基于热舒适性纳米喷泉的流动与传热特性

doi:10.16085/j.issn.1000-6613.2016.12.011

摘要/Abstract

摘要： 目前关于纳米喷泉流动与传热特性及微区域热舒适度方面的研究较少，为了研究其流动与传热机理，本文基于气-液两相流模型和金刚石-乙二醇/水纳米流体高沸点、低冰点等优良特性，在有限柱体空间内建立了一种基于热舒适性的新型高效换热喷泉-“纳米喷泉”，对比研究了金刚石-乙二醇/水纳米流体、水射流工质分别对喷泉流动与传热的影响，同时讨论了纳米颗粒体积分数v和表征流体流动情况的雷诺数（Reynolds，Re）对喷泉流动与传热的影响，分析了局部温度分布、流线分布、平均温度和流体换热量在空间内的变化，并依据ASHRAE 55-1992标准和ISO7730标准对微区域的热舒适度进行了评价。结果表明：随着Re数和v增大，换热强度均得以不同程度地提升，热舒适程度也逐渐增加。Re=1.0×10⁵和Re=1.2×10⁵时，纳米颗粒体积分数从0增加至1%的换热强度提升较为明显，前后两种Re数可分别强化1.5%和2.8%；Re=1.4×10⁵时，体积分数从3%增至5%的换热强度可提升11.5%，强化效果最为明显。故较小Re数下，较低组分的纳米流体强化换热效果较好；而在较大Re数下，较高组分纳米流体的强化换热效果更好。

关键词: 气液两相流, 传热, 数值模拟, 纳米喷泉, 热舒适性

Abstract: There were few researches about the flow and heat transfer characteristics of fountain based on thermal comfort of micro-regional,so a new kind of fountain model named "nano-fountain" was established in a limited cylinder space to investigate the associated characteristics,which has high thermal conductivity and two phases(H₂O-air and diamond-ethylene glycol[EG]/H₂O nanofluid-air). Then the flow and heat transfer characteristics of H₂O-air and diamond-EG/H₂O nanofluid-air were studied respectively with different nanoparticle volume fractions and Re numbers. The effects of local temperature,streamlines distribution,average temperature as well as the flow and heat transfer characteristics were discussed. In addition,thermal comfort was evaluated according to the ASHRAE standard 55-1992 and standard ISO7730. The results showed that heat transfer enhancement increases with the increase of Re numbers and volume fractions in different degrees,and thermal comfort also increases. Diamond-EG/H₂O nanofluid showed larger enhancement than H₂O,and could enhance the heat transfer by 1.5% and 2.8% respectively at Re=1.0×10⁵ and Re=1.2×10⁵;In addition,it could enhance the heat transfer by 11.5% when nanoparticle volume fraction increases from v=3% to 5% at Re=1.4×10⁵. Thus it showed larger enhancement in lower volume fraction at lower Re number,and heat transfer enhancement showed more obvious in large volume fraction at larger Re number.

Key words: gas-liquid flow, heat transfer, numerical simulation, nano-fountain, thermal comfort

中图分类号:

TK124

万永亮, 齐聪, 李春阳, 韩东太. 基于热舒适性纳米喷泉的流动与传热特性[J]. 化工进展, 2016, 35(12): 3807-3817.

WAN Yongliang, QI Cong, LI Chunyang, HAN Dongtai. Study on flow and heat transfer characteristics of nano-fountain based on thermal comfort[J]. Chemical Industry and Engineering Progree, 2016, 35(12): 3807-3817.

