基于硅基的垃圾焚烧飞灰中温热处理重金属稳固化实验

doi:10.16085/j.issn.1000-6613.2017-0141

化工进展 ›› 2017, Vol. 36 ›› Issue (09): 3514-3522.DOI: 10.16085/j.issn.1000-6613.2017-0141

基于硅基的垃圾焚烧飞灰中温热处理重金属稳固化实验

孙立, 吴新, 刘道洁, 李军辉, 李诗, 都艺伟

东南大学能源热转换及其过程测控教育部重点实验室, 江苏南京 210096

收稿日期:2017-01-20 修回日期:2017-04-05 出版日期:2017-09-05 发布日期:2017-09-05
通讯作者: 吴新,副教授,研究方向为高效清洁燃烧与污染物控制排放技术、流化床燃烧与气化、多相流传热流动、测试技术等。
作者简介:孙立(1992-),男,硕士研究生,研究方向为垃圾焚烧飞灰稳固化
基金资助:
国家重点研发计划项目（2016YFB0600602）。

Stabilization of heavy metals in municipal solid waste incineration fly ash using thermal treatment with silica-based material

SUN Li, WU Xin, LIU Daojie, LI Junhui, LI Shi, DU Yiwei

Key Laboratory of Energy Thermal Conversion and Process Control of Ministry of Education, Southeast University, Nanjing 210096, Jiangsu, China

Received:2017-01-20 Revised:2017-04-05 Online:2017-09-05 Published:2017-09-05

摘要/Abstract

摘要： 向垃圾焚烧飞灰（MSWI FA）中分别添加硅灰、硅溶胶、石英砂与一定比例的水，混合均匀并进行热处理。研究了添加物种类、热处理温度对垃圾焚烧飞灰中重金属浸出特性的影响，分析了飞灰热处理过程中重金属化学形态、晶体结构和微观形貌的变化。结果表明：热处理过程中，硅灰和硅胶与飞灰中的钙基物质反应生成CaSiO₃、Ca₂SiO₄、Ca₃SiO₄Cl₂、Ca₃Fe₂（SiO₄）₃以及氢氧硅磷灰石等硅酸盐相，转变了重金属的化学形态，将重金属稳固在硅酸盐晶格中，降低了飞灰的浸出毒性；在硅灰添加量为10%或JN-40硅胶添加量25%，热处理温度600℃条件下，热处理1h后，飞灰中Pb的浸出浓度由11.91mg/L分别降至0.79mg/L和0.78mg/L，Cd的浸出浓度由3.18mg/L分别降至0.09mg/L和0.10mg/L；热处理过程中Cr的浸出浓度有所上升但未超出生活垃圾填埋场控制标准。

关键词: 垃圾焚烧, 飞灰, 热处理, 重金属, 稳固化

Abstract: Heat treatments were performed with municipal solid waste incineration fly ash(MSWI FA),mixing with silica fume,colloidal silica,quartz sand respectively and a certain proportion of water. The effects of additive species,thermal treatment temperature on the leaching of critical heavy metals(Pb,Cd and Cr) were studied. The changes of chemical speciation of heavy metals,crystal structure and microstructure during heat treatment were also investigated. The results showed that silica fume and colloidal silica react with calcium-based materials in fly ash to form silicate phases such as CaSiO₃、Ca₂SiO₄、Ca₃SiO₄Cl₂、Ca₃Fe₂(SiO₄)₃ and hydroxyl-ellestadite during the heat treatment,changing the chemical speciation of heavy metals and stabilizing heavy metals in the silicate lattice,which reduces the leaching toxicity. The leaching concentration of Pb in fly ash decreased from 11.91mg/L to 0.79mg/L and 0.78mg/L,respectively,under the conditions of adding 10% silica fume or 25% JN-40 colloidal silica and heat treatment at 600℃ for one hour,while the leaching concentration of Cd decreased from 3.18mg/L to 0.09mg/L and 0.10mg/L,respectively. During the heat treatment,the leaching concentration of Cr increased but did not exceed the standard for pollution control on the landfill site of municipal solid waste.

Key words: municipal solid waste incineration, fly ash, thermal treatment, heavy metals, stabilization and solidification

中图分类号:

X705

孙立, 吴新, 刘道洁, 李军辉, 李诗, 都艺伟. 基于硅基的垃圾焚烧飞灰中温热处理重金属稳固化实验[J]. 化工进展, 2017, 36(09): 3514-3522.

SUN Li, WU Xin, LIU Daojie, LI Junhui, LI Shi, DU Yiwei. Stabilization of heavy metals in municipal solid waste incineration fly ash using thermal treatment with silica-based material[J]. Chemical Industry and Engineering Progress, 2017, 36(09): 3514-3522.

