徐一凡, 杨燕霞, 贾小平, 王芳. 基于复杂网络控制理论的换热网络旁路位置确定[J]. 化工进展, 2019, 38(07): 3046-3055.
[14]	杨蕊, 庄钰, 刘琳琳, 张磊, 都健. 功热交换网络综合的研究进展[J]. 化工进展, 2019, 38(06): 2550-2558.
[15]	蒋宁, 韩文巧, 郭风元, 徐英杰. 基于实际热负荷分布的换热网络优化改造[J]. 化工进展, 2018, 37(08): 2935-2941.