参考文献

[1] CHOI S U S,EASTMAN J A.Enhancing thermal conductivity of fluids with nanoparticles.ASME International menchanical engineering congress and exposition[C]//ASME International Mechanical Engineering Congress&Exposition,American Society of Mechanical Engineers,San Francisco,1995.
[2] XUAN Y M,LI Q.Heat transfer enhancement of nanofluids[J].International Journal of Heat and Fluid Flow,2000,21(1):58-64.
[3] XUAN Y M,LI Q,TIE P.The effect of surfactants on heat transfer feature of nanofluids[J].Experimental Thermal and Fluid Science,2013,46:259-262.
[4] HE Y R,JIN Y,CHEN H S,et al.Heat transfer and flow behavior of aqueous suspensions of TiO₂ nanoparticles (nanofluids) flowing upward through a vertical pipe[J].International Journal of Heat and Mass Transfer,2006,50(11):2272-2281.
[5] CHEN H S,DING Y L,HE Y R,et al.Rheological behavior of ethylene glycol based titania nanofluids[J].Chemical Physics Letters,2007,444(4):333-337.
[6] DING Y L,CHEN H S,HE Y R,et al.Forced convection heat transfer of nanofluids[J].Advanced Power Technology,2007,18(6):813-824.
[7] DING Y L,CHEN H S,WANG L,et al.Heat transfer intensification using nanofluids[J].KONA Power and Particle Journal,2007,25:23-38.
[8] HE Y R,MEN Y B,ZHAO Y H,et al.Numerical investigation into the convective heat transfer of TiO₂ nanofluids flowing through a straight tube under the laminar flow conditions[J].Applied Thermal Engineering,2009,29(10):1965-1972.
[9] QI C,HE Y R,YAN S N,et al.Numerical simulation of natural convection in a square enclosure filled with nanofluid using the two-phase Lattice Boltzmann method[J].Nanoscale Research Letters,2013,56(8):1-16.
[10] QI C,LIANG L,RAO Z H.Study on the flow and heat transfer of liquid metal based nanofluid with different nanoparticle radiuses using two-phase Lattice Boltzmann method[J].International Journal of Heat and Mass Transfer,2016,94:316-326.
[11] 齐聪,何光艳,李意民,等.方腔内Cu/Al₂O₃-H₂O混合纳米流体自然对流的格子Boltzmann模拟[J].物理学报,2015,64(2):024703.
[12] 齐聪,何玉荣,闫盛楠,等.矩形腔内纳米流体自然对流的两相格子Boltzmann模拟[J].工程热物理学报,2014,35(2):282-286.
[13] QI C,HE Y R,HU Y W,et al.Natural convection of Cu-Gallium nanofluid in enclosures[J].Journal of Heat Transfer,2011,133(12):122504.
[14] KEFAYATI G H R.Simulation of heat transfer and entropy generation of MHD natural convection of non-Newtonian nanofluid in an enclosure[J].International Journal of Heat and Mass Transfer,2016,92:1066-1089.
[15] 孙斌,赵朝.内螺纹管内金属氧化物-水纳米流体传热特性的数值模拟[J].化工进展,2014,33(3):563-587.
[16] 孙斌,张志敏,杨迪,等.减阻型纳米流体在圆管内的流动与换热特性[J].化工学报,2015,66(11):4401-4411.
[17] 林璟,方利国.纳米流体强化传热技术及其应用新进展[J].化工进展,2008,27(4):488-494.
[18] 李新芳,朱冬生.纳米流体传热性能研究进展与存在问题[J].化工进展,2006,25(8):875-879.
[19] 李蔚,黄丹,吴晓雨,等.超临界压力下纳米流体竖直管内流动换热[J].化工学报,2015,66(4):1265-1271.
[20] 吴信宇,吴慧英,屈健,等.纳米流体在芯片微通道中的流动与换热特性[J].化工学报,2008,59(9):2181-2187.
[21] 王鹏,白敏丽,吕继祖,等.纳米流体圆管内的湍流流动特性[J].化工学报,2014,65(1):17-26.
[22] 毕胜山,史琳.纳米流体沸腾传热研究进展[J].化工进展,2007,26(10):1411-1418.
[23] 厉曙光,张亚锋,李莉,等.喷泉对周围空气负离子和气象条件的影响[J].同济大学学报,2002,30(3):352-355.
[24] 万华根,金小刚,彭群生.基于物理模型的实时喷泉水流运动模拟[J].计算机学报,1998,21(9):774-779.
[25] 赵静谧,张慧,郑国勤.基于粒子系统的喷泉模拟[J].计算机应用研究,2006,1:244-249.
[26] 张志勤.喷泉周围热环境实验和理论研究[D].北京:清华大学,2004.
[27] 徐键卉,杜昊阳,雷望春,等.喷泉编码在DTN网络中的应用研究[J].无线电通信技术,2016,42(3):110-114.
[28] PAK B C,CHO Y I.Hydrodynamic and heat transfer study of dispersed fluids with submicron metallic oxide particles[J].Experimental Heat Transfer an International Journal,1998,11(2):151-170.
[29] XUAN Y,ROETZEL W.Conceptions for heat transfer correlation of nanofluids[J].International Journal of Heat and Mass Transfer,2000,43(19):3701-3707.
[30] BRINKMAN H C.The viscosity of concentrated suspensions and solutions[J].Journal of Chemical Physics,1952,20(4):571-571.
[31] MANSOUR R B,GALANIS N,NGUYEN C T.Effect of uncertainties in physical properties on forced convection heat transfer with nanofluids[J].Applied Thermal Engineering,2007,27(1):240-249.
[32] WANG X,XU X,CHOI S U S.Thermal conductivity of nanoparticle-fluid mixture[J].Journal of Thermophysics and Heat Transfer,1999,13(4):474-480.
[33] HAMILTON R L,CROSSER O K.Thermal conductivity of heterogeneous two-component systems[J].Industrial and Engineering Chemistry Fundamentals,1962,1(3):187-191.
[34] YU W,CHOI S U S.The role of interfacial layers in the enhanced thermal conductivity of nanofluids:a renovated Maxwell model[J].Journal of Nanoparticle Research,2003,5(1/2):167-171.
[35] DREW D A,PASSMAN S L.Relation of microstructure to constitutive equations[M]//Theory of Multicomponent Fluids.New York:Springer,1999:153-192.
[36] TZOU D Y.Thermal instability of nanofluids in natural convection[J].International Journal of Heat and Mass Transfer,2008,51(11):2967-2979.
[37] GOSSELIN L,DA SILVA A K.Combined "heat transfer and power dissipation" optimization of nanofluid flows[J].Applied Physics Letters,2004,85(18):4160-4162.
[38] ASHRAE Standard 55-1992[S].Thermal Environmental Conditions for Human Occupancy,1992.