参考文献

[1] 熊祖鸿,范根育,鲁敏,等. 垃圾焚烧飞灰处置技术研究进展[J]. 化工进展,2013,32(7):1678-1684. XIONG Z H,FAN G Y,LU M,et al. Treatment technologies of municipal solid waste incinerator fly ash:a review[J]. Chemical Industry and Engineering Progress,2013,32(7):1678-1684.
[2] BONTEMPI E,ZACCO A,BORGESE L,et al. A new powder filler,obtained by applying a new technology for fly ash inertisation procedure[C]//Advances in Science and Technology. Trans. Tech. Publications,2010,62:27-33.
[3] BENASSI L,BOSIO A,DALIPI R,et al. Comparison between rice husk ash grown in different regions for stabilizing fly ash from a solid waste incinerator[J]. Journal of Environmental Management,2015,159:128-134.
[4] BOSIO A,RODELLA N,GIANONCELLI A,et al. A new method to inertize incinerator toxic fly ash with silica from rice husk ash[J]. Environmental Chemistry Letters,2013,11(4):329-333.
[5] BOSIO A,GIANONCELLI A,ZACCO A,et al. A new nanotechnology of fly ash inertization based on the use of silica gel extracted from rice husk ash and microwave treatment[J]. Proceedings of the Institution of Mechanical Engineers Part N:Journal of Nanoengineering and Nanosystems,2014,228(1):27-32.
[6] BOSIO A,BONTEMPI E,RODELLA N,et al. Rice husk ash based composites,obtained by toxic fly ash inertization,and their applications as adsorbents[J]. Chemical Engineering Transactions,2014,37:631-636.
[7] LI X,CHEN Q,ZHOU Y,et al. Stabilization of heavy metals in MSWI fly ash using silica fume[J]. Waste Management,2014,34(12):2494-504.
[8] RODELLA N,BOSIO A,ZACCO A,et al. Arsenic stabilization in coal fly ash through the employment of waste materials[J]. Journal of Environmental Chemical Engineering,2014,2(3):1352-1357.
[9] 田书磊. 垃圾焚烧飞灰重金属热分离工艺及挥发特性研究[D]. 哈尔滨:哈尔滨工业大学,2007. TIAN S L. Thermal separation process and evaporation mechanism of heavy metal from MSWI fly ash[D]. Harbin:Harbin Institute of Technology,2007.
[10] 邓燚超. 垃圾焚烧飞灰低中温热处理过程中氯及重金属的迁徙特性分析[D]. 杭州:浙江大学,2007. DENG Y. Analysis the transferring characteristics of the chlorine and heavy metals of the MSWI fly ash in low and medium temperature heat treatment[D]. Hangzhou:Zhejiang University,2007.
[11] MENARD Y,ASTHANA A,PATISSON F,et al. Thermodynamic study of heavy metals behaviour during municipal waste incineration[J]. Process Safety & Environmental Protection,2006,84(4):290-296.
[12] 罗春晖. 生活垃圾焚烧飞灰水洗-稳定化试验研究[D]. 上海:东华大学,2003. LUO C H. Study on water-immobilization process of MSWI fly ash[D]. Shanghai:Donghua University,2003.
[13] 蔵本,康宏,高岡,昌輝,武田,信生. 飛灰中重金属の形態同定に関する研究(京都大学環境衛生工学研究会第19回シンポジウム講演論文集(1997年7月24日·25日,京都))——(一般講演)[J]. 環境衛生工学研究,1997,11(3):53-58.
[14] UMOREN I U,UDOH A P,UDOUSORO I I. Concentration and chemical speciation for the determination of Cu,Zn,Ni,Pb and Cd from refuse dump soils using the optimized BCR sequential extraction procedure[J]. Environment Systems and Decisions,2007,27(2):241-252.
[15] WU S,XU Y,SUN J,et al. Inhibiting evaporation of heavy metal by controlling its chemical speciation in MSWI fly ash[J]. Fuel,2015,158:764-769.
[16] ZHANG H,ZHAO Y,QI J. Thermal characterization of fly ash from one municipal solid waste incinerator (MSWI)in Shanghai[J]. Process Safety and Environmental Protection,2010,88:269-275.
[17] PARK Y J,HEO J. Vitrification of fly ash from municipal solid waste incinerator.[J]. Journal of Hazardous Materials,2002,91(1/2/3):83-93.
[18] KUO Y M,WANG J W,WANG C T,et al. Effect of water quenching and SiO₂ addition during vitrification of fly ash. Part 1:On the crystalline characteristics of slags[J]. Journal of Hazardous Materials,2008,152(3):994-1001.
[19] JAKOB A,STUCKI S,STRUIS R P W J. Complete heavy metal removal from fly ash by heat treatment:influence of chlorides on evaporation rates[J]. Environmental Science & Technology,1996,30(11):3275-3283.
[20] ZHANG H Y,ZHAO Y C,QI J Y. Measurement of composition variation of municipal solid waste incineration(MSWI) fly ash during thermal treatment[J]. Key Engineering Materials,2011,460-461:90-95.
[21] HU H,LUO G,LIU H,et al. Fate of chromium during thermal treatment of municipal solid waste incineration(MSWI)fly ash[J]. Proceedings of the Combustion Institute,2013,34(2):2795-2801.
[22] HU H,LIU H,SHEN W Q,et al. Comparison of CaO's effect on the fate of heavy metals during thermal treatment of two typical types of MSWI fly ashes in China[J]. Chemosphere,2013,93(4):590-596.
[23] KIRK D W,CHAN C C,MARSH H. Chromium behavior during thermal treatment of MSW fly ash[J]. Journal of Hazardous Materials,2002,90(1):39-49.
[24] LEE Y M,NASSARALLA C L. Standard free energy of formation of calcium chromate[J]. Materials Science and Engineering A,2006,437(2):334-339.
[25] WANG K S,SUN C J,LIU C Y. Effects of the type of sintering atmosphere on the chromium leachability of thermal-treated municipal solid waste incinerator fly ash[J]. Waste Management,2001,21(1):85-91.
[26] HU H Y,LIU H,ZHANG Q,et al. Sintering characteristics of CaO-rich municipal solid waste incineration fly ash through the addition of Si/Al-rich ash residues[J]. Journal of Material Cycles and Waste Management,2016,18(2):340-347.

基于硅基的垃圾焚烧飞灰中温热处理重金属稳固化实验

Stabilization of heavy metals in municipal solid waste incineration fly ash using thermal treatment with silica-based material

PDF (PC)

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

编辑推荐

Metrics

本文评价

[1]	许春树, 姚庆达, 梁永贤, 周华龙. 共价有机框架材料功能化策略及其对Hg(Ⅱ)和Cr(Ⅵ)的吸附性能研究进展[J]. 化工进展, 2023, 42(S1): 461-478.
[2]	李世霖, 胡景泽, 王毅霖, 王庆吉, 邵磊. 电渗析分离提取高值组分的研究进展[J]. 化工进展, 2023, 42(S1): 420-429.
[3]	顾永正, 张永生. HBr改性飞灰对Hg⁰的动态吸附及动力学模型[J]. 化工进展, 2023, 42(S1): 498-509.
[4]	李志远, 黄亚继, 赵佳琪, 于梦竹, 朱志成, 程好强, 时浩, 王圣. 污泥与聚氯乙烯共热解重金属特性[J]. 化工进展, 2023, 42(9): 4947-4956.
[5]	李卫华, 于倩雯, 尹俊权, 吴寅凯, 孙英杰, 王琰, 王华伟, 杨玉飞, 龙於洋, 黄启飞, 葛燕辰, 何依洋, 赵灵燕. 酸雨环境下填埋飞灰吨袋破损后重金属的溶出行为[J]. 化工进展, 2023, 42(9): 4917-4928.
[6]	李东泽, 张祥, 田键, 胡攀, 姚杰, 朱林, 卜昌盛, 王昕晔. 基于水泥窑脱硝的碳基还原NO _x 研究进展[J]. 化工进展, 2023, 42(9): 4882-4893.
[7]	王兰江, 梁瑜, 汤琼, 唐明兴, 李学宽, 刘雷, 董晋湘. 快速热解铂前体合成高分散的Pt/HY催化剂及其萘深度加氢性能[J]. 化工进展, 2023, 42(8): 4159-4166.
[8]	张杉, 仲兆平, 杨宇轩, 杜浩然, 李骞. 磷酸盐改性高岭土对生活垃圾热解过程中重金属的富集[J]. 化工进展, 2023, 42(7): 3893-3903.
[9]	李若琳, 何少林, 苑宏英, 刘伯约, 纪冬丽, 宋阳, 刘博, 余绩庆, 徐英俊. 原位热解对油页岩物性及地下水水质影响探索[J]. 化工进展, 2023, 42(6): 3309-3318.
[10]	庄捷, 薛锦辉, 赵斌成, 张文艺. 猪粪厌氧消化进程中重金属与腐殖质的有机结合机制[J]. 化工进展, 2023, 42(6): 3281-3291.
[11]	郑昕, 贾里, 王彦霖, 张靖超, 陈世虎, 乔晓磊, 樊保国. 污泥与煤泥混烧对重金属固留特性的影响[J]. 化工进展, 2023, 42(6): 3233-3241.
[12]	李卫华, 吴寅凯, 孙英杰, 尹俊权, 辛明学, 赵友杰. 垃圾焚烧飞灰重金属毒性浸出评价方法研究进展[J]. 化工进展, 2023, 42(5): 2666-2677.
[13]	常占坤, 张弛, 苏冰琴, 张聪政, 王健, 权晓慧. H₂S气态基质对污泥生物沥滤处理效能的影响[J]. 化工进展, 2023, 42(5): 2733-2743.
[14]	杨自强, 李风海, 郭卫杰, 马名杰, 赵薇. 市政污泥热处理过程中磷迁移转化的研究进展[J]. 化工进展, 2023, 42(4): 2081-2090.
[15]	王玉, 余广炜, 林佳佳, 黎长江, 江汝清, 邢贞娇, 余铖. 沼渣、飞灰和污泥生物炭制备建筑陶粒[J]. 化工进展, 2023, 42(2): 1039-1050.